transmission oil CHEVROLET SUBURBAN 1997 User Guide

Short Trip/City Maintenance Schedule -- Gasoline Engines I
The services shown in this schedule up to 100,000 miles
( 166 000 km) should be performed after 100,000 miles
(166
000 km) at the same intervals. The services shown
at
150,000 miles (240 000 km) should be performed at
the same interval after 150,000 miles (240
000 km).
See “Owner Checks and Services’’ and “Periodic
Maintenance Inspections” following.
Footnotes
The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that the
failure to perform this maintenance item will not nullify
the emission warranty or limit recall liability prior to the
completion of the vehicle’s useful life. We, however,
urge that all recommended maintenance services be
performed at the indicated intervals and the maintenance
be recorded.
# Lubricate the front suspension, kingpin bushings,
steering linkage, transmission shift linkage, transfer case
shift linkage, parking brake cable guides, front axle
propshaft splines and brake pedal springs. Ball joints and kingpin bushings should not
be lubricated unless
their temperature
is 10” F (- 12” C) or higher, or they
could be damaged.
+ A good time to check your brakes is during tire
rotation. See “Brake System Inspection” under “Periodic
Maintenance Inspection” in Part
C of this schedule.
** Drive axle service (see “Recommended Fluids and
Lubricants” in the Index for proper lubricant to use):
Locking Differential -- Drain fluid and refill at first
engine oil change. At subsequent oil changes, check
fluid level and add fluid as needed.
If driving in
dusty areas or towing a trailer, drain fluid and refill
every
15,000 miles (25 000 km).
Standard Differential -- Check fluid level and add
fluid as needed at every oil change.
If driving in
dusty areas or towing a trailer, drain fluid and refill
every
15,000 miles (25 000 km).
heavy-duty or off-road use.
More frequent lubrication may be required for
ProCarManuals.com

Short TripKity Maintenance Schedule -- Gasoline Engines
48,000 Miles (80 000 km)
0 Change engine oil and filter (or every
3 months, whichever occurs first).
An Emission Control Service.
0 Lubricate chassis components (or every
3 months, whichever occurs first).
(See footnote
#.)
0 Check readfront axle fluid level and add fluid as needed. Check constant velocity joints and
axle seals for leaking. (See footnote
**.)
0 Rotate tires. See “Tire Inspection and
Rotation’’ in the Index for proper rotation
pattern and additional information.
(See footnote
+.)
DATE SERVICED BY ACTUAL MILEAGE
50,000 Miles (83 000 km)
0 Change automatic transmission fluid and
filter
if the vehicle is mainly driven under
one or more of these conditions:
- In heavy city traffic where the outside
temperature regularly reaches
90 OF
(32°C) or higher.
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or
delivery service.
If you do not use your vehicle under any of these
conditions, the fluid andfilter
do not require changing.
DATE
SERVICED BY ACTUAL MILEAGE
7-17
ProCarManuals.com

I Short TripKity Maintenance Schedule -= Gasoline Engines I
99,000 Miles (165 000 km)
0 Change engine oil and filter (or every
3 months, whichever occurs first).
An Emission Control Service.
0 Lubricate chassis components (or every
3 months, whichever occurs first).
(See footnote
#.)
0 Check readfront axle fluid level and add
fluid as needed. Check constant velocity
joints and axle seals for leaking.
(See footnote
**.)
DATE ACTUAL MILEAGE
1
SERVICED BY
100,000 Miles (166 000 km)
0 Inspect spark plug wires.
0 Replace spark plugs.
0 Change automatic transmission fluid and
filter if the vehicle is mainly driven under
one or more of these conditions:
An Emission Control Service.
An Emission Control Service.
- In heavy city traffic where the outside
temperature regularly reaches
90 O F
(32 O C) or higher.
ProCarManuals.com

Long Tripmighway Maintenance Schedule -- Gasoline Engines
The services shown in this schedule up to 100,000 miles
(166
000 km) should be performed after 100,000 miles
(166
000 km) at the same intervals. The services shown
at
150,000 miles (240 000 km) should be performed at
the same interval after
150,000 miles (240 000 km).
See “Owner Checks and Services” and “Periodic
Maintenance Inspections” following.
Footnotes
3- The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that the
failure
to perform this maintenance item will not nullify
the emission warranty or limit recall liability prior to the
completion of the vehicle’s useful life. We, however,
urge that all recommended maintenance services be
performed at the indicated intervals and the maintenance
be recorded.
# Lubricate the front suspension, kingpin bushings,
steering linkage, transmission shift linkage, transfer case
shift linkage, parking brake cable guides, front axle
propshaft splines and brake pedal springs. Ball joints and
kinetin bushings should
not be lubricated unless
their tegperature is”1O”F
(- 12°C) or higher, or they
could be damaged.
+ A good time to check your brakes is during tire
rotation. See “Brake System Inspection” under “Periodic
Maintenance Inspections” in
Part C of this schedule.
* * Drive axle service (see “Recommended Fluids and
Lubricants” in the Index for proper lubricant to use):
Locking Differential -- Drain fluid and refill at first
engine oil change. At subsequent oil changes, check
fluid level and add fluid as needed.
Standard Differential -- Check fluid level and add
fluid as needed at every engine oil change.
7-30 -
ProCarManuals.com

