automatic transmission CHEVROLET TRACKER 1994 Owner's Manual

At Least Once a Year (CONT.)
CHECK
OR SERVICE
Brake Transmission
Shift Interlock
- BTSI
(Automatic Transmis-
sion)
Steering Column Lock
WHAT TO DO
1. Before you start, be sure you have enough room around the vehicle. It should be parked on a
2. Firmly apply the parking brake. (See “Parking Brake” in the Index if necessary).
NOTE: Be ready to apply the regular brake immediately if the vehicle begins to move.
3. With the engine off, turn the key to the “ON” position, but don’t start the engine. Without
level surface.
applying the regular brake, try
to move the shift lever out of “P” (Park) with normal effort,
If the shift lever moves out
of “P” (Park) , your vehicle’s BTSI needs service.
While parked, and with the parking brake set, try
to turn the key to “LOCK” in each shift lever
position.
0 With an automatic transmission, the key should turn to “LOCK” only when the shift lever is
With a manual transmission, the key will turn to “LOCK” only if you push the key in farther,
On vehicles with
the key release lever, try to turn the key to “LOCK” without pressing the lever.
The key should
turn to “LOCK” only with the key lever depressed. On all vehicles, the key
should come out only
in “LOCK”.
in
“P” (Park).
while turning
it towards “LOCK.”
!
I
I
I’
LLI . . . ProCarManuals.com

Maintenance Schedule
Section B: Owner Checks and Services (Cont.)
At Least Once a Year (CONT.)
CHECK
OR SERVICE
Parking Brake and
Automatic Transmission “P” (Park) Mechanism
Check
Underbody Flushing
WHAT TO DO
Park on a fairly steep hill, with the vehicle facing downhill. Keeping your foot on the regular
brake, set the parking brake.
0 To check the parking brake: With the engine running and transmission in “N” (Neutral),
__
slowly remove foot pressure from the regular brake pedal. Do this until the vehicle is held by
the parking brake only.
To check the “P” (Park) mechanism’s holding ability: Shift to “P” (Park). Then release all
brakes. If your vehicle
is four-wheel drive, be sure the transfer case is not in “N” (Neutral).
At least every spring, use plain water to flush any corrosive materials from the underbody. Take
care to clean thoroughly any areas where mud and other debris can collect.
I . .222 ProCarManuals.com

Maintenance Schedule
Section D: Recommended Fluids & Lubricants
NOTE: Fluids and lubricants identified below by name, part number or specification may be obtained from your GM Dealer.
USAGE
Engine Oil
Engine Coolant
Hydraulic Brake
System
Parking Brake Guides
Power Steering
System
Manual Transmission
Automatic
Transmission
FLUID/LUBRICANT
API service SH or SG Energy Conserving I1 oils of the proper viscosity. The “SH” or “SG”
designation may be shown alone or in combination with others, such as
“SH/CD,” or “SH, SG,
CD,” “SGKD,” etc. To determine the preferred viscosity for your vehicle’s engine, see “Engine
Oil”
in the Index.
50/50 mixture of water (preferably distilled) and good quality ethylene glycol base antifreeze
(GM Part
No. 1052753 or equivalent) conforming to GM Specification 1825M or approved
recycled coolant conforming to GM Specification
1825M.
Delco-Supreme 11’” Brake Fluid (GM Part No. 1052535 or equivalent DOT-3 brake fluid).
Chassis lubricant (GM Part
No. 1052497 or equivalent) or lubricant meeting requirements of
NLGI Grade
2, Category LB or GC-LB.
DEXR0N’-IIE Automatic Transmission Fluid.
SAE
75W-90 GL-4 (GM Part No. 12346074 Castrol‘ Syntorq GL-4 or equivalent) or SAE
75W-90 GL-5 Gear Lubricant.
DEXRON3-III
or DEXRON”-IIE Automatic Transmission Fluid.
225. . . ProCarManuals.com

Maintenance Schedule
Section D: Recommended Fluids & Lubr
USAGE
Key Lock Cylinders Manual Transmission
Shift Linkage
Automatic
Transmission
Shift Linkage
Clutch Linkage Pivot Points
Floor Shift Linkage
Chassis Lubrication
*icants (Cont.)
FLUID/LUBRICANT
Lubricate with Multi-Purpose Lubricant (GM Part No. 12345120) or synthetic SAE 5W-30
engine oil.
Chassis lubricant
(GM Part No. 1052497 or equivalent) or lubricant meeting requirements of
NLGI Grade 2, Category LB or GC-LB.
Engine oil.
Lithium base grease.
Engine oil.
Chassis lubricant (GM Part No.
1052497 or equivalent) or lubricant meeting requirements of
NLGI Grade
2, Category LB or GC-LB.
. .226
ProCarManuals.com

