air condition CHEVROLET TRACKER 1995 Owner's Manual

Maintenance Schedule I
60,000 Miles (100 000 km) (Continued)
test the cooling system and pressure cap.
An Emission Control Service.
0 Replace spark plugs. An Emission Control
Replace spark plug wires (or every
60 months, whichever occurs first).
0 Replace fuel filter (or every 30 months,
Service.
An Emission Control Service.
whichever occurs first, or sooner if filter is
clogged). An Emission Control Service.
0 Inspect the underhood wiring harness for
loose connections, chafed wires and
damage
(or every 60 months, whichever
occurs first).
An Emission Control Service.
0 Drain, refill and bleed the brake system.
0 Replace air cleaner filter. Replace filter
more often under dusty conditions.
An Emission Control Service.
0 Inspect fuel tank, cap and lines for damage
or leaks. Inspect fuel cap gasket
for any
damage. Replace parts as needed.
0 Rotate tires. See “Tire Inspection and
Rotation” in the Index for proper rotation
pattern
and additional information.
Change manual transmission fluid (or
every
15 months, whichever occurs first).
0 Inspect the valve lash and adjust if
necessary.
An Emission Control Service.
0 Check engine idle speed and adjust it to
underhood label specifications.
An Emission Control Service.?
An Emission Control Service. 3-
0 Inspect the locking front hubs (if equipped)
for correct operation (or every
3 months,
whichever occurs first). Repair or replace as
necessary.
7-22
ProCarManuals.com

I Maintenance Schedule I 1
72,000 Miles (120 000 km)
0 Change engine oil and filter (or every
3 months, whichever occurs first).
0 Rotate tires. See “Tire Inspection and
Rotation”
in the Index for proper rotation
pattern and additional information.
0 Inspect the locking front hubs (if equipped)
for correct operation (or every
3 months,
whichever occurs first). Repair or replace if
necessary.
An Emission Control Service.
R=Fl
ACTUAL MILEAGE SERVICED BY:
75,000 Miles (125 000 km)
0 Change engine oil and filter (or every
3 months, whichever occurs first).
An Emission Control Service.
0 Clean and repack the front wheel bearings
(or at each brake relining, whichever occurs
first).
in dusty conditions. Replace filter if
necessary.
An Emission Control Service.
0 Change manual transmission fluid (or every
15 months, whichever occurs first).
Inspect the valve lash and adjust if
necessary.
An Emission Control Service.
0 Check engine idle speed and adjust it to
underhood label specifications.
An Emission
Control Service.
t
0 Inspect air cleaner filter if you are driving
(Continued)
ProCarManuals.com

I Maintenance Schedule I 1
0 Drain, flush and refill cooling system (or
every
30 months, whichever occurs first).
See “Engine Coolant” in the Index for what
to use. Inspect hoses. Clean radiator,
condenser, pressure cap and neck. Pressure
test the cooling system and pressure cap.
An Emission Control Service.
0 Replace spark plugs. An Emission Control
0 Replace air cleaner filter. Replace filter
Service.
more often under dusty conditions.
An Emission Control Service.
0 Inspect fuel tank, cap and lines for damage
or leaks. Inspect fuel cap gasket for any
damage. Replace parts as needed.
An Emission Control Service.
0 Rotate tires. See “Tire Inspection and
Rotation” in the Index for proper rotation
pattern and additional information.
0 Change manual transmission fluid (or every
15 months, whichever occurs first).
0 Inspect the valve lash and adjust if
necessary.
An Emission Control Service.
0 Replace fuel filter (or every 30 months,
whichever occurs first, or sooner if filter is
clogged).
An Emission Control Service.
underhood label specifications. An Emission
Control Service.
0 Inspect the locking front hubs (if equipped)
for correct operation (or every
3 months,
whichever occurs first). Repair or replace as
necessary.
0 Check engine idle speed and adjust it to
(Continued)
ProCarManuals.com

Part C: Periodic Maintenance
Inspections
Listed below are inspections and services which should
be performed
at least twice a year (for instance, each
spring and fall). You should let your GM dealer’s
service department or other qualified service center do
these
jobs. Make sure any necessary repairs are
completed at once.
Restraint Systems
Now and then, make sure all your belts, buckles, latch
plates, retractors, anchorages and reminder systems are
working properly. Look for any loose parts or damage.
If you see anything that might keep a restraint system
from doing its job, have it repaired.
Steering, Suspension and Front-Wheel-
Drive Axle Boot and Seal Inspection
Inspect the front and rear suspension and steering
system for damaged, loose or missing parts, signs of
wear, or lack of lubrication. Inspect the power steering
lines and hoses for proper hookup, binding, leaks,
cracks, chafing, etc.,Clean and then inspect the drive
axle boot seals for damage, tears or leakage. Replace
seals
if necessary.
Exhaust System Inspection
Inspect the complete exhaust system. Inspect the body
near the exhaust system.
Look for broken, damaged,
missing or out-of-position parts as well as open seams,
holes, loose connections, or other conditions which
could cause
a heat build-up in the floor pan or could let
exhaust fumes into the vehicle. See “Engine Exhaust” in
the Index.
ProCarManuals.com

