engine CHEVROLET TRACKER 1996 Owners Manual

Part C: Periodic Maintenance
Inspections
Listed below are inspections and services which should
be performed at least twice a year (for instance, each
spring and fall). You should let your
GM dealer’s
service department or other qualified service center do
these jobs. Make sure any necessary repairs are
completed at once.
Proper procedures to perform these services may be
found
in a Geo service manual. See “Service and Owner
Publications” in the Index.
Steering, Suspension and Front- Wheel-Drive
Axle
Boot and Seal Inspection
Inspect the front and rear suspension and steering
system for damaged, loose or missing
parts, signs of
wear, or lack of lubrication. Inspect the power steering
lines and hoses for proper hook-up, binding, leaks,
cracks, chafing, etc. Clean and then inspect the drive
axle boot seals for damage, tears or leakage. Replace
seals if necessary.
Exhaust System Inspection
Inspect the complete exhaust system. Inspect the body
near the exhaust system.
Look for broken, damaged,
missing or out-of-position parts as well as open seams,
holes, loose connections, or other conditions which
could cause a heat build-up in the floor pan or could let
exhaust fumes into the vehicle. See “Engine Exhaust”
in
the Index.
Radiator and Heater Hose Inspection
Inspect the hoses and have them replaced if they are
cracked, swollen or deteriorated. Inspect all pipes,
fittings and clamps; replace as needed.
7-51
ProCarManuals.com

Part D: Recommended Fluids and
Lubricants
NOTE: Fluids and lubricants identified below by name,
part number or specification may be obtained from your
GM dealer.
USAGE
Engine Oil
Engine Coolant
FLUIDlLUBRICANT
Engine oil with the American
Petroleum Institute Certified For
Gasoline Engines “Starburst”
symbol
of the proper viscosity. To
determine the preferred viscosity
for your vehicle’s engine, see
“Engine Oil” in the Index.
50/50 mixture of clean water
(preferably distilled) and good
quality ethylene glycol base
antifreeze
(GM Part No. 1052753
or equivalent) conforming to GM
Specification 1825M
or approved
recycled coolant conforming
to
GM Specification 1825M. See
“Engine Coolant” in
the Index.
USAGE
Hydraulic Brake
System
Parking Brake
Cable Guides
Power Steering
System
Manual
Transmission
(All) and
Transfer Case
(4-Wheel-Drive)
~
Automatic
Transmission
Key Lock
Cylinders
FLUIDlLUBRICANT
Delco Supreme 11 @ Brake Fluid
(GM Part
No. 1052535 or
equivalent DOT-3 brake fluid).
Chassis lubricant (GM Part
No. 1052497 or equivalent) or
lubricant meeting requirements
of NLGI Grade 2, Category’ LB
or GC-LB.
DEXR0N’-I11 Automatic
Transmission Fluid.
GM Goodwrench Synthetic
Manual Transmission Gear Oil
(GM Part No. 12346190 - 1 qt.),
Castrol Syntorq@
LT or equivalent
SAE 75W-90 GL-4 gear oil.
DEXRON@-I11 Automatic
Transmission Fluid.
Multi-F‘urpose Lubricant, Superlube@
(GM Part No. 12346241
or equivalent).
7-53
ProCarManuals.com

