fuel cap CHRYSLER 200 2016 2.G User Guide

ONBOARD DIAGNOSTIC SYSTEM — OBD II
Your vehicle is equipped with a sophisticated Onboard
Diagnostic system called OBD II. This system monitors
the performance of the emissions, engine, and automatic
transmission control systems. When these systems are
operating properly, your vehicle will provide excellent
performance and fuel economy, as well as engine emis-
sions well within current government regulations.
If any of these systems require service, the OBD II system
will turn on the Malfunction Indicator Light (MIL). It will
also store diagnostic codes and other information to
assist your service technician in making repairs. Al-
though your vehicle will usually be drivable and not
need towing, see your authorized dealer for service as
soon as possible.
CAUTION!
•Prolonged driving with the MIL on could cause
further damage to the emission control system. It
could also affect fuel economy and driveability.
The vehicle must be serviced before any emissions
tests can be performed.
• If the MIL is flashing while the engine is running,
severe catalytic converter damage and power loss
will soon occur. Immediate service is required.
Loose Fuel Filler Cap Message
If the vehicle diagnostic system determines that the fuel
filler cap is loose, improperly installed, or damaged, a
“CHECK GASCAP” message will be displayed in the
Electronic Vehicle Information Center (EVIC) or Driver
Information Display (DID). Refer to “Electronic Vehicle
Information (EVIC) or Driver Information Display
(DID)” in “Understanding Your Instrument Panel” for
7
MAINTAINING YOUR VEHICLE 591

further information. Tighten the fuel filler cap until a
“clicking” sound is heard. This is an indication that the
fuel filler cap is properly tightened. Refer to “Onboard
Diagnostic System” in “Maintaining Your Vehicle” for
further information.
EMISSIONS INSPECTION AND MAINTENANCE
PROGRAMS
In some localities, it may be a legal requirement to pass
an inspection of your vehicle’s emissions control system.
Failure to pass could prevent vehicle registration.For states that require an Inspection and Mainte-
nance (I/M), this check verifies the “Malfunction
Indicator Light (MIL)” is functioning and is not
on when the engine is running, and that the OBD II
system is ready for testing. Normally, the OBD II system will be ready. The OBD II
system may
notbe ready if your vehicle was recently
serviced, recently had a dead battery or a battery replace-
ment. If the OBD II system should be determined not
ready for the I/M test, your vehicle may fail the test.
Your vehicle has a simple ignition actuated test, which
you can use prior to going to the test station. To check if
your vehicle’s OBD II system is ready, you must do the
following:
1. Cycle the ignition switch to the ON position, but do not crank or start the engine.
NOTE: If you crank or start the engine, you will have to
start this test over.
2. As soon as you cycle the ignition switch to the ON position, you will see the Malfunction Indicator Light
(MIL) symbol come on as part of a normal bulb check.
592 MAINTAINING YOUR VEHICLE

CAUTION!
Do not use chemical flushes in your engine oil as the
chemicals can damage your engine. Such damage is
not covered by the New Vehicle Limited Warranty.
Engine Oil Viscosity (SAE Grade) — 2.0L, 2.4L
Engine
MOPAR SAE 0W-20 engine oil approved to FCA US
Material Standard MS-6395 such as Pennzoil, Shell Helix
or equivalent is recommended for all operating tempera-
tures. This engine oil improves low temperature starting
and vehicle fuel economy.
The engine oil filler cap also shows the recommended
engine oil viscosity for your engine. For information on
engine oil filler cap location, refer to “Engine Compart-
ment” in this section.Lubricants which do not have both the engine oil certi-
fication mark and the correct SAE viscosity grade num-
ber should not be used.
Engine Oil Viscosity — 3.6L Engine
MOPAR SAE 5W-20 engine oil approved to FCA US
Material Standard MS-6395 such as Pennzoil, Shell Helix
or equivalent is recommended for all operating tempera-
tures. This engine oil improves low temperature starting
and vehicle fuel economy.
The engine oil filler cap also shows the recommended
engine oil viscosity for your engine. For information on
engine oil filler cap location, refer to the “Engine Com-
partment” illustration in this section.
NOTE:
MOPAR SAE 5W-30 engine oil approved to FCA
US Material Standard MS-6395 such as Pennzoil, Shell
Helix or equivalent may be used when SAE 5W-20 engine
oil meeting MS-6395 is not available.
7
MAINTAINING YOUR VEHICLE 597

FLUID CAPACITIES
U.S.Metric
Fuel (Approximate)
2.4L and 3.6L Engines 15.8 Gallons60 Liters
Engine Oil With Filter
2.4 Liter Engine (SAE 0W-20, API Certified) 5.5 Quarts5.2 Liters
3.6 Liter Engine (SAE 5W-20, API Certified) 6 Quarts5.6 Liters
Cooling System*
2.4 Liter Engine (MOPAR Antifreeze/Engine Coolant
10 Year/150,000 Mile Formula) 7.2 Quarts
6.8 Liters
3.6 Liter Engine (MOPAR Antifreeze/Engine Coolant
10 Year/150,000 Mile Formula) 8.7 Quarts
8.2 Liters
* Includes heater and coolant reservoir filled to MAX level.
7
MAINTAINING YOUR VEHICLE 653

