transmission fluid CHEVROLET TRACKER 1996 Owner's Manual

i Long TriplHighway Maintenance Schedule
50,000 Miles (83 000 km)
0 Change automatic transmission fluid and
filter
if the vehicle is mainly driven under
one or more
of these conditions:
- In heavy city traffic where the outside
temperature regularly reaches
90 OF
(32°C) or higher.
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or
delivery service.
If you do not use your vehicle under any of these
conditions, thefluid
andfilter do not require changing.
0 Replace Positive Crankcase Ventilation
(PCV) valve. Replace any worn, plugged or
collapsed hoses. An Emission Control Service.
7-38
ProCarManuals.com

Long Trip/Highway Maintenance Schedule
60,000 Miles (100 000 km) (Continued)
0 Drain, flush and refill cooling system (or
every
30 months, whichever occurs first).
See “Engine Coolant”
in the Index for
what to use. Inspect hoses. Clean radiator,
condenser, pressure cap and neck. Pressure
test the cooling system and pressure cap.
An Emission Control Service.
0 Replace spark plugs.
An Emission Control Service.
Replace air cleaner filter.
An Emission Control Service.
Inspect fuel tank, cap and lines and any
hoses for damage. Replace fuel tank cap
gasket.
An Emission Control Service,
17 Change manual transmission fluid (or every
30 months, whichever occurs first).
0 Replace fuel filter (or every 30 months,
whichever occurs first).
An Emission Control Service.
17 Inspect the locking front hubs (if equipped)
for correct operation (or every
3 months,
whichever occurs first). Repair or replace
as necessary.
0 Inspect the valve lash and adjust if
necessary.
An Emission Control Service.
0 Check engine idle speed and adjust it to
underhood label specifications.
An Emission Control Service.?
7-40
ProCarManuals.com

I Long Trip/Highway Maintenance Schedule
90,000 Miles (150 000 km)
0 Change engine oil and filter (or every
7.5 months, whichever occurs first).
An Emission Control Service.
0 Clean and repack the front wheel bearings
(or at each brake relining, whichever
occurs first).
0 Inspect engine accessory drive belts (or
every
24 months, whichever occurs first).
An Emission Control Service.
0 Inspect camshaft timing belt.
0 Drain, flush and refill cooling system (or
every
30 months, whichever occurs first).
See “Engine Coolant”
in the Index for
what to use. Inspect hoses. Clean radiator,
condenser, pressure cap and neck. Pressure
test the cooling system and pressure cap.
An Emission Control Service.
An
Emission Control Service.
Replace spark plugs.
An Emission Control Service.
0 Replace air cleaner filter.
An Emission Control Service.
0 Inspect fuel tank, cap and lines and any
hoses for damage. Replace fuel tank cap
gasket. An Emission Control Service.
CI Change manual transmission fluid (or every
30 months, whichever occurs first).
[7 Replace fuel filter (or every 30 months,
whichever occurs first).
An Emission Control Service.
0 Inspect the locking front hubs (if equipped)
for correct operation (or every 3 months,
whichever occurs first). Repair or replace
if necessary.
0 Inspect the valve lash and adjust if
necessary. An Emission Control Service.
7-44
ProCarManuals.com

r Long Trip/Highway Maintenance Schedule
100,000 Miles (1 66 000 km)
0 Change automatic, transmission fluid and
filter if the vehicle is mainly driven under
one or more of these conditions:
- In heavy city traffic where the outside
temperature regularly reaches
90 OF
(32 O C) or higher.
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or
delivery service.
If you do not use your vehicle under any of these
conditions,
the fluid andfilter do not require changing.
0 Replace Positive Crankcase Ventilation
(PCV) valve. Replace any worn, plugged or
collapsed hoses.
An Emission Control Service.
0 Inspect Exhaust Gas Recirculation (EGR)
17 Inspect fuel injector.
system. An Emission Control Service.
An Emission Control Service.
0 Replace evaporative emissions canister.
An Emissitin Control Service.
DATE SERVICED BY: ACTUAL MILEAGE
7-46
ProCarManuals.com

