boot CHEVROLET TRACKER 2003 2.G Owners Manual

Maintenance Schedule......................................6-2
Introduction...................................................6-2
Your Vehicle and the Environment....................6-2
Maintenance Requirements..............................6-2
How This Section is Organized.........................6-3
Part A: Scheduled Maintenance Services...........6-4
Using Your Maintenance Schedule....................6-4
Selecting the Right Schedule...........................6-5
Short Trip/City Scheduled Maintenance..............6-7
Long Trip/Highway Scheduled Maintenance......6-17
Part B: Owner Checks and Services................6-24
At Each Fuel Fill..........................................6-24
At Least Once a Month.................................6-24
At Least Twice a Year...................................6-25At Least Once a Year...................................6-25
Part C: Periodic Maintenance Inspections.........6-28
Steering, Suspension and Front Drive Axle
Boot and Seal Inspection............................6-28
Exhaust System Inspection............................6-28
Fuel System Inspection..................................6-28
Engine Cooling System Inspection...................6-28
Throttle System Inspection.............................6-29
Rear Axle and Front Axle
(Four-Wheel-Drive) Service.........................6-29
Brake System Inspection................................6-29
Part D: Recommended Fluids
and Lubricants..........................................6-30
Part E: Maintenance Record...........................6-32
Section 6 Maintenance Schedule
6-1

Part C: Periodic
Maintenance Inspections
Listed in this part are inspections and services which
should be performed at least twice a year (for instance,
each spring and fall).
You should let your dealer's
service department do these jobs. Make sure any
necessary repairs are completed at once.
Proper procedures to perform these services may be
found in a service manual. SeeService Publications
Ordering Information on page 7-11.
Steering, Suspension and Front
Drive Axle Boot and Seal Inspection
Inspect the front and rear suspension and steering
system for damaged, loose or missing parts, signs of
wear or lack of lubrication. Inspect the power steering
lines and hoses for proper hook-up, binding, leaks,
cracks, cha®ng, etc. Clean and then inspect the drive
axle boot seals for damage, tears or leakage. Replace
seals if necessary.
Exhaust System Inspection
Inspect the complete exhaust system. Inspect the body
near the exhaust system. Look for broken, damaged,
missing or out-of-position parts as well as open seams,
holes, loose connections or other conditions which
could cause a heat build-up in the ¯oor pan or could let
exhaust fumes into the vehicle. See
Engine Exhaust
on page 2-32.
Fuel System Inspection
Inspect the complete fuel system for damage or leaks.
Engine Cooling System Inspection
Inspect the hoses and have them replaced if they
are cracked, swollen or deteriorated. Inspect all pipes,
®ttings and clamps; replace as needed. Clean the
outside of the radiator and air conditioning condenser.
To help ensure proper operation, a pressure test of
the cooling system and pressure cap is recommended
at least once a year.
6-28

Inspection (cont.)
Steering, Suspension and Front Drive Axle
Boot and Seal.........................................6-28
Throttle System...........................................6-29
Instrument Panel Brightness.............................3-15
Instrument Panel Fuse Block............................5-90
Instrument Panel.............................................3-25
Cluster.......................................................3-25
Overview..................................................... 3-2
Interior Lamps................................................3-15
J
Jump Starting.................................................5-46
K
Key Lock Cylinders Service..............................6-25
Keyless Entry System....................................... 2-4
Keys............................................................... 2-2
L
Lamps...........................................................3-12
Exterior......................................................3-12
Interior.......................................................3-15
Lap Belt........................................................1-27
Lap-Shoulder Belt...................................1-17, 1-28LATCH System...............................................1-44
Child Restraints...........................................1-44
Securing a Child Restraint Designed for
the LATCH System...................................1-46
Leaving Your Vehicle With the Engine Running......2-29
Leaving Your Vehicle.......................................2-11
Light.............................................................3-27
Air Bag Readiness.......................................3-27
Anti-Lock Brake System Warning...................3-30
Brake System Warning.................................3-28
Charging System.........................................3-28
Four-Wheel-Drive.........................................3-35
Malfunction Indicator....................................3-31
Oil Pressure...............................................3-34
Overdrive Off..............................................3-35
Power Indicator...........................................3-36
Safety Belt Reminder...................................3-26
Loading Your Vehicle for
Off-Road Driving..........................................4-16
Loading Your Vehicle.......................................4-51
Locks............................................................. 2-8
Door........................................................... 2-8
Leaving Your Vehicle....................................2-11
Power Door.................................................. 2-9
Rear Door Security Locks.............................2-10
Long Trip/Highway De®nition.............................. 6-6
Long Trip/Highway Intervals............................... 6-6
Long Trip/Highway Scheduled Maintenance........6-17
Loss of Control...............................................4-15
7