1 Lung Tripmighway Maintenance Schedule -- Gasoline Engines
97,500 Miles (162 500 km)
0 Change engine oil and filter (or every
12 months, whichever occurs first).
0 Lubricate chassis components (or every
12 months, whichever occurs first).
(See footnote
#.)
0 Check readfront axle fluid level and add fluid
as needed. Check constant velocity joints and axle seals for leaking. (See footnote
**.)
0 Rotate tires. See “Tire Inspection and
Rotation” in the Index for proper rotation
pattern and additional information.
(See footnote
+.)
An Emission Control Service.
100,000 Miles (1 66 000 km)
0 Inspect spark plug wires.
Replace spark plugs.
0 Change automatic transmission fluid and
An Emission Control Service.
An Emission Control Service.
filter if the vehicle is mainly driven under
one or more of these conditions:
- In heavy city traffic where the outside
temperature regularly reaches
90°F
(32°C) or higher.
(Continued)
7-41
ProCarManuals.com

At Least %ice a Year
Restraint System Check
Make sure the safety belt reminder light and all your
belts, buckles, latch plates, retractors and anchorages are
working properly. Look for any other loose or damaged
safety belt system parts. If you see anything that might
keep a safety belt system from doing its job, have it
repaired. Have any torn or frayed safety belts replaced.
Also look for any opened or broken air bag coverings,
and have them repaired or replaced. (The air bag system
does not need regular maintenance.)
Wiper Blade Check
Inspect wiper blades for wear or cracking. Replace blade
inserts that appear worn or damaged or that streak or
miss areas of the windshield. Also
see “Wiper Blades,
Cleaning” in the Index.
Air Cleaner Filter Restriction Indicator Check
Your vehicle has an indicator on the engine that lets you
know when the air cleaner filter is dirty and needs to be
changed. Check indicator at least twice a year or when your
oil is changed. See
“Air Cleaner’’ in the Index
for more information. Inspect your air cleaner filter
restriction indicator more often if the vehicle is used in
dusty areas or under
off road conditions.
Automatic Transmission Check
Check the transmission fluid level; add if needed. See
“Automatic Transmission” in the Index. A fluid loss
may indicate a problem. Check the system and repair
if needed.
At Least Once a Year
Key Lock Cylinders Service
Lubricate the key lock cylinders with the lubricant
specified in Part
D.
Body Lubrication Service
Lubricate all fuel door, body hood and body door
hinges, rear compartment hinges, tailgate handle pivot
points, latches, locks and folding seat hardware.
Part D
tells you what to use. More frequent lubrication may be
required when exposed to a corrosive environment.
ProCarManuals.com

Part D: Recommended Fluids
and Lubricants
NOTE: Fluids and lubricants identified below by name,
part number or specification may be obtained from your
GM dealer.
USAGE
Engine Oil
(Gasoline
Engine)
Engine Coolant
Hydraulic Brake
System
FLUID/LUBRICANT
Engine oil with the American
Petroleum Institute Certified For Gasoline Engines “Starburst”
symbol of the proper viscosity.
To
determine the preferred viscosity
for your vehicle’s engine, see
“Engine Oil” in the Index.
50/50 mixture of clean water
(preferably distilled) and GM
Goodwrench@ DEX-COOLa or
Havoline@ DEX-COOL@
(silicate-free) coolant. See
“Engine Coolant” in the Index.
Delco Supreme 11
@ Brake Fluid
(GM Part No. 12377967 or
equivalent DOT-3 brake fluid).
USAGE
Parking Brake
Cable Guides
Power Steering
System
Automatic
Transmission
Key Lock
Cylinders
~~
Chassis
Lubrication
FLUIDLUBRICANT
Chassis lubricant (GM Part
No. 1052497 or equivalent) or
lubricant meeting requirements
of NLGI # 2, Category LB
or GC-LB.
GM Power Steering Fluid (GM
Part
No. 1052884 - 1 pint,
1050017
- 1 quart, or equivalent).
DEXRON@-111 Automatic
Transmission Fluid.
Multi-Purpose lubricant, Superlube@ (GM Part
No. 12346241
or equivalent).
Chassis lubricant (GM Part
No. 1052497 or equivalent) or
lubricant meeting requirements
of NLGI # 2, Category LB
or GC-LB.
7-49
ProCarManuals.com

