battery CHRYSLER 200 2017 2.G Service Manual

assure most efficient service. MOPAR engine air cleaner
filters are a high quality filter and are recommended.
Maintenance-Free Battery
Your vehicle is equipped with a maintenance-free battery.
You will never have to add water, nor is periodic mainte-
nance required.
WARNING!
•Battery fluid is a corrosive acid solution and can
burn or even blind you. Do not allow battery fluid to
contact your eyes, skin, or clothing. Do not lean over
a battery when attaching clamps. If acid splashes in
eyes or on skin, flush the area immediately with
large amounts of water. Refer to “Jump-Starting
Procedures” in “What To Do In Emergencies” for
further information.
• Battery gas is flammable and explosive. Keep flame
or sparks away from the battery. Do not use a booster
battery or any other booster source with an output
greater than 12 Volts. Do not allow cable clamps to
touch each other.
(Continued)
WARNING! (Continued)
•Battery posts, terminals, and related accessories con-
tain lead and lead compounds. Wash hands after
handling.
CAUTION!
• It is essential when replacing the cables on the
battery that the positive cable is attached to the
positive post and the negative cable is attached to the
negative post. Battery posts are marked positive (+)
and negative (-) and are identified on the battery
case. Cable clamps should be tight on the terminal
posts and free of corrosion.
• If a “fast charger” is used while the battery is in the
vehicle, disconnect both vehicle battery cables before
connecting the charger to the battery. Do not use a
“fast charger” to provide starting voltage.
Air Conditioner Maintenance
For best possible performance, your air conditioner should
be checked and serviced by an authorized dealer at the
start of each warm season. This service should include
458 MAINTAINING YOUR VEHICLE

WARNING!(Continued)
fuse with metal wires or any other material. Failure
to use proper fuses may result in serious personal
injury, fire and/or property damage.
• Before replacing a fuse, make sure that the ignition is
off and that all the other services are switched off
and/or disengaged.
• If the replaced fuse blows again, contact an autho-
rized dealer.
• If a general protection fuse for safety systems (air
bag system, braking system), power unit systems
(engine system, gearbox system) or steering system
blows, contact an authorized dealer.
Power Distribution Center (Fuses)
The Power Distribution Center is located in the engine
compartment near the battery. This center contains car-
tridge fuses, mini-fuses, micro-fuses, circuit breakers and
relays. A label that identifies each component is printed on
the inside of the cover.
Cavity Cartridge Fuse Blade Fuse Description
F06 – –Not Used
F07 – –Not Used
Power Distribution Center
7
MAINTAINING YOUR VEHICLE 477

CavityCartridge Fuse Blade Fuse Description
F65 –10 Amp RedIn Vehicle Temperature Sensor/
Humidity Sensor/Driver Assist System Module (DASM)/Park
Assist (PAM) – If Equipped With Engine Stop/Start Option
F66 –15 Amp Blue Instrument Panel Cluster (IPC)/
(Electronic Climate Control(ECC)) HVAC
F67 –10 Amp RedIn Vehicle Temperature Sensor/
Humidity Sensor/Drivers Assist System Module (DASM)/Park Assist (PAM) – If Equipped
F68 – –Not Used
F69 –10 Amp Red Gear Shift Module (GSM)/Active
Grill Shutter (AGS). – IfEquipped/EPB SW
F70 –5 Amp TanIntelligent Battery Sensor (IBS) –
If Equipped with Engine Stop/ Start Option
7
MAINTAINING YOUR VEHICLE 483

VEHICLE STORAGE
If you are leaving your vehicle dormant for more than 21
days you may want to take steps to protect your battery.
You may:
•Disconnect the negative cable from the battery. •
Anytime you store your vehicle, or keep it out of service
(i.e. vacation) for two weeks or more, run the air
conditioning system at idle for about five minutes in the
fresh air and high blower setting. This will ensure
adequate system lubrication to minimize the possibility
of compressor damage when the system is started again.
REPLACEMENT BULBS
Interior Bulbs
Bulb Number
Front Courtesy/Reading Lamp 578/W5W
Center Courtesy/Reading Lamp 578/W5W
Visor Vanity Lamp A6220
Glove Compartment Lamp A6220
Shift Indicator Lamp IKLE14140
Rear Compartment (Trunk) Lamp 579
NOTE: For lighted switches, see your authorized dealer for replacement.
488 MAINTAINING YOUR VEHICLE

