brake fluid CHEVROLET TRACKER 1998 1.G User Guide

Downloaded from www.Manualslib.com manuals search engine What to Add
When you do need brake fluid, use only DOT-3
brake fluid
-- such as Delco Supreme 11 @ (GM Part
No. 12377967). Use new brake fluid from a sealed
container only.
Always clean the brake fluid reservoir cap and the area
around the cap before removing it. This will help keep
dirt from entering the reservoir.
I
With the wrong kind of fluid in your brake
system, your brakes may not work well, or they
may not even work at
all. This could cause a
crash. Always use the proper brake fluid.
NOTICE:
0
0
Using the wrong fluid can badly damage
brake system parts. For example, just
a few
drops of mineral-based oil, such as engine
oil, in your brake system
can damage brake
system parts
so badly that they’ll have to be
replaced. Don’t let someone put in the
wrong kind of fluid.
If you spill brake fluid on your vehicle’s
painted surfaces, the paint finish can be
damaged. Be careful not
to spill brake fluid
on your vehicle.
If you do, wash it off
immediately. See “Appearance Care” in
the Index.
6-31
-

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
I 1
I Short Trip/City Definition
Follow the Short Trip/City Maintenance Schedule if
any one of these conditions is true for your vehicle:
Most trips are less than 5 to 10 miles (8 to 16 km).
This is particularly important when outside
temperatures are below freezing.
driving in stop-and-go traffic).
of your vehicle. or other commercial application.
Most trips include extensive idling (such as frequent
You frequently tow a trailer or use a carrier on top
If the vehicle is used for delivery service, police, taxi
One of the reasons you should follow this schedule
if you operate your vehicle under any of these
conditions is that these conditions cause engine
oil to break down soonex
I Short Trip/City Intervals
Every 3,000 Miles (5 000 km): Engine Oil and
Filter Change (or
3 months, whichever occurs first).
Free-Wheeling
Hubs Inspection (if equipped)
(or
3 months, whichever occurs first).
Every 6,000 Miles (10 000 km): Tire Rotation.
Every 15,000 Miles (25 000 km): Air Cleaner Filter
Inspection,
if driving in dusty conditions. Front
Wheel Bearing Repack
(2WD only) (or at each
brake relining, whichever occurs first). Automatic
Transmission Service (severe conditions only).
Manual Transmission Fluid Change. Transfer Case
Fluid Change. Differential Fluid Change. Engine Idle
Speed Check. Valve Lash (Clearance) Adjustment.
Propeller Shafts and U-Joints Inspection (or every
15 months, whichever occurs fist).
Every 30,000 Miles (50 000 km): Air Cleaner Filter
Replacement. Spark Plug Replacement. Engine
Accessory Drive Belt Inspection (or every
24 months,
whichever occurs first). Cooling System Service
(or every
30 months, whichever occurs first). Fuel
Filter Replacement (or every
30 months, whichever
occurs first).
(Continued)

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
I Short TripKity Intervals I
Every 45,000 Miles (75 000 km): Automatic
Transmission Fluid Hose Replacement (or every
45 months, whichever occurs first).
Every 50,000 Miles (83 000 km): Positive Crankcase
Ventilation (PCV) Valve Replacement.
Every 60,000 Miles (100 000 km): Engine Timing
and Distributor Check. Fuel Tank Cap Gasket
Replacement. Emission System Hoses Inspection.
Camshaft Timing Belt Replacement. Brake Fluid Service. Spark Plug Wire Replacement (or every
60 months, whichever occurs first). Wiring Harness
and Connectors Inspection (or every
60 months,
whichever occurs first).
At 90,000 Miles (150 000 km): Camshaft Timing
Belt Inspection.
Every 100,000 Miles (166 000 km): Automatic
Transmission Service (normal conditions). Fuel
Injector Inspection. Evaporative Emissions
Canister Replacement.
These intervals only summarize maintenance services.
Be sure to follow the complete maintenance schedule
on the following pages.
{Long Trip/Highway Definition
Follow this maintenance schedule only if none of
the conditions from the Short TripKity Maintenance
Schedule is true. Do not use this schedule if the vehicle
is used for trailer towing, driven in a dusty area or used
off paved roads. Use the Short TripKity schedule for
these conditions.
Driving a vehicle with a filly warmed engine
under highway conditions causes engine oil to
break down slowel:
7-6