A bout Driving Your Tracker ..... 3
ABS ......................... 103
Adding Coolant ................ 171
Additives. Engine
Oil ............ 165
Adjustment. Clutch
............. 169
Air Cleaner .................... 165
Air Conditioner Controls
......... 85
Air Filter Replacement
........... 166
Air Intake Lever ................ 84
Airflow Lever
.................. 84
Alignment and Tire Balance
.
Wheel ...................... 187
Aluminum Wheels
.............. 193
AM/FM Stereo
................ 88
With Cassette Tape and Compact
Disc Player
................ 93
With Cassette Tape Player ...... 89
Antenna
...................... 98
Anti-Lock Brakes
.............. 103
To Use ..................... 103
Appearance Care ............... I89
Appearance Care and Materials
.... 195
Appearance Care. Service and
..... 155
Approaching
a Hill .............. 1 10
Ashtrays and Lighter ............ 62
Ashtray. Front
................. 63
Ashtray. Rear .................. 63
Assist Grips. Passenger .......... 62
Add-on
Electrical Equipment
..... 196
Adjustable Steering Column
...... 53
Audio Systems ................. 87
Audio Systems. Comfort
Controls and
................. 83
Automatic
Freewheeling Hubs
........... 47
Transmission
................ 42
Transmission Fluid ............ 167
Axle. Front
.................... 170
Axle
. Rear .................... 169
Babies. Smaller Children
and (Safety Belts)
............. 26
Balance. Wheel Alignment
and Tire
.................... 187
Battery
....................... 176
BBB Auto Line
- Alternative Dispute
Resolution Program. GM
Participation
in ............. 235
Before Leaving
on a Long Trip .... 120
Belt. Lap-Shoulder .............. 20
Bi-Level ...................... 84
Bin. Coinholder and ............. 61
Bins. Instrument Panel ........... 61
Blizzard. If You’re Caught in a ... 124
Box. Glove
.................... 60
Brakes
Adjustment
.................. 176
Anti-Lock (ABS)
............. 103
Fluid ....................... 1 74
Master Cylinder
.......... 174
Parking
......... 48 Brakes
Pedal Travel
................. i76
System Parts. Replacing ........ 176
System Warning Light
......... 69
Trailer ...................... i27
Wear ...................... 175
Braking (Control of
a Vehicle) ..... 102
Braking
in Emergencies .......... 104
“Break.In. .. New Vehicle ........ 39
Bright Metal Parts. Protecting
Exterior
.................... 192
Brightness Control
.............. 57
Bulb Replacement .............. 177
Stoplight .................. 181
Headlights .................. 177
Rear Combination
............ 180
Rear Sidemarker
.............. 179
Sidemarker ......... . .179
Bulbs. Halogen
............... 177
Bulbs. Replacement
............. 199
Canadian Roadside Assistance ... 237
Canvas Top
Preparing for Storage
.......... 80
Special Care for
.............. 193
Capacities and Specifications
...... 200
Carbon Monoxide .............. 51
Center High-Mounted
Front Parking and Turn Signal
... 178
Removing and Installing Your
... 76
243 ...
ProCarManuals.com

