lock CHEVROLET SILVERADO 1999 1.G Owners Manual

yellowblue
6-69
Underhood Electrical CenterThe underhood electrical center is located on the
driver's side of the engine compartment near the battery.
Lift the cover for access to the fuse/relay block.
You can remove fuses with a fuse extractor. The fuse
extractor is located in the underhood electrical center. To
remove fuses if you don't have a fuse extractor, hold the
end of the fuse between your thumb and index finger
and pull straight out.

yellowblue
6-71
Name Usage
STUD #1 Accessory Power/Trailer Wiring
Feed
ABS Anti
-Lock Brakes
IGN A Ignition Switch
AIR A.I.R. System
RAP #1 Retained Accessory Power, Power
Mirrors, Power Door Locks,
Power Seat(s)
IGN B Ignition Switch
RAP #2 Not Used
STUD #2 Accessory Power/Trailer Wiring
Brake Feed
TRL R TRN Right Turn Signal Trailer Wiring
TRL L TRN Left Turn Signal Trailer Wiring
IGN 1 Ignition, Fuel Controls
INJ B Ignition, Fuel Controls (Relay)
STARTER Starter (Relay)
PARK LP Parking Lamps
FRT HVAC Climate Control System
STOP LP Exterior Lamps, Stoplamps
ECM 1 VCM/PCM
CHMSL Center High Mounted Stoplamp
VEH STOP Stoplamps, Cruise ControlName Usage
TRL B/U Backup Lamps Trailer Wiring
INJ A Fuel Controls, Ignition
RR HVAC Not Used
VEH B/U Vehicle Backup Lamps
ENG 1 Engine Controls, Canister Purge,
Fuel System
ETC Electronic Throttle Control
IGN E A/C Compressor Relay, Rear
Window Defogger, Daytime
Running Lamps, A.I.R. System
B/U LP Backup Lamps, BTSI
ATC Automatic Transfer Case
RR DEFOG Rear Window Defogger, Heated
Mirrors (Relay)
RR PRK Right Rear Parking Lamps
ECM B VCM/PCM
F/PMP Fuel Pump (Relay)
O2 A Oxygen Sensors
O2 B Oxygen Sensors
LR PRK Left Rear Parking Lamps
RR DEFOG Rear Window Defogger, Heated
Mirrors
HDLP Headlamps (Relay)

yellowblue
6-72
Name Usage
TRL PRK Parking Lamps Trailer Wiring
RT HDLP Right Headlamps
DRL Daytime Running Lamps (Relay)
HTD MIR Heated Mirrors
LT HDLP Left Headlamps
A/C Air Conditioning
AUX PWR Cigarette Lighter, Auxiliary
Power Outlets
SEO 2 Special Equipment Option Power,
Power Seats, Aux Roof Mnt Lamp
SEO 1 Special Equipment Option Power,
Aux Roof Mnt Lamp, Cell Phone
DRL Daytime Running Lamps
A/C A/C (Relay)
FOG LP Fog Lamps
FOG LP Fog Lamps (Relay)
RADIO Audio System, Instrument Cluster,
Climate Control System
CIGAR Cigarette Lighter,
Auxiliary Power OutletsName Usage
RT TURN Right Turn Signals
BTSI Brake
-Transmission
Shift Interlock
LT TURN Left Turn Signals
FR PRK Front Parking Lamps,
Sidemarker Lamps
W/W PMP Windshield Washer Pump
HORN Horn (Relay)
IGN C Ignition Switch, Fuel Pump,
PRND321 Display, Crank
RDO AMP Not Used
HAZ LP Exterior Lamps, Hazard Lamps
EXP LPS Not Used
HORN Horn
CTSY LP Interior Lamps
RR WPR Not Used
TBC Body Control Module, Remote
Keyless Entry, Headlamps

yellowblue
7-20
Manual Transmission Check
Check the transmission fluid level; add if needed.
See ªManual Transmission Fluidº in the Index. Check
for leaks. A fluid loss may indicate a problem. Have the
system inspected and repaired if needed.
Automatic Transmission Check
Check the transmission fluid level; add if needed.
See ªAutomatic Transmission Fluidº in the Index. A
fluid loss may indicate a problem. Check the system and
repair if needed.
Hydraulic Clutch System Check
Check the fluid level in the clutch reservoir. See
ªHydraulic Clutch Fluidº in the Index. A fluid loss in
this system could indicate a problem. Have the system
inspected and repaired at once.At Least Once a Year
Key Lock Cylinders Service
Lubricate the key lock cylinders with the lubricant
specified in Part D.
Body Lubrication Service
Lubricate all body hood hinges, hood latch assembly,
secondary latch, pivots, spring anchor, release pawl,
tailgate hinge, tailgate linkage, tailgate handle pivot
points, latch bolt, fuel door hinge, locks and folding seat
hardware. Part D tells you what to use. More frequent
lubrication may be required when exposed to a
corrosive environment.

