tires CHRYSLER 200 2013 1.G Service Manual

WARNING!
Fast spinning tires can be dangerous. Forces gener-
ated by excessive wheel speeds may cause damage, or
even failure, of the axle and tires. A tire could
explode and injure someone. Do not spin your vehi-
cle’s wheels faster than 30 mph (48 km/h) or for
longer than 30 seconds continuously without stop-
ping when you are stuck and do not let anyone near
a spinning wheel, no matter what the speed.
SHIFT LEVER OVERRIDE
If a malfunction occurs and the shift lever cannot be
moved out of the PARK position, you can use the
following procedure to temporarily move the shift lever:
1. Turn the engine OFF.2. Firmly apply the parking brake.
3. Remove the rubber cupholder liner. Squeeze one side
of the liner’s center to expose its edge and facilitate
removal.
4. Turn the ignition to the ACC or ON/RUN position, but do not start the engine.
5. Press and maintain firm pressure on the brake pedal.
6. Insert a screwdriver or similar tool into the access hole (at the front of the cupholder) and push and hold the
override release lever forward.
7. Move the shift lever to the NEUTRAL position.
8. The vehicle may then be started in NEUTRAL.
9. Reinstall the cupholder liner.
416 WHAT TO DO IN EMERGENCIES

Once A Month Or Before A Long Trip:
•Check engine oil level
• Check windshield washer fluid level
• Check the tire inflation pressures and look for unusual
wear or damage
• Check the fluid levels of the coolant reservoir, brake
master cylinder, power steering and transmission as
needed
• Check function of all interior and exterior lights
Required Maintenance Intervals.
Refer to the maintenance schedules on the following
page for the required maintenance intervals.At Every Oil Change Interval As Indicated By Oil Change Indicator System:
•Change oil and filter.
• Rotate the tires. Rotate at the first sign of irregu-
lar wear, even if it occurs before the oil indicator
system turns on.
• Inspect battery and clean and tighten terminals as
required.
• Inspect automatic transmission fluid if equipped
with dipstick.
• Inspect brake pads, shoes, rotors, drums, hoses
and park brake.
•
Inspect engine cooling system protection and hoses.
• Inspect exhaust system.
• Inspect engine air cleaner if using in dusty or
off-road conditions.8
M
A I
N T
E
N
A
N
C E
S
C
H E
D
U L
E
SMAINTENANCE SCHEDULES 477

Diagnostic Procedure Manuals
Diagnostic Procedure Manuals are filled with diagrams,
charts and detailed illustrations. These practical manuals
make it easy for students and technicians to find and fix
problems on computer-controlled vehicle systems and
features. They show exactly how to find and correct
problems the first time, using step-by-step troubleshoot-
ing and drivability procedures, proven diagnostic tests
and a complete list of all tools and equipment.
Owner’s Manuals
These Owner’s Manuals have been prepared with the
assistance of service and engineering specialists to ac-
quaint you with specific Chrysler Group LLC vehicles.
Included are starting, operating, emergency and mainte-
nance procedures as well as specifications, capabilities
and safety tips.Call toll free at:
•
1–800–890–4038 (U.S.)
• 1–800–387–1143 (Canada)
Or
Visit us on the Worldwide Web at:
• www.techauthority.com
DEPARTMENT OF TRANSPORTATION UNIFORM
TIRE QUALITY GRADES
The following tire grading categories were established by
the National Highway Traffic Safety Administration. The
specific grade rating assigned by the tire’s manufacturer
in each category is shown on the sidewall of the tires on
your vehicle.
All passenger car tires must conform to Federal safety
requirements in addition to these grades.
9
IF YOU NEED CONSUMER ASSISTANCE 491

