steering CHEVROLET VENTURE 2004 1.G Owner's Guide

Instrument Panel Fuse Block
The instrument panel fuse
block is located to the right
of the glove box on the
end of the instrument
panel.
Pull the door open to access the instrument panel fuse
block.
Fuse Usage
SWC
BACKLIGHTSteering Wheel Radio Control
Switches (Illumination)
PCM/PASS
KEY/CLUSTERInstrument Cluster to PRNDL
Indicators
PWR MIRROR Power Remote Control Mirror Switch
CRUISECruise Control Module, Switch and
Release Switch
Blank Not Used
PCM/CRANKPowertrain Control Module (PCM),
Ignition Crank
PASS KEY PASS-Key
®III System
5-107

Scheduled Maintenance
Service MaintenanceIMaintenanceII
Change engine oil and lter. Reset oil life system. SeeEngine Oil on
page 5-13.An Emission Control Service.••
Lubricate chassis components.See footnote #.••
Visually check for any leaks or damage.See footnote (k).••
Inspect engine air cleaner lter. If necessary, replace lter. SeeEngine Air
Cleaner/Filter on page 5-18.An Emission Control Service. See footnote †.••
Rotate tires and check ination pressures and wear. SeeTires on page 5-58.••
Inspect brake system.See footnote (a).••
Check engine coolant and windshield washer uid levels and add uid as
needed.••
Perform any needed additional services. See “Additional Required Services” in
this section.••
Inspect suspension and steering components.See footnote (b).•
Inspect engine cooling system.See footnote (c).•
Inspect wiper blades.See footnote (d).•
Inspect restraint system components.See footnote (e).•
Lubricate body components.See footnote (f).•
Check transaxle uid level and add uid as needed.•
Replace passenger compartment air lter.See footnote (g).•
Inspect throttle system.See footnote (j).•
6-5

Additional Required Services (cont’d)
Service and Miles (Kilometers)25,000
(41 500)50,000
(83 000)75,000
(125 000)100,000
(166 000)125,000
(207 500)150,000
(240 000)
Replace spark plugs and inspect
spark plug wires.An Emission
Control Service.•
Engine cooling system service
(or every 5 years, whichever occurs
rst).An Emission Control Service.
See footnote (i).•
Inspect engine accessory drive belt.
An Emission Control Service.•
Maintenance Footnotes
†The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that the
failure to perform this maintenance item will not nullify
the emission warranty or limit recall liability prior to
the completion of the vehicle’s useful life. We, however,
urge that all recommended maintenance services be
performed at the indicated intervals and the
maintenance be recorded.
#Lubricate the suspension, steering linkage, transaxle
shift linkage and the underbody contact points and
linkage.(a)Visually inspect brake lines and hoses for proper
hook-up, binding, leaks, cracks, chang, etc. Inspect
disc brake pads for wear and rotors for surface
condition. Inspect drum brake linings for wear or cracks.
Inspect other brake parts, including drums, wheel
cylindeers, calipers, parking brake, etc. Check parking
brake adjustment.
(b)Visually inspect front and rear suspension and
steering system for damaged, loose or missing parts,
signs of wear or lack of lubrication. Inspect power
steering lines and hoses for proper hook-up, binding,
leaks, cracks, chang, etc.
6-7

Recommended Fluids and
Lubricants
Fluids and lubricants identied below by name, part
number or specication may be obtained from your
dealer.
Usage Fluid/Lubricant
Engine OilEngine oil which meets GM Standard
GM6094M and displays the
American Petroleum Institute
Certied for Gasoline Engines
starburst symbol. GM Goodwrench
oil meets all the requirements for
your vehicle. To determine the proper
viscosity for your vehicle’s engine,
seeEngine Oil on page 5-13.
Engine Coolant50/50 mixture of clean, drinkable
water and use only
DEX-COOL
®Coolant. SeeEngine
Coolant on page 5-22.
Usage Fluid/Lubricant
Hydraulic Brake
SystemDelco Supreme 11 Brake Fluid or
equivalent DOT-3 brake uid.
Windshield
Washer SolventGM Optikleen
®Washer Solvent.
Power Steering
SystemGM Power Steering Fluid
(GM Part No. U.S. 89021184, in
Canada 89021186).
Automatic
TransaxleDEXRON
®-III Automatic
Transmission Fluid.
Key Lock
CylindersMulti-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241, in
Canada 10953474.
Chassis
LubricationChassis Lubricant
(GM Part No. U.S. 12377985, in
Canada 88901242) or lubricant
meeting requirements of NLGI #2,
Category LB or GC-LB.
6-12

