wheel CHRYSLER 200 2016 2.G Warranty Booklet

TOWING IS COVERED
If your vehicle has to be towed because a part covered by warranty failed, towing to the nearest FCA
Retailer will be covered by the Roadside Assistance Program (for details, see page 10).
Important: Some vehicles have special towing requirements. See your Owner’s Manual for towing
instructions.
3/60 BASIC WARRANTY
If required because of a defect in material or workmanship, the 3/60 Basic Warranty will cover the
adjustment, repair or replacement of any factory-installed part of your vehicle except tires for3 years
or 60,000 kilometres, whichever occurs first. The following items are exceptions; they are only
covered (if defective) for 1 year or 20,000 kilometres, whichever occurs first:
• light bulbs and fuses
• wiper blades
• clutch discs
• brakes (rotors, pads, linings and drums)
• windshield and rear window
• wheel alignment and wheel balancing
Tires are warranted by the tire manufacturers, not by FCA. For details, see the tire manufacturer’s
warranty booklet in your glovebox. Your FCA Retailer may be able to assist you if you experience
a problem with a factory-installed tire.
Tires and spare tire should be replaced after six years, regardless of the remaining tread. Failure to
follow this warning can result in sudden tire failure. You could lose control and have an accident
resulting in serious injury or death.
5/100 POWERTRAIN WARRANTY
The following powertrain components are covered for 5 years or 100,000 kilometres,whichever
occurs first, measured from the vehicle’s original warranty start date.
Vehicles placed in taxi, limousine, postal or ambulance service and all SRT vehicles are excluded
from the 5-year or 100,000-kilometre Powertrain Warranty and are covered only under the 3-year or
60,000-kilometre Basic Warranty.
• Gas Engine (If equipped) – Cylinder block and all internal parts; cylinder head assemblies; timing
case, timing chain, timing belt, gears and sprockets; vibration damper; oil pump; water pump and
housing; intake and exhaust manifolds; flywheel with starter ring gear; core plugs; valve covers;
oil pan; turbocharger housing and internal parts; turbocharger wastegate actuator; supercharger;
serpentine belt tensioner; seals and gaskets for listed components only.
• Diesel Engine (If equipped) – Cylinder block and all internal parts; cylinder head assemblies; core
plugs; fuel injection pump and injectors; intake and exhaust manifolds; oil pan; oil pump; timing
gear drive belts and/or chains and cover; turbocharger housing and internal parts; valve covers;
water pump and housing; seals and gaskets for listed components only.
• Front-Wheel Drive (If equipped) –Transaxle case and all internal parts; axle shaft assemblies;
constant velocity joints and boots; differential cover; oil pan; transaxle speed sensors; transaxle
solenoid assembly; PRNDL position switch; transaxle electronic controller; torque converter; seals
and gaskets for listed components only.
• Rear-Wheel Drive (If equipped)– Transmission case and all internal parts; torque converter,
drive/flex plate; transmission range switch; transmission control module; bell housing; oil pan;
seals and gaskets for listed components only. Rear axle housing and all internal parts; axle shafts;
axle shaft bearings; driveshaft assemblies; driveshaft centre bearings; universal joints and yokes;
seals and gaskets for listed components only.
Note: Manual transmission clutch parts are not covered at any time.
4

•4-Wheel Drive (4x4) (If equipped)– Transfer case and all internal parts; transfer case control
module and shift mode motor assembly; axle housing and all internal parts; axle shafts; axle shaft
bearings; driveshaft assemblies (front and rear); driveshaft centre bearings; universal joints and
yokes; disconnect housing assembly; seals and gaskets for listed components only.
• All-Wheel Drive (AWD) (If equipped)– Power transfer unit and all internal parts; driveshaft and
axle shaft assemblies; constant velocity joints and boots; axle housing and all internal parts;
differential carrier assembly and all internal parts; output ball bearing; output flange; end cover;
viscous converter clutch; overrunning clutch; vacuum motor; torque tube; pinion spacer and shim;
seals and gaskets for these parts only.
