ESP CHRYSLER 200 2016 2.G Repair Manual

Please note that it is the owner’s responsibility to main-
tain the proper level of protection against freezing ac-
cording to the temperatures occurring in the area where
the vehicle is operated.
NOTE:
•Some vehicles require special tools to add coolant
properly. Failure to fill these systems properly could
lead to severe internal engine damage. If any coolant is
needed to be added to the system, please contact your
local authorized dealer.
• Mixing engine coolant (antifreeze) types is not recom-
mended and can result in cooling system damage. If
HOAT and OAT coolant are mixed in an emergency,
have a authorized dealer drain, flush, and refill with
OAT coolant (conforming to MS.90032) as soon as
possible.Cooling System Pressure Cap
The cap must be fully tightened to prevent loss of engine
coolant (antifreeze), and to ensure that engine coolant
(antifreeze) will return to the radiator from the coolant
recovery tank.
The cap should be inspected and cleaned if there is any
accumulation of foreign material on the sealing surfaces.
WARNING!
• Do not open hot engine cooling system. Never add
engine coolant (antifreeze) when the engine is
overheated. Do not loosen or remove the cap to cool
an overheated engine. Heat causes pressure to
build up in the cooling system. To prevent scalding
or injury, do not remove the pressure cap while the
system is hot or under pressure.
(Continued)
612 MAINTAINING YOUR VEHICLE

Special Care
•If you drive on salted or dusty roads or if you drive
near the ocean, hose off the undercarriage at least once
a month.
• It is important that the drain holes in the lower edges
of the doors, rocker panels, and trunk be kept clear and
open.
• If you detect any stone chips or scratches in the paint,
touch them up immediately. The cost of such repairs is
considered the responsibility of the owner.
• If your vehicle is damaged due to a collision or similar
cause that destroys the paint and protective coating,
have your vehicle repaired as soon as possible. The
cost of such repairs is considered the responsibility of
the owner. •
If you carry special cargo such as chemicals, fertilizers,
de-icer salt, etc., be sure that such materials are well
packaged and sealed.
• If a lot of driving is done on gravel roads, consider
mud or stone shields behind each wheel.
• Use MOPAR Touch Up Paint on scratches as soon as
possible. Your authorized dealer has touch up paint to
match the color of your vehicle.
Wheel And Wheel Trim Care
• All wheels and wheel trim, especially aluminum and
chrome plated wheels, should be cleaned regularly
with a mild soap and water to prevent corrosion.
• To remove heavy soil and/or excessive brake dust, use
MOPAR Wheel Cleaner.
620 MAINTAINING YOUR VEHICLE

Interior Care
Use MOPAR Total Clean to clean fabric upholstery and
carpeting.
Use MOPAR Total Clean to clean vinyl upholstery.
MOPAR Total Clean is specifically recommended for
leather upholstery.
Your leather upholstery can be best preserved by regular
cleaning with a damp soft cloth. Small particles of dirt
can act as an abrasive and damage the leather upholstery
and should be removed promptly with a damp cloth.
Stubborn soils can be removed easily with a soft cloth
and MOPAR Total Clean. Care should be taken to avoid
soaking your leather upholstery with any liquid. Please
do not use polishes, oils, cleaning fluids, solvents, deter-
gents, or ammonia-based cleaners to clean your leather
upholstery. Application of a leather conditioner is not
required to maintain the original condition.
WARNING!
Do not use volatile solvents for cleaning purposes.
Many are potentially flammable, and if used in
closed areas they may cause respiratory harm.
CAUTION!
Direct contact of air fresheners, insect repellents,
suntan lotions, or hand sanitizers to the plastic,
painted, or decorated surfaces of the interior may
cause permanent damage. Wipe away immediately.
CAUTION!
Damage caused by these type of products may not be
covered by your New Vehicle Limited Warranty.
622 MAINTAINING YOUR VEHICLE

Warranty expires. The manufacturer stands behind only
the manufacturer’s service contracts. If you purchased a
manufacturer’s service contract, you will receive Plan
Provisions and an Owner Identification Card in the mail
within three weeks of the vehicle delivery date. If you
have any questions about the service contract, call the
manufacturer’s Service Contract National Customer
Hotline at 1-800-521-9922 (Canadian residents, call (800)
465-2001 English / (800) 387-9983 French).
The manufacturer will not stand behind any service
contract that is not the manufacturer’s service contract. It
is not responsible for any service contract other than the
manufacturer’s service contract. If you purchased a ser-
vice contract that is not a manufacturer’s service contract,
and you require service after the manufacturer’s New
Vehicle Limited Warranty expires, please refer to the
contract documents, and contact the person listed in
those documents.We appreciate that you have made a major investment
when you purchased the vehicle. An authorized dealer
has also made a major investment in facilities, tools, and
training to assure that you are absolutely delighted with
the ownership experience. You will be pleased with their
sincere efforts to resolve any warranty issues or related
concerns.
WARNING!
Engine exhaust (internal combustion engines only),
some of its constituents, and certain vehicle compo-
nents contain, or emit, chemicals known to the State
of California to cause cancer and birth defects, or
other reproductive harm. In addition, certain fluids
contained in vehicles and certain products of compo-
nent wear contain, or emit, chemicals known to the
State of California to cause cancer and birth defects,
or other reproductive harm.
670 IF YOU NEED CONSUMER ASSISTANCE