Gem Section 9 Index
Air ~ag ...................................... I -24
Adding Equipment
............................ 1-30
How Does it Restrain
........................ 1-28
How it Works
.............................. 1-26
Location
.................................... l-26
Readiness Light ......................... 1-25, 2-61
Servicing
................................... 1-2 9
What Makes it Inflate
.......................... 1-27
What Will
You See After it Inflates ............... 1-28
AirCleaner
.................................... 6-13
Airconditioning
................................ 3-2
Air Conditioning Refrigerants ..................... 6-64
Alignment and Balance, Tire
...................... 6-46
Aluminum Wheels, Cleaning
...................... 6-54
Antenna
...................................... 3-19
Antifreeze
............................. 6-24
Anti-Lock
When Should it Inflate ......................... 1-27
Brake System Active Light ................. 2-64, 4-8
Brake System Warning Light
................ 2-63, 4-6
Brakes ...................................... 4- 6
Appearance Care ................................ 6-48 Appearance Care Materials
....................... 6-56
Arbitration Program .............................. 8-7
Audio Systems
.................................. 3-6
Overdrive
............................... 2-13
Overdrive
Off Switch .......................... 2-13
Shifting
..................................... 2-10
TEUIS~~SS~O~ ............................ 2-8.2-10
Transmission Check ........................... 7-48
Transmission Fluid
............................ 6-15
Transmission Operation
........................ 2-10
Transmission Park Mechanism Check
............. 7-50
Axle, Front
.................................... 6-23
Axle, Rear
. . ............................. 6-21
Ashtrays
...................................... 2-40
Automatic
Starting Your Engine
........................... 2-8
Battery
................. .: ................... 6-33
Jump Starting ................................. 5-2
Warnings
.................................... 5-2
BBB Auto Line ................................. 8-7
Better Business Bureau Mediation ................... 8-7
9-1
ProCarManuals.com

Driving City
........................................ 4-34
Defensive
.................................... 4-1
Drunken ..................................... 4-2
Freeway
.................................... 4-35
Guidelines
.................................. 4- 14
InaBlizzard ................................. 4-41
In. Foreign Countries ........................... 6-4
In the Rain
.................................. 4-31
Night ...................................... 4-29
Off-Road
................................... 4-14
On Curves.
.................................... 4-9
On Grades While Towing a Trailer ............... 4-53
On Hill and Mountain Roads .................... 4-37
On Snow
and Ice ............................. 4-40
Throughwater
............................... 4-33
WetRoads
.................................. 4-31
Winter
...................................... 4-39
With a Trailer
................................ 4-52
DrunkenDriving
................................ 4-2
Easy Entry Seat ................................ 1-4
Electrical
Equipment. Adding ................. 2-9. 6-57
Electrical System
............................... 6-57
Engine
........................................ 6-8
Coolant
..................................... 6-24
Coolant Level Check
.......................... 7-47 Coolant Temperature
Gage
. . ......... 2-64
Exhaust
................ ......... 2-25
Identification
...... ........... 6-57
Main Fuse Block ...... ......... 6-60
Oil Level Check ............ ......... 7-47
Overheating
................................. 5-12
Running While Parked
......................... 2-25
Specifications
................................ 6-62
Stating Your
............................. 2-8, 2-9
Engine Compartment
Main Fuse Block .............. 6-60
EngineOil ..................................... 6-9
Adding
.............. ................... 6 -10
Additives ................................... 6-12
Checking ................................... 6-10
Used
....................................... 6-13
When to Change
.............................. 6-12
Ethanol
........................................ 6-3
Exhaust, Engine
.................. .............. 2-25
Fabric Cleaning
............................... 6-49
Fifth
Gear, Manual Transmission ................... 2-14
FillingYourTank
................................ 6-4
Filter.
Air ..................................... 6-14
Finish Care
.................................... 6-52
FinishDamage
................................. 6-55
First Gear, Manual Transmission ................... 2-14
Flashers, Hazard Warning
......................... 5-1
9-4
ProCarManuals.com

