spare tire CHEVROLET S10 1997 2.G Owners Manual

Downloaded from www.Manualslib.com manuals search engine Section 5 Problems on the Road
Here you'll:find.what ta do about some problems .that ciin "Ciel%af bfi the road.
5- 2 Hazard. Warning Flaihers.
5-2 .Other Warning Devices
5-3 Jump Starting
5-7 Towing Your Vehicle
5-1 2 Engine Overhearing
5-22
5-22
5-23
5-35
5-36
Engine Fan Noise
Ita Tife Goes Flat
Changirig
x Flat 'Tire
Compact Spare Tire (Tf Equipped)
If You're Stuck: In Sand, Mud,
Ice or Snow

Downloaded from www.Manualslib.com manuals search engine Removing the Spare.’Tire and Tools
The jacking equipment you’I1 need. is .stored inside the
plastic jack covef.which is behind the-fr-ont seats, -either
on the center of the wall (extmded cab) ‘or ‘on the
p-assenger’s side .of the wxll (regular cab).
The following steps will tell youhow to use the jack and
change a tire.
This is the jack cover for the extended cab. The cover
.for the re,gular cab is similar. To remove it, turn the
phstic wing nu% counterclmkwis.e. Rem-ove the.
J ac R cover.

Downloaded from www.Manualslib.com manuals search engine Turn .the wi~%g imt. cwnterclockwise :and rem-ove the
wheel blocks., jack and wheel wrench.
Your spare tire is stored underneath the rear of your
vehicle; See “Compact S-pare Tire” later in this section
for more mformation- about the compact spare.
NOTICQ
Never remove or restow a tire frodto a stowage.
psition under the vehicle while the .vehicle is
suppiorted by .a jack+ Always tighten th.e tire
fully against the: underside- of the vehicle
when restowiqg.
$-E
. _.. - .

Downloaded from www.Manualslib.com manuals search engine Turn the wheel wrench c0unterclo'ckwiA-e t$ lower the
.spare tire. Keep turning the wheel wrench irntil the spare
tire can be pulled out from under .the vehicle.
When the tire has been completely lowered, tilt the
retainer at the end of the cable.,and pill it through the-
wheel Gpening:. Puli the tire out from underthe vehicle. I
To help avoid v.ehicle .damage, do not drive th-e
vehicle before $he- cable is restored.
Pwf.the spare .tire nearae- flat tire. The tools you'll be, wing include. the jack (A) and wheel
wrench (€3). Your vehicle may also liava an optional hub,
cap I:emov.d to-ol.
5-26

Downloaded from www.Manualslib.com manuals search engine Getting under a vehicle when it is jacked up is
dangerous. If the vehicle slips off the jack, you
could be badly injured or killed. Never get under
a vehicle when
it is supported only by a jack.
I
1 NOTICE:
Raising your vehicle with the jack improperly
positioned
can damage the vehicle and even make
the vehicle
fall. To help avoid personal injury
and vehicle
damage, be sure to fit the jack
18t head into the proper location before raising
your vehicle.
4. Raise the vehicle by turning the jack handle
clockwise. Raise the vehicle far enough off the
ground so there is enough room for the spare tire
to fit.
5. Remove all the wheel nuts and take off the flat-tire;

Downloaded from www.Manualslib.com manuals search engine I
Incorrect wheel nuts or imprdperly tightened
wheel nuts can cause th,e-wheel to become loose
and-even comeaff. This. could lead to 'an accident.
Fk swe'to use the corre-ct whee1 nuts. If pu have
to .iiep-lsrC.e them, be sure. to get 'new GM origin.al
equipment
wheel nuts.
Stop somewhere as soon as you can and have the
nuts tightened with a torque wpsnch to 95 lb-ft
(I30 Nmj.
I NOTICE:
Improperly .. tiightened wheel nuts: can lead to
brake - pulsatian-and r.otor damage. To avoid
expe-nsive brake
repairs; evenly tighten the wheel
nuts in the proper sequence and to the proper
tGrque spe~~citign.
Storing .a F1i ' or Spare .Tire and To&
A CAUTION:
Storing a jack, a tire or other equipment In the
passenger .compartment of the vehicle could
cause injury. In .r.,sudden stop -or collision, loose
equipment, could strike smneome. Stote all these
in the proper place.
Don't use the existing hoist to store a tire with an
,aluminum wheel or it could &amage the wheel.
Secure. the tire in the pichp bed.
Follow this diagram to store the underbody
-mounted spare.