Index
Fluid Automatic Transmission
....... 167
Brake
...................... 174
Manual Transmission
.......... 168
Power Steering ............... 173
Recommended
............... 225
Windshield Washer
........... 174
Foreign Countries. Fuels
in ....... 1.57
Foreign Material Paint Damage
.... 194
Four-wheel Drive
.............. 46
Four-wheel Drive (Service) ....... 170
Four-Wheel-Drive Vehicle. Off-Road
Driving With Your Geo
........ 108
Freeway Driving ............... 120
Freewheeling Hubs
Automatic
................. 47
Manual
..................... 46
Ashtray
..................... 63
Axle
....................... 170
Seat ........................ 10
Seat Side Pockets ............. 61
Seatbacks. Reclining .......... IO
Towing Hook-ups ............. 138
Fuel ......................... 156
FuelGage
..................... 69
Fuels in Foreign Countries ........ 157
Fuse Block, Instrument Panel ..... 198
Fuse Block, Main ............... 198
Fuses and Circuit Breakers ....... 196
Folding Rear
Seat
............... 13
Front Gages
Engine Coolant Temperature
.... 70
Fuel
....................... 69
Warning Lights and Indicators ... 68
Gasolines for Cleaner Air ........ 157
Glass
......................... 19 1
Glove Box .................... 60
GM Participation
in RBB Auto Line .
Alrernative Dispute Resolution
Program
.................. 235
Grips . Passenger Assist .......... 62
Guidelines. Driving ............. 107
Halogen Bulbs
............... 177
Hazard Warning Flashers
......... 132
Head Restraints
................ I1
Headlights .................... 177
Heater Controls
................ 84
Heater. Engine Coolant
(Block) .... 41
Heating ....................... 84
Highway Hypnosis
.............. 12 1
Hill and Mountain Roads ......... 121
Hill. Approaching a ............. 1 IO
Hitches ....................... 126
Hood Release .................. IS9
Hood . Checking Things under the . . 159
Hook.Ups . Front Towing ......... 138
Hook.Ups. Rear Towing
......... I39
Horn ......................... 53
Headlight High/Low Beam ....... 56
How to Add Coolant to the
How
to Add Coolant to the
Hubs. Freewheeling
Coolant
Recovery Tank
........ 142
Radiator
............... . .144
Automatic
................... 47
Manual
..................... 46
Hydroplaning .................. 118
Hypnosis. Highway
............. 121
Identification Number. Vehicle .... 196
Identification. Engine ............ 196
If a Tire Goes Flat .............. 146
If You’re Stuck: In Sand. Mud. Ice
or Snow .................... 153
Ignition Switch
................. 39
Incline
. Driving Across an ........ 113
Incline. Stalling on
an ........... 114
Intlation - Tire Pressure .......... 184
Inside Day/Night Rearview Mirror
...................... 59
Inside Rearview Mirror
.......... 59
Instrument Cluster .............. 66
Instrument Panel ............... 64
Instrument Panel Bins
........... 61
Instrument Panel Fuse Block ...... 198
Instrument Panel
. Cleaning the
Topof
..................... 191
Interior Lights ................. 57
Jump Starting
................. 133
... 246
ProCarManuals.com

Index
Steam Corning from Your Engine . . 140
Column. Adjustable
........... 53
Fluid. Power ................. 173
Power
...................... 104
Steering
...................... 104
In Emergencies ............... 105
Tips
........................ 104
Compartments. Door
.......... 60
Storage
Preparing Your Canvas Top for
. . 80
Vehicle
..................... 176
Stuck: In Sand. Mud. Ice or Snow
. . 153
Sun Visors
.................... 61
Sunroof. Opening and Closing
Your
....................... 74
Switch. Ignition
................ 39
Symbols. Vehicle
............... 7
Symbols. Safety Warnings and .... 5
Tachometer .................. 68
Tailgate
....................... 38
Tank. Filling Your .............. 158
Temperature Control Lever ....... 84
Terrain. Scanning
the ............ 109
Theft ......................... 39
Theft Deterrent Feature AM/FM Stereo
with Cassette Tape
AM/FM Stereo
with Cassette Tape
and Compact Disc Player
..... 96
Player
.................... 91
Thermostat .................... 172
... 250
Tips. Steering ................ 104
Tips. Ventilation
................ 87
Tires
......................... 183
Balance. Wheel Alignment and
. . 187
Buying New ................. 186
Chains
..................... 188
Inflation Pressure
............. 184
Inspection and Rotation
........ 185
Temperature Grades
........... 187
Traction Grades
.............. 187
Treadwear
................... 186
Uniform Quality Grading
....... 186
When It’s Time for New
....... 186
AM/FM Stereo
............... 89
and Compact Disc Player
..... 93
Player
.................... 90
Top Strap (Child Restraints)
....... 28
Top. Convertible
................ 72
Torque
Lock .................. 49
Towing
A Trailer .................... 125
Rear Hook-Ups
.............. 139
Recreational Vehicle
.......... 129
Your Vehicle
................. 136
Trailer Brakes
.................. 127
Changing a Flat .............. 146
Loading
.................... 18 I
Tone. Setting the
AM/FM Stereo
with Cassette Tape
AM/FM Stereo
with Cassette Tape
Front Hook-Ups
.............. 138 Trailer. Towing
a
............... 125
Transfer Case
.................. 47
Transfer Case (Service)
.......... 170
Transmission Automatic
................... 42
Fluid. Automatic
............. 167
Fluid. Manual
................ 168
Manual
..................... 44
Transportation. Courtesy
......... 237
Traveling to Remote Areas
....... 109
Trip Odometer
................. 67
Trip. Before Leaving on a Long
.... 120
Turn Signal and Lane Change
Indicator
.................... 54
Turn SignalLights Control/Headlight
Beam Lever
................. 54
Underbody Maintenance ....... 194
Understanding Radio Reception ... 97
Uniform Tire Quality Grading
..... 186
Uphill. Driving ................. 111
Used Oil. What to Do With ....... 165
Used Replacement Wheels
........ 189
Using the Recovery Hooks ....... 154
Vehicle Control of a
................. 102
Damage Warnings ............ 6
Dimensions ................. 202
Environment and Your
......... 204
Identification Number
(VIN) .... 196
ProCarManuals.com