At Least Twice a Year Automatic Transmission Check
Restraint System Check
Make sure the safety belt reminder light and all your
belts, buckles, latch plates, retractors and anchorages are
working properly.
Look for any other loose or damaged
safety belt system parts.
If you see anything that might
keep a safety belt system from doing its job, have it
repaired. Have
any torn or frayed safety belts replaced.
Also look for any opened or broken air bag covers, and
have them repaired or replaced.
(The air bag system
does not need regular maintenance.)
Fluid Level Check
Check the transfer case, axle differential(s) and
automatic
or manual transmission fluid levels and add as
needed. See “Transfer Case,” “Axle, Rear,” “Axle,
Front” and “Automatic Transmission” or “Manual
Transmission”
in the Index. A fluid loss in these systems
could indicate a problem. Have the system inspected and
repaired
at once.
Check the transmission fluid level; add if needed. See
“Automatic Transmission”
in the Index. A fluid IOSS may
indicate
a problem. Check the system and repair if needed.
At Least Once a Year
Key Lock Cylinders Service
Lubricate the key lock cylinders with the lubricant
specified
in Part D.
Body Lubrication Service
Lubricate all body door hinges. Also lubricate all hinges
and latches, including those for the hood, rear
compartment, glove box door, console door and any
folding seat hardware.
Part D tells you what to use.
More frequent lubrication may be required when
exposed
to a corrosive environment.
7-48
ProCarManuals.com

Part D: Recommended Fluids and
Lubricants
NOTE: Fluids and lubricants identified below by name,
part number or specification may be obtained from your
GM dealer.
USAGE
Engine Oil
Engine Coolant
FLUIDlLUBRICANT
Engine oil with the American
Petroleum Institute Certified For
Gasoline Engines “Starburst”
symbol
of the proper viscosity. To
determine the preferred viscosity
for your vehicle’s engine, see
“Engine Oil” in the Index.
50/50 mixture of clean water
(preferably distilled) and good
quality ethylene glycol base
antifreeze
(GM Part No. 1052753
or equivalent) conforming to GM
Specification 1825M
or approved
recycled coolant conforming
to
GM Specification 1825M. See
“Engine Coolant” in
the Index.
USAGE
Hydraulic Brake
System
Parking Brake
Cable Guides
Power Steering
System
Manual
Transmission
(All) and
Transfer Case
(4-Wheel-Drive)
~
Automatic
Transmission
Key Lock
Cylinders
FLUIDlLUBRICANT
Delco Supreme 11 @ Brake Fluid
(GM Part
No. 1052535 or
equivalent DOT-3 brake fluid).
Chassis lubricant (GM Part
No. 1052497 or equivalent) or
lubricant meeting requirements
of NLGI Grade 2, Category’ LB
or GC-LB.
DEXR0N’-I11 Automatic
Transmission Fluid.
GM Goodwrench Synthetic
Manual Transmission Gear Oil
(GM Part No. 12346190 - 1 qt.),
Castrol Syntorq@
LT or equivalent
SAE 75W-90 GL-4 gear oil.
DEXRON@-I11 Automatic
Transmission Fluid.
Multi-F‘urpose Lubricant, Superlube@
(GM Part No. 12346241
or equivalent).
7-53
ProCarManuals.com

