ECO mode CHEVROLET SILVERADO 2004 1.G Service Manual

For regular cab models, the equipment you’ll need is
behind the passenger’s seat. For Extended and
crew cab models, the equipment is on the shelf behind
the passenger’s side second row seat.
1. If there is a cover, move the seats forward and turn
the wing nut on the cover counterclockwise to
remove it. For crew cab models, pull up the second
row seat with the loop at the base of the seat
cushion to access the tools.2. To release the bottle jack from its holder, turn the
knob on the bottle jack counterclockwise to lower
the jack head.
3. The wheel blocks and the wheel block
retainer can be removed by turning the wing
nut counterclockwise.
4. There is also a wing nut used to retain the
storage bag and tools. To remove it, turn the wing
nut counterclockwise.
You’ll use the jack handle extensions and the wheel
wrench to remove the underbody-mounted spare tire.
1500 Crew Cab
5-95

{CAUTION:
Rust or dirt on the wheel, or on the parts to
which it is fastened, can make the wheel nuts
become loose after a time. The wheel could
come off and cause an accident. When you
change a wheel, remove any rust or dirt from
the places where the wheel attaches to the
vehicle. In an emergency, you can use a cloth
or a paper towel to do this; but be sure to use
a scraper or wire brush later, if you need to, to
get all the rust or dirt off.
{CAUTION:
Never use oil or grease on studs or nuts.
If you do, the nuts might come loose.
Your wheel could fall off, causing a
serious accident.7. After mounting the
spare, put the wheel
nuts back on with the
rounded end of the nuts
toward the wheel.
Tighten each wheel nut
by hand. Then use the
wheel wrench to tighten
the nuts until the wheel
is held against the hub.
Front Position All Models
5-103

Capacities and Specications
Please refer toRecommended Fluids and Lubricants on page 6-13for more information. All capacities are
approximate. When adding see the refrigerant charge label under the hood for charge capacity information
and requirements.
Capacities and Specications
Engine VIN Code Spark Plug Gap
VORTEC™ 4300 V6 W 0.060 inches (1.52 mm)
VORTEC™ 4800 V8 V 0.040 inches (1.01 mm)
VORTEC™ 5300 V8 T 0.040 inches (1.01 mm)
VORTEC™ 6000 V8 U 0.040 inches (1.01 mm)
VORTEC™ 6000 V8 N 0.040 inches (1.01 mm)
VORTEC™ 8100 V8 G 0.060 inches (1.52 mm)
Wheels and Tires
Model Description Torque
C/K 1500 & C/K 2500 6 Bolts (14 mm) 140 lb ft (190Y)
C/K 3500 8 bolts (14 mm) 140 lb ft (190Y)
Tire PressureSee the Certication/Tire label on the rear edge of the
driver’s door or the incomplete vehicle document in the cab.
5-132

For prompt and efficient assistance when calling, please
provide the following to the Roadside Assistance
Representative:
Your name, home address, and home
telephone number
Telephone number of your location
Location of the vehicle
Model, year, color, and license plate number
Mileage, Vehicle Identication Number and delivery
date of the vehicle
Description of the problem
While we hope you never have the occasion to use our
service, it is added security while traveling for you
and your family. Remember, we are only a phone
call away. Chevrolet Roadside Assistance:
1-800-CHEV-USA (1-800-234-8872), text
telephone (TTY) users, call 1-888-889-2438.
Chevrolet reserves the right to limit services or
reimbursement to an owner or driver when, in
Chevrolet’s judgement, the claims become excessive in
frequency or type of occurrence.
Roadside Assistance is not part of or included in the
coverage provided by the New Vehicle Limited Warranty.
Chevrolet reserves the right to make any changes or
discontinue the Roadside Assistance program at
any time without notication.
Canadian Roadside Assistance
Vehicles purchased in Canada have an extensive
roadside assistance program accessible from anywhere
in Canada or the United States. Please refer to the
Warranty and Owner Assistance Information book.
Courtesy Transportation
Chevrolet has always exemplied quality and value in
its offering of motor vehicles. To enhance your
ownership experience, we and our participating dealers
are proud to offer Courtesy Transportation, a customer
support program for new vehicles.
The Courtesy Transportation program is offered to retail
purchase/lease customers in conjunction with the
Bumper-to-Bumper coverage provided by the New
Vehicle Limited Warranty. Several transportation
options are available when warranty repairs are
required. This will reduce your inconvenience during
warranty repairs.
Plan Ahead When Possible
When your vehicle requires warranty service, you
should contact your dealer and request an appointment.
By scheduling a service appointment and advising
your service consultant of your transportation needs,
your dealer can help minimize your inconvenience.
7-7