CORROSION WARRANTY
For 3 years, regardless of distance driven, your Corrosion Warranty covers any body sheet metal
panel which develops a hole caused by corrosion.
In addition, outer body panels are covered against holes caused by corrosion up to 5 years or 160,000
kilometres, whichever occurs first. An outer body panel is a sheet metal panel which can be seen
while walking around the vehicle, and which is painted body colour.
This warranty applies only to holes caused by corrosion. Cosmetic or surface corrosion (resulting
from stone chips or scratches in the paint, for example) will not be repaired under this warranty.
If corrosion damage is obviously neglected and allowed to worsen until a hole develops, this warranty
will not cover the repair.
EMISSION WARRANTIES
FCA Canada Inc. warrants that your new vehicle was designed, built and equipped to conform at the
time of sale with applicable federal and provincial emissions standards, and that the vehicle is, at the
time of sale, free from defects in material and workmanship which would cause it to fail to conform
to the applicable emission standards within the warranty periods specified. A covered defect is one
which causes your vehicle to fail to meet applicable emission control regulations.
To keep your vehicle operating properly and in conformance with emission regulations, see the
Scheduled Maintenance instructions in your Owner’s Manual and herein. Only FCA parts should be
used for maintenance and repair of your vehicle’s emission control systems.
You should keep any receipts for maintenance service and pass them on to the next owner of your
vehicle, in case questions arise concerning maintenance. FCA Canada Inc. has the right to deny
warranty coverage if your vehicle has not been properly maintained, or if repairs are needed because
parts other than FCA parts were used; however, denial will not be based on the lack of maintenance
records alone.
Warranty service must be performed by an authorized FCA Retailer.
If emergency warranty service is required and an authorized retailer is not available, contact FCA
Customer Assistance (page 9) and request emission warranty service help.
EMISSION DEFECT WARRANTY
The 3/60 Basic Warranty covers all emission control components for 3 years or 60,000 kilometres,
whichever occurs first. The Emission Defect Warranty provides longer coverage for specified
components.
The Defect Warranty covers the following major emission control parts, if so equipped, for 8 years
or 130,000-kilometres, whichever occurs first:
• catalytic converter
• powertrain control module
To receive this coverage the vehicles onboard diagnostic system must indicate a failed emission
component.
5

EMISSION PERFORMANCE WARRANTY
The Emission Performance Warranty only applies to cars and trucks with a GVW less than 3,855 kg
(8,500 lb).
For2 years or 40,000 kilometres, whichever occurs first, the Performance Warranty will cover the
cost of repairing or adjusting any components or parts of your vehicle that might be necessary to pass
an approved provincial Inspection/Maintenance (I/M) program’s emissions test, but only if:
• your vehicle failed an approved provincial I/M emissions test; and
• your vehicle was properly maintained and operated until it failed the test; and
• warranty service is required in order for your vehicle to pass the provincial I/M test
Provincial test fees, if any, are not covered by this warranty.
If your province does not require emission testing, this 2/40 Emission Performance Warranty does not
apply.
HOW TO GET SERVICE UNDER THIS WARRANTY
If your vehicle fails an approved I/M emissions test within the Emission Performance Warranty
period, take it to an authorized FCA Retailer as soon as possible. Give the service representative the
printout that shows your vehicle failed the test. If possible, bring all service receipts, maintenance logs
and records to prove that your vehicle has been properly maintained.
WHAT IS NOT COVERED
DAMAGE FROM MISUSE OR ACCIDENT
The warranties in this booklet do not cover repairs required due to fire, accidents, abuse, negligence,
objects striking your vehicle, carrying corrosive materials (such as chemicals, acids and fertilizers),
misuse (such as driving over curbs, overloading, spinning wheels, etc.), racing or participating in a
racing event, improper disconnection of components, modifying the exhaust system, tampering or
making adjustments which do not comply with FCA specifications.