USAGE
Manual
Transmission
Shift Linkage Clutch Linkage
Pivot Points
Floor Shift
Litikage
Chassis
Lubrication
Zear Axle (All)
md Front Axle
:Four-wheel
Drive)
FLUID/LUBRICANT
Chassis lubricant (GM Part
No. 1052497 or equivalent) or
lubricant meeting requirements
of NLGI Grade 2, Category LB
or GC-LB.
Lithium base grease.
Lubriplate Lubricant aerosol
(GM
Part No. 12346293 or equivalent)
OF lubricant meeting requirements
of
NLGI Grade 2 Cat.egory LB or
Chassis lubricant (GM
Part
No. 1052497 or equivalent) or
lubricant meeting requirements
of NLGI Grade 2, Category LB
or GC-LB.
Axle Lubricant (GM Part
No. 12345977) or SAE $OW-90
GL-5 Gear Lubricant.
GC-LB.
USAGE
(GM Part No. 105 15 15) or Washer Solvent
GM Optikleen@ Washer Solvent
Windshield
. FLUINLUBRICANT
Hood Latch
Lubriplate lubricant aerosol (GM
Assembly Pivots, Part No. 12346293 or equivalent)
Spring Anchor
or lubricant meeting requirements
and Release
or GC-LB. Pawl
of NLGI Grade 2, Category LB
Hood and Door Multi-purpose lubricant, Superlube@
Hinges (GM
Part No. 12346241 or
equivalent.
equivalent).
Weatherstrip
Part No. 12345579 or equivalent).
Conditioning Dielectric
Silicone Grease (GM
See “Replacement
Parts” in the Index for recommended
replacement filters, valves and spark
plugs.
7-54
ProCarManuals.com

Gem Section 9 Index
Air ~ag ...................................... I -24
Adding Equipment
............................ 1-30
How Does it Restrain
........................ 1-28
How it Works
.............................. 1-26
Location
.................................... l-26
Readiness Light ......................... 1-25, 2-61
Servicing
................................... 1-2 9
What Makes it Inflate
.......................... 1-27
What Will
You See After it Inflates ............... 1-28
AirCleaner
.................................... 6-13
Airconditioning
................................ 3-2
Air Conditioning Refrigerants ..................... 6-64
Alignment and Balance, Tire
...................... 6-46
Aluminum Wheels, Cleaning
...................... 6-54
Antenna
...................................... 3-19
Antifreeze
............................. 6-24
Anti-Lock
When Should it Inflate ......................... 1-27
Brake System Active Light ................. 2-64, 4-8
Brake System Warning Light
................ 2-63, 4-6
Brakes ...................................... 4- 6
Appearance Care ................................ 6-48 Appearance Care Materials
....................... 6-56
Arbitration Program .............................. 8-7
Audio Systems
.................................. 3-6
Overdrive
............................... 2-13
Overdrive
Off Switch .......................... 2-13
Shifting
..................................... 2-10
TEUIS~~SS~O~ ............................ 2-8.2-10
Transmission Check ........................... 7-48
Transmission Fluid
............................ 6-15
Transmission Operation
........................ 2-10
Transmission Park Mechanism Check
............. 7-50
Axle, Front
.................................... 6-23
Axle, Rear
. . ............................. 6-21
Ashtrays
...................................... 2-40
Automatic
Starting Your Engine
........................... 2-8
Battery
................. .: ................... 6-33
Jump Starting ................................. 5-2
Warnings
.................................... 5-2
BBB Auto Line ................................. 8-7
Better Business Bureau Mediation ................... 8-7
9-1
ProCarManuals.com

