warning light CHRYSLER 200 CONVERTIBLE 2011 1.G Workshop Manual

Road Tire Installation
Vehicles Equipped With Wheel Covers
1. Mount the road tire on the axle.
2. To ease the installation process for steel wheels with
wheel covers, install two lug nuts on the mounting studs
which are on each side of the valve stem. Install the lug
nuts with the cone shaped end of the nut toward the
wheel. Lightly tighten the lug nuts.
WARNING!
To avoid the risk of forcing the vehicle off the jack,
do not tighten the wheel nuts fully until the vehicle
has been lowered. Failure to follow this warning may
result in personal injury.Tire And Wheel Cover Or Center Cap
1 — Valve Stem4 — Wheel Cover
2 — Valve Notch 5 — Mounting Stud
3 — Wheel Lug Nut
388 WHAT TO DO IN EMERGENCIES

3. Align the valve notch in the wheel cover with the
valve stem on the wheel. Install the cover by hand,
snapping the cover over the two lug nuts. Do not use a
hammer or excessive force to install the cover.
4. Install the remaining lug nuts with the cone shaped
end of the nut toward the wheel. Lightly tighten the lug
nuts.
WARNING!
To avoid the risk of forcing the vehicle off the jack,
do not tighten the wheel nuts fully until the vehicle
has been lowered. Failure to follow this warning may
result in personal injury.
5. Lower the vehicle to the ground by turning the jack
handle counterclockwise. 6. Finish tightening the lug nuts. Push down on the
wrench while at the end of the handle for increased
leverage. Tighten the lug nuts in a star pattern until each
nut has been tightened twice. The correct tightness of
each lug nut is 100 ft/lbs (135 N·m). If in doubt about the
correct tightness, have them checked with a torque
wrench by your authorized dealer or service station.
7. After 25 miles (40 km) check the lug nut torque with a
torque wrench to ensure that all lug nuts are properly
seated against the wheel.
Vehicles Without Wheel Covers
1. Mount the road tire on the axle.
2. Install the remaining lug nuts with the cone shaped
end of the nut toward the wheel. Lightly tighten the lug
nuts.
6
WHAT TO DO IN EMERGENCIES 389

CAUTION!
Do not use a portable battery booster pack or any
other booster source with a system voltage greater
than 12 Volts or damage to the battery, starter motor,
alternator or electrical system may occur.
WARNING!
Do not attempt jump-starting if the battery is frozen.
It could rupture or explode and cause personal injury.
Preparations For Jump-Start
The battery in your vehicle is located between the left
front headlight assembly and the left front wheel splash
shield. To allow jump-starting there are remote battery
posts located on the left side of the engine compartment.
Remote Battery Posts
1 — Remote Positive(+) Post (covered with protective cap)
2 — Remote Negative (-) Post
6
WHAT TO DO IN EMERGENCIES 391

Refrigerant Recovery And Recycling
R-134a air conditioning refrigerant is a hydrofluoro-
carbon (HFC) that is endorsed by the Environmental
Protection Agency and is an ozone-saving product. How-
ever, the manufacturer recommends that air conditioning
service be performed by authorized dealers or other
service facilities using recovery and recycling equipment.
NOTE:Use only manufacturer approved A/C System
Sealers, Stop Leak Products, Seal Conditioners, Compres-
sor Oil, and Refrigerants.
A/C Air Filter – If Equipped
Refer to the “Maintenance Schedule” for the proper
maintenance intervals.
WARNING!
Do not remove the A/C Air Filter while the blower is
operating or personal injury may result. The A/C Air Filter is located in the fresh air inlet behind
the glove box. Perform the following procedure to re-
place the filter:
1. Open the glove box and remove all contents.
2. Push in on the sides of the glove box and lower the
door.
3. Disconnect the glove box door dampener from the slot
on the side of the box. This is done by grasping the
dampener connector (on the outside of the box) and the
end of the connector pin (on the inside of the box) with
your thumb and forefinger and pulling outward while
lightly lifting upward on the door with your other hand.
Once disconnected, the dampener will retract under-
neath the instrument panel if you release it.
4. Pivot the glove box downward.
5. Disengage the two retaining tabs that secure the filter
cover to the HVAC housing and remove the cover.
416 MAINTAINING YOUR VEHICLE

