warning light CHEVROLET SILVERADO 2003 1.G Owner's Manual

Turn Signals When Towing a Trailer
The arrows on your instrument panel will ¯ash whenever
you signal a turn or lane change. Properly hooked up,
the trailer lamps will also ¯ash, telling other drivers
you're about to turn, change lanes or stop.
When towing a trailer, the arrows on your instrument
panel will ¯ash for turns even if the bulbs on the trailer
are burned out. Thus, you may think drivers behind
you are seeing your signal when they are not. It's
important to check occasionally to be sure the trailer
bulbs are still working.
Driving On Grades
Reduce speed and shift to a lower gearbeforeyou start
down a long or steep downgrade. If you don't shift
down, you might have to use your brakes so much that
they would get hot and no longer work well.
If you have an automatic transmission, you can tow in
DRIVE (D). You may want to shift the transmission
to lower gear selection if the transmission shifts too often
(e.g., under heavy loads and/or hilly conditions).
You may also want to activate the tow/haul mode if the
transmission shifts too often. See
Tow/Haul Mode
Light on page 3-53.If you have a 5-speed manual transmission and you are
towing a trailer, it's better not to use FIFTH (5) gear.
Just drive in FOURTH (4) gear (or, as you need
to, a lower gear).
If you have a 6-speed manual transmission and you are
towing a trailer, it's better not to use SIXTH (6) gear.
Drive in FIFTH (5) gear (or, as you need to, a lower gear).
When towing at high altitude on steep uphill grades,
consider the following: Engine coolant will boil at a lower
temperature than at normal altitudes. If you turn your
engine off immediately after towing at high altitude
on steep uphill grades, your vehicle may show signs
similar to engine overheating. To avoid this, let the
engine run while parked (preferably on level ground)
with the automatic transmission in PARK (P) (or
the manual transmission out of gear and the parking
brake applied) for a few minutes before turning the
engine off. If you do get the overheat warning,
see
Engine Overheating on page 5-33.
4-87

When to Check and What to Use
The clutch master cylinder
reservoir is located in the
rear of the engine
compartment on the
driver's side of the vehicle.
See
Engine Compartment
Overview on page 5-10
for more information
on location.
Refer to the Maintenance Schedule to determine how
often you should check the ¯uid level in your clutch
master cylinder reservoir and for the proper ¯uid. See
Part B: Owner Checks and Services on page 6-12andPart D: Recommended Fluids and Lubricants on
page 6-19.
How to Check and Add Fluid
The proper ¯uid should be added if the level does not
reach the bottom of the diaphragm when it's in place in
the reservoir. See the instructions on the reservoir cap.
Engine Coolant
The cooling system in your vehicle is ®lled with
DEX-COOLžengine coolant. This coolant is designed
to remain in your vehicle for 5 years or 150,000 miles
(240 000 km), whichever occurs ®rst, if you add only
DEX-COOL
žextended life coolant.
The following explains your cooling system and how to
add coolant when it is low. If you have a problem
with engine overheating, see
Engine Overheating on
page 5-33.
A 50/50 mixture of clean, drinkable water and
DEX-COOL
žcoolant will:
·Give freezing protection down to-34ÉF (-37ÉC).
·Give boiling protection up to 265ÉF (129ÉC).
·Protect against rust and corrosion.
·Help keep the proper engine temperature.
·Let the warning lights and gages work as they
should.
5-30

