engine overheat CHEVROLET TRAX 2020 User Guide

Chevrolet TRAX Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13556235) - 2020 - CRC - 9/19/19
230 Vehicle Care
Caution
Failure to follow the specific
coolant fill procedure could cause
the engine to overheat and could
cause system damage. If coolant
is not visible in the surge tank,
contact your dealer.
If no problem is found, check to see
if coolant is visible in the coolant
surge tank. If coolant is visible but
the coolant level is not at the
indicated level mark, add a 50/
50 mixture of clean, drinkable water
and DEX-COOL coolant at the
coolant surge tank, but be sure the
cooling system, including the
coolant surge tank pressure cap, is
cool before you do it.
1. Remove the coolant surge tank pressure cap when the cooling
system, including the coolant
surge tank pressure cap and
upper radiator hose, is no
longer hot.
Turn the pressure cap slowly
counterclockwise about
one-quarter of a turn. If you
hear a hiss, wait for that to
stop. This will allow any
pressure still left to be vented
out the discharge hose.
2. Keep turning the pressure cap slowly and remove it.3. Fill the coolant surge tank withthe proper mixture to the
indicated level mark.
4. With the coolant surge tank pressure cap off, start the
engine and let it run until you
can feel the upper radiator
hose getting hot. Watch out for
the engine cooling fan.
By this time, the coolant level
inside the coolant surge tank
may be lower. If the level is
lower, add more of the proper
mixture to the coolant surge
tank until the level reaches the
indicated level mark.
5. Replace the pressure cap tightly.
6. Verify coolant level after the engine is shut off and the
coolant is cold. If necessary,
repeat coolant fill procedure
Steps 1–6.
If the coolant still is not at the proper
level when the system cools down
again, see your dealer.

Chevrolet TRAX Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13556235) - 2020 - CRC - 9/19/19
Vehicle Care 231
Caution
If the pressure cap is not tightly
installed, coolant loss and engine
damage may occur. Be sure the
cap is properly and tightly
secured.
Engine Overheating
The vehicle has an indicator to warn
of the engine overheating. See
Engine Coolant Temperature
Warning Light0108.
If the decision is made not to lift the
hood when this warning appears,
get service help right away. See
Roadside Assistance Program
0 321.
If the decision is made to lift the
hood, make sure the vehicle is
parked on a level surface.
Then check to see if the engine
cooling fan is running. If the engine
is overheating, the fan should be
running. If it is not, do not continue
to run the engine. Have the vehicle
serviced.
Caution
Do not run the engine if there is a
leak in the engine cooling system.
This can cause a loss of all
coolant and can damage the
system and vehicle. Have any
leaks fixed right away.
If Steam Is Coming from the
Engine Compartment
{Warning
Steam and scalding liquids from a
hot cooling system are under
pressure. Turning the pressure
cap, even a little, can cause them
to come out at high speed and
you could be burned. Never turn
the cap when the cooling system,
including the pressure cap, is hot.
Wait for the cooling system and
pressure cap to cool.
If No Steam Is Coming from
the Engine Compartment
If an engine overheat warning is
displayed but no steam can be seen
or heard, the problem may not be
too serious. Sometimes the engine
can get a little too hot when the
vehicle:
. Climbs a long hill on a hot day
. Stops after high-speed driving
. Idles for long periods in traffic
If the overheat warning is displayed
with no sign of steam: 1. Turn the air conditioning off.
2. Turn the heater on to the highest temperature and to the
highest fan speed. Open the
windows as necessary.
3. When it is safe to do so, pull off the road, shift to P (Park) or
N (Neutral) for an automatic
transmission or Neutral for a
manual transmission, and let
the engine idle.

Chevrolet TRAX Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13556235) - 2020 - CRC - 9/19/19
232 Vehicle Care
If the overheat warning no longer
displays, the vehicle can be driven.
Continue to drive the vehicle slowly
for about 10 minutes. Keep a safe
vehicle distance from the vehicle in
front. If the warning does not come
back on, continue to drive normally
and have the cooling system
checked for proper fill and function.
If the warning continues, pull over,
stop, and park the vehicle
right away.
If there is no sign of steam, idle the
engine for three minutes while
parked. If the warning is still
displayed, turn off the engine until it
cools down.
Power Steering Fluid
(1.4L L4 Engine (LUV))
The vehicle has electric power
steering and does not use power
steering fluid.
Power Steering Fluid
(1.8L L4 Engine)
SeeEngine Compartment Overview
0 218 for information on the location
of the power steering fluid reservoir.
When to Check Power Steering
Fluid
It is not necessary to regularly
check power steering fluid unless a
leak is suspected in the system or
an unusual noise is heard. A fluid
loss in this system could indicate a
problem. Have the system inspected
and repaired.
How to Check Power Steering
Fluid
Check the level after the vehicle has
been driven for at least 20 minutes
so the fluid is warm. To check the power steering fluid:
1. Turn the ignition to off and let the engine compartment
cool down.
2. Wipe the cap and the top of the reservoir clean.
3. Unscrew the cap and pull it straight up.
4. Wipe the dipstick with a clean rag.
5. Replace the cap and completely tighten it.
6. Remove the cap again and look at the fluid level on the
dipstick.