Throttle Linkage Inspection
Inspect the throttle linkage for interference or binding,
and for damaged or missing parts. Replace parts as
needed. Accelerator and cruise control cables should
not
be lubricated.
Rear Axle (All) and Front Axle
(Four-Wheel Drive) Service
Check the gear lubricant level and add if needed. See
“Rear Axle” and “Four-Wheel Drive”
in the Index. A
fluid loss may indicate a problem. Check the system(s),
and repair the system(s) if needed. Refer
to “Scheduled
Maintenance Services,” earlier
in this section, to
determine when to change the lubricant.
Brake System Inspection
Inspect the complete system. Inspect brake lines and
hoses for proper hookup, binding, leaks, cracks, chafing,
etc. Inspect disc brake pads for wear and rotors for
surface condition. Also inspect drum brake linings for
wear and cracks. Inspect other brake parts, including
drums, wheel cylinders, calipers, parking brake, etc.
Check parking brake adjustment.
You may need to have
your brakes inspected more often if your driving habits
or conditions result in frequent braking.
Clutch System Service
Check clutch pedal free travel and adjust as necessary.
See “Clutch Adjustment’’ in
the Index.
7-53
ProCarManuals.com

Service Manuals
Service manuals contain diagnosis and repair
information for all chassis and body systems. They
may
be useful for owners who wish to get a greater
understanding of their vehicle. They are also useful
for
owners with the appropriate skill level or training who
wish
to perform “do-it-yourself’ service. These are
authentic General Motors service manuals meant for
professional, qualified technicians.
Service Bulletins
Service bulletins covering various subjects are regularly sent to all General Motors’ dealerships. GM monitors
product performance in the field. When service methods
are found which promote better service on GM vehicles,
bulletins are created to help the technician perform better service. Service bulletins may involve any number of
vehicles. Some will describe inexpensive service; others will describe expensive service. Some will advise
of new
or unexpected conditions, and others may help avoid
future costly repairs. Service bulletins are meant for
qualified technicians. In some cases they refer to service manuals, specialized tools, equipment and safety
procedures necessary to service the vehicle. Since these
bulletins are issued throughout the model year and
beyond, an index
is required and published quarterly to
help identify specific bulletins. Subscriptions are
available. You can order an index at the toll-free numbers
listed previously, or ask a GM dealerhetailer to see
an
index or individual bulletin.
Owner Publications
Owner’s manuals, warranty folders and various owner
assistance booklets provide owners with general
operation and maintenance information.
8-8
-- ~ . .- ProCarManuals.com

Gee Section 9 Index
Adding Automatic Transmission Fluid
.................. 6-22
Brake Fluid
................................. 6-32
Electrical Equipment
.................... 2- 10. 6.59
Engine Coolant .............................. 6-26
Engineoil
.................................. 6-13
Manual Transmission Fluid
.................... 6-23
Power Steering Fluid
......................... 6-29
SoundEquipment
............................ 3-18
Windshield Washer Fluid
................. 2-3 1, 6-30
Adjustable Steering Column ...................... 2-27
Aircleaner
.................................... 6-16
Air Cleaner Filter Replacement
.................... 6- 18
Air Conditioning ................................ 3-3
Air Conditioning Controls ......................... 3-3
AirIntakeLever
................................. 3-2
Airflow Lever 3-
I
Alignment and Balance, Tires ..................... 6-46
Aluminum Wheels, Cleaning
...................... 6-56
Antifreeze
..................................... 6-25
Anti-Lock ..................................... 4-6
Anti-Lock Brakes
............................... 4-6
Appearance Care ............................... 6-49
Appearance Care and Materials
.................... 6-58
Ashtrays Front
...................................... 2-36
...................................
Antenna ...................................... 3-19 Rear
....................................... 2-37
Audio Systems
.................................. 3-5
Automatic Transmission
......................... 2-11
Drive
(D) Position ............................ 2-13
Low(L)Position
............................. 2-14
Neutral
(N) Position .......................... 2-13
Park (P) Position
............................. 2-11
Reverse (R) Position
.......................... 2-12
Second (2) Position
........................... 2-13
Starting Your Engine
........................... 2-9
Automatic Transmission Fluid
..................... 6-19
Adding .................................... 6-22
Checking
................................... 6-22
Axle, Front
.................................... 6-25
Axle, Rear
.................................... 6-24
Battery
...................................... 6-34
BBB Auto Line
................................. 8-3
Bi-Level
....................................... 3-2
Brake Warnings
.................................... 5-2
Blizzard
...................................... 4-38
Adjustment
................................. 6-33
Fluid, Adding
............................... 6-31
Master Cylinder
............................. 6-31
Parking
.................................... 2-20
PedalTravel
................................ 6-33
9-1
--.. p-.. ........ ... _-i-.-_'.-.-- ..... .=_ ___.~~~~-~_.i_i~.---~ ~~~ ..__________I ProCarManuals.com