Maintenance Chart
Required Maintenance Intervals
Refer to the maintenance schedules on the following page
for the required maintenance intervals.
At Every Oil Change Interval As Indicated By OilChange Indicator System:
•Change oil and filter
• Rotate the tires. Rotate at the first sign of irregular
wear, even if it occurs before the oil indicator
system turns on.
At Every Oil Change Interval As Indicated By Oil Change Indicator System:
•Inspect battery and clean and tighten terminals as
required
• Inspect brake pads, shoes, rotors, drums, hoses and
park brake
• Inspect engine cooling system protection and hoses
• Inspect exhaust system
• Inspect engine air cleaner if using in dusty or
off-road conditions
Mileage:20,000
30,000
40,000
50,000
60,000
70,000
80,000
90,000
100,000
110,000
120,000
130,000
140,000
150,000
Or Years: 2 3 4 5 6 7 8 9 10 11 12 13 14 15
Or Kilometers:
32,000
48,000
64,000
80,000
96,000
112,000
128,000
144,000
160,000
176,000
192,000
208,000
224,000
240,000
Additional Inspections
Inspect the CV joints. X X X X X X X
Inspect front suspension, boot seals, tie rod ends,
and replace if necessary. XXX X X X X
Inspect the brake linings, parking brake function. X X X X X X X
8
MAINTENANCE SCHEDULES 507

Automatic Headlights...................... .123
Automatic High Beams ..................... .124
Automatic Temperature Control (ATC) ...........318
Automatic Transaxle ....................... .347
Automatic Transmission ..................348, 472
Adding Fluid ....................... .472, 503
Fluid And Filter Changes ...................472
Fluid Change .......................... .472
Fluid Level Check .....................470, 471
Fluid Type ......................... .470, 503
Special Additives ........................ .471
Autostick ............................... .354
Auto Unlock, Doors .........................26
Auto Up Power Windows .....................33
Axle Lubrication .......................... .503
Battery .............................. .251, 458
Charging System Light ....................251
Key Fob Battery Replacement .................19
Keyless Key Fob Replacement ................19
Remote Battery Replacement .................19
Belts, Seat .................................83
Body Mechanism Lubrication ..................462
B-Pillar Location .......................... .379
Brake Assist System ........................ .366Brake Control System, Electronic
................364
Brake Fluid .............................. .503
Brake System ......................... .364, 469
Anti-Lock (ABS) ........................ .364
Fluid Check ........................ .469, 503
Master Cylinder ........................ .469
Warning Light .......................... .249
Brake/Transmission Interlock ..................348
Brightness, Interior Lights ....................129
Bulb Replacement ....................488, 490, 494
Bulbs, Light ........................ .85, 488, 494
Camera, Rear ............................ .208
Capacities,

Fluid .......................... .500
Caps, Filler Fuel ................................. .406
Oil (Engine) ..................... .449, 450, 456
Radiator (Coolant Pressure) .................467
Carbon Monoxide Warning .................82, 403
Cargo Area Features ....................... .236
Cargo Compartment ....................... .236
Car Washes .............................. .472
Certification Label ......................... .409
Chains, Tire ............................. .392
Changing A Flat Tire ....................... .425
10
INDEX 521

Delay................................ .123
High Beam/Low Beam Select Switch ...........127
Lights On Reminder ..................... .125
On With Wipers ........................ .123
Passing ............................... .127
Replacing ............................. .490
Switch ............................... .122
Time Delay ............................ .123
Head Restraints ............................114
Head Rests ...............................114
Heated Mirrors ........................... .100
Heater, Engine Block ....................... .346
High Beam/Low Beam Select (Dimmer) Switch .....127
Hill Start Assist ........................... .367
Holder, Coin ............................. .232
HomeLink (Garage Door Opener) ...............213
Ignition Key....................................9
Illuminated Entry ...........................16
Courtesy Lights ..........................16
Front Courtesy Overhead Console .............16
Illuminated Entry .........................16
Remote Keyless Entry Key Fob ................16
Inside Rearview Mirror .......................93 Instrument Cluster
............244, 251, 254, 263, 267
Instrument Cluster ...................... .273
Instrument Panel And Controls .................243
Instrument Panel Lens Cleaning ................476
Interior Appearance Care .....................474
Interior Fuses ............................ .487
Interior Lights ............................ .128
Intermittent Wipers (Delay Wipers) ..............131
Introduction ................................4
Inverter Outlet (115V) ...................... .229
Jacking Instructions ........................ .427
Jack Location ............................ .425
Jack Operation ........................ .425, 427
Jump Starting ............................ .435
Key Fob Emer
gency Key ...........................10
Lock The Doors ..........................18
Panic Alarm .............................19
Programming Additional Key Fobs ..........14, 19
Remote Battery Replacement .................19
Remote Keyless Entry ....................10, 17
Unlatch The Trunk ........................18
Unlock The Doors .........................17
526 INDEX