Flash-to-Pass Feature .....
Flat Tire. Changing ...............
Fluid Capacities ......................
Fluids and Lubricants ................
Fourth Gear. Manual Transmission . .
Four-wheel Drive .............
French Language Manual . .
Front Axle ................
Foreign Countries. Fuel ...........
..... 2-30
..... 5-22
... 6-63
..... 7-53
...... 6-4
........ 2-14
..... 2.16. 6.22
.......... 6-23
.. ............. 11
Front Seat Side Pockets .......................... 2-39
Front Sidemarker Lamp Bulb Replacement
........... 6-37
FrontTowing
................................... 5-9
Fuel .......................................... 6-2
Front
Turn Signal Lamp Bulb Replacement
.......... 6-36
Canada
...................................... 6-3
DoorLock
................................... 6-5
Filling
Your Tank ............................... 6-4
Gage
....................................... 2-69
.Fuses and Circuit Breakers
....................... 6-58
In Foreign Countries ........................... 6-4
Gages Engine Coolant Temperature
............ ... 2-64
..................................... Fuel 2-69
GAWR ....................................... 4-46
Gear Positions, Automatic Transmission ............. 2- 10 Gear
Positions. Manual Transmission
............... 2-14
GloveBox
.................................... 2-39
Gross Axle Weight Rating
.... ................ 4-46
Guide en FranGais
, 11
GVWR ................ .................. 4-46
Gross Vehicle Weight Rating ...................... 4-46 .. ......... .....................
Halogen Bulbs ..................... .... 6-34
Hazard Warning Flashers
.............. . . 5-1
Head Restraints
..................... ....... 1-3
Headlamps
....................... ......... 2-29
High/Low Beam Changer
.................... 2-29
Highway Hypnosis
.............................. 4-37
Bulb
Replacement
............ ......... 6-34
Hearing Impaired, Customer Assistance
.............. 8-3
Heating ........................................ 3-3
Hill and Mountain Roads
......................... 4-37
Hitches, Trailer
........ ..................... 4-51
Hood Checking Things Under
............... ....... 6-6
Prop
..................... ............... 6-7
Release
...................................... 6-6
Horn
......................................... 2-28
Hubs. Freewheeling ............................. 2-17
Hydroplaning
.................................. 4-33
9-5
ProCarManuals.com

Ignition Positions ....... ............ 2-4
Inflation, Tire
................................ 6-41
Inside Daymight Rearview Mirror ................. 2-37
Inspections
.................................... 7-51
Exhaust Systems
............................. 7-5 1
Front-Wheel-Drive Axle Boot .................. 7-5 1
Front-Wheel-Drive Axle Seal ................... 7-5 1
Radiator and Heater Hose ...................... 7-51
RearAxle
................................... 7-52
Steering
.................................... 7-51
Suspension
................... ........... 7-51
Throttle Linkage
.............................. 7-52
Instrument Panel
............................... 2-56
Brightness Control
............................ 2-36
Cleaning
.................................... 6-51
Cluster ..................................... 2-58
Fuse Block .................................. 6-58
Interior
Lamps .................... ... 2-36
Brake
System
.... ....................... 7-52
Jack. Tire
....
Jump Starting . .
.................... 5-23
................... 5-2
Key Lock Cylinders Service ..................... 7-48 .
Keys .......................................... 2-1
Labels
Certification
................................. 4-46
Certification/Tire
............................. 4-46
Service Parts Identification ..................... 6-57
8 Tire-Loading Information ...................... 4-46
Vehicle Identification Number ................... 6-57
Lamps
...................................... 2-35
Dome ................. ........... 2-36
Interior
............ ......... 2-36
On Reminder ......... , ... ....... 2-29
Lamps Control
........................ . . 2-29
Leaving
Your Vehicle ............................. 2-4
Leaving Your Vehicle with the Engine Running
....... 2-22
Lighter
....................................... 2-40
Lights
Air Bag Readiness
................... 1-25.2.6. 2-61
Anti-Lock
Brake System Active ............. 2-64. 4-8
Anti-Lock Brake System Warning
....... . . 2.63, 4.6
Brake System Warning
........... .... 2-62
Charging System
........................... 2-61
Cruise ...................................... 2-33
Daytime Running Lamps Indicator ............... 2-69
Oil Pressure ................................. 2-67
Overdrive0
fi ................................ 2-69
Rear Window Defogger
......................... 3-5
9-6
ProCarManuals.com