Service Publications Ordering
Information
Service Manuals
Service Manuals have the diagnosis and repair
information on engines, transmission, axle, suspension,
brakes, electrical, steering, body, etc.
RETAIL SELL PRICE: $120.00
Transmission, Transaxle, Transfer
Case Unit Repair Manual
This manual provides information on unit repair service
procedures, adjustments, and specications for GM
transmissions, transaxles, and transfer cases.
RETAIL SELL PRICE: $50.00
Service Bulletins
Service Bulletins give technical service information
needed to knowledgeably service General Motors cars
and trucks. Each bulletin contains instructions to
assist in the diagnosis and service of your vehicle.
In Canada, information pertaining to Product Service
Bulletins can be obtained by contacting your General
Motors dealer or by calling 1-800-GM-DRIVE
(1-800-463-7483).
Owner’s Information
Owner publications are written specically for owners
and intended to provide basic operational information
about the vehicle. The owner’s manual will include
the Maintenance Schedule for all models.
In-Portfolio: Includes a Portfolio, Owner’s Manual, and
Warranty Booklet.
RETAIL SELL PRICE: $35.00
Without Portfolio: Owner’s Manual only.
RETAIL SELL PRICE: $25.00
7-13

A
Accessory Inator...........................................5-76
Accessory Power Outlets.................................3-25
Adding Washer Fluid.......................................5-38
Additional Program Information.........................7-10
Additives, Fuel................................................. 5-6
Add-On Electrical Equipment...........................5-105
Adjusting the Bucket Seats...............................1-14
Adjusting the Captain’s Chairs (Second Row)......1-20
Adjusting the Speakers
(Balance/Fade)....................3-64, 3-68, 3-80, 3-96
Adjusting the Split Bench Seats (Second Row)..... 1-8
Air Bag
Readiness Light..........................................3-41
Air Bag Systems.............................................1-92
How Does an Air Bag Restrain?....................1-99
Servicing Your Air Bag-Equipped Vehicle.......1-102
What Makes an Air Bag Inate?....................1-99
What Will You See After an Air Bag Inates?.....1-100
When Should an Air Bag Inate?...................1-98
Where Are the Air Bags?..............................1-95
Air Cleaner/Filter, Engine.................................5-18
Airbag Sensing and Diagnostic Module (SDM)....7-10
All-Wheel Drive......................................5-48, 5-96
All-Wheel Drive Disable Warning Message..........3-57
All-Wheel-Drive (AWD) System.........................4-11
AM .............................................................3-121AM-FM Radio.................................................3-62
Antenna, Fixed Mast......................................3-122
Antenna, XM™ Satellite Radio Antenna System . . . 3-122
Anti-lock Brake System (ABS)............................ 4-7
Anti-Lock Brake, System Warning Light..............3-43
Appearance Care............................................5-97
Care of Safety Belts and Built-in Child
Restraint Harness...................................5-100
Chemical Paint Spotting..............................5-103
Cleaning the Inside of Your Vehicle................5-97
Cleaning the Outside of Your Vehicle............5-100
Finish Damage..........................................5-102
Sheet Metal Damage..................................5-102
Underbody Maintenance.............................5-103
Vehicle Care/Appearance Materials...............5-103
Weatherstrips............................................5-100
Arming and Disarming the Content
Theft-Deterrent System.................................2-69
Arming Conrmation........................................2-28
Arming with the Power Lock Switch...................2-27
Arming with the Remote Keyless Entry
Transmitter.................................................2-28
Arming with Your Key......................................2-28
Audio Speakers............................................3-110
Audio System(s).............................................3-61
AM-FM Radio.............................................3-62
Audio Steering Wheel Controls....................3-120
Care of Your CD and DVD Player................3-122
1