Treadwear
The Treadwear grade is a comparative rating, based on
the wear rate of the tire when tested under controlled
conditions on a specified government test course. For
example, a tire graded 150 would wear one and one-half
times as well on the government course as a tire graded
100. The relative performance of tires depends upon the
actual conditions of their use, however, and may depart
significantly from the norm due to variations in driving
habits, service practices, and differences in road charac-
teristics and climate.
Traction Grades
The Traction grades, from highest to lowest, are AA, A, B,
and C. These grades represent the tire’s ability to stop on
wet pavement, as measured under controlled conditions on
specified government test surfaces of asphalt and concrete.
A tire marked C may have poor traction performance.
WARNING!
The traction grade assigned to this tire is based on
straight-ahead braking traction tests, and does not
include acceleration, cornering, hydroplaning, or
peak traction characteristics.
492 IF YOU NEED CONSUMER ASSISTANCE

Temperature Grades
The temperature grades are A (the highest), B, and C,
representing the tire’s resistance to the generation of heat
and its ability to dissipate heat, when tested under
controlled conditions on a specified indoor laboratory
test wheel. Sustained high temperature can cause the
material of the tire to degenerate and reduce tire life, and
excessive temperature can lead to sudden tire failure. The
grade C corresponds to a level of performance, which all
passenger car tires must meet under the Federal Motor
Vehicle Safety Standard No. 109. Grades B and A repre-
sent higher levels of performance on the laboratory test
wheel, than the minimum required by law.
WARNING!
The temperature grade for this tire is established for
a tire that is properly inflated and not overloaded.
Excessive speed, under-inflation, or excessive load-
ing, either separately or in combination, can cause
heat buildup and possible tire failure.
9
IF YOU NEED CONSUMER ASSISTANCE 493

About Your Brakes....................... .324
ABS (Anti-Lock Brake System) ................327
Adding Engine Coolant (Antifreeze) ............444
Adding Fuel ............................ .377
Adding Washer Fluid ..................... .439
Additives, Fuel .......................... .371
Airbag ..................................60
Airbag Deployment ........................71
Airbag Light .............................68
Airbag Maintenance ........................73
Airbag, Side ..............................64
Airbag, Window (Side Curtain) ................64
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . .433
Air Conditioner Maintenance .................435
Air Conditioning ......................... .276
Air Conditioning Controls ...................276
Air Conditioning Filter .....................289
Air Conditioning, Operating Tips ..............290
Air Conditioning Refrigerant .................435Air Conditioning System
....................276
Air Pressure, Tires ........................ .348
Alarm System (Security Alarm) ................19
Alterations/Modifications, Vehicle ...............7
Antenna, Satellite Radio .....................264
Antifreeze (Engine Coolant) ..................443
Disposal ............................. .446
Anti-Lock Brake System (ABS) ................327
Anti-Lock Warning Light ....................327
Anti-Theft Security Alarm (Theft Alarm) ..........19
Appearance Care ........................ .454
Ashtray ............................... .197
Assistance Towing ........................ .126
Auto Down Power Windows ..................37
Automatic Dimming Mirror ..................107
Automatic Door Locks ......................34
Automatic Oil Change Indicator ...............216
Automatic Temperature Control (ATC) ..........281
Automatic Transaxle ........................12
496 INDEX

Interior Lights.......................... .170
Intermittent Wipers (Delay Wipers) .............173
Introduction ..............................4
Jacking Instructions ....................... .400
Jack Location ........................... .398
Jack Operation .......................... .398
Jump Starting ........................... .410
Key-In Reminder ..........................15
Keyless Entry System .......................22
Keyless Entry System (Sedan) .................22
Key, Programming .........................17
Key, Replacement ..........................16
Keys ...................................12
Key, Sentry (Immobilizer) ....................15
Knee Bolster ..............................60 Lane Change and Turn Signals
................218
Lane Change Assist ....................... .168
Lap/Shoulder Belts .........................46
Latches ............................... .101
Hood ............................... .163
Lead Free Gasoline ....................... .369
Leaks, Fluid ............................ .101
Life of Tires ............................ .356
Light Bulbs ............................. .101
Lights ................................ .101
Airbag ................................68
Back-Up ............................. .469
Battery Saver ......................... .171
Brake Assist Warning ....................334
Brake Warning ........................ .213
Bulb Replacement ...................... .466
Daytime Running ...................... .169
Electronic Stability Program (ESP) Indicator .....334
504 INDEX