Disconnecting, tampering with or changing the reading of the odometer will void your warranties.
DAMAGE FROM THE ENVIRONMENT
The warranties in this booklet do not cover fading or deterioration caused by exposure to the elements,
or repairs required due to airborne fallout, acid rain, chemicals, tree sap, insects, bird or insect
droppings, salt, sand, gravel, road hazards, hail, windstorms, lightning, floods or any other event of
nature.
Road salt, car washes, scuffs and scratches, and everyday abrasion from sand and dirt can affect the
appearance of a vehicle’s wheels (steel, chrome and aluminum) and other undercarriage parts. Some
surface corrosion with use is normal; it is not a defect and is not covered by any warranty.
NORMAL MAINTENANCE AND WEAR
The warranties in this booklet do not cover normal maintenance services, such as oil and filter
changes, general lubrication, tire rotation, engine tune-ups and replacing spark plugs. Required
maintenance services are described in detail in your Owner’s Manual and herein. The warranties also
do not cover worn wiper blades, clutch discs, brake rotors, pads, linings or drums, windshield and rear
window, wheel alignment and wheel balancing (unless they are defective, see page 4).
6

IN REMOTE LOCATIONS
If your vehicle suffers a warrantable mechanical breakdown at a considerable distance from a FCA
Retailer, we reserve the right to engage a nearby non-FCA service facility to repair your vehicle, to
minimize inconvenience to you.
In very remote areas, if your vehicle cannot be taken by road to the servicing retailer, transportation
by rail or water may be necessary. The program will cover a tow to the dock or rail terminal and also
to the retailer at the end of the trip, but special transportation by rail or water must be arranged for
and paid by you. We will reimburse you for special transportation costs, up to $300 per incident.
IF YOU HAVE TO PAY
If you have to pay for a service that is normally covered by the program, you may claim
reimbursement under the following conditions:
•You must have called the toll-free number first for assistance
• Towing claims must be accompanied by the original detailed repair bill and towing invoice
• Reimbursement will be limited to the local Roadside Assistance contractor rates, to a maximum of
$100 per incident, unless otherwise noted
• Only original receipts, bills and/or charge card copies submitted by you will be accepted for
consideration for reimbursement. Originals will be returned upon request
• Mail your claims to:
FCA Canada Roadside Assistance
248 Pall Mall, P.O. Box 5845
London, Ontario N6A 4T4
FCA Canada reserves the right to decline any claim presented for payment later than 30 days from
the date the service was performed, or if service was provided by an unlicensed garage or individual.
OPTIONAL FCA CANADA SERVICE
CONTRACTS
Even with our comprehensive factory warranty and any applicable statutory warranty, they may not
give you total protection for your ownership period, nor do they provide the regular maintenance
which is required to keep your new vehicle at its optimal operating condition. If you lease a vehicle,
you should be aware of your obligation to maintain and repair the vehicle.
FCA Canada Service Contracts can enhance your new vehicle’s factory warranty from the day of
delivery and provide mechanical coverage on most major components
††when your factory warranty
expires. There are 3 types of plans available for purchase to suit most needs and the average length
of ownership.
Vehicles placed in police, taxi, limousine, postal or ambulance service and all SRT vehicles may
qualify for a service contract. Please see your selling retailer for Special UseService Contract
availability.
††Subject to limitations. Details available at your selling retailer.
1. POWERTRAIN PLANS*
Powertrain plans complement the factory powertrain warranty by providing enhanced roadside
coverage and car rental allowance if your vehicle is not drivable and must be kept overnight. Certain
plans also provide additional distance coverage.
Major components covered are:
• engine •transmission •front-wheel drive •rear-wheel drive
• 4-wheel drive (4x4) •all-wheel drive vehicles
2. GOLDPLANS*
Each plan provides full mechanical repair protection to non-powertrain (Gold) components. Certain
plans also provide full mechanical protection against powertrain component repairs beyond your
vehicle’s powertrain warranty coverage. Contracts are available with or without a deductible.
12