Safety Belt Reminder ..................... 1-1 3. 2.60
Service Engine Soon
.......................... 2-65
Loading Your Vehicle
. . ..................... 4-46
Locks
............ ................... 2-3
Cylinders
....... ................ 7-48
Door ........... ................... 2-3
FuelDoor
.................................... 6-5
Key Lock Cylinder Service
..................... 7-48
PowerDoor
.................................. 2-3
Steering Column Lock Check
................ 1 .. 7-50
Window
.................................... 2-27
Rear Door Security
............................. 2-4
Low, Automatic Transmission
..................... 2- 12
Lowering and Raising the Canvas Top
.............. 2-49
Lubricants and Fluids
............................ 7-53
Lubrication Service, Body
........................ 7-48
Maintenance, Normal Replacement
Pa& ........... 6-62
Maintenance Record
............. ' ............... 7-55
Maintenance Schedule
............................ 7-1
Long Tripmighway Definition
................... 7-6
Long Tripmghway Intervals
................ 7-6, 7-32
Periodic Maintenance Inspections
................ 7-5 1
Owner Checks and Services ..................... 7-47
Recommended Fluids and Lubricants
............. 7-53
Scheduled Maintenance Services
... ............ 7-3 Short
Trip/City Definition
..................... 7-4
Short Trip/City Intervals
.................. 7.4,7. 7.8
Maintenance. Underbody
......................... 6-55
Maintenance When Trailer Towing
................. 4-55
Malfunction Indicator Lamp
...................... 2-65
Manual Adjust Mirror
........................... 2-37
ManualFrontSeat ............................... 1-1
Manual Transmission ........................ 2.8. 2.14
Shifting
.................. .................. 2-14
Starting Your Engine
........................... 2-8
Fluid
....................................... 6-19
Methanol
....................................... 6-3
Mirrors
....................................... 2-37
Convex Outside
.............................. 2-38
Inside Daymight Rearview
..................... 2-37
Manual Adjust ............................... 2-37
Power Remote Control ......................... 2-38
MMT ......................................... 6-3
Model Reference
......... ......... 111
Mountain Roads ............................ 4-37
Multifunction Lever
............................. 2-28
...
Neutral, Automatic Transmission ................. 2-11
Neutral, Manual Transmission
..................... 2-15
New Vehicle Break-In ............................ 2-6
Night Vision ................................. 4-30
9-7
ProCarManuals.com

Odometer .................................... 2-59
Odometer. Trip
................................. 2-59
Off-Road Driving
.............................. 4- 14
Off-Road Recovery
............................. 4- 11
Oil. Engine
...................................... 6-9
Oil Pressure Light
.............................. 2-67
Overdrive. Automatic Transmission ................ 2- 13
Overdrive
Off Light ............................. 2-69
Overheating Engine ............................. 5- 12
Owner Checks and Services ....................... 7-47
Owner Publications. Ordering
...................... 8-9
..... Paint Spotting. Chemical . . ... 6-55
Park
Automat.ic Transmission
..................... 2-10
Shifting Into ................................. 2-21
Shifting out
of .......... ... ... 2-23
Parking
AtNight
..................................... 2-6
Brake
...................................... 2-20
Brake Mechanism Check ....................... 7-50
Over Things That Bum ............ ..... 2-24
With a Trailer ................................ 4-54
Your Vehicle. Manual Transmission .............. 2-24
Parking Lamp Bulb Replacement .................. 6-36
Passenger Position .............................. 1-3 1 Passing
....................... ... .... 4-11
Power Periodic Maintenance Inspections
................ 7-51
Door Locks .............. .......... . .2-3
Remote Control Mirror ........................ 2-38
Steering
..................................... 4-9
Steering
Fluid ................................ 6-27
Windows ................................... 2-27
Power Mode Selector Switch
...................... 2-13
Pregnancy. Use
of Safety Belts .................... 1-31
Preparing Your Canvas
Top for Storage ............. 2-54
Problems
on the Road ............................ 5-1
Publications. Service and Owner
................ 8-9
Radiator. Coolant .............................. 5-19
Radiator Pressure Cap ........................... 6-26
Radios ........................................ 3-6
Rain. Driving
In ................................ 4-31
Rear
Axle ....................................... 6-21
Combination Lamp Bulb Replacement ............ 6-38
Seat Passengers .............................. 1-31
Sidemarker Lamp Bulb Replacement ............. 6-38
Radio Reception ................................ 3-17
Door Security Locks ........................... 2-4
Towing
..................................... 5-10
ProCarManuals.com