yellowblue
7-21
Starter Switch Check
CAUTION:
When you are doing this check, the vehicle could
move suddenly. If it does, you or others could be
injured. Follow the steps below.
1. Before you start, be sure you have enough room
around the vehicle.
2. Firmly apply both the parking brake (see ªParking
Brakeº in the Index if necessary) and the regular brake.
NOTE: Do not use the accelerator pedal, and be
ready to turn off the engine immediately if it starts.
3. On automatic transmission vehicles, try to start the
engine in each gear. The starter should work only in
PARK (P) or NEUTRAL (N). If the starter works in
any other position, your vehicle needs service.
On manual transmission vehicles, put the shift lever
in NEUTRAL (N), push the clutch down halfway
and try to start the engine. The starter should work
only when the clutch is pushed down all the way to
the floor. If the starter works when the clutch isn't
pushed all the way down, your vehicle needs service.Brake
-Transmission Shift Interlock (BTSI) Check
(Automatic Transmission)
CAUTION:
When you are doing this check, the vehicle could
move suddenly. If it does, you or others could be
injured. Follow the steps below.
1. Before you start, be sure you have enough room
around the vehicle. It should be parked on a
level surface.
2. Firmly apply the parking brake
(see ªParking Brakeº in the Index if necessary).
NOTE: Be ready to apply the regular brake
immediately if the vehicle begins to move.
3. With the engine off, turn the key to the
RUN position, but don't start the engine. Without
applying the regular brake, try to move the shift
lever out of PARK (P) with normal effort. If the shift
lever moves out of PARK (P), your vehicle's BTSI
needs service.

yellowblue
7-22
Ignition Transmission Lock Check
While parked, and with the parking brake set, try to turn
the ignition key to LOCK in each shift lever position.

With an automatic transmission, the key should turn
to LOCK only when the shift lever is in PARK (P).

With a manual transmission, the key should turn to
LOCK only when you press the key release button.
On all vehicles, the key should come out only in LOCK.
Parking Brake and Automatic Transmission
PARK (P) Mechanism Check
CAUTION:
When you are doing this check, your vehicle
could begin to move. You or others could be
injured and property could be damaged. Make
sure there is room in front of your vehicle in case
it begins to roll. Be ready to apply the regular
brake at once should the vehicle begin to move.
Park on a fairly steep hill, with the vehicle facing
downhill. Keeping your foot on the regular brake, set the
parking brake.

To check the parking brake's holding ability: With
the engine running and transmission in
NEUTRAL (N), slowly remove foot pressure from
the regular brake pedal. Do this until the vehicle is
held by the parking brake only.

To check the PARK (P) mechanism's holding ability:
With the engine running, shift to PARK (P). Then
release all brakes.
Underbody Flushing Service
At least every spring, use plain water to flush any
corrosive materials from the underbody. Take care to
clean thoroughly any areas where mud and other debris
can collect.

yellowblue
7-26
USAGEFLUID/LUBRICANT
Key Lock
CylindersMulti-Purpose Lubricant,
Superlube
(GM Part
No. 12346241 or equivalent).
Floor Shift
LinkageLubriplate
Lubricant Aerosol
(GM Part No. 12346293 or
equivalent) or lubricant meeting
requirements of NLGI # 2
Category LB or GC
-LB.
Chassis
LubricationChassis Lubricant (GM Part
No. 12377985 or equivalent) or
lubricant meeting requirements of
NLGI # 2, Category LB or
GC
-LB.
Differential,
FrontSAE 80W-90 Axle Lubricant (GM
Part No. 1052271 or equivalent).
USAGEFLUID/LUBRICANT
Rear AxleSAE 75W-90 Synthetic Axle
Lubricant (GM Part
No. 12378261) or equivalent
meeting GM
Specification 9986115.
Manual Transfer
CaseDEXRON
-III Automatic
Transmission Fluid.
Automatic
Transfer CaseAutomatic Transfer Case Fluid
(GM Part No. 12378396).
Front Axle
Propshaft Spline
or One
-Piece
Propshaft Spline
(Two
-Wheel
Drive with
Auto. Trans.)
Spline Lubricant, Special
Lubricant (GM Part
No. 12345879) or lubricant
meeting requirements of
GM 9985830.

