belt CHEVROLET SILVERADO 2019 Repair Manual

Chevrolet Silverado Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
1500-11698642) - 2019 - CRC - 2/20/19
Vehicle Care 413
Caution (Continued)
the appearance and feel of
leather or soft trim, and are not
recommended.
Do not use cleaners that increase
gloss, especially on the instrument
panel. Reflected glare can decrease
visibility through the windshield
under certain conditions.
Caution
Use of air fresheners may cause
permanent damage to plastics
and painted surfaces. If an air
freshener comes in contact with
any plastic or painted surface in
the vehicle, blot immediately and
clean with a soft cloth dampened
with a mild soap solution.
Damage caused by air fresheners
would not be covered by the
vehicle warranty.
Care of Seat Belts
Keep belts clean and dry.
{Warning
Do not bleach or dye seat belt
webbing. It may severely weaken
the webbing. In a crash, they
might not be able to provide
adequate protection. Clean and
rinse seat belt webbing only with
mild soap and lukewarm water.
Allow the webbing to dry.
Floor Mats
{Warning
If a floor mat is the wrong size or
is not properly installed, it can
interfere with the pedals.
Interference with the pedals can
cause unintended acceleration
and/or increased stopping
distance which can cause a crash (Continued)
Warning (Continued)
and injury. Make sure the floor
mat does not interfere with the
pedals.
Use the following guidelines for
proper floor mat usage:
. The original equipment floor
mats were designed for your
vehicle. If the floor mats need
replacing, it is recommended
that GM certified floor mats be
purchased. Non-GM floor mats
may not fit properly and may
interfere with the pedals. Always
check that the floor mats do not
interfere with the pedals.
. Do not use a floor mat if the
vehicle is not equipped with a
floor mat retainer on the driver
side floor.
. Use the floor mat with the
correct side up. Do not turn
it over.
. Do not place anything on top of
the driver side floor mat.

Chevrolet Silverado Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
1500-11698642) - 2019 - CRC - 2/20/19
420 Service and Maintenance
Additional Required ServicesMaintenance Schedule
Additional Required
Services - Normal
12 000 km/7,500 mi
24 000 km/15,000 mi
36 000 km/22,500 mi
48 000 km/30,000 mi
60 000 km/37,500 mi
72 000 km/45,000 mi
84 000 km/52,500 mi
96 000 km/60,000 mi
108 000 km/67,500 mi
120 000 km/75,000 mi
132 000 km/82,500 mi
144 000 km/90,000 mi
156 000 km/97,500 mi
168 000 km/105,000 mi 180 000 km/112,500 mi
192 000 km/120,000 mi
204 000 km/127,500 mi
216 000 km/135,000 mi
228 000 km/142,500 mi
240 000 km/150,000 mi
Rotate tires and perform Required Services.
Check engine oil level and oil life percentage.
Change engine oil and filter, if needed. Check
engine air filter life percentage and status.
Change engine air filter, if needed.
@ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @
Replace passenger compartment air filter. (1)@ @@@@@
If the vehicle is not equipped with the engine air
filter life system, replace engine air cleaner
filter. (2)@ @@
Inspect evaporative control system. (3)@@@
Replace spark plugs. Inspect spark plug wires.
(Except 2.7L L4 Turbo Engine)@
Replace spark plugs. Inspect spark plug wires.
(2.7L L4 Turbo Engine Only)@ @
Change transfer case fluid, if equipped with
4WD. (4)@
Drain and fill engine cooling system. (5)@
Visually inspect accessory drive belts. (6)@
Replace brake fluid. (7)
Replace windshield wiper blades. (8)
@ @@
@@ @
@ @@ @
Replace hood and/or body lift support gas struts.@
@

Chevrolet Silverado Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
1500-11698642) - 2019 - CRC - 2/20/19
422 Service and Maintenance
Maintenance Schedule
Additional Required
Services - Severe12 000 km/7,500 mi
24 000 km/15,000 mi
36 000 km/22,500 mi
48 000 km/30,000 mi
60 000 km/37,500 mi
72 000 km/45,000 mi
84 000 km/52,500 mi
96 000 km/60,000 mi
108 000 km/67,500 mi
120 000 km/75,000 mi
132 000 km/82,500 mi
144 000 km/90,000 mi
156 000 km/97,500 mi
168 000 km/105,000 mi 180 000 km/112,500 mi
192 000 km/120,000 mi
204 000 km/127,500 mi
216 000 km/135,000 mi
228 000 km/142,500 mi
240 000 km/150,000 mi
Rotate tires and perform Required Services.