•Make sure that the radiator and coolant recovery
bottle overflow hoses are not kinked or obstructed.
•Keep the front of the radiator clean. If your vehicle is
equipped with air conditioning, keep the front of the
condenser clean.
•Do not change the thermostat for Summer or Winter
operation. If replacement is ever necessary, install
ONLY the correct type thermostat. Other designs may
result in unsatisfactory cooling performance, poor gas
mileage, and increased emissions.
Brake System
In order to assure brake system performance, all brake
system components should be inspected periodically.
Refer to the “Maintenance Schedule” for the proper
maintenance intervals.
WARNING!
Riding the brakes can lead to brake failure and
possibly a collision. Driving with your foot resting or
riding on the brake pedal can result in abnormally
high brake temperatures, excessive lining wear, and
possible brake damage. You would not have your full
braking capacity in an emergency.
Master Cylinder – Brake Fluid Level Check
Check the fluid level in the master cylinder immediately
if the brake system warning light indicates system fail-
ure.
Check the fluid level in the master cylinder when per-
forming underhood services.
7
MAINTAINING YOUR VEHICLE 427

We appreciate that you have made a major investment
when you purchased the vehicle. An authorized dealer
has also made a major investment in facilities, tools, and
training to assure that you are absolutely delighted with
the ownership experience. You’ll be pleased with their
sincere efforts to resolve any warranty issues or related
concerns.
WARNING!
Engine exhaust, some of its constituents, and certain
vehicle components contain, or emit, chemicals
known to the State of California to cause cancer and
birth defects, or other reproductive harm. In addi-
tion, certain fluids contained in vehicles and certain
products of component wear contain, or emit, chemi-
cals known to the State of California to cause cancer
and birth defects, or other reproductive harm.
WARRANTY INFORMATION
See the Warranty Information Booklet, located on the
DVD, for the terms and provisions of Chrysler Group
LLC warranties applicable to this vehicle and market.
MOPARPARTS
MOPAR fluids, lubricants, parts, and accessories are
available from an authorized dealer. They are recom-
mended for your vehicle in order to help keep the vehicle
operating at its best.
REPORTING SAFETY DEFECTS
In the 50 United States and Washington, D.C.
If you believe that your vehicle has a defect that could
cause a crash or cause injury or death, you should
immediately inform the National Highway Traffic Safety
Administration (NHTSA) in addition to notifying the
manufacturer.
476 IF YOU NEED CONSUMER ASSISTANCE

About Your Brakes....................... 310
ABS (Anti-Lock Brake System) .............. 313
Accessory Delay, Power .................... 12
Adding Engine Coolant (Antifreeze) .......... 423
Adding Fuel ........................... 361
Adding Washer Fluid ..................... 419
Additives, Fuel ......................... 355
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . 413
Air Conditioner Maintenance ............... 415
Air Conditioning ........................ 276
Air Conditioning Controls ................. 276
Air Conditioning Filter .................287,416
Air Conditioning Refrigerant .............415,416
Air Conditioning System .............276,280,415
Air Conditioning, Operating Tips ............ 288
Air Pressure, Tires ....................... 333
Airbag ................................ 56
Airbag Deployment ....................... 63
Airbag Light ................... 61,62,66,81,195Airbag Maintenance
....................... 65
Airbag, Side ........................ 59,60,62
Airbag, Window (Side Curtain) ............... 60
Alarm System (Security Alarm) ............18,203
Alarm, Panic ............................ 25
Alterations/Modifications, Vehicle ............. 7
Antenna, Satellite Radio ................238,263
Anti-Lock Brake System (ABS) .............. 313
Anti-Lock Warning Light .................. 313
Anti-Theft Security Alarm (Theft Alarm) ........ 18
Antifreeze (Engine Coolant) ..............423,451
Disposal ........................... 425
Appearance Care ........................ 432
Ashtray ............................... 181
Assistance Towing ....................... 125
Auto Down Power Windows ................ 34
Auto Unlock, Doors ....................... 32
Automatic Dimming Mirror ................ 108
482 INDEX