yellowblue
8-6
Chevrolet Roadside Assistance Program
To enhance Chevrolet's strong commitment to customer
satisfaction, Chevrolet is excited to announce the
establishment of the Chevrolet Roadside Assistance
Center. As the owner of a 1999 Chevrolet, membership
in Roadside Assistance is free.
Roadside Assistance is available 24 hours a day,
365 days a year, by calling 1
-800-CHEV-USA (243-8872).
This toll-free number will provide you over
-the-phone
roadside assistance with minor mechanical problems. If your problem cannot be resolved over the
phone, our advisors have access to a nationwide network
of dealer recommended service providers. Roadside
membership is free; however some services may incur costs.
Roadside offers two levels of service to the customer,
Basic Care and Courtesy Care:

Toll
-free number, 1-800-CHEV-USA (243-8872)

Free towing for warranty repairs

Basic over
-the-phone technical advice

Available dealer services at reasonable costs (i.e.,
wrecker services, locksmith/key service, glass
repair, etc.)
ROADSIDE Courtesy Care PROVIDES:

Roadside Basic Care services (as outlined previously)
Plus:

FREE Non
-Warranty Towing (to the closest dealer
from a legal roadway)

FREE Locksmith/Key Service (when keys are lost
on the road or locked inside)

FREE Flat Tire Service (spare installed on the road)

FREE Jump Start (at home or on the road)

FREE Fuel Delivery ($5 of fuel delivered on
the road)

9-yellowblue
9-1
Section 9 Index
A
ccessory Power Outlet 2-65 . . . . . . . . . . . . . . . . . . . . . . . . .
Adding Equipment to the Outside of Your Vehicle 6-3 . . . . . .
Air Bag 1-25 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Adding Equipment 1-35 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
How Does it Restrain 1-29 . . . . . . . . . . . . . . . . . . . . . . . . . .
How it Works 1-27 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Location 1-27 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Off Light 1-33, 2-71 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Off Switch 1-31 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Readiness Light 1-27, 2-71 . . . . . . . . . . . . . . . . . . . . . . . . .
Servicing 1-34 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
What Makes it Inflate 1-29 . . . . . . . . . . . . . . . . . . . . . . . . . .
What Will You See After it Inflates 1-29 . . . . . . . . . . . . . . .
When Should it Inflate 1-28 . . . . . . . . . . . . . . . . . . . . . . . . .
Air Cleaner Filter, Engine 6-16 . . . . . . . . . . . . . . . . . . . . . . . .
Air Cleaner Filter Restriction Indicator Check 7-19 . . . . . . . .
Air Conditioning 3-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Air Conditioning Refrigerants 6-76 . . . . . . . . . . . . . . . . . . . . .
Air Dam Removal 4-14 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Air Dam Replacement 4-16 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Air Filter, Passenger Compartment 3-5, 6-18, 6-77 . . . . . . . .
Alignment and Balance, Tire 6-51 . . . . . . . . . . . . . . . . . . . . . .
Aluminum Wheels, Cleaning 6-59 . . . . . . . . . . . . . . . . . . . . . .
Antenna 3-28 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Antifreeze 6-29, 6-75, 7-25 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Anti-Lock
Brake System Warning Light 2-74, 4-7 . . . . . . . . . . . . . . . .
Brakes 4-7 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Appearance Care 6
-54 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Appearance Care and Materials 6-62 . . . . . . . . . . . . . . . . . . . .
Arbitration Program 8-3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Armrest Storage Compartment 2-64 . . . . . . . . . . . . . . . . . . . .
Ashtrays 2-64 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Audio Equipment, Adding 3-26 . . . . . . . . . . . . . . . . . . . . . . . .
Audio Systems 3-8 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Automatic Transmission
Check 7
-20 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fluid 6-19, 7-25 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Park Mechanism Check 7-22 . . . . . . . . . . . . . . . . . . . . . . . .
Starting Your Engine 2-16 . . . . . . . . . . . . . . . . . . . . . . . . . .
Operation 2-20 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Auxiliary Battery 4-69 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Auxiliary Roof Mounted Lamp Switch 2-54 . . . . . . . . . . . . . .
Axle, Front 6-27, 7-26 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Axle, Locking Rear 2-42 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Axle, Rear 6-25, 7-26 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Battery 6-37 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Auxiliary 4-69 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Jump Starting 5-3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Message 2-82 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Replacement, Keyless Entry 2-7 . . . . . . . . . . . . . . . . . . . . .
Run-Down Protection 2-56 . . . . . . . . . . . . . . . . . . . . . . . . .
Warnings 5-3, 5-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
BBB Auto Line 8-3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

