radiator cap CHRYSLER 200 2012 1.G Owners Manual

NOTE:There are steps that you can take to slow down
an impending overheat condition:
•If your air conditioner (A/C) is on, turn it off. The A/C
system adds heat to the engine cooling system and
turning the A/C off can help remove this heat.
•You can also turn the temperature control to maximum
heat, the mode control to floor and the blower control
to high. This allows the heater core to act as a
supplement to the radiator and aids in removing heat
from the engine cooling system.
WARNING!
You or others can be badly burned by hot engine
coolant (antifreeze) or steam from your radiator. If
you see or hear steam coming from under the hood,
do not open the hood until the radiator has had time
to cool. Never try to open a cooling system pressure
cap when the radiator or coolant bottle is hot.
Engine Oil Overheating (2.4L Engine Only) — If
Equipped
During sustained high-speed driving or trailer tow up
long grades on a hot day, the engine oil temperature may
become too hot. If this happens, the “HOTOIL” message
flashes in the odometer and the vehicle speed will be
reduced to 53 mph (85 km/h) until the engine oil
temperature is reduced.
NOTE: The vehicle speed is reduced to a maximum of
53 mph (85 km/h). You may of course, reduce your
vehicle speed further if needed.
6
WHAT TO DO IN EMERGENCIES 387

shield. To allow jump-starting there are remote battery
posts located on the left side of the engine compartment.WARNING!
•Take care to avoid the radiator cooling fan when-
ever the hood is raised. It can start anytime the
ignition switch is on. You can be injured by
moving fan blades.
•Remove any metal jewelry such as watch bands or
bracelets that might make an inadvertent electrical
contact. You could be seriously injured.
•Batteries contain sulfuric acid that can burn your
skin or eyes and generate hydrogen gas which is
flammable and explosive. Keep open flames or
sparks away from the battery.
1. Set the parking brake, shift the automatic transmission
into PARK and turn the ignition to LOCK.
2. Turn off the heater, radio, and all unnecessary electri-
cal accessories.
Remote Battery Posts
1 — Remote Positive (+) Post (covered with protective cap)
2 — Remote Negative (-) Post
6
WHAT TO DO IN EMERGENCIES 399

Cooling System
WARNING!
•When working near the radiator cooling fan, dis-
connect the fan motor lead or turn the ignition
switch to the LOCK position. The fan is tempera-
ture controlled and can start at anytime the igni-
tion switch is in the ON position.
•You or others can be badly burned by hot engine
coolant (antifreeze) or steam from your radiator. If
you see or hear steam coming from under the
hood, do not open the hood until the radiator has
had time to cool. Never try to open a cooling
system pressure cap when the radiator is hot.
Coolant Checks
Check engine coolant (antifreeze) protection every
12 months (before the onset of freezing weather, where
applicable). If the engine coolant (antifreeze) is dirty orrusty in appearance, the system should be drained,
flushed, and refilled with fresh engine coolant (anti-
freeze). Check the front of the A/C condenser for any
accumulation of bugs, leaves, etc. If dirty, clean by gently
spraying water from a garden hose vertically down the
face of the condenser.
Check the coolant recovery bottle tubing for brittle rub-
ber, cracking, tears, cuts, and tightness of the connection
at the bottle and radiator. Inspect the entire system for
leaks.
Cooling System – Drain, Flush, And Refill
If the engine coolant (antifreeze) is dirty or contains a
considerable amount of sediment, clean and flush with a
reliable cooling system cleaner. Follow with a thorough
rinsing to remove all deposits and chemicals. Properly
dispose of the old engine coolant (antifreeze).
Refer to the “Maintenance Schedule” for the proper
maintenance intervals.
428 MAINTAINING YOUR VEHICLE