Automatic Door Locks..................... 32
Automatic Headlights .................... 158
Automatic Oil Change Indicator ..........201,213
Automatic Temperature Control (ATC) ......... 280
Automatic Transaxle ................ 294,297,429
Adding Fluid .................. 431,432,453
Filter ............................. 432
Fluid and Filter Changes ............... 432
Fluid Level Check ................. 431,432
Interlock System .................. 299,300
Reset Mode ......................... 303
Selection Of Lubricant ................. 453
Shifting ........................... 297
Automatic Transmission Fluid Type ......................... 429
Special Additives ..................... 430
Autostick ............................. 304 B-Pillar Location
........................ 328
Battery ............................... 413
Keyless Transmitter Replacement (RKE) ..... 25
Location ........................... 413
Belts, Seat ............................ 42,80
Body Mechanism Lubrication ............... 417
Brake Assist System ...................... 316
Brake System ........................... 427
Anti-Lock (ABS) ..................... 313
Fluid Check ..................... 427,453
Master Cylinder ..................... 427
Parking ........................... 310
Warning Light ....................... 197
Brake, Parking .......................... 310
Brake/Transaxle Interlock .................. 300
Brakes ............................... 427
Break-In Recommendations, New Vehicle ........ 78
Bulb Replacement ..................... 446,447
Bulbs, Light .......................... 83,446
10
INDEX 483

Calibration, Compass..................... 216
Capacities, Fluid ........................ 451
Caps, Filler Fuel .............................. 361
Oil (Engine) ...................... 403,411
Power Steering ...................... 309
Radiator (Coolant Pressure) ............. 424
Car Washes ............................ 433
Carbon Monoxide Warning ...............80,357
Cargo (Vehicle Loading) ................... 363
Cellular Phone ....................... 11 1,275
Certification Label ....................... 363
Chains, Tire ............................ 341
Changing A Flat Tire ..................... 380
Chart, Tire Sizing ........................ 324
Check Engine Light
(Malfunction Indicator Light) ............... 406
Checking Your Vehicle For Safety ............. 79
Checks, Safety ........................... 79 Child Restraint
.................... 67,69,73,75
Child Restraint Tether Anchors .............71,73
Cigar Lighter ........................... 181
Clean Air Gasoline ....................... 353
Cleaning Wheels ............................ 435
Windshield Wiper Blades ............... 418
Climate Control ......................... 275
Clock ........................ 221,224,243,252
Coin Holder ........................... 183
Compact Disc (CD) Maintenance ............. 275
Compact Spare Tire ...................... 336
Compass ........................... 208,216
Compass Calibration ..................... 216
Compass Variance ....................... 217
Computer, Trip/Travel .................... 214
Connector UCI .............................. 266
Universal Consumer Interface (UCI) ....... 266
484 INDEX

Flooded, Starting..................... 295
Fuel Requirements ................. 353,451
Jump Starting ....................... 390
Oil ......................... 409,451,452
Oil Change Interval .............201,213,410
Oil Filler Cap .................... 403,411
Oil Filter ........................... 412
Oil Filter Disposal .................... 412
Oil Selection ..................... 410,451
Oil Synthetic ........................ 412
Overheating ........................ 378
Starting ........................... 294
Temperature Gauge ................... 194
Engine Oil Viscosity ...................... 411
Enhanced Accident Response Feature .......... 63
Entry System, Illuminated .................. 20
Ethanol ............................... 354
Event Data Recorder ...................... 66
Exhaust Gas Caution ................... 80,357Exhaust System
....................... 80,419
Extender, Seat Belt ........................ 55
Exterior Lights .......................... 83
Fabric Care ............................ 436
Filler Location Fuel .................... 194,361
Filters Air Cleaner ......................... 413
Air Conditioning .................. 287,416
Automatic Transaxle .................. 432
Engine Oil ....................... 412,452
Engine Oil Disposal ................... 412
Flash-To-Pass ........................... 162
Flashers .............................. 378
Hazard Warning ..................... 378
Turn Signal .................... 83,162,450
Flexible Fuel Vehicles Cruising Range ...................... 360
Engine Oil ......................... 359
10
INDEX 487