significantly from the norm due to variations in driving
habits, service practices, and differences in road charac-
teristics and climate.
Traction Grades
The Traction grades, from highest to lowest, are AA, A, B,
and C. These grades represent the tire’s ability to stop on
wet pavement, as measured under controlled conditions
on specified government test surfaces of asphalt and
concrete. A tire marked C may have poor traction perfor-
mance.
WARNING!
The traction grade assigned to this tire is based on
straight-ahead braking traction tests, and does not
include acceleration, cornering, hydroplaning, or
peak traction characteristics.
Temperature Grades
The temperature grades are A (the highest), B, and C,
representing the tire’s resistance to the generation of heat
and its ability to dissipate heat, when tested under
controlled conditions on a specified indoor laboratory
test wheel. Sustained high temperature can cause the
material of the tire to degenerate and reduce tire life, and
excessive temperature can lead to sudden tire failure. The
grade C corresponds to a level of performance, which all
passenger vehicle tires must meet under the Federal
Motor Vehicle Safety Standard No. 109. Grades B and A
represent higher levels of performance on the laboratory
test wheel, than the minimum required by law.
674 IF YOU NEED CONSUMER ASSISTANCE

About Your Brakes....................... .474
Adaptive Cruise Control (ACC) (Cruise Control) . . .182
Adding Engine Coolant (Antifreeze) ............611
Additives, Fuel .......................... .527
Adjust Down .............................. .141
Forward ............................. .141
Rearward ............................ .141
Up ................................ .141
AirBag.............................. .61, 62
Advance Front Air Bag ...............62, 63, 64
Air Bag Operation .......................64
Air Bag Warning Light ..................65, 82
Driver Knee Air Bag ......................75
Enhanced Accident Response ................81
Event Data Recorder (EDR) .................85
FrontAirBag......................61, 62, 65
Front Passenger Knee Air Bag ...............75
If A Deployment Occurs ...................80 Knee Impact Bolsters
.....................74
Maintaining Your Air Bag System ............84
Redundant Air Bag Warning Light ............83
Side Air Bags ...........................75
Transporting Pets ...................... .107
Air Bag Deployment ........................61
Air Bag Light ..................... .82, 110, 322
Air Bag Maintenance .......................84
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . .599
Air Conditioner Maintenance .................601
Air Conditioning ..................... .398, 403
Air Conditioning Controls ................398, 403
Air Conditioning Filter ..................419, 602
Air Conditioning, Operating Tips ...........418, 420
Air Conditioning Refrigerant .................601
Air Conditioning System ..........398, 403, 416, 601
Air Filter .............................. .599
Air Pressure, Tires ........................ .502
678 INDEX

Coolant (Antifreeze).....................654
Cooling ............................. .609
Exhaust Gas Caution .................109, 528
Fails To Start ......................... .449
Flooded, Starting ...................... .449
Fuel Requirements ..................... .524
Jump Starting ......................... .572
Oil .......................... .595, 653, 654
Oil Filler Cap ...................589, 590, 597
Oil Filter ............................ .598
Oil Selection ...................... .596, 653
Oil Synthetic ......................... .598
Overheating .......................... .545
Starting ............................. .447
Engine Oil Viscosity ...................... .597
Engine Oil Viscosity Chart ...................597
Enhanced Accident Response Feature ............81
Entry System, Illuminated ....................21
Ethanol ............................ .525, 529Event Data Recorder
........................85
Exhaust Gas Caution ...................109, 528
Exhaust System ...................... .109, 606
Exterior Lighting ..................... .159, 646
Exterior Lights ........................112,646
Filters Air Cleaner .......................... .599
Air Conditioning ....................419, 602
Engine Oil ........................ .598, 654
Engine Oil Disposal .....................598
Flashers Hazard Warning ....................... .545
Turn Signal ..................112, 165, 347, 644
Flash-To-Pass ........................... .165
Flexible Fuel Vehicles Cruising Range ........................ .531
Engine Oil ........................... .531
Fuel Requirements ...................529, 530
684 INDEX