Check engine oil level and oil life percentage.
Change engine oil and filter, if needed. Check
engine air filter life percentage and status.
Change engine air filter, if needed.
@ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @
Replace passenger compartment air filter. (1)@ @@@@@
If the vehicle is not equipped with the engine air
filter life system, replace engine air cleaner
filter. (2)@ @@
Inspect evaporative control system. (3)@@@
Replace spark plugs. Inspect spark plug wires.
(Except 2.7L L4 Turbo Engine)@
Replace spark plugs. Inspect spark plug wires.
(2.7L L4 Turbo Engine Only)@ @
Change automatic transmission fluid and filter.@@@
Change transfer case fluid, if equipped with
4WD. (4)@@@
Drain and fill engine cooling system. (5)@
Visually inspect accessory drive belts. (6)@
Replace brake fluid. (7)
Replace windshield wiper blades. (8)
@ @@
@@ @
@ @@ @
Replace hood and/or body lift support gas struts.@
@

Chevrolet Silverado Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
1500-11698642) - 2019 - CRC - 2/20/19
424 Service and Maintenance
Additional
Maintenance and Care
Your vehicle is an important
investment and caring for it properly
may help to avoid future costly
repairs. To maintain vehicle
performance, additional
maintenance services may be
required.
It is recommended that your dealer
perform these services—their
trained dealer technicians know
your vehicle best. Your dealer can
also perform a thorough
assessment with a multi-point
inspection to recommend when your
vehicle may need attention.
The following list is intended to
explain the services and conditions
to look for that may indicate
services are required.
Battery
The 12-volt battery supplies power
to start the engine and operate any
additional electrical accessories. .
To avoid break-down or failure to
start the vehicle, maintain a
battery with full cranking power.
. Trained dealer technicians have
the diagnostic equipment to test
the battery and ensure that the
connections and cables are
corrosion-free.
Belts
. Belts may need replacing if they
squeak or show signs of
cracking or splitting.
. Trained dealer technicians have
access to tools and equipment
to inspect the belts and
recommend adjustment or
replacement when necessary.
Brakes
Brakes stop the vehicle and are
crucial to safe driving.
. Signs of brake wear may include
chirping, grinding, or squealing
noises, or difficulty stopping. .
Trained dealer technicians have
access to tools and equipment
to inspect the brakes and
recommend quality parts
engineered for the vehicle.
Fluids
Proper fluid levels and approved
fluids protect the vehicle’s systems
and components. See
Recommended Fluids and
Lubricants 0427 for GM approved
fluids.
. Engine oil and windshield
washer fluid levels should be
checked at every fuel fill.
. Instrument cluster lights may
come on to indicate that fluids
may be low and need to be
filled.
Hoses
Hoses transport fluids and should
be regularly inspected to ensure
that there are no cracks or leaks.
With a multi-point inspection, your
dealer can inspect the hoses and
advise if replacement is needed.

Chevrolet Silverado Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
1500-11698642) - 2019 - CRC - 2/20/19
Technical Data 431
Technical Data
Vehicle Identification
Vehicle IdentificationNumber (VIN) . . . . . . . . . . . . . . . 431
Service Parts Identification Label . . . . . . . . . . . . . . . . . . . . . . . . 431
Vehicle Data
Capacities andSpecifications . . . . . . . . . . . . . . . 432
Engine Drive Belt Routing . . . . 434
Vehicle Identification
Vehicle Identification
Number (VIN)
This legal identifier is in the front
corner of the instrument panel, on
the driver side of the vehicle. It can
be seen through the windshield from
outside. The Vehicle Identification
Number (VIN) also appears on the
Vehicle Certification and Service
Parts labels and certificates of title
and registration.