Additional Program Information
Courtesy Transportation is available during the
Bumper-to-Bumper warranty coverage period, but itis
notpart of the New Vehicle Limited Warranty. A
separate booklet entitled “Warranty and Owner
Assistance Information” furnished with each new vehicle
provides detailed warranty coverage information.
Courtesy Transportation is available only at participating
dealers and all program options, such as shuttle
service, may not be available at every dealer. Please
contact you dealer for specic information about
availability. All Courtesy Transportation arrangements
will be administered by appropriate dealer personnel.
Canadian Vehicles:For warranty repairs during
the Complete Vehicle Coverage period of the General
Motors of Canada New Vehicle Limited Warranty,
alternative transportation may be available under the
Courtesy Transportation Program. Please consult
your dealer for details.
General Motors reserves the right to unilaterally modify,
change or discontinue Courtesy Transportation at
any time and to resolve all questions of claim eligibility
pursuant to the terms and conditions described
herein at its sole discretion.
Vehicle Data Collection and Event
Data Recorders
Your vehicle, like other modern motor vehicles, has a
number of sophisticated computer systems that monitor
and control several aspects of the vehicle’s
performance. Your vehicle uses on-board vehicle
computers to monitor emission control components to
optimize fuel economy, to monitor conditions for air bag
deployment and, if so equipped, to provide anti-lock
braking and to help the driver control the vehicle
in difficult driving situations. Some information may be
stored during regular operations to facilitate repair
of detected malfunctions; other information is stored only
in a crash or near crash event by computer systems
commonly called event data recorders (EDR).
In a crash or near crash event, computer systems, such
as the Air Bag Sensing and Diagnostic Module (SDM)
in your vehicle may record information about the
condition of the vehicle and how it was operated, such
as engine speed, brake applications, throttle position,
vehicle speed, safety belt usage, air bag readiness, air
bag performance data, and the severity of a collision.
This information has been used to improve vehicle crash
performance and may be used to improve crash
performance of future vehicles and driving safety. Unlike
the data recorders on many airplanes, these on-board
systems do not record sounds, such as conversation of
vehicle occupants.
7-9

Mirrors (cont.)
Outside Power Mirrors..................................2-62
Outside West Coast-Type Mirrors...................2-61
Model Reference................................................ vi
MyGMLink.com................................................ 7-3
N
New Vehicle Break-In......................................2-22
Noise Control System, Tampering......................5-61
Normal Maintenance Replacement Parts............6-16
O
Odometer......................................................3-35
Off-Road Driving.............................................4-21
Off-Road Recovery..........................................4-18
Oil
Engine.......................................................5-20
Pressure Gage............................................3-50
OIL LIFE RESET............................................3-67
Oil Life System...............................................3-57
OIL PRESSURE LOW.....................................3-67
Older Children, Restraints................................1-32
Online Owner Center........................................ 7-3
OnStar
®Personal Calling.................................2-66
OnStar®Services............................................2-66
OnStar®Steering Wheel Controls......................2-67
OnStar®System.............................................2-65OnStar
®Virtual Advisor....................................2-67
Other Warning Devices...................................... 3-6
Outlet Adjustment...................................3-24, 3-32
Outside
Automatic Dimming Mirror.............................2-64
Camper-Type Mirrors....................................2-61
Convex Mirror.............................................2-65
Curb View Assist Mirrors..............................2-64
Heated Mirrors............................................2-65
Manual Mirrors............................................2-60
Power Foldaway Mirrors...............................2-63
Power Mirrors.............................................2-62
West Coast-Type Mirrors..............................2-61
Outside Power Camper-Type Mirror...................2-62
Overdrive Disable...........................................3-52
Overdrive Disable (Allison Transmission
®) ...........2-30
Overheated Engine Protection Operating Mode
(V8 Engines Only).......................................5-38
Overseas – Customer Assistance........................ 7-5
Owner Checks and Services.............................. 6-9
Owners, Canadian............................................... ii
Owner’s Information........................................7-12
P
Parental Control............................................3-114
Park (P)
Shifting Into................................................2-49
Shifting Out of............................................2-51
11

