maintenance schedule CHRYSLER 200 2016 2.G User Guide

Brake System
In order to assure brake system performance, all brake
system components should be inspected periodically.
Refer to the “Maintenance Schedule” for the proper
maintenance intervals.
WARNING!
Riding the brakes can lead to brake failure and
possibly a collision. Driving with your foot resting or
riding on the brake pedal can result in abnormally
high brake temperatures, excessive lining wear, and
possible brake damage. You would not have your full
braking capacity in an emergency.
Brake Master Cylinder
The fluid in the master cylinder should be checked when
performing under hood services or immediately if the
“Brake Warning Light” is illuminated.Be sure to clean the top of the master cylinder area before
removing the cap. If necessary, add fluid to bring the
fluid level up to the requirements described on the brake
fluid reservoir. With disc brakes, fluid level can be
expected to fall as the brake pads wear. Brake fluid level
should be checked when pads are replaced. However,
low fluid level may be caused by a leak and a checkup
may be needed.
Use only manufacturer’s recommended brake fluid. Re-
fer to “Fluids, Lubricants, And Genuine Parts” in “Main-
taining Your Vehicle” for further information.
WARNING!
•
Use only manufacturer’s recommended brake
fluid. Refer to “Fluids, Lubricants, And Genuine
Parts” in “Maintaining Your Vehicle” for further
information. Using the wrong type of brake fluid
(Continued)
7
MAINTAINING YOUR VEHICLE 615

MAINTENANCE SCHEDULES
CONTENTS
MAINTENANCE SCHEDULE .............660▫Maintenance Chart ....................662
8

MAINTENANCE SCHEDULE
Your vehicle is equipped with an automatic oil change
indicator system. The oil change indicator system will
remind you that it is time to take your vehicle in for
scheduled maintenance.
Based on engine operation conditions, the oil change
indicator message will illuminate. This means that ser-
vice is required for your vehicle. Operating conditions
such as frequent short-trips, trailer tow, extremely hot or
cold ambient temperatures will influence when the “Oil
Change Required” message is displayed. Severe Operat-
ing Conditions can cause the change oil message to
illuminate as early as 3,500 miles (5,600 km) since last
reset. Have your vehicle serviced as soon as possible,
within the next 500 miles (805 km).
Your authorized dealer will reset the oil change indicator
message after completing the scheduled oil change. If a
scheduled oil change is performed by someone otherthan your authorized dealer, the message can be reset by
referring to the steps described under “Oil Change Reset”
in “Electronic Vehicle Information Center (EVIC)” or
Driver Information Display (DID)” in “Understanding
Your Instrument Panel” for further information.
NOTE:
Under no circumstances should oil change inter-
vals exceed 10,000 miles (16,000 km), twelve months or
350 hours of engine run time, whichever comes first. The
350 hours of engine run or idle time is generally only a
concern for fleet customers.
Severe Duty All Models
Change Engine Oil at 4,000 miles (6,500 km) if the vehicle
is operated in a dusty and off road environment or is
operated predominately at idle or only very low engine
RPM’s. This type of vehicle use is considered Severe
Duty.
660 MAINTENANCE SCHEDULES

Once A Month Or Before A Long Trip:
•Check engine oil level.
• Check windshield washer fluid level.
• Check tire pressure and look for unusual wear or
damage. Rotate tires at the first sign of irregular wear,
even if it occurs before the oil indicator system turns
on.
• Check the fluid levels of the coolant reservoir and
brake master cylinder, fill as needed.
• Check function of all interior and exterior lights.
Required Maintenance Intervals
Refer to the maintenance schedules on the following
page for the required maintenance intervals.At Every Oil Change Interval As Indicated By Oil Change Indicator System:
•Change oil and filter
• Rotate the tires. Rotate at the first sign of irregu-
lar wear, even if it occurs before the oil indicator
system turns on.
• Inspect battery and clean and tighten terminals as
required
• Inspect brake pads, shoes, rotors, drums, hoses
and park brake
• Inspect engine cooling system protection and
hoses
• Inspect exhaust system
• Inspect engine air cleaner if using in dusty or
off-road conditions 8
MAINTENANCE SCHEDULES 661