Flat Tire........................................................5-78
Flat Tire, Changing.........................................5-78
Flip and Fold Rear Seats.................................. 1-7
Fluid
Automatic Transaxle.....................................5-20
Power Steering...........................................5-36
Windshield Washer......................................5-38
FM Stereo....................................................3-121
Folding or Reclining the Seatbacks.....1-9, 1-15, 1-20
Folding the Seatback.......................................1-24
Following Distance..........................................4-46
Front Reading Lamps......................................3-20
Front Seat Storage Net....................................2-56
Fuel............................................................... 5-4
Additives...................................................... 5-6
California Fuel.............................................. 5-5
Filling a Portable Fuel Container....................5-10
Filling Your Tank........................................... 5-7
Fuels in Foreign Countries.............................. 5-6
Gage.........................................................3-49
Gasoline Octane........................................... 5-4
Gasoline Specications.................................. 5-5
Low Warning Message.................................3-57
Fuses
Fuses and Circuit Breakers.........................5-106
Windshield Wiper.......................................5-106G
Gage
Engine Coolant Temperature.........................3-44
Fuel..........................................................3-49
Speedometer..............................................3-39
Tachometer.................................................3-40
Garage Door Opener.......................................2-48
Garage Door Opener Compartment...................2-55
Gasoline
Octane........................................................ 5-4
Specications............................................... 5-5
Gate Operator and Canadian Programming........2-51
Glove Box.....................................................2-52
GM Mobility Program for Persons with
Disabilities.................................................... 7-6
H
Hatch Ajar Warning Message............................3-56
Hazard Warning Flashers................................... 3-6
Head Restraints............................................... 1-6
Headlamp Wiring...........................................5-105
7

Headlamps....................................................5-50
Bulb Replacement.......................................5-50
Front Turn Signal, Sidemarker and Parking
Lamps....................................................5-52
Halogen Bulbs............................................5-50
Headphones.................................................3-109
Highway Hypnosis...........................................4-26
Hill and Mountain Roads..................................4-26
Hitches..........................................................4-44
HomeLink
®Transmitter....................................2-48
HomeLink®Transmitter, Programming................2-49
Hood
Checking Things Under................................5-10
Release.....................................................5-11
Horn............................................................... 3-7
How the System Works...................................3-24
How to Add Coolant to the Coolant Recovery
Tank ..........................................................5-30
How to Add Coolant to the Radiator..................5-32
How to Add Fluid Automatic Transaxle Fluid.......5-22
How to Check................................................5-69
How to Check Automatic Transaxle Fluid............5-20
How to Check Power Steering Fluid..................5-37
How to Inspect the Engine Air Cleaner/Filter.......5-18
How to Use This Manual...................................... ii
How to Wear Safety Belts Properly...................1-32
Hydroplaning..................................................4-21
I
If No Steam Is Coming From Your Engine..........5-27
If Steam Is Coming From Your Engine...............5-26
If the Light Is Flashing.....................................3-47
If the Light Is On Steady.................................3-47
If You Are Caught in a Blizzard.........................4-30
If You Are Stuck in Sand, Mud, Ice or Snow.......4-32
If You Do Decide To Pull A Trailer.....................4-42
Ignition Positions.............................................2-32
Infants and Young Children, Restraints...............1-56
Ination - Tire Pressure...................................5-68
Instrument Panel
Cluster.......................................................3-37
Overview..................................................... 3-4
Switchbank.................................................3-21
Instrument Panel Brightness.............................3-18
Instrument Panel Fuse Block..........................5-107
Interior Lamps................................................3-18
Interior Lamps Control.....................................3-18
Interior Lamps Override...................................3-18
J
Jump Starting.................................................5-43
8