Engine Identification
The eighth character in the VIN is
the engine code. This code
identifies the vehicle's engine,
specifications, and replacement parts. See
“Engine Specifications”
under Capacities and Specifications
0 432 for the vehicle's engine code.
Service Parts
Identification Label
There may be a label on the inside
of the glove box that contains the
following information:
.
Vehicle Identification
Number (VIN)
. Model designation
. Paint information
. Production options and special
equipment
If there is no label, there is a
barcode on the certification label on
the center (B) pillar to scan for this
same information.

Chevrolet Silverado Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
1500-11698642) - 2019 - CRC - 2/20/19
434 Technical Data
Engine Drive Belt Routing
If the vehicle has a diesel engine,
see the Duramax diesel
supplement.
2.7L Engine
4.3L, 5.3L, and 6.2L Engines

Chevrolet Silverado Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
1500-11698642) - 2019 - CRC - 2/20/19
Customer Information 447
Vehicle Data
Recording and
Privacy
The vehicle has a number of
computers that record information
about the vehicle’s performance and
how it is driven. For example, the
vehicle uses computer modules to
monitor and control engine and
transmission performance, to
monitor the conditions for airbag
deployment and deploy them in a
crash, and, if equipped, to provide
antilock braking to help the driver
control the vehicle. These modules
may store data to help the dealer
technician service the vehicle.
Some modules may also store data
about how the vehicle is operated,
such as rate of fuel consumption or
average speed. These modules may
retain personal preferences, such as
radio presets, seat positions, and
temperature settings.
Event Data Recorders
This vehicle is equipped with an
event data recorder (EDR). The
main purpose of an EDR is to
record, in certain crash or near
crash-like situations, such as an air
bag deployment or hitting a road
obstacle, data that will assist in
understanding how a vehicle’s
systems performed. The EDR is
designed to record data related to
vehicle dynamics and safety
systems for a short period of time,
typically 30 seconds or less. The
EDR in this vehicle is designed to
record such data as:
.How various systems in your
vehicle were operating;
. Whether or not the driver and
passenger safety belts were
buckled/fastened;
. How far (if at all) the driver was
depressing the accelerator and/
or brake pedal; and,
. How fast the vehicle was
traveling. These data can help provide a
better understanding of the
circumstances in which crashes and
injuries occur.
Note
EDR data are recorded by your
vehicle only if a non-trivial crash
situation occurs; no data are
recorded by the EDR under normal
driving conditions and no personal
data (e.g., name, gender, age, and
crash location) are recorded.
However, other parties, such as law
enforcement, could combine the
EDR data with the type of
personally identifying data routinely
acquired during a crash
investigation.
To read data recorded by an EDR,
special equipment is required, and
access to the vehicle or the EDR is
needed. In addition to the vehicle
manufacturer, other parties, such as
law enforcement, that have the
special equipment, can read the
information if they have access to
the vehicle or the EDR.