Please review these recommendations for using Hybrid
Organic Additive Technology (HOAT) engine coolant
(antifreeze). When adding engine coolant (antifreeze):
•The manufacturer recommends using MOPAR
Antifreeze/Coolant 5 Year/100,000 Mile Formula
HOAT (Hybrid Organic Additive Technology) or
equivalent.
•Mix a minimum solution of 50% HOAT engine coolant
and distilled water. Use higher concentrations (not to
exceed 70%) if temperatures below34°F (37°C) are
anticipated.
•Use only high purity water such as distilled or deion-
ized water when mixing the water/engine coolant
(antifreeze) solution. The use of lower quality water
will reduce the amount of corrosion protection in the
engine cooling system. Please note that it is the owner’s responsibility to main-
tain the proper level of protection against freezing ac-
cording to the temperatures occurring in the area where
the vehicle is operated.
NOTE:
Mixing engine coolant (antifreeze) types will
decrease the life of the engine coolant (antifreeze) and
will require more frequent coolant changes.
Cooling System Pressure Cap
The cap must be fully tightened to prevent loss of engine
coolant (antifreeze), and to ensure that the engine coolant
(antifreeze) will return to the radiator from the coolant
recovery bottle.
The cap should be inspected and cleaned if there is any
accumulation of foreign material on the sealing surfaces.
430 MAINTAINING YOUR VEHICLE

The radiator normally remains completely full, so there is
no need to remove the radiator cap unless checking for
engine coolant (antifreeze) freeze point or replacing cool-
ant. Advise your service attendant of this. As long as the
engine operating temperature is satisfactory, the coolant
bottle need only be checked once a month. When addi-
tional engine coolant (antifreeze) is needed to maintain
the proper level, it should be added to the coolant bottle.
Do not overfill.
Points To Remember
NOTE:When the vehicle is stopped after a few miles
(kilometers) of operation, you may observe vapor coming
from the front of the engine compartment. This is nor-
mally a result of moisture from rain, snow, or high
humidity accumulating on the radiator and being vapor-
ized when the thermostat opens, allowing hot engine
coolant (antifreeze) to enter the radiator. If an examination of your engine compartment shows no
evidence of radiator or hose leaks, the vehicle may be
safely driven. The vapor will soon dissipate.
•Do not overfill the coolant recovery bottle.
•Check engine coolant (antifreeze) freeze point in the
radiator and in the coolant recovery bottle. If engine
coolant (antifreeze) needs to be added, the contents of
the coolant recovery bottle must also be protected
against freezing.
•If frequent engine coolant (antifreeze) additions are
required, or if the level in the coolant recovery bottle
does not drop when the engine cools, the cooling
system should be pressure tested for leaks.
•Maintain engine coolant (antifreeze) concentration at
50% HOAT engine coolant (antifreeze) (minimum)
and distilled water for proper corrosion protection of
your engine, which contains aluminum components.
432 MAINTAINING YOUR VEHICLE

•Make sure that the radiator and coolant recovery
bottle overflow hoses are not kinked or obstructed.
•Keep the front of the radiator clean. If your vehicle is
equipped with air conditioning, keep the front of the
condenser clean.
•Do not change the thermostat for Summer or Winter
operation. If replacement is ever necessary, install
ONLY the correct type thermostat. Other designs may
result in unsatisfactory cooling performance, poor gas
mileage, and increased emissions.
Brake System
In order to assure brake system performance, all brake
system components should be inspected periodically.
Refer to the “Maintenance Schedule” for the proper
maintenance intervals.
WARNING!
Riding the brakes can lead to brake failure and
possibly a collision. Driving with your foot resting or
riding on the brake pedal can result in abnormally
high brake temperatures, excessive lining wear, and
possible brake damage. You would not have your full
braking capacity in an emergency.
Master Cylinder – Brake Fluid Level Check
Check the fluid level in the master cylinder immediately
if the brake system warning light indicates system fail-
ure.
Check the fluid level in the master cylinder when per-
forming underhood services.
7
MAINTAINING YOUR VEHICLE 433