Playing a Specic Loaded CD.........................3-104
Playing the Radio...................3-62, 3-66, 3-78, 3-94
Power
Accessory Outlets........................................3-25
Door Locks.................................................2-10
Electrical System.......................................5-106
Rear Quarter Windows.................................2-26
Six-Way Seats.............................................. 1-4
Sliding Door................................................2-16
Sliding Door Warning Message......................3-54
Steering Fluid.............................................5-36
Windows....................................................2-25
Power Steering...............................................4-12
Pretensioners, Safety Belt................................1-52
Primary Radio Controls..................................3-116
Programmable Automatic Door Locks.................2-12
Programmable
Modes.......2-63, 2-64, 2-65, 2-66, 2-67, 2-68, 2-69
Programming Mode
Entering.....................................................2-62
Exiting.......................................................2-71
Programming the HomeLink
®Transmitter...........2-49
Q
Questions and Answers About Safety Belts.........1-31
R
Radiator Pressure Cap....................................5-25
Radio Data System (RDS)...............3-65, 3-77, 3-93
Radio Messages...................3-64, 3-71, 3-83, 3-100
Radios..........................................................3-61
AM-FM Radio.............................................3-62
Care of Your CD and DVD Player................3-122
Care of Your CDs and DVDs.......................3-121
Radio with CD....................................3-65, 3-76
Radio with Six-Disc CD................................3-93
Rear Seat Audio..............................3-116, 3-118
Setting the Time for Radios with Radio
Data Systems (RDS)................................3-61
Setting the Time for Radios without Radio
Data Systems (RDS)................................3-61
Theft-Deterrent..........................................3-119
Understanding Reception............................3-121
12

Securing a Child Restraint
Center Seat Position............................1-73, 1-75
Designed for the LATCH System...................1-69
Rear Outside Seat Position...........................1-69
Right Front Seat Position..............................1-78
Security Message, PASS-Key
®III ......................3-56
Security While You Travel.................................. 7-6
Service........................................................... 5-3
Adding Equipment to the Outside of Your
Vehicle..................................................... 5-4
Doing Your Own Work................................... 5-3
Engine Soon Light.......................................3-45
Publications Ordering Information...................7-13
Traction System Warning Message.................3-50
Service Bulletins.............................................7-13
Service Engine Soon Light in the United States
or Check Engine Light in Canada..................3-45
Service Manuals.............................................7-13
Setting Preset PTYs (RDS Only).......................3-98
Setting Preset Stations............3-63, 3-67, 3-79, 3-95
Setting the Time
Radios with Radio Data Systems (RDS).........3-61
Radios without Radio Data Systems (RDS).....3-61
Setting the Tone (Bass/Treble) . . . 3-63, 3-68, 3-80, 3-96
Sheet Metal Damage.....................................5-102
Shifting Into Park (P).......................................2-40
Shifting Out of Park (P)...................................2-42
Shoulder Belt Height Adjuster...........................1-35Side Window Latches......................................2-25
Skidding........................................................4-16
Sliding Door Delayed Locking...........................2-12
Sliding Door Lock...........................................2-14
Sliding Door, Power........................................2-16
Sliding Door Security Lock...............................2-15
Sliding Doors, Dual.........................................2-13
Some Other Rainy Weather Tips.......................4-22
Special Fabric Cleaning Problems.....................5-98
Specications, Capacities...............................5-113
Speedometer..................................................3-39
Split Bench Seats............................................. 1-8
Starting Your Engine.......................................2-33
Steering........................................................4-12
Steering in Emergencies..................................4-13
Steering Tips..................................................4-12
Steering Wheel Controls, Audio.......................3-120
Steering Wheel, Tilt Wheel................................. 3-7
Stereo RCA Jacks.........................................3-110
Storage Areas................................................2-52
Compact Overhead Console..........................2-53
Convenience Center.....................................2-59
Convenience Net.........................................2-58
Cupholder(s)...............................................2-53
Front Seat Storage Net................................2-56
Glove Box..................................................2-52
Luggage Carrier..........................................2-56
Overhead Console.......................................2-54
Rear Storage Area.......................................2-58
15