Chevrolet Silverado Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
1500-11698642) - 2019 - CRC - 2/20/19
464 Index
Door (cont'd)Locks . . . . . . . . . . . . . . . . . . . . . . . . . . . 45
Power Locks . . . . . . . . . . . . . . . . . . . . 46
Drive Belt Routing, Engine . . . . . . 434
Driver Assistance Systems . . . . . 254
Driver Information
Center (DIC) . . . . . . . . . . . . . 160, 161
Driver Mode Control . . . . . . . . . . . . 247
Driver Mode Control Light . . . . . . 157
Driving Assistance Systems . . . . . . . . . . 261
Characteristics andTowing Tips . . . . . . . . . . . . . . . . . 277
Defensive . . . . . . . . . . . . . . . . . . . . . 199
Drunk . . . . . . . . . . . . . . . . . . . . . . . . . 199
For Better Fuel Economy . . . . . . . 30
Hill and Mountain Roads . . . . . . 207
If the Vehicle is Stuck . . . . . . . . . 209
Loss of Control . . . . . . . . . . . . . . . 201
Off-Road . . . . . . . . . . . . . . . . . . . . . 201
Off-Road Recovery . . . . . . . . . . . 200
Vehicle Load Limits . . . . . . . . . . . 210
Wet Roads . . . . . . . . . . . . . . . . . . . 206
Winter . . . . . . . . . . . . . . . . . . . . . . . . 207
Dual Automatic Climate Control System . . . . . . . . . . . . . . . . 191E
E85 or FlexFuel . . . . . . . . . . . . . . . . 273
Electric Parking Brake . . . . . . . . . . 242
Electric Parking Brake Light . . . . 153
Electrical Equipment,Add-On . . . . . . . . . . . . . . . . . . . . . . . 307
Electrical System Engine Compartment FuseBlock . . . . . . . . . . . . . . . . . . . . . . . . 352
Fuses and Circuit Breakers . . . 351
Instrument Panel Fuse
Block . . . . . . . . . . . . . . . . . . . 355, 358
Overload . . . . . . . . . . . . . . . . . . . . . 351
Electronic Stability Control
(ESC) Off Light . . . . . . . . . . . . . . . . 156
Emergency OnStar . . . . . . . . . . . . . . . . . . . . . . . 450
Engine Air Cleaner/Filter . . . . . . . . . . . . . 327
Check Light (Malfunction
Indicator) . . . . . . . . . . . . . . . . . . . . 150
Compartment Overview . . . . . . . 317
Coolant Temperature Gauge . . . . . . . . . . . . . . . . . . . . . . 146
Coolant Temperature Warning Light . . . . . . . . . . . . . . . 156
Cooling System . . . . . . . . . . . . . . . 328
Drive Belt Routing . . . . . . . . . . . . 434 Engine (cont'd)
Exhaust . . . . . . . . . . . . . . . . . . . . . . 229
Fan . . . . . . . . . . . . . . . . . . . . . . . . . . . 334
Heater . . . . . . . . . . . . . . . . . . . . . . . . 224
Oil Life System . . . . . . . . . . . . . . . 324
Oil Pressure Gauge . . . . . . . . . . 145
Oil Pressure Light . . . . . . . . . . . . 158
Overheated Protection
Operating Mode . . . . . . . . . . . . . 334
Overheating . . . . . . . . . . . . . . . . . . 332
Power Messages . . . . . . . . . . . . . 168
Running While Parked . . . . . . . . 229
Starting . . . . . . . . . . . . . . . . . . . . . . . 222
Engine Air Filter Life System . . . . 326
Entry Lighting . . . . . . . . . . . . . . . . . . . 185
Equipment, Towing . . . . . . . . . . . . . 286
Event Data Recorders . . . . . . . . . . 447
Exit Lighting . . . . . . . . . . . . . . . . . . . . 185
Extended Parking . . . . . . . . . . . . . . . 228
Extender, Seat Belt . . . . . . . . . . . . . . 84
Exterior Cargo Lamps . . . . . . . . . . 183
Exterior Lamp Controls . . . . . . . . . 177
Exterior Lamps Off Reminder . . . 179
Exterior Lighting Battery
Saver . . . . . . . . . . . . . . . . . . . . . . . . . 187

Chevrolet Silverado Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