yellowblue
9-2
Before Leaving on a Long Trip 4-37 . . . . . . . . . . . . . . . . . . . .
Better Business Bureau Mediation 8-3 . . . . . . . . . . . . . . . . . . .
Blizzard, Driving In 4-42 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Brake
Adjustment 6
-37 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fluid 6-34, 7-25 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Master Cylinder 6-34 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Parking 2-33 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Pedal Travel 6-37 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Replacing System Parts 6-37 . . . . . . . . . . . . . . . . . . . . . . . .
System Warning Light 2-74 . . . . . . . . . . . . . . . . . . . . . . . . .
Trailer 4-60 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Transmission Shift Interlock Check 7-21 . . . . . . . . . . . . . . .
Wear 6-36 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Brakes, Anti-Lock 4-7 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Braking 4-6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Braking in Emergencies 4-9 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Break-In, New Vehicle 2-13 . . . . . . . . . . . . . . . . . . . . . . . . . .
BTSI Check 7-21 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Bulb Replacement 6-38 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Camper Type Mirror 2-59 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Camper Wiring Harness 4-52 . . . . . . . . . . . . . . . . . . . . . . . . . .
Canadian Roadside Assistance 8-7 . . . . . . . . . . . . . . . . . . . . . .
Capacities and Specifications 6-74 . . . . . . . . . . . . . . . . . . . . . .
Carbon Monoxide 2-39, 2-40, 4-43 . . . . . . . . . . . . . . . . . . . .
Care of Your Cassette Tape Player 3-27 . . . . . . . . . . . . . . . . . .
Cargo
Lamp 2
-55 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lamp Bulb Replacement 6-41 . . . . . . . . . . . . . . . . . . . . . . .
Lamp On Message 2-87 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cassette Deck Service 7-18 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cassette Tape Player 3-11, 3-13 . . . . . . . . . . . . . . . . . . . . . . . Cassette Tape Player Care 3
-27 . . . . . . . . . . . . . . . . . . . . . . . .
Cassette/Compact Disc Storage 2-63, 2-64 . . . . . . . . . . . . . . .
Cellular Telephone 2-65 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Center High-Mounted Stoplamp Bulb Replacement 6-41 . . . .
Center Overhead Console 2-60 . . . . . . . . . . . . . . . . . . . . . . . .
Center Passenger Position 1-36 . . . . . . . . . . . . . . . . . . . . . . . .
Certification Label 4-46 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Certification/Tire Label 4-46 . . . . . . . . . . . . . . . . . . . . . . . . . .
Chains, Safety 4-60 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Chains, Tire 6-53 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Change Engine Oil Message 2-86 . . . . . . . . . . . . . . . . . . . . . .
Changing a Flat Tire 5-18 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Check Coolant Temp Message 2-84 . . . . . . . . . . . . . . . . . . . . .
Check Eng Oil Level Message 2-85, 6-12 . . . . . . . . . . . . . . . .
Check Eng Oil Pressure Message 2-85 . . . . . . . . . . . . . . . . . .
Checking Transmission Fluid 6-22 . . . . . . . . . . . . . . . . . . . . .
Checking Your Restraint Systems 1-66 . . . . . . . . . . . . . . . . . .
Chemical Paint Spotting 6-61 . . . . . . . . . . . . . . . . . . . . . . . . . .
Child Restraints 1-46 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Securing in a Rear Outside Seat Position 1-54 . . . . . . . . . . .
Securing in the Center Seat Position 1-56 . . . . . . . . . . . . . .
Securing in the Right Front Seat Position 1-58 . . . . . . . . . .
Top Strap 1-52 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Where to Put 1-50, 1-51 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Chrome Wheels, Cleaning 6-59 . . . . . . . . . . . . . . . . . . . . . . . .
Cigarette Lighter 2-64 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Circuit Breakers and Fuses 6-65 . . . . . . . . . . . . . . . . . . . . . . .
Cleaner, Air 6-16 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cleaning
Aluminum Wheels 6
-59 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Exterior Lamps/Lenses 6-58 . . . . . . . . . . . . . . . . . . . . . . . .
Fabric 6-54 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Glass Surfaces 6-57 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .