transmission oil CHEVROLET S10 1997 2.G Owners Manual

Downloaded from www.Manualslib.com manuals search engine Shift Light Check Gages Light.
SHIFT
You have the SHIFT light
if you have a manual
transmission. This light
comes- on very briefly as a
bulb check wh-en
you start
the engine. Shifting when
the indicator light is on will
help
you get the best fuel
economy. See “Shift Light”
in the Index.
Daytime Running Lamps Indicator Light
This light is ,on the
instrument panel. It goes on
whenever the
DIU are on,
the ignition is on, the
headlamp switch
is off
and the parking brake-
:::(-)
.ma is released.
CHECK
GAGES
The CHECK GAGES light
will come
on briefly when
y9u
are starting the engine.
If the light comes on and stays on while you are driving,
check
your coolant temperature and engine oil pressure
gages
to see if they are in the warning zones.
2-63

Downloaded from www.Manualslib.com manuals search engine When. you tow a tixiilkr, y-our vehicle ha.s to’have extra
wiring :and a- heavy-duty turn signal flasher. (included in
the- optional trailering package).
The arrows-on your instrument panel will flash
whenever.
you signal a turn 01- 1-me. change, Properly
hooked .up, the &&la lamps will also flash, telling other
drivers you’re
about to :turn, change lanes or stop.
When towing a:txailer,
the. arrows. on your hstrument
panel will flash for turm even if the bulbs on the trailer
are burned out. Thus, you may think drivers behind you
axe seeing your signal when they arenot. ICs important
to check. occasionally to.be sure- the trider bulbs are.
still working.
Driving On .Grades
Reduce speed and shiftlo dower. ge.ar. ,befure you start
dawn B long -or steep downgrade. If-you do-n’t shift
down,
you might have to use your brakes wmuch that
they would
get hot and no longer work weIl.
If you have an.aut~~atic-transm~ssion, you should use
DRIVE (D) when towing a trailer. Operating your
vehicle in DRIVE @) when towing a. trail& will
Mze: heat:buiidup and merid the life af y.our
transmissioil. Qr, if you have, a-manu-ai transmission,
it’s
better not to use FIFTH (S), just drive in FOURTH (4)
(or, as you need to, a lower gew).
4-56

Downloaded from www.Manualslib.com manuals search engine Section 6 Service and. Appearance Care
Here:you will find inf6frriatisn about 'the care of your vehicle. This section begins with Service and fuel information,,
and then it.shows how to check important fluid and lubriean~.Ievz=ls.. There is a1s.o technical informatkm &;gut your
vehicle, and a pmt devoteft to itsappearance c.are.
Fuel
Fuels in Foreign Countrks
Filling
Your Tank
Checking Things Ugdgr lhs Hood
Engine Oil
Air Cleaner
Autam-atic Trans-missi-on Fluid.
Manual Transmission Fluid..
Hy.draulk Clutch
Rear Axle
Four-wheel Drive
Engine' Coolant
Radiator Pressare- Cap
'Thermg-sgat
P6we.r. Steering Fluid
..
6-29
6-3.1
6- 3-5.
6 -3 5
-6-42
6-44
-6-53
6-53
6-57
6-6.1
6-62
'6-63
6-67
6-68
&'70
Windshield. Washer Fluid
Brakes
Battery
Bulb Replacement
Windshield;
Wiper Blade Rephement
Tires
Appearance Care
Cleaning the Inside of Your Vehicle
Cleaning the Outside
of Your Vehicle
Appearance Care Materids Chat
Vehicle Identification Number (VIN)
Electrical Sptem
Replacement Bulbs
Capacities -and Specificztions
Air Conditioning Refrigerants
6" 1

Downloaded from www.Manualslib.com manuals search engine When you lift the hood, you’ll see these items on the “VORTEC” 4300 engine:
A. Battery
E.
Coolant Recovery Tank
C. Engine Oil Dipstick
D. Transmission Dipstick
E. Engine Oil Fill
F. Power Steering Reservoir
G. Brake Master Cylinder
H. Air Cleaner
I. Windshield Washer Fluid

Downloaded from www.Manualslib.com manuals search engine When to Check and Change
.A goad time to check-your a0tomati.c transmission fluid
level is when the en.gine .oil is chanzed,
C.hange
both the fluid an.d filter every 50,000-miles
(8'3 000 km) if the vehicle is mainly driven under one or
more of these conditions:
In heavy city traf€ic where the-outsi.de. temperature
regularly reaches.
906F (.32'C) or higher.
In hilly or mountainom terrain.
0 When doing frequent trailer towing.
0 Uses. such as found in taxi, police or delivery service.
If
you do not use your vehicle under any of the-se
cqnditions, the fluid and filter do not require changing.
See "Scheduled Maintenance Services"
in the Index,
How to Check
B.eCanse this operation can be a little difficult, you
may cho.Oge to have this dme at your GM de-alership
Service
Department
If you do it ywrsiAf, be sure to follow all the instruaims
here, uryclu coukd get a false re.adirig on the dipstick.
NOTICE:
Too much or too little fluid can damage- your
transmission,
TQO much can mean that s.ome of
the fluid could come out and fall on hot engine
parts or exhaust system parts, starting a fire. Be
sure to getan accurate reading if .you .check .your
transmission fluid.
Wait &t least.30 minutes before checking the
transmissioil fluid
level if.you have been driving:
* When ou&ide te:mperatures ar~ above 9C>-'F (32 O C).
0 At high spe>ed fbr.quite-.a while.
0 Tn'heavy traffic -- especidly in hot weather.
While pulling
a. trailer:
To -get the right reading, the flui,d'should be at dermal
operating temperature, which- is 1:80."F to 208°F
(82QG to 33°C).

Downloaded from www.Manualslib.com manuals search engine HOW to Add Fluid Manual TransmisSion Fluid
Referto- the. M-aintenance Schedule t~ dtztermirie. what
kind of- tram~ssion fluid to. me. See “Recommended
Fluids and Lubricants:” in. the Index.
Add fluid only after checking tktrmsmission fluid HOT.
(A COLD check is used .only as a reference.) If the fluid
levd is low, add Only enough of the proper flvid. to bring
the le,vel up t.0 the HOT area fora hat check. It doesdt
take much fluid, ,generally less than Qne pint (0.5 L).
Don t ove.$ll.
NOTICE:
We recommend you use only fluid labeled
DEXRON@-III, because. fluid with that label is
made especidy
for-. your automatic transmission.
.Damage caused.
by fluid other than DEXRON-111
is not covered by y.our new vehicle warranty.
After srddiag fluid-, recheck the fluid Ievel as
When the-correct fluid level Ls obtained, .push the
described under “How to Check.”
dipstick back
in all the way; then flip the handle
down
to lock the dipstick in place.
A good time to have it checked is when-the engine
oil is changed. However, the fluid in your manual
transmission doesn’t require charging..
How to Check
Because this operation can be a little difficult, you
may choose to have this done at.you-r GM dealership
Service Department.
‘If YOU do it yourself, be sure. to follow all the
instructions here, or
you could ge.t a false reading,
NOTICE:
Too much or too little-fluid can damage your
transmission.
Too much can mean that same: u1
the fluid could come; out and fall on hot engine.
parts
or exhaust system p-arts, starting a fire. Be
sure
to get an accurate reading if you check your
tranqmission fluid.