Some driving conditions or climates may cause a brake
squeal when the brakes are ®rst applied or lightly
applied. This does not mean something is wrong with
your brakes.
Properly torqued wheel nuts are necessary to help
prevent brake pulsation. When tires are rotated, inspect
brake pads for wear and evenly tighten wheel nuts in
the proper sequence to GM torque speci®cations.
Brake linings should always be replaced as complete
axle sets.
See
Brake System Inspection on page 6-18.
Brake Pedal Travel
See your dealer if the brake pedal does not return to
normal height, or if there is a rapid increase in
pedal travel. This could be a sign of brake trouble.
Brake Adjustment
Every time you make a brake stop, your disc brakes
adjust for wear.
Replacing Brake System Parts
The braking system on a vehicle is complex. Its many
parts have to be of top quality and work well together if
the vehicle is to have really good braking. Your
vehicle was designed and tested with top-quality GM
brake parts. When you replace parts of your brakingsystem Ð for example, when your brake linings wear
down and you need new ones put in Ð be sure you get
new approved GM replacement parts. If you do not,
your brakes may no longer work properly. For example,
if someone puts in brake linings that are wrong for
your vehicle, the balance between your front and rear
brakes can change Ð for the worse. The braking
performance you have come to expect can change in
many other ways if someone puts in the wrong
replacement brake parts.
Battery
Your new vehicle comes with a maintenance free
ACDelcožbattery. When it's time for a new battery, get
one that has the replacement number shown on the
original battery's label. We recommend an ACDelco
ž
battery. SeeEngine Compartment Overview on
page 5-10for battery location.
Warning:Battery posts, terminals and related
accessories contain lead and lead compounds,
chemicals known to the State of California to cause
cancer and reproductive harm. Wash hands after
handling.
5-47

Uniform Tire Quality Grading
Quality grades can be found where applicable on the
tire sidewall between tread shoulder and maximum
section width. For example:
Treadwear 200 Traction AA Temperature A
The following information relates to the system developed
by the United States National Highway Traffic Safety
Administration, which grades tires by treadwear, traction
and temperature performance. (This applies only to
vehicles sold in the United States.) The grades are
molded on the sidewalls of most passenger car tires. The
Uniform Tire Quality Grading system does not apply to
deep tread, winter-type snow tires, space-saver or
temporary use spare tires, tires with nominal rim
diameters of 10 to 12 inches (25 to 30 cm), or to some
limited-production tires.
While the tires available on General Motors passenger
cars and light trucks may vary with respect to these
grades, they must also conform to federal safety
requirements and additional General Motors Tire
Performance Criteria (TPC) standards.
Treadwear
The treadwear grade is a comparative rating based on
the wear rate of the tire when tested under controlled
conditions on a speci®ed government test course. For
example, a tire graded 150 would wear one and a half
(1.5) times as well on the government course as a tire
graded 100. The relative performance of tires depends
upon the actual conditions of their use, however, and may
depart signi®cantly from the norm due to variations in
driving habits, service practices and differences in road
characteristics and climate.
Traction ± AA, A, B, C
The traction grades, from highest to lowest, are AA, A, B,
and C. Those grades represent the tire's ability to stop on
wet pavement as measured under controlled conditions
on speci®ed government test surfaces of asphalt and
concrete. A tire marked C may have poor traction
performance. Warning: The traction grade assigned to
this tire is based on straight-ahead braking traction tests,
and does not include acceleration, cornering,
hydroplaning, or peak traction characteristics.
5-75