Lowering and Raising the Canvas Top...............2-43
Luggage Carrier..............................................2-36
Lumbar........................................................... 1-3
Manual Controls............................................ 1-3
M
Maintenance, Normal Replacement Parts............5-95
Maintenance Schedule.....................................6-24
At Each Fuel Fill.........................................6-24
At Least Once a Month................................6-24
At Least Once a Year..................................6-25
At Least Twice a Year..................................6-25
Brake System Inspection..............................6-29
Engine Cooling System Inspection.................6-28
Exhaust System Inspection...........................6-28
Fuel System Inspection................................6-28
How This Section is Organized....................... 6-3
Introduction.................................................. 6-2
Long Trip/Highway Scheduled Maintenance......6-17
Maintenance Requirements............................. 6-2
Part A - Scheduled Maintenance Services......... 6-4
Part B - Owner Checks and Services.............6-24
Part C - Periodic Maintenance Inspections.......6-28
Part D - Recommended Fluids and Lubricants....6-30
Part E - Maintenance Record........................6-32
Rear Axle and Front Axle
(Four-Wheel-Drive) Service........................6-29Maintenance Schedule (cont.)
Selecting the Right Schedule.......................... 6-5
Short Trip/City Scheduled Maintenance............. 6-7
Steering, Suspension and Front Drive Axle
Boot and Seal Inspection..........................6-28
Throttle System Inspection............................6-29
Using Your................................................... 6-4
Your Vehicle and the Environment................... 6-2
Maintenance When Trailer Towing.....................4-59
Making Turns.................................................4-57
Malfunction Indicator Light................................3-31
Manual Lumbar Controls.................................... 1-3
Manual Seats................................................... 1-2
Manual Transmission.......................................2-16
Fluid..........................................................5-26
Operation...................................................2-23
Manual Windows............................................2-13
Matching Transmitter(s) to Your Vehicle............... 2-6
Mexico, Central America and Caribbean
Islands/Countries (Except Puerto Rico and
U.S. Virgin Islands) ± Customer Assistance....... 7-5
Mirrors..........................................................2-34
Manual Rearview Mirror................................2-34
Outside Convex Mirror.................................2-35
Outside Manual Mirrors................................2-34
Outside Power Mirrors..................................2-34
MyGMLink.com................................................ 7-3
8

Short Trip/City Scheduled Maintenance................ 6-7
Shoulder Belt Height Adjuster...........................1-19
Skidding........................................................4-15
Some Other Rainy Weather Tips.......................4-34
Special Care for Canvas Top and Plastic
Windows....................................................5-84
Special Fabric Cleaning Problems.....................5-80
Speci®cations, Capacities.................................5-93
Speedometer..................................................3-26
Stalling on an Incline.......................................4-27
Starter Switch Check.......................................6-26
Starting Your Engine.......................................2-16
Steering in Emergencies..................................4-12
Steering, Suspension and Front Drive Axle
Boot and Seal Inspection..............................6-28
Steering Tips..................................................4-11
Steering........................................................4-11
Storage Areas................................................2-35
Coinholder(s)..............................................2-35
Convenience Net.........................................2-37
Cupholder(s)...............................................2-35
Glove Box..................................................2-35
Luggage Carrier..........................................2-36
Storing a Flat or Spare Tire and Tools...............5-77
Stuck in Sand, Mud, Ice or Snow......................4-44
Sun Visors.....................................................2-14
Supplemental Restraint System (SRS)...............1-54
Adding Equipment to Your
Air Bag-Equipped Vehicle..........................1-61
How Does an Air Bag Restrain?....................1-58Supplemental Restraint System (SRS) (cont.)
Servicing Your Air Bag-Equipped Vehicle.........1-60
What Makes an Air Bag In¯ate?....................1-57
What Will You See After an
Air Bag In¯ates?......................................1-58
When Should an Air Bag In¯ate?...................1-57
Where Are the Air Bags?..............................1-56
T
Tachometer....................................................3-26
Tailgate Lock Release.....................................2-11
Tailgate.........................................................2-11
Throttle System Inspection...............................6-29
Tilt Wheel........................................................ 3-5
Tire In¯ation Check.........................................6-24
Tires.............................................................5-59
Buying New Tires........................................5-62
Chains.......................................................5-66
Changing a Flat Tire....................................5-67
If a Tire Goes Flat.......................................5-66
In¯ation -- Tire Pressure...............................5-60
Inspection and Rotation................................5-60
Uniform Tire Quality Grading.........................5-63
Wheel Alignment and Tire Balance.................5-64
Wheel Replacement.....................................5-64
When It Is Time for New Tires......................5-62
To Use the Engine Coolant Heater....................2-18
Top Strap Anchor Location...............................1-43
12