Key Fob Battery Service (Remote Keyless Entry).....19
Key Fob Programming (Remote Keyless Entry) ......19
Key Fob, Remote Keyless Entry .................17
Key-In Reminder ............................11
Keyless Enter-N-Go ..........................28
Enter The Trunk ....................... .18, 28
KeyFob................................28
Lock The Vehicle’s Doors .................18, 28
Passive Entry ............................28
Passive Entry Programming ..................28
Remote Control ..........................28
Unlock From The Driver’s Side .............17, 28
Unlock From The Passenger Side ............17, 28
Keyless Entry System ........................17
Keyless Go .................................9
Keys .....................................9
Lane Change And Turn Signals .................126
Lane Change Assist ........................ .127
LaneSense ............................... .163
Lap/Shoulder Belts ..........................39
Latches ..................................85
Lead Free Gasoline ........................ .400
Leaks, Fluid ...............................85
Life Of Tires ............................. .391Light Bulbs
........................ .85, 488, 494
Light Replacement ..................... .488, 494
Lights ............................ .85, 122, 488
AirBag ......................... .64, 83, 248
Automatic Headlights .....................123
Battery Saver .......................... .130
Brake Assist Warning ..................... .371
Brake Warning ......................... .249
Bulb Replacement .....................490, 494
Cruise ......................... .267, 268, 269
Daytime Running ....................... .125
Dimmer Switch, Headlight ..............126, 127
Engine Temperature Warning ................251
Exterior ............................ .85, 494
Fog .............................. .125, 495
Front Replacement ....................... .494
Hazard Warning Flasher ...................414
Headlights ......................... .122,

490
Headlights On Reminder ...................125
Headlights On With Wipers .................123
Headlight Switch ........................ .122
High Beam ............................ .127
High Beam/Low Beam Select ................127
Illuminated Entry .........................16
Instrument Cluster ...................... .12210
INDEX 527

Intensity Control........................ .129
Interior ............................... .128
License ............................... .499
Lights On Reminder ..................... .125
Low Fuel ............................. .261
Malfunction Indicator (Check Engine) ..........256
Parade Mode (Daytime Brightness) ............130
Park ............................. .265, 266
Passing ............................... .127
Reading ........................... .127, 211
Seat Belt Reminder ...................... .247
Security Alarm ......................... .250
Service ............................... .490
Side Marker ........................ .492, 494
Tire Pressure Monitoring (TPMS) ..........259, 394
Traction Control ........................ .371
Turn Signal ....................85, 126, 267, 492
Vanity Mirror .......................... .100
Warning (Instrument Cluster Description) . . . .251, 267
Loading Vehicle ........................... .409
Tires................................. .379
Locks ....................................23
Automatic Door ..........................26
Auto Unlock .............................26
Child Protection ..........................26 Door
..................................23
Power Door .............................25
Low Tire Pressure System .....................394
Lubrication, Body ......................... .462
Lug Nuts ............................... .415
Maintenance Free Battery .....................458
Maintenance Procedures ..................... .454
Maintenance Schedule ...................... .506
Malfunction Indicator Light (Check Engine) . . . .256, 452
Manual, Service ........................... .516
Marker Lights, Side ........................ .492
Master Cylinder (Brakes) .................... .469
Memory

Feature (Memory Seat) ................117
Memory Seat ..............................117
Memory Seats And Radio .....................117
Methanol ............................... .400
Mirrors ..................................93
Electric Powered ........................ .100
Electric Remote ......................... .100
Exterior Folding ..........................99
Heated ............................... .100
Outside ................................98
Rearview ...............................93
Vanity ............................... .100
Modifications/Alterations, Vehicle ................6
528 INDEX

Windows...............................32
Power Seats Down ................................ .109
Forward .............................. .108
Rearward ............................. .108
Up.................................. .109
Pregnant Women And Seat Belts .................44
Preparation For Jacking ..................... .426
Pretensioners Seat Belts ...............................45
Radial Ply Tires ........................... .385
Radiator Cap (Coolant Pressure Cap) .............467
Radio Frequency General Information .............12, 14, 21, 23, 31
Radio Operation .......................... .305
Radio Remote Controls ..................... .304
Radio (Sound Systems) ..................... .303
Rain Sensitive Wiper System ...................133
Rear Camera ............................. .208
Rear Cupholder ........................... .230
Rear ParkSense System ...................168, 175
Rear Seat, Folding ..........................116
Rear Window Defroster ..................... .240
Rear Window Features ...................... .240Recreational Towing
.........................411
Reformulated Gasoline ...................... .400
Refrigerant .............................. .459
Reminder, Lights On ....................... .125
Reminder, Seat Belt ..........................38
Remote Control Starting System ...........................21
Remote Keyless Entry Key Fob Battery Replacement .................19
Lock The Doors ..........................18
Panic Alarm .............................19
Programming Additional Key Fobs ..........14, 19
Remote Battery Replacement .................19
Remote Keyless Entry ....................10, 17
Unlatch The Trunk ........................18
Unlock The Doors .........................17
Remote Sound System (Radio) Controls ...........304
Remote Starting Enter Remote Start Mode ....................22
EVIC

Remote Start Abort Message .............22
Exit Remote Start Mode .....................23
How To Use Remote Start ...................21
Remote Starting System .....................21
To Exit Remote Start Mode And Drive The Vehicle . .23
Remote Starting System .......................21
530 INDEX