A
Accessory Power Outlets.................................3-19
Adding a Snow Plow or Similar Equipment.........4-61
Adding Washer Fluid.......................................5-43
Additional Program Information........................... 7-8
Additives, Fuel................................................. 5-5
Add-On Electrical Equipment...........................5-109
Add-On Equipment..........................................4-60
Adjusting the Speakers
(Balance/Fade)..................3-74, 3-78, 3-88, 3-101
After Off-Road Driving.....................................4-37
Air Bag Systems.............................................1-64
Adding Equipment to Your Air Bag-Equipped
Vehicle...................................................1-80
Air Bag Off Switch.......................................1-71
How Does an Air Bag Restrain?....................1-69
Passenger Sensing System...........................1-76
Servicing Your Air Bag-Equipped Vehicle.........1-80
What Makes an Air Bag In¯ate?....................1-69
What Will You See After an Air Bag In¯ates?......1-70
When Should an Air Bag In¯ate?...................1-68
Where Are the Air Bags?..............................1-66
Air Bag .........................................................3-37
Off Light.....................................................3-37
Passenger Status Indicator...........................3-40
Readiness Light..........................................3-36
Air Cleaner/Filter, Engine.................................5-21
Air Conditioning..............................................3-30
All-Wheel Drive (AWD) System.........................2-44All-Wheel Drive...............................................5-54
AM-FM Radio.................................................3-72
AM .............................................................3-123
Antenna, Fixed Mast......................................3-125
Antenna, XMŸ Satellite Radio Antenna
System.....................................................3-125
Anti-Lock Brake, System Warning Light..............3-45
Anti-lock Brake System..................................... 4-6
Appearance Care..........................................5-100
Care of Safety Belts...................................5-103
Chemical Paint Spotting..............................5-106
Cleaning the Inside of Your Vehicle..............5-100
Cleaning the Outside of Your Vehicle............5-103
Finish Damage..........................................5-106
Sheet Metal Damage..................................5-105
Underbody Maintenance.............................5-106
Vehicle Care/Appearance Materials...............5-107
Weatherstrips............................................5-103
Approaching a Hill..........................................4-28
Ashtrays........................................................3-20
Audio Output................................................3-117
Audio System(s).............................................3-71
AM-FM Radio.............................................3-72
Audio Steering Wheel Controls....................3-122
Care of Your Cassette Tape Player...............3-123
Care of Your CD and DVD Player................3-124
Care of Your CDs and DVDs.......................3-124
Chime Level Adjustment.............................3-125
Fixed Mast Antenna...................................3-125
Radio with Cassette and CD.........................3-85
1

Audio System(s) (cont.)
Radio with CD............................................3-75
Radio with Six-Disc CD................................3-98
Rear Seat Audio (RSA)...............................3-120
Setting the Time for Radios with Radio Data
Systems (RDS)........................................3-72
Setting the Time for Radios without Radio
Data Systems (RDS)................................3-72
Theft-Deterrent Feature...............................3-121
Understanding Radio Reception...................3-123
XMŸ Satellite Radio Antenna System...........3-125
Automatic Headlamp System............................3-15
Automatic Transfer Case..................................2-37
Automatic Transmission Check..........................6-13
Automatic Transmission Shift Lock Control
System Check.............................................6-15
Automatic Transmission...................................2-22
Fluid..................................................5-23, 5-26
Operation...................................................2-25
Auxiliary Battery..............................................4-94
Auxiliary Roof Mounted Lamp Switch.................3-17
B
Backing Up....................................................4-86
BATTERY NOT CHARGING.............................3-65
Battery Replacement......................................... 2-6
Battery Run-Down Protection............................3-19
Battery Warning Light......................................3-42Battery..........................................................5-47
Before Leaving on a Long Trip.........................4-44
Before You Drive...........................................3-111
Before You Go Off-Roading..............................4-24
Body Lubrication Service..................................6-14
Brake Adjustment............................................5-47
Brake Fluid....................................................5-44
Brake Pedal Travel.........................................5-47
Brake Wear...................................................5-46
Brake............................................................2-44
Parking......................................................2-44
System Inspection.......................................6-18
System Warning Light..................................3-44
Brakes..........................................................5-44
Braking in Emergencies..................................... 4-8
Braking........................................................... 4-6
Break-In, New Vehicle.....................................2-20
BUCKLE PASSENGER....................................3-65
BUCKLE SEATBELT.......................................3-65
Bulb Replacement...........................................5-59
Center High-Mounted Stoplamp (CHMSL) and
Cargo Lamp............................................5-63
Front Turn Signal, Sidemarker and Daytime
Running Lamps........................................5-61
Halogen Bulbs............................................5-59
Headlamps.................................................5-59
Pickup Box Identi®cation and Fender Marker
Lamps....................................................5-65
Replacement Bulbs......................................5-67
Roof Marker Lamps.....................................5-62
2