Downloaded from www.Manualslib.com manuals search engine A, Hub Cap Removal Tool (Some Mmiels)
E. Cover (Extended Cab)
%. Cover (Stand,ard Cab)
D. Hub Cap Removal Tool (Some Models)
E. Bdt
Compact Spare Tire (If Equippe.d)
Although the compact spare-tire was fully inflated when
your vehicle w.as new, it can lose air after a time. Check
the. inflation pressure regularly. It should be 60 psi
(420 kPa).
After installing the compact spare on your vehicle, you
should stop as 'soon as possible and 'm.ake-. sure your
spare tire
is cor-rec.tly inflated. The compact spare is
made to perform well at speeds up to 65 :mph
(I 05 krn/h) for distances up to 3,000 miles (5.000 km),
so you can finish your trip and have your full-size tire
repaired or replaceid where.you
want. Of course, it's best
to replace y0.w spare with a full-size tire as soon as you
can. Your spare will last longer and be: in .good shape in
case you-need it again.
I NOTICE: I
When the compact 'spare: is installed, don't ta.ke
your vehicle through
an automatic car wash with
guide rails, The compact spare can get caught on
the rails; That can damage the tire and wheel,
-and maybe other-parts of your vehicle.

Downloaded from www.Manualslib.com manuals search engine Dan’t use your. campacl. spare .on othex vehicle-s,
And don’t mix .yoat cumpact c spa^. tirem-wheel with
:olher-whe;els-ar tk~. They won’t fit. Keep yirur. spare
tire and its whd together.
NOTICE.:
Tire chains: won’t - fit your xornpact .spare. Using
th.em can damage.yaur ve~hicle .and can damage:
the chains
too-. Don’t use :tire chains an your
CaPnpact.-spaPe.
If You’re .Stuck.: In
Ice or Snow
What: you d.on”t want to .do when yo.t~e vehcle is sty& i.~
t.0 spin your wheels too fast. Tlie melhod known as
‘:rocking” can heIp you. g-et out whm you’re: stack, but
you must use: caution.
explode.,. and you or oth-ers could be.injure& And,
the tran3mission or other pqrts of the. .vehicle. cm.
,overheatc That :could cause an engine
compartment fire
:or other damage. When yo.u’re.
.stuck, .spin the wheels as little-as passsble. Dan%
spin the- wheels above 35 mph (55 kmh) as shown
‘on the speedometer.

Downloaded from www.Manualslib.com manuals search engine Inflation -- Tire Pressure
The CertificationlTire label, which is on the driver’s
door edge, .above .the door latch shows the correct
inflation pressures for your
tires when they’re cold.
“Cold” means your vehicle has been sitting
for at least
three hours
or driven no more than 1 mile (1.6 km).
NOTICE:
Don’t let anyone tell you that underinflation or
overinflation is all right. It’s not. If your tires
don’t
have enough air (underinflation), you can
get
the following:
Too much flexing
Toa much heat
@ Tire overloading
0 Bad wear
Bad handling
Bad fuel economy.
NOTICE: (Continued)
NOTICE: (Continued)
If your tires have too much air (overinflation),
you can get the following:
9 Unusual wear
Bad handhg
0 Rough ride
1) Needless damage from road hazards.
When to Check
Check your tires once a month or more. Also, check the
tire pressure
of the spare tire.
If you have a compact
spare tire, it should be at 60 psi
(420 kPa).
How to Check
Use a good quality pocket-type gage to check tire
pressure.
You can’t tell if your tires are properly inflated
simply by looking at them. Radial tires may
look
properly inflated even when they’re underinflated,
Be sure to put the valve caps back on the valve stems.
They help prevent leaks by keeping out dirt and moisture.
6-45

Downloaded from www.Manualslib.com manuals search engine Tire Inspection and Rotation
Tires should be rotated every 6,000 to 8,000 miles
(10 QOO. to 13 0.00 km). Any time you notice unusual
wear, rotate your tires
as soon as possible and check
wheel alignment. Also check for damaged tires or
wheels. See “When
It’s Time for New Tires” and
“Wheel Replacement” later in this section for
more information.
The purpose
of regular rotation. is to achieve more
uniform wear for
all tires on the vehicle. The first
rotation is the mast important. See “Scheduled
Maintenance Services”
in the Index for scheduled
rotation intervals.
If your vehicle has a compact spare tire, don’t include it
in your tire rotation.
After the tires have bea rotated, adjust the front
and rear
inflation. pressures
as shown on the Certificatioflire
label. Make certain that all wheel nuts
are. properly
tightened. See “Wheel Nut Torque” in the Index.
6-46 ,,,. .. -~I