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
Follow this maintenance schedule only if none of the
conditions from the Short Trip/City Maintenance
Schedule is true.
Do not use this schedule if the vehicle
is used for trailer towing, driven in a dusty area or used
off paved roads. Use the Short Trip/City schedule for
these conditions.
Driving a vehicle with af.lly warmed engine under
highway conditions causes engine oil
to break
down slower,
~ - Long'T.l.ip/Hi-ghway Intervals
Every 7,500 Miles (12 500 km): Engine Oil and Filter
Change
(or every 12 months, whichever occurs first).
Chassis Lubrication (or every
12 months, whichever
occurs first). Drive Axle Service. Tire Rotation.
Replacement. Air Cleaner Filter Replacement. Front
Wheel Bearing Repack
(2WD only) (or at each brake
relining, whichever occurs first).
Transmission Service (severe conditions only).
Drive Belt Inspection. Fuel Tank, Cap and
Lines Inspection.
Inspection. Spark Plug Replacement. Positive Crankcase Ventilation (PCV) Valve Inspection.
Every 150,000 Miles (240 000 km): Cooling System
Service (or every
-60 months, whichever occurs first).
These intervals only summarize. maintenance services.
Be sure
to follow the complete maintenance schedule
on the following pages.
Every 30,000 Miles (50 000 km): Fuel Filter
Every 50,000 Miles (83 000 km): Automatic
Every 60,000 Miles (100 000 km): Engine Accessory
Every 100,000 Miles (166 000 km): Spark Plug Wire
7-6

Downloaded from www.Manualslib.com manuals search engine I S.hort TriplCity Maintenance Schedule I
99,000 Miles (1 65 000 knz)
Change. engine oil and .filter (or every
3 .months, whichever -occurs first).
ATI Emisston Control S~rvice,
Lu.bricate chassis c.omponents (or every
3 .months, whi-chever occurs first).
(See footnote #.>
0 Check readfront axle fluid l.evel and add
flu-id
as needed. Check constant velocity
joints and
axk seals for leaking.
(.Se.e,footnote
*-?I
ACTUAL MILEAGE SERVICED BY:
lOO,.OOO Miles (166 000 km-)
0 Inspect spark plug wires.
Cl Replace spark plugs.
0 Change automatic transmission fluid and
An Emission Control Service.
An Emission Control Service.
filter if -the vehicle is mainly driven under
one or more of these conditions:
- In heavy city traffic where the outside.
temperature-
re:plarly reaches 90°F
(32 ' C) or hig-her;
-- In hill-y or mou.ntainous terrain.
- When doing frequent trailer towing.
- Uses such .as found in t>axi, police or
delivery service.
(Continz lea)
7-35

Downloaded from www.Manualslib.com manuals search engine I
: Re@ornrmended Fluids
NOTE: Fluids and lubricants identified below by name,
part numb.er
or specification may be obtained from your
GM dealer.
USAGE
Engine- Oil
I Engine Coolant
Coolant
Supplement
Sealer
FLUIDLUBRICANT
Engine oil with the American
Petroleum Institute Certified
For
Gasoline Engines “Starburst”
symbol
-of the proper viscosity. To
deterniine the preferred viscosity
for
your vehicle’s engine, see
“Engine Oil”
in the Index.
50/50 mixture of clean water
(preferably distilled) and use only
GM Goodwrench-@ DEX-COOL TM
or Havoline’ DEX-COOL TM
coolant. S.ee “Engine C.oolant” in
the
Index.
GM Part NO. 3634621 or
equivalent ‘with
a complete flush
and refill.
USAGE
Hydraulic Brake
System
Hydraulic Clutch System
Power Steering
System
Manual
Transmission
with
V6 Engine
Manual
Transmission
with L4 Engine
Automatic
Transmission Key Lock
Cylinders
FLUIDLUBRICANT
Delco Supreme 11 * Brake Fluid
(GM Part
No. 12377967 or
equivalent DOT-3 brake fluid).
Hydraulic Clutch Fluid
(GM Part
No. 12345347 or equivalent
DOT-3 brake fluid).
GM Power Steering Fluid
(GM Part No. 1052884 - 1 pint,
1050017
- 1 quart, or equivalent).
Synchromesh Transmission Fluid
(GM Part No. 12345349
or equivalent).
Manual Transmission Fluid (GM
Part
No. 12377916 or equivalent).
DEXRON@-I11 Automatic
Transmission Fluid.
Multi-Purpose lubricant; Superlube@
(GM Part No. 12346241
or equivalent).