Transmitter Battery Replacement.............25
Belts, Seat ...............................110
Body Mechanism Lubrication .................605
B-Pillar Location ......................... .495
Brake Assist System ...................... .478
Brake Control System, Electronic ..............475
Brake Fluid ............................ .657
Brake System ........................ .474, 615
Anti-Lock (ABS) ....................... .474
Fluid Check ....................... .615, 657
Master Cylinder ....................... .615
Warning Light ........................ .323
Brake/Transmission Interlock .................453
Brightness, Interior Lights ...................167
Bulb Replacement ..................639, 641, 646
Bulbs, Light .......................112, 639, 646
Camera, Rear ........................... .268
Capacities, Fluid ......................... .653Caps, Filler
Fuel ................................ .532
Oil (Engine) ....................589, 590, 597
Radiator (Coolant Pressure) ................612
Carbon Monoxide Warning ...............109, 528
Cargo Area Features ...................... .304
Cargo Compartment ...................... .304
Car Washes ............................ .619
Certification Label ........................ .536
Chains, Tire ............................ .512
Changing A Flat Tire ...................... .558
Chart, Tire Sizing ........................ .489
Check Engine Light (Malfunction Indicator Light) . .592
Checking Your Vehicle For Safety ..............108
Checks, Safety .......................... .108
Child Restraint ............................86
Child Restraints Booster Seats ...........................90
Center Seat LATCH ......................99
680 INDEX

Coolant (Antifreeze).....................654
Cooling ............................. .609
Exhaust Gas Caution .................109, 528
Fails To Start ......................... .449
Flooded, Starting ...................... .449
Fuel Requirements ..................... .524
Jump Starting ......................... .572
Oil .......................... .595, 653, 654
Oil Filler Cap ...................589, 590, 597
Oil Filter ............................ .598
Oil Selection ...................... .596, 653
Oil Synthetic ......................... .598
Overheating .......................... .545
Starting ............................. .447
Engine Oil Viscosity ...................... .597
Engine Oil Viscosity Chart ...................597
Enhanced Accident Response Feature ............81
Entry System, Illuminated ....................21
Ethanol ............................ .525, 529Event Data Recorder
........................85
Exhaust Gas Caution ...................109, 528
Exhaust System ...................... .109, 606
Exterior Lighting ..................... .159, 646
Exterior Lights ........................112,646
Filters Air Cleaner .......................... .599
Air Conditioning ....................419, 602
Engine Oil ........................ .598, 654
Engine Oil Disposal .....................598
Flashers Hazard Warning ....................... .545
Turn Signal ..................112, 165, 347, 644
Flash-To-Pass ........................... .165
Flexible Fuel Vehicles Cruising Range ........................ .531
Engine Oil ........................... .531
Fuel Requirements ...................529, 530
684 INDEX

Maintenance.......................... .532
Replacement Parts ...................... .531
Starting ............................. .531
Flooded Engine Starting ....................449
Floor Console ........................... .300
Fluid, Brake ............................ .657
Fluid Capacities ......................... .653
Fluid Leaks .............................112
Fluid Level Checks Brake ............................... .615
Engine Oil ........................... .595
Fluids, Lubricants And Genuine Parts ...........654
Fog Lights .......................... .163, 647
Fog Light Service ........................ .647
Folding Rear Seat ........................ .152
Forward Collision Warning ..................209
Freeing A Stuck Vehicle .....................576
Front Position Light ...................... .646
Fuel .................................. .524Additives
............................ .527
Clean Air ............................ .525
Ethanol .......................... .525, 529
Filler Cap (Gas Cap) .....................532
Gasoline ............................. .524
Light ............................... .340
Materials Added ....................... .527
Methanol ............................ .525
Octane Rating ..................... .524, 654
Requirements ......................... .524
Specifications ......................... .654
Tank Capacity ......................... .653
Fuel, Flexible ........................... .529
Fuses ................................. .625
Garage Door Opener (HomeLink) ..........274, 282
Gas Cap (Fuel Filler Cap) ...................532
Gasoline,

Clean Air ....................... .525
Gasoline, Reformulated .....................52510
INDEX 685

Memory Seats And Radio...................153
Methanol .............................. .525
Mirrors ............................... .120
Electric Powered ....................... .129
Electric Remote ........................ .129
Exterior Folding ....................... .128
Heated .............................. .130
Outside ............................. .128
Rearview ......................... .120, 121
Vanity .............................. .131
Modifications/Alterations, Vehicle ...............7
Monitor, Tire Pressure System ................514
MOPAR Parts ........................ .593, 671
MTBE/ETBE ........................... .525
Multi-Function Control Lever .................164
New Vehicle Break-In Period .................107
Occupant Restraints ........................47 Octane Rating, Gasoline (Fuel)
.............524, 654
Oil, Engine ......................... .595, 654
Capacity ............................ .653
Change Interval ....................... .596
Checking ............................ .595
Dipstick ............................. .595
Disposal ............................. .598
Filter ............................ .598, 654
Filter Disposal ........................ .598
Identification Logo ..................... .596
Materials Added To ..................... .598
Pressure Warning Light ...................328
Recommendation ....................596, 653
Synthetic ............................ .598
Viscosity ......................... .597, 653
Oil Filter, Change ........................ .598
Oil Filter, Selection ....................... .598
Oil Pressure Light ........................ .328
Onboar

d Diagnostic System ..................591
690 INDEX