Caps, FillerFuel .............................. 368
Oil (Engine) ..................... 409,417
Power Steering ...................... 321
Radiator (Coolant Pressure) ............. 430
Car Washes ............................ 439
Carbon Monoxide Warning ...............86,364
Cellular Phone ....................... 100,274
Chains, Tire ............................ 350
Changing A Flat Tire ..................... 388
Chart, Tire Sizing ........................ 333
Check Engine Light
(Malfunction Indicator Light) ............... 412
Checking Your Vehicle For Safety ............. 85
Checks, Safety ........................... 85
Child Restraint .................... 72,74,79,82
Child Restraint Tether Anchors .............77,79
Child Safety Locks ........................ 34
Cigar Lighter ........................... 180 Clean Air Gasoline
....................... 361
Cleaning Wheels ............................ 441
Windshield Wiper Blades ............... 424
Climate Control ......................... 274
Clock ........................ 221,224,242,251
Coin Holder ........................... 182
Compact Disc (CD) Maintenance ............. 274
Compact Spare Tire ...................... 345
Compass ........................... 207,214
Compass Calibration ..................... 215
Compass Variance ....................... 215
Computer, Trip/Travel .................. 20,213
Connector UCI .............................. 265
Universal Consumer Interface (UCI) ....... 265
Console .............................. 147
Console, Floor ....................... 147,182
Contract, Service ........................ 479
488 INDEX

Coolant Pressure Cap (Radiator Cap).......... 430
Cooling System ......................... 428
Adding Coolant (Antifreeze) ............. 429
Coolant Capacity ..................... 455
Coolant Level .................... 428,431
Disposal of Used Coolant ............... 431
Drain, Flush, and Refill ................ 428
Inspection .......................... 431
Points to Remember .................. 432
Pressure Cap ........................ 430
Radiator Cap ....................... 430
Selection of Coolant (Antifreeze) ....429,455,456
Corrosion Protection ..................... 438
Crankcase Ventilation Module ............... 20
Cruise Light ........................... 201
Cupholders ...................... 147,180,444
Customer Assistance ..................... 477
Customer Programmable Features ............ 219Data Recorder, Event
...................... 71
Daytime Running Lights ................... 153
Dealer Service .......................... 414
Deck Lid, Power Release ................... 38
Defroster, Rear Window ................... 186
Defroster, Windshield ................87,277,283
Delay (Intermittent) Wipers ...............30,157
Diagnostic System, Onboard ................ 411
Dimmer Switch, Headlight ................. 152
Dipsticks Automatic Transmission .............437,438
Oil (Engine) ........................ 415
Power Steering ...................... 321
Disabled Vehicle Towing ................... 404
Disposal Antifreeze (Engine Coolant) ............. 431
Engine Oil ......................... 418
Door Locks, Automatic .................... 32
Door Opener, Garage ..................... 164
10
INDEX 489

PowerDeck Lid Release ..................... 38
Door Locks ......................... 32
Mirrors ............................ 98
Outlet (Auxiliary Electrical Outlet) ........ 176
Seats ............................. 136
Steering ........................ 320,321
Sunroof ........................... 173
Windows ........................... 35
Pregnant Women and Seat Belts .............. 57
Preparation for Jacking .................... 389
Pretensioners Seat Belts ........................... 52
Programmable Electronic Features ............ 219
Programming Transmitters
(Remote Keyless Entry) .................... 25
Radial Ply Tires ......................... 344
Radiator Cap (Coolant Pressure Cap) .......... 430Radio Operation
........................ 274
Radio Remote Controls .................... 272
Rear Cupholder ......................... 181
Rear Seat, Folding .................... 146,147
Rear Window Defroster ................... 186
Rear Window Features .................... 186
Rearview Mirrors ........................ 96
Recorder, Event Data ...................... 71
Recreational Towing ...................... 383
Reformulated Gasoline .................... 361
Refrigerant ............................ 422
Reminder, Seat Belt ....................... 56
Remote Control Door Locks ......................... 21
Security Alarm ....................... 18
Remote Keyless Entry (RKE) ................. 21
Remote Keyless Entry (Sedan) ............... 21
Remote Sound System (Radio) Controls ........ 272
Remote Starting System .................... 27
498 INDEX