maintenance CHEVROLET TRACKER 1997 Repair Manual
[x] Cancel search | Manufacturer: CHEVROLET, Model Year: 1997, Model line: TRACKER, Model: CHEVROLET TRACKER 1997Pages: 388, PDF Size: 20.12 MB
Page 347 of 388

Long Tripmighway Maintenance Schedule 1
I7 Check engine idle speed and adjust it to
underhood label specifications.
An Emission Control Service. (See footnote?.)
0 Inspect propeller shafts and u-joints for
looseness and damage (or every
15 months,
whichever occurs first). Inspect more
frequently if used off-road or for pulling a
trailer. Tighten u-joint flange bolts
if necessary.
DATE SERVICED BY: ACTUAL MILEAGE
82,500 Miles (137 500 km)
17 Change engine oil and filter (or every
7.5 months, whichever occurs first).
17 Rotate tires. See “Tire Inspection and
Rotation’’ in the Index for proper rotation
pattern and additional information.
(See footnote
+.)
0 Inspect the locking front hubs (if equipped)
for correct operation
(or every 3 months,
whichever occurs first). Repair or replace
if necessary.
An Emission Control Service.
7-45
ProCarManuals.com
Page 348 of 388

Long ”rip/Highway Maintenance Schedule I
90,000 Miles (150 000 km)
0 Change engine oil and filter (or every
7.5 months, whichever occurs first).
An Emission Control Service.
0 Clean and repack the front wheel bearings
(or at each brake relining, whichever
occurs first).
Inspect engine accessory drive belts (or
every
24 months, whichever occurs first).
An Emission Control Service.
0 Inspect camshaft timing belt.
An Emission Control Service. (See footnote ?.)
0 Drain, flush and refill cooling system (or
every
30 months, whichever occurs first).
See “Engine Coolant” in the Index for what
to use. Inspect hoses. Clean radiator,
condenser, pressure cap and neck. Pressure
test the cooling system and pressure cap.
An Emission Control Sewice. (See footnote?.)
0 Replace spark plugs.
0 Replace air cleaner filter.
0 Inspect fuel tank, cap and lines and any
hoses for damage or leaks. Replace fuel
tank cap gasket.
An Emission Control Service.
(See footnote T.)
0 Change manual transmission fluid (or every
30 months, whichever occurs first).
0 Replace fuel filter (or every 30 months,
whichever occurs first).
An Emission Control
Service. (See footnote “f )
0 Inspect the locking front hubs (if equipped)
for correct operation (or every
3 months,
whichever occurs first). Repair or replace
if necessary.
An Emission. Control Service.
An Emission Control
Service.
7-46
ProCarManuals.com
Page 350 of 388

Long Tripmighway Maintenance Schedule I
100,000 Miles (1 66 000 km)
0 Change automatic transmission fluid and
filter if the vehicle is mainly driven under
one or more
of these conditions:
- In heavy city traffic where the outside
temperature regularly reaches
90 O F
(32°C) or higher.
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or
delivery service.
lfyo~l do not use your vehicle under any of
these conditions, the.fZuid and filter do not
require changing.
0 Replace Positive Crankcase Ventilation
(PCV) valve. Replace any worn, plugged or
collapsed hoses.
An Emission Control Service.
17 Inspect Exhaust Gas Recirculation (EGR)
0 Inspect fuel injector.
0 Replace evaporative emissions canister.
system.
An Emission Control Service.
An Emission
Control Service.
An Emission Control Service.
DATE
SERVICED BY ACTUAL MILEAGE
7-48
ProCarManuals.com
Page 352 of 388