Radios (cont.)
Theft-Deterrent..........................................3-127
Understanding Reception............................3-128
RANGE SHIFT INHIBITED (Allison
Transmission
®Only).....................................3-67
RDS Messages.............................3-80, 3-91, 3-105
Rear Axle......................................................5-59
Locking......................................................4-12
Rear Door Security Locks................................2-13
Rear Doors....................................................2-14
Rear Safety Belt Comfort Guides......................1-29
Rear Seat Audio (RSA)..................................3-125
Rear Seat Entertainment System.....................3-114
Rear Seat Operation......................................... 1-9
Rear Seat Outside Passenger Positions
(Extended Cab and Crew Cab)......................1-26
Rear Seat Passengers, Safety Belts..................1-26
Rear Seat Top Strap Anchors (Crew
Cab Models)...............................................1-46
Rear Seat Top Strap Anchors (Extended
Cab Models)...............................................1-45
Rear Window Defogger............................3-24, 3-31
Rearview Mirror, Automatic Dimming with
Compass and Temperature Display................2-58
Rearview Mirror, Automatic Dimming with OnStar
®,
Compass and Temperature Display..................2-55
Rearview Mirrors.............................................2-55
Reclining Seatbacks.......................................... 1-6
Recommended Fluids and Lubricants.................6-13
Recreational Vehicle Towing.............................4-53REDUCED ENGINE POWER...........................3-67
Regular Cab and Extended Cab Models.............1-73
Remote Control.............................................3-119
Remote Keyless Entry System............................ 2-4
Remote Keyless Entry System, Operation............ 2-5
Removing the Flat Tire and Installing the
Spare Tire..................................................5-98
Removing the Spare Tire and Tools...................5-94
Replacement Bulbs.........................................5-72
Replacing Brake System Parts..........................5-52
Reporting Safety Defects
Canadian Government..................................7-11
General Motors...........................................7-11
United States Government............................7-10
Restraint System Check
Checking Your Restraint Systems...................1-84
Replacing Restraint System Parts After
a Crash..................................................1-85
Restraint Systems
Checking....................................................1-84
Replacing Parts...........................................1-85
Resynchronization............................................. 2-7
Retained Accessory Power (RAP)......................2-24
Right Front Passenger Position, Safety Belts......1-24
Right Front Passenger Position Top Strap Anchor
(Regular and Extended Models).....................1-43
RIGHT REAR DOOR AJAR (Crew Cab).............3-68
Roadside
Assistance Program....................................... 7-6
13