Larger CMdren .............................. 1-43
Passenger Position ............................ 1-3 1
Questions
and Answers ........................ 1-17
Reminder Light
......................... 1 - 13. 2.60
Replacing After
a Crash ........................ 1-46
Right Front Passenger Position
.................. 1-3 1
Smaller Children and Babies
.................... 1-35
Use During Pregnancy
........... : ............. 1-31
Safety Chains
................................... 4-51
Safety Defects. Reporting
......................... 8-8
'Safety Warnings and Symbols ....................... iv
Scheduled Maintenance Services
.................... 7-3
Seatback. Reclining Front
......................... 1-2
Seats
EasyEntry ................................. 1-4
ManualFront
................................. 1-1
Rear
.................................... 1-5. 1-9
Restraint Systems .............................. 1-1
Seat Controls
................................. 1-1
Securing a Child Restraint
...................... 1-37
Second Gear. Automatic Transmission .............. 2- 12
Second Gear. Manual Transmission
................. 2- 14
. RearSeat Passengers .......................... 1-31
WhyTheyWork
.............................. 1-14 Service
.............................. ... 6-1
Bulletins. Ordering ............................. 8-9
Engine Soon Light
............................ 2-65
Manuals. Ordering
............................. 8-9
Parts Identification Label ....................... 6-57
Publications. Ordering .......................... 8'9
Work. Doing Your
Own ......................... 6-1
Service and Appearance Care
...................... 6-1
Service and Owner Publications .................... 8-9
Service Publications
.............................. 8-9
Servicing Your
Air Bag-Equipped Geo .............. 1-29
SheetMetalDamage
............................ 6-54
Shift Lever ............................... 2-10. 2-14
ShiftSpeeds ................................... 2-15
Shifting Automatic Transmission
..................... 2-10
Into Park (P) ................................. 2-21
Manual Transmission .......................... 2-14
OutofPark .................................. 2-23
Side Window. Removing and Installing the
........... 2-47
SignalingWs
................................ 2-28
Skidding ...................................... 4-13
Sound Equipment. Adding
........................ 3-18
Specifications
and Capacities ...................... 6-62
9-10
. ProCarManuals.com

Specifications. Engine ................ ....... 6-62
Speech Impaired. Customer Assistance
............... 8-3
Speedometer ................................... 2- 59
Stains, Cleaning
................................ 6-50
Starter Switch Check
............................ 7-49
Steam
...................................... 5-12
Steering
......................... . . 4-9
Column Lock Check
............. ....... 7-50
Power
.................................. . . 4-9
Storage Areas
... ... .............. 2-39
Stuck: In Sand, Mud, Ice or Snow
.................. 5-33
Sun Visors .................................... 2-41
Sunroof
....................................... 2-43
Symbols, Vehicle
............. ............. vi
In Emergencies ............................. 4- 10
Tips
........................... ... I .*. 4-9
Storage, Vehicle
.............................. 6-33
Tachometer
................................ 2-59
Tailgate
........................................ 2-5
Tailgate Lock Release ............................ 2-5
Tape Player Care
............................... 3- 18
Theft-Deterrent Feature,
CD Player ................ 3-15
Thermostat
.................................... 6-26
Third Gear, Manual Transmission
.................. 2-14
Theft
.......................................... 2-5
Tire Chains ........................... . . 6-47
Tire Loading
................................. 4-46
Tire-Loading Information Label
................... 4-46
Tires
....................................... 6.40
Alignment and Balance
................. . . 6-46
Buying New
..................... .... 6-44
Chains ............................ . . 6-47
Changing
a Flat ....................... . . 5-22
Inflation
.................................... 6-41
Inflation Check
............................... 7-47
Cleaning
.................................. 6-54
Inspection and Rotation
........................ 6-42
Loading
.................................. 4-46
Temperature
............................... 6-45
Uniform Quality Grading
....................... 6-44
Wear Indicators
.............................. 6-43
Wheel Replacement
........................... 6-46
When It’s Time for New
....................... 6-43
Pressure
. . ... ................... 6-41
Traction
...................... .......... 6-45
Treadwear
................ ............ 6-45
TopStrap
..................................... 1-38
TorqueLock ................................... 2-23
Torque, Wheel Nut
......................... 5-31, 6-63
Towing a Trailer
................................ 4-48
Towing, Recreational Vehicle
..................... 4-43
Towing Your Vehicle
............................. 5-7
9-11
ProCarManuals.com