Engine Temperature Warning...............212
Exterior ............................. .101
Fog ................................ .168
Headlights ........................... .166
Headlights On With Wipers ................176
Headlight Switch ...................... .166
High Beam Indicator .....................224
Illuminated Entry ........................21
Instrument Cluster ..................... .166
Interior ............................. .170
License ............................. .471
Lights On Reminder .....................167
Low Fuel .............................211
Malfunction Indicator (Check Engine) .........222
Map Reading ......................... .170
Oil Pressure .......................... .212
Passing ............................. .168
Seat Belt Reminder ..................... .212Security Alarm (Theft Alarm)
................19
Service .............................. .466
Theft Alarm (Security Alarm) ...............219
Tire Pressure Monitoring (TPMS) ............220
Traction Control ....................... .334
Turn Signal .......................... .101
Voltage ...............................211
Warning (Instrument Cluster Description) ......210
Loading Vehicle ......................... .380
Capacities ........................... .381
Tires ............................... .343
Locks ..................................32
Automatic Door .........................34
Auto Unlock ...........................34
Child Protection .........................35
Door .................................32
Power Door ............................33
Low Tire Pressure System ...................360
10
INDEX 505

PretensionersSeat Belts ..............................54
Programmable Electronic Features .............237
Radial Ply Tires ......................... .350
Radiator Cap (Coolant Pressure Cap) ...........445
Radio Operation ......................... .276
Radio Remote Controls .....................274
Rear Cupholder ......................... .198
Rear Seat, Folding ........................ .161
Rearview Mirrors ........................ .107
Rear Window Defroster .....................204
Rear Window Features .....................204
Recorder, Event Data .......................74
Recreational Towing ...................... .392
Reformulated Gasoline .....................369
Refrigerant ............................. .436
Reminder, Seat Belt .........................58 Remote Control
Door Locks ............................22
Security Alarm ..........................19
Remote Keyless Entry (RKE) ..................22
Remote Keyless Entry (Sedan) .................22
Remote Sound System (Radio) Controls .........274
Remote Starting System ......................28
Remote Trunk Release .......................40
Replacement Bulbs ....................... .465
Replacement Keys .........................16
Replacement Parts ........................ .427
Replacement Tires ........................ .357
Reporting Safety Defects ....................489
Resetting Oil Change Indicator ................216
Restraint, Head .......................... .157
Restraints, Child ...........................75
Rotation, Tires .......................... .359
508 INDEX

Service Manuals......................... .490
Settings, Personal ........................ .237
Setting the Clock ......................... .240
Shift Lever Override ...................... .416
Shoulder Belts ............................46
Side Airbag ..............................69
Side Window Demisters (Defrosters) ............289
Signals, Turn ........................... .101
Snow Chains (Tire Chains) ...................358
Snow Tires ............................. .351
Spare Tire .............................. .352
Speed Control (Cruise Control) ................177
Speedometer .............................211
Starting ............................... .296
Automatic Transmission ..................296
Cold Weather ......................... .298
Engine Fails to Start .....................298
Starting and Operating .....................296
Starting Procedures ....................... .296Steering
Power .............................. .323
Tilt Column .......................... .176
Wheel, Tilt ........................... .176
Steering Wheel Audio Controls ...............274
Steering Wheel Mounted Sound System Controls . . .274
Storage ............................... .465
Storage, Vehicle .......................... .288
Stuck, Freeing ........................... .414
Sun Roof .............................. .190
Supplemental Restraint System - Airbag ..........60
Synthetic Engine Oil ...................... .431
Tachometer ............................. .214
Taillights .............................. .469
Telescoping Steering Column .................176
Temperature Control, Automatic (ATC) ..........281
Temperature Gauge, Engine Coolant ............210
Theft Alarm (Security Alarm) ..................19
510 INDEX