Flash-To-Pass Feature....................................... 3-9
Flat Tire, Changing.........................................5-80
Flat Tire........................................................5-79
Fluid.............................................................5-23
Automatic Transmission........................5-23, 5-26
Manual Transmission....................................5-28
Power Steering...........................................5-42
Windshield Washer......................................5-43
FM Stereo....................................................3-123
Fog Lamps....................................................3-16
Folding the Rear Seat....................................... 1-8
Following Distance..........................................4-86
Footnotes........................................................ 6-5
Four-Wheel Drive....................................2-33, 5-56
Four-Wheel-Drive Light....................................3-52
Front Axle Locking Feature...............................2-33
Front Axle......................................................5-57
Front Reading Lamps (If Equipped)...................3-18
Front Storage Area.........................................2-65
Fuel Information Button....................................3-57
FUEL LEVEL LOW.........................................3-66
Fuel............................................................... 5-4
Additives...................................................... 5-5
California Fuel.............................................. 5-5
Filling a Portable Fuel Container..................... 5-8
Filling Your Tank........................................... 5-6
Fuels in Foreign Countries.............................. 5-6Fuel (cont.)
Gage.........................................................3-53
Gasoline Octane........................................... 5-4
Gasoline Speci®cations.................................. 5-5
Low Warning Light.......................................3-54
System Inspection.......................................6-17
Fuses..........................................................5-110
Fuses and Circuit Breakers.........................5-110
Windshield Wiper.......................................5-109
G
Gage............................................................3-47
Engine Coolant Temperature.........................3-47
Fuel..........................................................3-53
Oil Pressure...............................................3-51
Speedometer..............................................3-35
Tachometer.................................................3-35
Transmission Temperature.............................3-47
Voltmeter Gage...........................................3-42
Gasoline......................................................... 5-4
Octane........................................................ 5-4
Speci®cations............................................... 5-5
Getting Familiar with Off-Road Driving................4-26
Glove Box.....................................................2-64
GM Mobility Program for Persons with
Disabilities.................................................... 7-5
7

H
Hazard Warning Flashers................................... 3-6
Head Restraints............................................... 1-7
Headlamp High/Low Beam Changer.................... 3-9
Headlamps....................................................5-59
Bulb Replacement.......................................5-59
Front Turn Signal, Sidemarker and Daytime
Running Lamps........................................5-61
Halogen Bulbs............................................5-59
Pickup Box Identi®cation and Fender Marker
Lamps....................................................5-65
Roof Marker Lamps.....................................5-62
Headphones.................................................3-116
Heated Seats................................................... 1-5
Heating.........................................................3-30
Heavy-DutyTrailer Wiring Harness Package........4-90
Highway Hypnosis...........................................4-45
Hill and Mountain Roads..................................4-46
Hitches..........................................................4-85
Hood.............................................................. 5-8
Checking Things Under.................................. 5-8
Release....................................................... 5-9
Horn............................................................... 3-7
How to Add Coolant to the Coolant Surge Tank
Gasoline Engines........................................5-38
How to Add Fluid............................5-25, 5-28, 5-29
How to Check and Add Fluid............................5-30
How to Check Lubricant...................................5-55How to Check Power Steering Fluid..................5-43
How to Check........................5-23, 5-26, 5-28, 5-70
How to Inspect...............................................5-21
How to Use This Manual...................................... ii
How to Wear Safety Belts Properly...................1-15
Hydraulic Clutch System Check........................6-14
Hydraulic Clutch.............................................5-29
Hydroplaning..................................................4-41
I
If No Steam Is Coming From Your Engine..........5-35
If Steam Is Coming From Your Engine...............5-34
If the Light is Flashing.....................................3-50
If the Light Is On Steady.................................3-50
If You Are Stuck in Sand, Mud, Ice or Snow.......4-52
If You Do Decide To Pull A Trailer.....................4-68
If You're Caught in a Blizzard...........................4-50
Ignition Positions.............................................2-20
Ignition Transmission Lock Check......................6-15
Infants and Young Children, Restraints...............1-34
In¯ation -- Tire Pressure..................................5-69
Inspection......................................................6-18
Brake System.............................................6-18
Engine Cooling System................................6-17
Exhaust System..........................................6-17
Fuel System...............................................6-17
Part C - Periodic Maintenance.......................6-17
8