1500-11698642) - 2019 - CRC - 2/20/19
466 Index
H
Halogen Bulbs . . . . . . . . . . . . . . . . . . 347
Hazard Warning Flashers . . . . . . . 181
Head Restraints . . . . . . . . . . . . . . . . . 68
Head-up Display . . . . . . . . . . . . . . . . 164
HeadlampsAiming . . . . . . . . . . . . . . . . . . . . . . . . 347
Automatic . . . . . . . . . . . . . . . . . . . . . 180
Bulb Replacement . . . . . . . . . . . . 347
Daytime RunningLamps (DRL) . . . . . . . . . . . . . . . . 180
Flash-to-Pass . . . . . . . . . . . . . . . . . 180
Headlamps, Front Turn Signal, Sidemarker, and
Parking Lamps . . . . . . . . . . . . . . 348
High-Beam On Light . . . . . . . . . . 158
High/Low Beam Changer . . . . . 179
Lamps On Reminder . . . . . . . . . 159
Heated
Rear Seats . . . . . . . . . . . . . . . . . . . . . 78
Steering Wheel . . . . . . . . . . . . . . . 132
Heated and Ventilated Front Seats . . . . . . . . . . . . . . . . . . . . . . . . . . 75
Heated Mirrors . . . . . . . . . . . . . . . . . . . 58
Heater
Engine . . . . . . . . . . . . . . . . . . . . . . . . 224
Heating . . . . . . . . . . . . . . . . . . . . 189, 191
High-Beam On Light . . . . . . . . . . . . 158 High-Speed Operation . . . . . . . . . . 370
Hill and Mountain Roads . . . . . . . . 207
Hill Descent Control (HDC) . . . . . 246
Hill Descent Control Light . . . . . . . 154
Hill Start Assist (HSA) . . . . . . . . . . 244
Hood . . . . . . . . . . . . . . . . . . . . . . . . . . . 315
Horn . . . . . . . . . . . . . . . . . . . . . . . . . . . . 132
How to Wear Seat Belts
Properly . . . . . . . . . . . . . . . . . . . . . . . . 80
HVAC . . . . . . . . . . . . . . . . . . . . . . 189, 191
I
Ignition Positions . . . . . . . . . . 218, 220
Ignition Transmission Lock Check . . . . . . . . . . . . . . . . . . . . . . . . . 344
Immobilizer . . . . . . . . . . . . . . . . . . . . . . 54
Indicator Pedestrian Ahead . . . . . . . . . . . . 155
Vehicle Ahead . . . . . . . . . . . . . . . . 155
Infants and Young Children, Restraints . . . . . . . . . . . . . . . . . . . . . 100
Information Publication Ordering . . . . . . . . . . 444
Infotainment . . . . . . . . . . . . . . . . . . . . 188
Infotainment System . . . . . . . . . . . . 448
Instrument Cluster . . . . . . . . . . . . . . 139
Interior Rearview Mirrors . . . . . . . . . 59
Introduction . . . . . . . . . . . . . . . . . . . . . . . 2
J
Jump Starting - North America . . . . . . . . . . . . . . . . . . . . . . . 396
K
Keyless EntryRemote (RKE) System . . . . . 34, 42
Keys . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
L
Labeling, Tire Sidewall . . . . . . . . . . 362
Lamps Daytime Running (DRL) . . . . . . 180
Dome . . . . . . . . . . . . . . . . . . . . . . . . . 184
Exterior Cargo . . . . . . . . . . . . . . . . 183
Exterior Controls . . . . . . . . . . . . . . 177
Exterior Lamps OffReminder . . . . . . . . . . . . . . . . . . . 179
Exterior Lighting Battery Saver . . . . . . . . . . . . . . . . . . . . . . . 187
License Plate . . . . . . . . . . . . . . . . . 350
Malfunction Indicator
(Check Engine) . . . . . . . . . . . . . 150
On Reminder . . . . . . . . . . . . . . . . . 159
Reading . . . . . . . . . . . . . . . . . . . . . . 185
Lane Change Alert (LCA) . . . . . . . 268
Lane Departure Warning (LDW) . . . . . . . . . . . . . . . . 270
Lane Keep Assist (LKA) . . . . . . . . 270

Chevrolet Silverado Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
1500-11698642) - 2019 - CRC - 2/20/19
Index 467
Lane Keep Assist Light . . . . . . . . . 154