Electrical System ............................... 6-62
Electrochromic Daymight Rearview Mirror
.......... 2-44
Electronic Compass
............................. 2-44
Engine
.................................. 6.10. 6.12
Coolant
..................................... 6-26
Coolant Heater
............................... 2-15
Coolant Level Check
.......................... 7-43
Coolant Temperature Gage
..................... 2-68
Cooling System
.............................. 6-71
Exhaust
..................................... 2-29
Identification
................................ 6-61
OilLevelCheck
.............................. 7-43
Overheating
................................. 5-11
Running While Parked
......................... 2-30
Specifications ................................ 6-69
StartingYour
................................ 2-13
Engineoil
.................................... 6-14
Adding
..................................... 6-15
Additives
................................... 6-17
Checking
................................... 6-14
Pressure Gage
................................ 2-71
Used
....................................... 6-17
Whentochange
.............................. 6-17
Entry to the Rear Seat (Suburban Second Seat)
........ 1 - 14
Ethanol
........................................ 6-5
Exhaust, Engine
................................ 2-29
Fabric Cleaning
............................... 6-53
Filling Your Tank
................................ 6-6
Filter, Engine Oil
............................... 6-17
Finish Damage
................................. 6-59
Filter,
Air
..................................... 6-18
Finishcare
.................................... 6-57 First
Gear. Automatic Transmission
................ 2- 19
Flashers. Hazard Warning ......................... 5-2
Flat Tire. Changing
............................. 5-22
Fluid Capacities
................................ 6-71
Fluid Leak Check
............................... 6-36
Fluids and Lubricants
............................ 7-49
Folding the Rear Seat
(2-Door Utility) ............... 1-8
Folding the Rear Seat (+Door Utility) .............. 1-10
Folding the Second Seat (Suburban)
................ 1-12
Foreign Countries. Fuel
........................... 6-5
Four-wheel Drive
......................... 2-20. 6-24
French Language Manual
11
FrontAxle .................................... 6-25
Front Axle Locking Feature
....................... 2-20
Front Park/Turn Signal Bulb Replacement
...... 6-39. 6-40
Front Sidemarker Lamp
Bulb Replacement ........... 6-41
FrontTowing
................................... 5-9
Fuel .......................................... 6-3
Filling Your Tank
.............................. 6-6
Gage
....................................... 2-74
In Foreign Countries
........................... 6-5
Tank Capacity
............................... 6-72
Fuses and Circuit Breakers
....................... 6-63
.. ...........................
Gages
Engine Coolant Temperature
.................... 2-68
Engine Oil Pressure
........................... 2-71
Fuel
....................................... 2-74
Speedometer
................................. 2-63
Tachometer
.................................. 2-63
Voltmeter
................................... 2-66
GAWR
....................................... 4-42
Garage
Door Opener
............................ 2-48
ProCarManuals.com

Odometer ........................ ........ 2-63
Odometer. Trip
................................. 2-63
Off-Road Driving
.............................. 4-14
Off-Road Recovery
............................. 4- 1 1
Opener, Garage Door ............................ 2-48
Overdrive, Automatic Transmission
................ 2- 19
Overheating Engine
............................. 5- 11
Owner Checks and Services
....................... 7-43
Owner Publications, Ordering
................ 8- 11, 8- 12
Oil. Engine
.................................... 6-14
Paint Spotting. Chemical
. . ................. 6-59
Park Automatic Transmission
..................... 2- 17
Shifting Into ................................. 2-26
Shifting Out of
............................... 2-28
Parking AtNight
.................................... 2-11
Brake ...................................... 2-25
Brake Mechanism Check
....................... 7-46
Lots
....................................... 2-11
Over Things That Burn
........................ 2-29
With
a Trailer ................................ 4-53
Passenger Position
.............................. 1-3 1
Passing ....................................... 4-12
Periodic Maintenance Inspections
.................. 7-47
Power Auxiliary Outlet
.............................. 2-59
DoorLocks
................................... 2-4
Lumbar Adjustment
............................ 1-4 Option Fuses
.............................. 6-63
Remote
Control Mirror ........................ 2-47
Seat
......................................... 1-3
Steering
..................................... 4-9
Steering Fluid
................................ 6-30
Take-Off .................................... 4-55
Winches
.................................... 4-55
Windows
................................... 2-31
Power Lumbar Adjustment
........................ 1-4
Pregnancy, Use of Safety Belts .................... 1-30
Problems
on the Road ............................ 5-1
Protecting Exterior Bright Metal Parts ............... 6-58
PTO
......................................... 4-55
Publications, Service and Owner
.............. 8- 11, 8- 12
Radiator
..................................... 5-18
Radiator Pressure Cap
........................... 6-29
Radio Reception
................................ 3-28
Radios
........................ 3-1 1.3-13. 3.15. 3.20
Rain. Driving In
................................ 4-30
Reading Lamps
................................ 2-43
Rear Axle
....................................... 6-24
Child Security Locks
........................... 2-5
Lamp Bulb Replacement
....................... 6-43
Outside Seat Position
.......................... 1-40
Safety Belt Comfort Guides
..................... 1-45
Seat Passengers
.............................. 1-39
Window Defogger
............................ 3-10
Windshield Washer ........................... 2-36
9-7
ProCarManuals.com