At Least Twice a Year Automatic Transmission Check
Restraint System Check
Make sure the safety belt reminder light and all your
belts, buckles, latch plates, retractors and anchorages are
working properly.
Look for any other loose or damaged
safety belt system parts. If you see anything that might
keep a safety belt system from doing its job, have it
repaired. Have any torn or frayed safety belts replaced.
Also look for any opened or broken air bag coverings,
and have them repaired or replaced. (The air bag system
does not need regular maintenance.)
Wiper Blade Check
Inspect wiper blades for wear or cracking. Replace blade
inserts that appear worn
or damaged or that streak or
miss areas of the windshield. Also
see “Wiper Blades,
Cleaning”
in the Index.
Fluid Level Check
Check the transfer case, axle differential(s) and
automatic or manual transmission fluid levels and add as
needed. See “Transfer Case,” “Axle, Rear,”
“Axle, Front” and “Automatic Transmission” or
“Manual Transmission”
in the Index. Check for leaks.
A fluid loss in these systems could indicate a problem.
Have the system inspected and repaired at once. Check
the transmission fluid level; add if needed. See
“Automatic Transmission” in the Index. A fluid
loss
may indicate a problem. Check the system and repair
if needed.
At Least Once a Year
Key Lock Cylinders Service
Lubricate the key lock cylinders with the lubricant
specified in Part
D.
Body Lubrication Service
Lubricate all body door hinges. Also lubricate all hinges
and latches, including those for the hood, rear
compartment, glove box door, console door and any
folding seat hardware. Part
D tells you what to use.
More frequent lubrication may be required when
exposed to a corrosive environment.
7-50
ProCarManuals.com
Page 355 of 388

I
Part C: Periodic Maintenance
Inspections
Listed below are inspections and services which should
be performed at least twice a year (for instance, each spring and fall). You should let your
GM dealer’s
service department or other qualified service center do
these
jobs. Make sure any necessary repairs are
completed at once.
Proper procedures to perform these services may be
found in a
GM service manual. See “Service and Owner
Publications” in the Index.
Steering, Suspension and Front Drive Axle
Boot and Seal Inspection
Inspect the front and rear suspension and steering
system for damaged, loose
or missing parts, signs of
wear
or lack of lubrication. Inspect the power steering
lines and hoses
for proper hook-up, binding, leaks,
cracks, chafing,
etc. Clean and then inspect the drive
axle boot seals for damage, tears or leakage. Replace
seals if necessary.
Exhaust System Inspection
Inspect the complete exhaust system. Inspect the body
near the exhaust system. Look
for broken, damaged,
missing or out-of-position parts as well
as open seams,
holes, loose connections or other conditions which could
cause a heat build-up in the floor pan or could let
exhaust fumes into the vehicle. See “Engine Exhaust” in
the Index.
Radiator and Heater Hose Inspection
Inspect the hoses and have them replaced if they are
cracked, swollen
or deteriorated. Inspect all pipes,
fittings and clamps; replace as needed.
7-53
ProCarManuals.com
Page 356 of 388

Throttle Linkage Inspection
Inspect the throttle linkage for interference or binding,
and for damage or missing parts. Replace parts as
needed. Replace any cables that have high effort or
excessive wear.
Do not lubricate accelerator and cruise
control cables.
Rear Axle (All) and Front Axle
(Four-wheel Drive) Service
Check the gear lubricant level and add if needed. See
“Rear Axle” and “Four-wheel Drive” in
the Index. A
fluid loss may indicate a problem. Check the system(s),
and repair the system(s) if needed. Refer to “Scheduled
Maintenance Services,” earlier
in this section, to
determine when to change the lubricant.
Brake System Inspection
Inspect the complete system. Inspect brake lines and
hoses for proper hook-up, binding, leaks, cracks,
chafing, etc. Inspect disc brake pads for wear and rotors
for surface condition. Also inspect drum brake linings
for wear and cracks. Inspect other brake parts, including
drums, wheel cylinders, calipers, parking brake, etc.
Check parking brake adjustment. You may need to have
your brakes inspected more often if your driving habits
or conditions result in frequent braking.
Clutch System Service
Check clutch pedal free travel and adjust as necessary.
See “Clutch Adjustment’’ in the Index.
7-54
ProCarManuals.com
Page 359 of 388

Part E: Maintenance Record
After the scheduled services are performed, record the
date, odometer reading and who performed the service
in
the boxes provided after the maintenance interval. Any
additional information
from “Owner Checks and
Services” or “Periodic Maintenance” can be added on
the following record pages.
Also, you should retain all
maintenance receipts. Your owner information portfolio
is a convenient place to store them.
I
Maintenance Record
ODOMETER
DATE MAINTENANCE PERFORMED
SERVICED
BY READJNG
7-57
ProCarManuals.com
Page 360 of 388