Inspection (cont.)
Steering and Suspension..............................6-17
Throttle System...........................................6-18
Transfer Case and Front Axle
(All-Wheel Drive)......................................6-18
Transfer Case and Front Axle (Four-Wheel
Drive).....................................................6-18
Instrument Panel Brightness Control..................3-18
Instrument Panel Fuse Block..........................5-110
Instrument Panel.............................................3-34
Cluster.......................................................3-34
Overview..................................................... 3-4
Interior Lamps................................................3-18
J
Jump Starting.................................................5-48
K
Key Lock Cylinders Service..............................6-14
Key Release Button (Manual Transmission)........2-21
KEYFOB X BATTERY LOW.............................3-67
Keyless Entry System....................................... 2-4
Keys............................................................... 2-3
L
Lamps On Reminder.......................................3-15
Lamps...........................................................3-14
Exterior......................................................3-14
Interior.......................................................3-18
Lap Belt........................................................1-25
Lap-Shoulder Belt...........................................1-16
LATCH System...............................................1-47
Child Restraints...........................................1-47
Securing a Child Restraint Designed for the
LATCH System........................................1-49
Latches, Seatback............................................ 1-7
Leaving Your Vehicle With
the Engine Running
(Automatic Transmission Only).......................2-48
LEFT REAR DOOR AJAR (Crew Cab)...............3-67
Light.............................................................3-37
Air Bag Off .................................................3-37
Air Bag Readiness.......................................3-36
Anti-Lock Brake System Warning...................3-45
Battery Warning..........................................3-42
Brake System Warning.................................3-44
Cruise Control.............................................3-52
Four-Wheel-Drive.........................................3-52
Low Fuel Warning.......................................3-54
9

Light (cont.)
Malfunction Indicator....................................3-49
Passenger Air Bag Status Indicator................3-40
Safety Belt Reminder...................................3-36
Tow/Haul Mode...........................................3-53
Traction Off................................................3-46
Up-Shift.....................................................3-43
Listening to a DVD................................3-97, 3-110
Loading Your Vehicle for Off-Road Driving..........4-24
Loading Your Vehicle.......................................4-58
Locking Rear Axle...........................................4-13
Lockout Protection..........................................2-12
Lock-Out Switch.............................................2-17
Locks............................................................. 2-9
Delayed Locking........................................... 2-9
Door........................................................... 2-7
Lockout Protection.......................................2-12
Power Door.................................................. 2-8
Programmable Automatic Door Locks.............2-10
Rear Door Security Locks.............................2-12
Loss of Control...............................................4-21
LOW COOLANT LEVEL..................................3-67
Low Fuel Warning Light...................................3-54
Lumbar........................................................... 1-4
Power Controls............................................. 1-4M
Maintenance, Normal Replacement Parts..........5-121
Maintenance Schedule.....................................6-12
At Each Fuel Fill.........................................6-12
At Least Once a Month................................6-12
At Least Once a Year..................................6-14
At Least Twice a Year..................................6-13
At the First 100, 1,000 and 6,000 Miles
(160, 1 600 and 10 000km).......................6-12
Brake System Inspection..............................6-18
Engine Cooling System Inspection.................6-17
Exhaust System Inspection...........................6-17
Fuel System Inspection................................6-17
How This Section is Organized....................... 6-3
Introduction.................................................. 6-2
Maintenance Requirements............................. 6-2
Part A - Scheduled Maintenance Services......... 6-4
Part B - Owner Checks and Services.............6-12
Part C - Periodic MaintenanceInspections......6-17
Part D - Recommended Fluids and Lubricants . . . 6-19
Part E - Maintenance Record........................6-22
Scheduled Maintenance................................. 6-5
Steering and Suspension Inspection...............6-17
Throttle System Inspection............................6-18
10