Maintenance Chart
Mileage:20,000
30,000
40,000
50,000
60,000
70,000
80,000
90,000
100,000
110,000
120,000
130,000
140,000
150,000
Or Years: 2 3 4 5 6 7 8 9 10 11 12 13 14 15
Or Kilometers:
32,000
48,000
64,000
80,000
96,000
112,000
128,000
144,000
160,000
176,000
192,000
208,000
224,000
240,000
Additional Inspections
Inspect the CV joints. X X X X X X X
Inspect front suspension, boot seals, tie rod ends,
and replace if necessary. XXX X X X X
Inspect the brake linings, parking brake function. X X X X X X X
Inspect front accessory drive belt, tensioner, idler
pulley, and replace if necessary X
Additional Maintenance
Replace engine air cleaner filter. XX X XX
Replace air conditioning/cabin air filter. X X X X X X X
662 MAINTENANCE SCHEDULES

Mileage:20,000
30,000
40,000
50,000
60,000
70,000
80,000
90,000
100,000
110,000
120,000
130,000
140,000
150,000
Or Years: 2 3 4 5 6 7 8 9 10 11 12 13 14 15
Or Kilometers:
32,000
48,000
64,000
80,000
96,000
112,000
128,000
144,000
160,000
176,000
192,000
208,000
224,000
240,000
Replace spark plugs ** X
Flush and replace the engine coolant at 10 years
or 150,000 miles (240,000 km) whichever comes
first. XX
Inspect and replace PCV valve if necessary. X
** The spark plug change interval is mileage based only,
yearly intervals do not apply.WARNING!
• You can be badly injured working on or around a
motor vehicle. Do only service work for which you
have the knowledge and the right equipment. If
(Continued)
8
MAINTENANCE SCHEDULES 663

WARNING!(Continued)
you have any doubt about your ability to perform a
service job, take your vehicle to a competent me-
chanic.
• Failure to properly inspect and maintain your ve-
hicle could result in a component malfunction and
effect vehicle handling and performance. This
could cause an accident.
664 MAINTENANCE SCHEDULES

Lights On Reminder.....................163
Low Fuel ............................ .340
Malfunction Indicator (Check Engine) .........333
Parade Mode (Daytime Brightness) ...........169
Park ............................... .346
Passing ............................. .165
Reading .......................... .166, 272
Seat Belt Reminder ..................... .321
Security Alarm ........................ .325
Service .............................. .641
Side Marker ....................... .644, 646
Tire Pressure Monitoring (TPMS) .........337, 514
Traction Control ....................... .485
Turn Signal ..............112, 164, 165, 347, 644
Vanity Mirror ......................... .131
Warning (Instrument Cluster Description) . . .326, 347
Loading Vehicle ......................... .536
Tires ............................... .495Locks
..................................31
Automatic Door .........................34
Auto Unlock ...........................34
Child Protection .........................34
Door .................................31
Power Door ............................33
Low Tire Pressure System ...................514
Lubrication, Body ........................ .605
Lug Nuts .............................. .546
Maintenance Free Battery ....................599
Maintenance Procedures ....................594
Maintenance Schedule ..................... .660
Malfunction Indicator Light (Check Engine) . . .333, 592
Manual, Service ......................... .672
Marker Lights, Side ....................... .644
Master Cylinder (Brakes) ....................615
Memory Feature (Memory Seat) ...............153
Memory Seat ........................... .153
10
INDEX 689

Remote Starting System......................27
Remote Trunk Release .......................45
Replacement Bulbs ....................... .639
Replacement Parts ........................ .593
Replacement Tires ........................ .510
Reporting Safety Defects ....................671
Restraint, Head .......................... .148
Restraints, Child ...........................86
Restraints, Occupant ........................47
Rotation, Tires .......................... .513
Safety Checks Inside Vehicle ..................110
Safety Checks Outside Vehicle ................112
Safety Defects, Reporting ....................671
Safety, Exhaust Gas ....................... .109
Safety Information, Tire .....................488
Safety Tips ............................. .108
Schedule, Maintenance .....................660 Seat Belt
Adjustable Upper Shoulder Belt Anchorage ......55
Automatic Locking Retractor (ALR) ...........58
Energy Management Feature ................58
Lap/Shoulder Belt Operation ................53
Lap/Shoulder Belts .......................50
Lap/Shoulder Belt Untwisting ...............55
Pregnant Women ........................57
Seat Belt Extender .......................56
Seat Belt Pretensioner .....................58
Seat Belt Reminder .......................49
Seat Belt System .........................47
Seat Belt Maintenance ..................... .624
Seat Belt Reminder .........................49
Seat Belts ............................ .48, 110
Adjustable Shoulder Belt ...................55
Adjustable Upper Shoulder Anchorage .........55
Child Restraint ..........................86
Extender ..............................56
10
INDEX 693