Maintenance Record
7-58
ProCarManuals.com
Page 372 of 388

1997 CHEVROLET/GEO SERVICE PUBLICATIONS ORDERING INFORMATION
The following publications covering the operation and servicing of your vehicle can be purchased by filling out
the Service Publication
Order Form in this book and mailing it in with your check, money o\
rder,
or credit card information to Helm, Incorporated (address below.)
~~ ~~
CURRENT PUBLICATIONS FOR 1997 CHEVROLETIGEO
SERVICE MANUALS
Service Manuals have the diagnosis and repair information
on engines, transmission, axle, suspension, brakes,
electrical, steering, body, etc.
RETAIL SELL PRICE:
$90.00
TRANSMISSION, TRANSAXLE, TRANSFER CASE UNIT REPAIR MANUAL
This manual provides information on unit repair service
procedures, adjustments and specifications for the
1997
GM transmissions, transaxles and transfer cases.
RETAIL SELL PRICE: $40.00
SERVICE BULLETINS
Service Bulletins give technical service information needed
to knowledgeably service General Motors cars and trucks.
Each bulletin contains instructions to assist in the
diagnosis and service of your vehicle.
PLEASE COMPLETE THE ORDER FORM SHOWN ON
THE FOLLOWING PAGE AND MAIL TO:
Helm, Incorporated P.O. Box 07130 Detroit, MI 48207
OWNER’S INFORMATION
Owner publications are written directly for Owners and
intended to provide basic operational information about the
vehicle. The owner’s manual will include the Maintenance
Schedule for all models.
In-Portfolio: Includes a Portfolio, Owner’s Manual and
Warranty Booklet. RETAIL SELL PRICE:
$15.00
Without Portfolio: Owner’s Manual only.
RETAIL SELL PRICE:
$1 0.00
CURRENT & PAST MODEL ORDER FORMS
Service Publications are available for current and past
model GM vehicles. To request an order form, please
specify year and model name of the vehicle.
OR ORDER TOLL FREE: 1-800-782-4356
Monday-Friday 8:OO AM - 6:OO PM Eastern Time
For Credit Card Orders Only
(VlSA-MasterCard-Discover)
ProCarManuals.com
Page 381 of 388

Methanol ...................................... 6-4
Mirrors
....................................... 2-39
Convex Outside
.............................. 2-41
ManualAdjust
............................... 2-40
Power Remote Control
......................... 2-40
MMT
......................................... 6-4
ModelReference
................................. 111
Mountain Roads ................................ 4-38
Multifunction Lever
............................. 2-29
...
Neutral. Automatic Transmission ................. 2- 12
Neutral. Manual Transmission
..................... 2- 15
New Vehicle Break-In
............................ 2-7
Nightvision
................................... 4-31
Odometer
.................................... 2-61
Odometer. Trip
................................. 2-61
Off-Road Driving
.............................. 4- 15
Off-RoadRecovery
............................. 4-12
Oil. Engine
.................................... 6-10
Oil Pressure Light
......................... 2.69. 6. IO
Overdrive. Automatic Transmission ................ 2- 14
Overdrive Off Light ............................. 2-71
Overheating Engine
............................. 5 . 13
Owner Checks and Services
....................... 7-49
Owner Publications. Ordering
..................... 8- 11
Paint Spotting. Chemical
........................ 6-56
Park
Automatic Transmission
....................... 2- 10 Shifting Into
................................. 2-23
Shifting Out of
............................... 2-25
AtNight
..................................... 2-6
Brake
...................................... 2-21
Brake Mechanism Check
....................... 7-52
Over Things That Burn
........................ 2-26
With a Trailer
................................ 4-55
Your Vehicle. Manual Transmission
.............. 2-26
Parking Lamp Bulb Replacement
.................. 6-35
Passenger Position
......................... 1.25. 1-31
Parking
Passing
....................................... 4-12
Periodic Maintenance Inspections
.................. 7-53
DoorLocks
................................... 2-4
Remote Control Mirror
........................ 2-40
Steering
.................................... 4-10
Steering Fluid
................................ 6-26
Windows
................................... 2-28
Power Indicator Light
........................... 2-70
Power Mode Selector Switch
...................... 2-14
Pregnancy. Use of Safety Belts
.................... 1-24
Problems on the Road
............................ 5-1
Publications. Service and Owner ................... 8-11
Radiator. Coolant .............................. 5-20
Radiator Pressure Cap
........................... 6-26
Radio Reception
................................ 3-17
Radios ............................... 3-7.3-8. 3-11
Rain. Driving In
................................ 4-32
Preparing
Your Canvas Top for Storage ............. 2-56
9-7
ProCarManuals.com