Lap-Shoulder Belt . . . . . . . . . . . . . . . 82
LATCH SystemReplacing Parts after aCrash . . . . . . . . . . . . . . . . . . . . . . . .117
LATCH, Lower Anchors and Tethers for Children . . . . . . . . . . . 106
LED Lighting . . . . . . . . . . . . . . . . . . . . 348
Lighting Entry . . . . . . . . . . . . . . . . . . . . . . . . . 185
Exit . . . . . . . . . . . . . . . . . . . . . . . . . . . 185
Illumination Control . . . . . . . . . . . 184
LED . . . . . . . . . . . . . . . . . . . . . . . . . . 348
Task . . . . . . . . . . . . . . . . . . . . . . . . . . 183
Lights Airbag Readiness . . . . . . . . . . . . . 148
Antilock Brake System
(ABS) Warning . . . . . . . . . . . . . . 153
Brake System Warning . . . . . . . 152
Charging System . . . . . . . . . . . . . 149
Check Engine (Malfunction Indicator) . . . . . . . . . . . . . . . . . . . . 150
Cruise Control . . . . . . . . . . . . . . . . 159
Door Ajar . . . . . . . . . . . . . . . . . . . . . 159
Driver Mode Control . . . . . . . . . . 157
Electric Parking Brake . . . . . . . . 153
Electronic Stability Control (ESC), Off . . . . . . . . . . . . . . . . . . . 156 Lights (cont'd)
Engine Coolant
Temperature Warning . . . . . . . 156
Engine Oil Pressure . . . . . . . . . . 158
Flash-to-Pass . . . . . . . . . . . . . . . . . 180
Four-Wheel-Drive . . . . . . . . . . . . . 154
Front Fog Lamp . . . . . . . . . . . . . . 159
High-Beam On . . . . . . . . . . . . . . . . 158
High/Low Beam Changer . . . . . 179
Hill Descent Control . . . . . . . . . . 154
Lane Keep Assist . . . . . . . . . . . . . 154
Low Fuel Warning . . . . . . . . . . . . 158
Seat Belt Reminders . . . . . . . . . . 147
Security . . . . . . . . . . . . . . . . . . . . . . 158
Service Electric Parking
Brake . . . . . . . . . . . . . . . . . . . . . . . 153
Tire Pressure . . . . . . . . . . . . . . . . . 157
Tow/Haul Mode . . . . . . . . . . . . . . . 154
Traction Off . . . . . . . . . . . . . . . . . . . 155
Limited-Slip Differential . . . . . . . . . 251
Locking Rear Axle . . . . . . . . . . . . . . 251
Locks Automatic Door . . . . . . . . . . . . . . . . . 47
Delayed Locking . . . . . . . . . . . . . . . . 46
Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45
Lockout Protection . . . . . . . . . . . . . . 47
Power Door . . . . . . . . . . . . . . . . . . . . . 46
Safety . . . . . . . . . . . . . . . . . . . . . . . . . . 47 Loss of Control . . . . . . . . . . . . . . . . . 201
Low Fuel Warning Light . . . . . . . . . 158
Low-Profile Tires . . . . . . . . . . . . . . . . 362
Lower Anchors and Tethers
for Children (LATCH
System) . . . . . . . . . . . . . . . . . . . . . . . 106
Lumbar Adjustment . . . . . . . . . . . . . . 71
Front Seats . . . . . . . . . . . . . . . . . . . . . 71
M
MaintenanceRecords . . . . . . . . . . . . . . . . . . . . . . 430
Maintenance and Care Additional . . . . . . . . . . . . . . . . . . . . . 424
Maintenance Schedule . . . . . . . . . 417 Recommended Fluids andLubricants . . . . . . . . . . . . . . . . . . . 427
Transfer Case . . . . . . . . . . . . . . . . 236
Malfunction Indicator Lamp . . . . . 150
Manual Mirrors . . . . . . . . . . . . . . . . . . 56
Manual Mode . . . . . . . . . . . . . . . . . . . 233
Manual Windows . . . . . . . . . . . . . . . . 62
Memory Features . . . . . . . . . . . . . . . . 13
Memory Seats . . . . . . . . . . . . . . . . . . . 73
Messages Engine Power . . . . . . . . . . . . . . . . 168
Vehicle . . . . . . . . . . . . . . . . . . . . . . . 167
Vehicle Speed . . . . . . . . . . . . . . . . 168