Theft-Deterrent Systems...................................2-20
Content Theft-Deterrent................................2-20
Passlock
®...................................................2-22
TIGHTEN FUEL CAP......................................3-70
Tilt Wheel........................................................ 3-7
Tire Sidewall Labeling......................................5-74
Tire Size.......................................................5-77
Tire Terminology and Denitions........................5-79
Tires.............................................................5-74
Buying New Tires........................................5-86
Chains.......................................................5-91
Changing a Flat Tire....................................5-93
Dual Tire Operation.....................................5-83
If a Tire Goes Flat.......................................5-92
Ination - Tire Pressure................................5-82
Inspection and Rotation................................5-83
Spare Tire................................................5-113
Uniform Tire Quality Grading.........................5-88
Wheel Alignment and Tire Balance.................5-89
Wheel Replacement.....................................5-89
When It Is Time for New Tires......................5-86
To Use the Engine Coolant Heater....................2-26
Tonneau Cover...............................................2-68
Top Strap......................................................1-42
Top Strap Anchor Location...............................1-43
Torque Lock (Automatic Transmission)...............2-51
Total Weight on Your Vehicle’s Tires..................4-88
Tow/Haul Mode (Automatic Transmission)...........2-30
Tow/Haul Mode Light.......................................3-52
Tow/Haul Mode, Overdrive Disable....................3-52Towing
Power Take-Off (PTO)................................4-100
Recreational Vehicle.....................................4-53
Towing a Trailer..........................................4-70
Your Vehicle...............................................4-52
Traction
Assist System (TAS)...................................... 4-9
Manual Selectable Ride................................4-11
Off Light.....................................................3-45
TRACTION ACTIVE........................................3-70
Trailer
Recommendations.......................................4-69
Trailer Brakes.................................................4-90
Trailer Wiring Harness.....................................4-95
TRANS HOT IDLE ENGINE (Allison
Transmission
®Only).....................................3-71
Transfer Case........................................5-58, 5-60
Transmission
Fluid, Automatic..................................5-27, 5-30
Fluid, Manual..............................................5-33
Temperature Gage.......................................3-46
Up-Shift Light..............................................3-43
TRANSMISSION HOT.....................................3-70
Transmission Operation, Automatic....................2-27
Transmission Operation, Manual........................2-31
Transmission, Transaxle, Transfer Case Unit
Repair Manual............................................7-11
Transportation Options...................................... 7-8
Traveling to Remote Areas...............................4-25
Trip Information Button....................................3-54
16

Trip Odometer................................................3-35
Truck-Camper Loading Information....................4-67
Turn and Lane Change Signals.......................... 3-8
TURN SIGNAL ON.........................................3-72
Turn Signal/Multifunction Lever........................... 3-7
Turn Signals When Towing a Trailer..................4-92
Two-Tiered Loading.........................................4-62
U
Underhood Fuse Block...................................5-127
Understanding Radio Reception.......................3-128
Uniform Tire Quality Grading............................5-88
United States – Customer Assistance.................. 7-4
Up-Shift Light.................................................3-43
Using Cleaner on Fabric................................5-115
Using Song List Mode...................................3-112
Using the Recovery Hooks (Except SS Model).......4-51
V
Vehicle
Control........................................................ 4-5
Damage Warnings........................................... iv
Loading......................................................4-56
Parking Your...............................................2-52
Symbols......................................................... ivVehicle Data Collection and Event Data
Recorders.................................................... 7-9
Vehicle Identication
Number (VIN)............................................5-122
Service Parts Identication Label..................5-122
Vehicle Personalization
Memory Seat..............................................2-70
Vehicle Storage..............................................5-53
Video Screen................................................3-117
Visors...........................................................2-19
Voltmeter Gage..............................................3-42
W
Warning Lights, Gages and Indicators................3-33
Warnings
DIC Warnings and Messages........................3-64
Hazard Warning Flashers............................... 3-6
Other Warning Devices.................................. 3-6
Safety and Symbols......................................... iii
Vehicle Damage.............................................. iv
Washing Your Vehicle....................................5-117
Weight Distributing Hitches and Weight
Carrying Hitches..........................................4-89
Weight of the Trailer........................................4-72
Weight of the Trailer Tongue.............................4-87
What Kind of Engine Oil to Use........................5-22
What to Add..................................................5-50
What to Do with Used Oil................................5-25
17