Brake Adjustment
.................................. 6-33
Fluid
....................................... 6-29
Master Cylinder
.............................. 6-29
Parking
..................................... 2-20
PedalTravel
................................. 6-32
Replacing System Parts
........................ 6-33
System Warning Light
......................... 2-62
Trailer
...................................... 4-51
Transmission Shift Interlock
.................... 2-23
Transmission Shift Interlock Check
............... 7-49
Wear
....................................... 6-32
Brakes.Ant i.Lock ............................... 4-6
Braking ........................................ 4-5
Braking in Emergencies
..... ................ 4-8
Break.In. New Vehicle
....................... 2-6
Brightness Control .............................. 2-36
BTSI
......................................... 2-23
BTSICheck
................................... 7-49
Bulb Replacement
.............................. 6-34
Canadian Roadside Assistance
. . ........ 8-6
Canvas Top And Plastic Window Care
...................... 6-53
Lowering
and Raising ......................... 2-49
Preparing for Storage
.......................... 2-54
Removing and Installing
....................... 2-53 Capacities and Specifications
.................... 6-62
Carbon Monoxide
......................... 2.25, 4.42
Cassette Deck Service
........................... 7-47
Cassette Tape Player
.................. . . 3.8, 3.11
Cassette Tape Player Care
........... ........ 3-18
CD Player Theft-Deterrent Feature
................. 3-15
Certification Label
.............................. 4-46
Certificationmire Label
........................ 4-46
Chains. Safety
.................... ........ 4-51
Chains. Tire ...................... ........ 6-47
Changing a
Flat Tire .............. ........... 5-22
Charging System Light
.......................... 2-61
Checking Your Restraint Systems
.................. 1-46
Chemical Paint Spotting .......................... 6-55
Child Restraints
...................... ...... 1-37
Securing in a Rear Seat Position
......... ... 1-38
Securing in the Right Front Seat Position . . ... 1-40
TopStrap
................................. 1-38
WheretoPut
................................ 1-37
Cigarette Lighter
............................... 2-40
Circuit Breakers and Fuses
....................... 6-58
Cleaner. Air
................................... 6-13
Cleaning Aluminum Wheels
............................ 6-54
Canvas Top and Plastic Window ................. 6-53
Fabric
...................................... 6-49
Glass
....................................... 6-51
InsideofYourGeo ............................ 6-48
9-2
ProCarManuals.com

Flash-to-Pass Feature .....
Flat Tire. Changing ...............
Fluid Capacities ......................
Fluids and Lubricants ................
Fourth Gear. Manual Transmission . .
Four-wheel Drive .............
French Language Manual . .
Front Axle ................
Foreign Countries. Fuel ...........
..... 2-30
..... 5-22
... 6-63
..... 7-53
...... 6-4
........ 2-14
..... 2.16. 6.22
.......... 6-23
.. ............. 11
Front Seat Side Pockets .......................... 2-39
Front Sidemarker Lamp Bulb Replacement
........... 6-37
FrontTowing
................................... 5-9
Fuel .......................................... 6-2
Front
Turn Signal Lamp Bulb Replacement
.......... 6-36
Canada
...................................... 6-3
DoorLock
................................... 6-5
Filling
Your Tank ............................... 6-4
Gage
....................................... 2-69
.Fuses and Circuit Breakers
....................... 6-58
In Foreign Countries ........................... 6-4
Gages Engine Coolant Temperature
............ ... 2-64
..................................... Fuel 2-69
GAWR ....................................... 4-46
Gear Positions, Automatic Transmission ............. 2- 10 Gear
Positions. Manual Transmission
............... 2-14
GloveBox
.................................... 2-39
Gross Axle Weight Rating
.... ................ 4-46
Guide en FranGais
, 11
GVWR ................ .................. 4-46
Gross Vehicle Weight Rating ...................... 4-46 .. ......... .....................
Halogen Bulbs ..................... .... 6-34
Hazard Warning Flashers
.............. . . 5-1
Head Restraints
..................... ....... 1-3
Headlamps
....................... ......... 2-29
High/Low Beam Changer
.................... 2-29
Highway Hypnosis
.............................. 4-37
Bulb
Replacement
............ ......... 6-34
Hearing Impaired, Customer Assistance
.............. 8-3
Heating ........................................ 3-3
Hill and Mountain Roads
......................... 4-37
Hitches, Trailer
........ ..................... 4-51
Hood Checking Things Under
............... ....... 6-6
Prop
..................... ............... 6-7
Release
...................................... 6-6
Horn
......................................... 2-28
Hubs. Freewheeling ............................. 2-17
Hydroplaning
.................................. 4-33
9-5
ProCarManuals.com