Chevrolet TRAX Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13556235) - 2020 - CRC - 9/19/19
Index 345
Drive SystemsAll-Wheel Drive . . . . . . . . . . 191, 236
Driver Assistance Systems . . . . . 198
Driver Behavior . . . . . . . . . . . . . . . . . 161
Driver Information Center (DIC) . . . . . . . . . . . . . . . . . . 111
Driving
Better Fuel Economy . . . . . . . . . 162
Defensive . . . . . . . . . . . . . . . . . . . . . 163
Drunk . . . . . . . . . . . . . . . . . . . . . . . . . 163
Environment . . . . . . . . . . . . . . . . . . 161
Hill and Mountain Roads . . . . . . 167
If the Vehicle is Stuck . . . . . . . . . 169
Loss of Control . . . . . . . . . . . . . . . 166
Off-Road Recovery . . . . . . . . . . . 165
Vehicle Load Limits . . . . . . . . . . . 169
Wet Roads . . . . . . . . . . . . . . . . . . . 166
Winter . . . . . . . . . . . . . . . . . . . . . . . . 168
Driving the Vehicle . . . . . . . . . . . . . . . . 2
E
Electrical Equipment, Add-On . . . . . . . . . . . . . . . . . . . . . . . 212
Electrical System Engine Compartment FuseBlock . . . . . . . . . . . . . . . . . . . . . . . . 249
Fuses and Circuit Breakers . . . 248 Electrical System (cont'd)
Instrument Panel Fuse
Block . . . . . . . . . . . . . . . . . . . . . . . . 252
Overload . . . . . . . . . . . . . . . . . . . . . 248
Rear Compartment Fuse Block . . . . . . . . . . . . . . . . . . . . . . . . 254
Emergency
OnStar . . . . . . . . . . . . . . . . . . . . . . . 332
Engine Air Cleaner/Filter . . . . . . . . . . . . . 225
Check Light (MalfunctionIndicator) . . . . . . . . . . . . . . . . . . . . 102
Compartment Overview . . . . . . . 218
Coolant Temperature Warning Light . . . . . . . . . . . . . . . 108
Cooling System . . . . . . . . . . . . . . . 227
Drive Belt Routing . . . . . . . . . . . . 316
Exhaust . . . . . . . . . . . . . . . . . . . . . . 185
Heater . . . . . . . . . . . . . . . . . . . . . . . . 180
Oil Life System . . . . . . . . . . . . . . . 223
Oil Pressure Light . . . . . . . . . . . . 109
Overheating . . . . . . . . . . . . . . . . . . 231
Power Messages . . . . . . . . . . . . . .118
Reduced Power Light . . . . . . . . . .110
Running While Parked . . . . . . . . 185
Starting . . . . . . . . . . . . . . . . . . . . . . . 178 Entry Lighting . . . . . . . . . . . . . . . . . . . 127
Event Data Recorders . . . . . . . . . . 329
Exit Lighting . . . . . . . . . . . . . . . . . . . . 127
Extended Parking . . . . . . . . . . . . . . . 184
Extender, Seat Belt . . . . . . . . . . . . . . 53
Exterior Lamp Controls . . . . . . . . . 122
Exterior Lighting Battery
Saver . . . . . . . . . . . . . . . . . . . . . . . . . 128
F
Filter,Engine Air Cleaner . . . . . . . . . . . 225
Flash-to-Pass . . . . . . . . . . . . . . . . . . . 123
Flashers, Hazard Warning . . . . . . 124
Flat Tire . . . . . . . . . . . . . . . . . . . . . . . . 274 Changing . . . . . . . . . . . . . . . . . . . . . 276
Floor Mats . . . . . . . . . . . . . . . . . . . . . . 296
Fluid
Automatic Transmission . . . . . . 224
Brakes . . . . . . . . . . . . . . . . . . . . . . . . 234
Power Steering . . . . . . . . . . . . . . . 232
Washer . . . . . . . . . . . . . . . . . . . . . . . 233
Fog Lamps Front . . . . . . . . . . . . . . . . . . . . . . . . . 125
Folding Mirrors . . . . . . . . . . . . . . . . . . 30
Folding Seatback . . . . . . . . . . . . . . . . 41
Forward Collision Alert (FCA) System . . . . . . . . . . . . . . . . . 203