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
Long TriplHighway Intervals I
Every 7,500 Miles (12 500 km): Engine Oil and Filter
Change (or every
7.5 months, whichever occurs first).
Free-Wheeling Hubs Inspection (if equipped) (or every
3 months, whichever occurs first). Tire Rotation.
Transmission Service (severe conditions only).
Engine Idle Speed Check. Valve Lash (Clearance)
Adjustment. Propeller Shafts and U-Joints Inspection (or every
15 months, whichever occurs first).
Every 30,000 Miles (50 000 km): Engine Accessory
Drive Belt Inspection (or every
24 months, whichever
occurs first). Cooling System Service (or every
30 months, whichever occurs first). Spark Plug
Replacement. Air Cleaner Filter Replacement. Fuel
Tank, Cap and Lines Inspection. Front Wheel Bearing
Repack (2WD only) (or at each brake relining,
whichever occurs first). Manual Transmission Fluid
Change. Transfer Case Fluid Change. Differential
Fluid Change. Fuel Filter Replacement (or every
30 months, whichever occurs first).
Every 15,000 Miles (25 000 km): Automatic
Long Tripmighway Intervals
Every 45,000 Miles (75 000 km): Automatic
Transmission Fluid Hose Replacement (or every
45 months, whichever occurs first).
Every 50,000 Miles (83 000 km): Positive Crankcase
Ventilation (PCV) Valve Replacement.
Every 60,000 Miles (100 000 km): Engine Timing
and Distributor Check. Fuel Tank Cap Gasket
Replacement. Emission System Hoses Inspection.
Camshaft Timing Belt Replacement. Spark Plug
Wire Replacement (or every
60 months, whichever
occurs first). Wiring Harness and Connectors
Inspection (or every
60 months, whichever occurs
first). Brake Fluid Service.
At 90,000 Miles (150 000 km): Camshaft Timing
Belt Inspection.
Every 100,000 Miles (166 000 km): Automatic
Transmission Service (normal conditions). Fuel
Injector Inspection. Evaporative Emissions
Canister Replacement.
These intervals only summarize maintenance services.
Be sure to
follow the complete maintenance schedule on
the following pages.
7-7

Downloaded from www.Manualslib.com manuals search engine I Short TYiplCity Maintenance Schedule I
12,000 Miles (20 000 km)
0 Change engine oil and filter (or every 3 months, whichever occurs first).
c] Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
0 Inspect the locking front hubs (if equipped) for correct operation (or every
An Emission Control Service.
rotation pattern and additional information. (See footnote +.)
3 months, whichever occurs first). Repair or replace if necessary.
15,000 Miles (25 000 km)
0 Change engine oil and filter (or every 3 months, whichever occurs first).
0 Inspect air cleaner filter if you are driving in dusty conditions. Replace
An Emission Control Service.
filter if necessary.
An Emission Control Service. (See footnote?.)
bearings
(or at each brake relining, whichever occurs first).
under one or more
of these conditions:
0 For Two-Wheel-Drive vehicles only: Clean and repack the front wheel
0 Change automatic transmission fluid and filter if the vehicle is mainly driven
- In heavy city traffic where the outside temperature regularly r\
eaches
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
90°F (32°C) or higher.
DATE 1
MILEAGE
I DATE I
MILEAGE
ACTUAL SERVICED BY:

Downloaded from www.Manualslib.com manuals search engine I Short TripKity Maintenance Schedule I
39,000 Miles (65 000 km)
Change engine oil and filter (or every 3 months, whichever occurs first).
Inspect the locking front hubs (if equipped) for correct operation (or every
An Emission Control Service.
3 months, whichever occurs first). Repair or replace if necessary\
.
42,000 MiZes (70 000 km)
Change engine oil and filter (or every 3 months, whichever occurs first).
0 Rotate tires. See “Tire Inspection and Rotation” in the I\
ndex for proper
Inspect the locking front hubs (if equipped) for correct operation (or every
An Emission Control Service.
rotation pattern and additional information. (See footnote +.)
3 months, whichever occurs first). Repair or replace if necessary\
.
45,000 Miles (75 000 km)
I7 Change engine oil and filter (or every 3 months, whichever occurs first).
13 For Tw-Wheel-Drive vehicles only: Clean and repack the front wheel
0 Replace automatic transmission fluid hose (or every 45 months, whichever
An Emission Control Sewice.
bearings (or at each brake relining, whichever occurs first). \
occurs first).
I DATE I
MILEAGE
DATE
I
MILEAGE ACTUAL I SERVICEDBY:
I DATE I
MILEAGE
7-16