Chevrolet TRAX Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13556235) - 2020 - CRC - 9/19/19
Index 349
OnStar Emergency . . . . . . . . . . . . . 332
OnStar Overview . . . . . . . . . . . . . . . 331
OnStar Security . . . . . . . . . . . . . . . . 333
OnStar System . . . . . . . . . . . . . . . . . 141
Operate Pedal Light . . . . . . . . . . . . 106
OutletsPower . . . . . . . . . . . . . . . . . . . . . . . . . . 95
Overheating, Engine . . . . . . . . . . . . 231
Overview . . . . . . . . . . . . . . . . . . . . . . . 130 Instrument Panel . . . . . . . . . . . . . . . . 5
Owner Manual Indicator . . . . . . . . 104
P
Park
Shifting Out of . . . . . . . . . . . . . . . . 183
Park Assist . . . . . . . . . . . . . . . . . . . . . 201
Parking . . . . . . . . . . . . . . . . . . . . . . . . . 184 Brake . . . . . . . . . . . . . . . . . . . . . . . . . 192
Brake and P (Park)Mechanism Check . . . . . . . . . . 238
Extended . . . . . . . . . . . . . . . . . . . . . 184
Over Things That Burn . . . . . . . 184
Ultrasonic Sensor Light . . . . . . . 107
Passenger Airbag Status Indicator . . . . . . . . . . . . . . . . . . . . . . 101
Passenger Compartment Air
Filter . . . . . . . . . . . . . . . . . . . . . . . . . . 158
Passenger Sensing System . . . . . 61 Perchlorate Materials
Requirements, California . . . . . . 215
Personalization Vehicle . . . . . . . . . . . . . . . . . . . . . . . .118
Phone Apple CarPlay andAndroid Auto . . . . . . . . . . . . . . . . 148
Bluetooth . . . . . . . . . . . . . . . . 143, 144
Port USB . . . . . . . . . . . . . . . . . . . . . . . . . . 137
Power
Door Locks . . . . . . . . . . . . . . . . . . . . . 22
Mirrors . . . . . . . . . . . . . . . . . . . . . . . . . . 30
Outlets . . . . . . . . . . . . . . . . . . . . . . . . . 95
Protection, Battery . . . . . . . . . . . . 128
Reduced Engine Light . . . . . . . . .110
Retained Accessory (RAP) . . . 181
Seat Adjustment . . . . . . . . . . . . . . . . 38
Steering Fluid . . . . . . . . . . . . . . . . . 232
Windows . . . . . . . . . . . . . . . . . . . . . . . 31
Power Steering Warning
Lights . . . . . . . . . . . . . . . . . . . . . . . . . 106
Pregnancy, Using Seat Belts . . . . 52
Privacy Vehicle Data Recording . . . . . . . 329
Program Courtesy Transportation . . . . . . 323
Prohibited Fuels . . . . . . . . . . . . . . . . 208 Proposition
65 Warning,
California . . . . . . . . . . . .214, 236, 282,
Back Cover
Publication Ordering Information . . . . . . . . . . . . . . . . . . . . 326
R
RadioAM-FM . . . . . . . . . . . . . . . . . . . . . . . 134
Satellite . . . . . . . . . . . . . . . . . . . . . . . 136
Radio Frequency Statement . . . . 327
Radio Reception . . . . . . . . . . . . . . . . 136
Reading Lamps . . . . . . . . . . . . . . . . . 126
Rear Seat Armrest . . . . . . . . . . . . . . . 46
Rear Seats . . . . . . . . . . . . . . . . . . . . . . 42
Rear Vision Camera (RVC) . . . . . 199
Rear Window Washer/Wiper . . . . . 94
Rearview Mirrors . . . . . . . . . . . . . . . . 30
Automatic Dimming . . . . . . . . . . . . . 31
Reclining Seatbacks . . . . . . . . . . . . . 39
Recommended
Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . 208
Recommended Fluids and Lubricants . . . . . . . . . . . . . . . . . . . . . 309
Records
Maintenance . . . . . . . . . . . . . . . . . . 312
Recreational Vehicle Towing . . . . 286