Downloaded from www.Manualslib.com manuals search engine Short TripKity Maintenance Schedule
17 Inspect the underhood wiring harness for loose connections, chafed wires and
damage (or every
60 months, whichever occurs first).
An Emission Control Service. (See footnote?.)
0 Drain, refill and bleed the brake system.
0 Replace the camshaft timing belt.
0 Replace air cleaner filter.
0 Inspect fuel tank, cap and lines for damage or leaks. Inspect fuel cap gasket
An Emission Control Service. (See footnote ?.)
An Emission Control Service.
for any damage. Replace parts as needed.
An Emission Control Service. (See footnote?.)
0 Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
rotation pattern and additional information. (See footnote
+.)
0 Replace fuel filter (or every 30 months, whichever occurs first).
An Emission Control Service. (See footnote?.)
0 Change manual transmission fluid.
0 Change transfer case fluid.
Change differential fluid.
0 Inspect the valve lash and adjust if necessary.
An Emission Control Service.
(Continued)
7-21

Downloaded from www.Manualslib.com manuals search engine I Short Trip/City Maintenance Schedule 1
75,000 Miles (125 000 km) DATE I
O Change engine oil and filter (or every 3 months, whichever occurs first).
0 For Two-Wheel-Drive vehicles only: Clean and repack the front wheel
0 Change automatic transmission fluid and filter if the vehicle is mainly driven
An Emission Control Service.
bearings (or at each brake relining, whichever occurs first). \
under one or more of these conditions:
- In heavy city traffic where the outside temperature regularly r\
eaches
90 OF (32 O C) or higher.
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or delivery service.
If you do not use your vehicle under any of these conditions, change the fluid
and filter every
100,000 miles (166 000 km).
filter if necessary.
An Emission Control Service. (See footnote?.)
0 Inspect air cleaner filter if you are driving in dusty conditions. Replace
0 Change manual transmission fluid.
0 Change transfer case fluid.
0 Change differential fluid.
0 Inspect the valve lash and adjust if necessary.
An Emission Control Service.
MILEAGE
7-24

Downloaded from www.Manualslib.com manuals search engine I Short Trip/City Maintenance Schedule I
84,000 Miles (I40 000 km)
0 Change engine oil and filter (or every 3 months, whichever occurs first).
0 Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
Inspect the locking front hubs (if equipped) for correct operation (or every
An Emission Control Service.
rotation pattern and additional information. (See footnote +.)
3 months, whichever occurs first). Repair or replace if necessary\
.
87,000 Miles (I45 000 km)
0 Change engine oil and filter (or every 3 months, whichever occurs first).
0 Inspect the locking front hubs (if equipped) for correct operation (or every
An Emission Control Service.
3 months, whichever occurs first). Repair or replace if necessary.
90,000 Miles (150 000 km)
0 Change engine oil and filter (or every 3 months, whichever occurs first).
For Two-Wheel-Drive vehicles only: Clean and repack the front wheel
0 Replace automatic transmission fluid hose (or every 45 months, whichever
An Emission Control Sewice.
bearings (or at each brake relining, whichever occurs first).
occurs first).
I DATE I
MILEAGE
I DATE I
I MILEAGE ACTUAL I SERVICEDBY: I
I DATE I
MILEAGE
7-26

Downloaded from www.Manualslib.com manuals search engine Long Tripmighway Maintenance Schedule
30,000 Miles (50 000 km) (Continued)
0 For Two-Wheel-Drive vehicles only: Clean and repack the front wheel
0 Change automatic transmission fluid and filter if the vehicle is mainly driven
bearings (or at each brake relining, whichever occurs first). \
under one or more of these conditions:
- In heavy city traffic where the outside temperature regularly reaches
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or delivery service.
If you do not use your vehicle under any of these conditions, change the fluid
and filter every
100,000 miles (166 000 km).
rotation pattern and additional information. (See footnote +.)
90°F (32°C) or higher.
0 Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
0 Inspect engine accessory drive belts (or every 24 months, whichever
occurs first).
An Emission Control Service.
first). See “Engine Coolant” in the Index for what to use. Inspect hoses. Clean
radiator, condenser, pressure cap and neck. Pressure test the cooling system
and pressure cap.
An Emission Control Service. (See footnote“f)
0 Drain, flush and refill cooling system (or every 30 months, whichever occurs
7-34