ECU CHRYSLER 200 CONVERTIBLE 2014 1.G Workshop Manual

4. Turn the jack screw to the left until the jack can beplaced under the jacking location. Once the jack is
positioned, turn the jack screw to the right until the
jack head is properly engaged to the jacking location
on the wheel to be changed. Do not raise the vehicle
until you are sure the jack is securely engaged.
Rear Jacking LocationJack Engaged (Front Jacking Location)6
WHAT TO DO IN EMERGENCIES 405

9. Lower the jack until it is free. Remove the wheelblocks. Reassemble the lug wrench to the jack assem-
bly and stow it in the spare tire area. Secure the
assembly using the means provided. Release the park-
ing brake before driving the vehicle.
WARNING!
A loose tire or jack thrown forward in a collision or
hard stop could endanger the occupants of the ve-
hicle. Always stow the jack parts and the spare tire in
the places provided.
10. Place the deflated (flat) tire in the cargo area and have
the tire repaired or replaced as soon as possible.
11. Check the tire pressure as soon as possible. Correct the tire pressure as required.
Road Tire Installation
Vehicles Equipped With Wheel Covers
1. Mount the road tire on the axle.
2. To ease the installation process for steel wheels withwheel covers, install two lug nuts on the mounting
studs which are on each side of the valve stem. Install
the lug nuts with the cone shaped end of the nut
toward the wheel. Lightly tighten the lug nuts.
WARNING!
To avoid the risk of forcing the vehicle off the jack,
do not tighten the wheel nuts fully until the vehicle
has been lowered. Failure to follow this warning may
result in personal injury.
408 WHAT TO DO IN EMERGENCIES

Proper towing or lifting equipment is required to prevent
damage to your vehicle. Use only tow bars and other
equipment designed for this purpose, following equip-
ment manufacturer ’s instructions. Use of safety chains is
mandatory. Attach a tow bar or other towing device to
main structural members of the vehicle, not to bumpers
or associated brackets. State and local laws regarding
vehicles under tow must be observed.
If you must use the accessories (wipers, defrosters, etc.)
while being towed, the ignition must be in the ON/RUN
position, not the ACC position.
If your vehicle’s battery is discharged, refer toShift
Lever Override in this section for instructions on shifting
the transmission out of PARK for towing.CAUTION!
• Do not use sling type equipment when towing.
Damage to the fascia will occur.
• When securing the vehicle to a flatbed truck, do not
attach to front or rear suspension components.
Damage to your vehicle may result from improper
towing.
• Do not push or tow this vehicle with another
vehicle as damage to the bumper fascia and trans-
mission may result.
The manufacturer recommends towing your vehicle with
all four wheels OFF the ground using a flatbed.
6
WHAT TO DO IN EMERGENCIES 419

Protection Agency and is an ozone-saving product. How-
ever, the manufacturer recommends that air conditioning
service be performed by authorized dealer or other
service facilities using recovery and recycling equipment.
NOTE:Use only manufacturer approved A/C system
sealers, stop leak products, seal conditioners, compressor
oil, and refrigerants.
A/C Air Filter – If Equipped
Refer to the “Maintenance Schedule” for the proper
maintenance intervals.
WARNING!
Do not remove the A/C air filter while the blower is
operating or personal injury may result.
The A/C Air Filter is located in the fresh air inlet behind
the glove box. Perform the following procedure to re-
place the filter: 1. Open the glove box and remove all contents.
2. Push in on the sides of the glove box and lower the
door.
3.
Disconnect the glove box door dampener from the slot
on the side of the box. This is done by grasping the
dampener connector (on the outside of the box) and the
end of the connector pin (on the inside of the box) with
your thumb and forefinger and pulling outward while
lightly lifting upward on the door with your other hand.
Once disconnected, the dampener will retract under-
neath the instrument panel if you release it.
4. Pivot the glove box downward.
5. Disengage the two retaining tabs that secure the filter cover to the HVAC housing and remove the cover.
436 MAINTAINING YOUR VEHICLE

Use only manufacturer’s recommended brake fluid. Re-
fer to “Fluids, Lubricants, and Genuine Parts” in “Main-
taining Your Vehicle” for further information.
WARNING!
•Use only manufacturer’s recommended brake
fluid. Refer to “Fluids, Lubricants, and Genuine
Parts” in “Maintaining Your Vehicle” for further
information. Using the wrong type of brake fluid
can severely damage your brake system and/or
impair its performance. The proper type of brake
fluid for your vehicle is also identified on the
original factory installed hydraulic master cylinder
reservoir.
(Continued)
WARNING! (Continued)
•To avoid contamination from foreign matter or
moisture, use only new brake fluid or fluid that has
been in a tightly closed container. Keep the master
cylinder reservoir cap secured at all times. Brake
fluid in a open container absorbs moisture from the
air resulting in a lower boiling point. This may
cause it to boil unexpectedly during hard or pro-
longed braking, resulting in sudden brake failure.
This could result in a collision.
• Overfilling the brake fluid reservoir can result in
spilling brake fluid on hot engine parts, causing
the brake fluid to catch fire. Brake fluid can also
damage painted and vinyl surfaces, care should be
taken to avoid its contact with these surfaces.
(Continued)
7
MAINTAINING YOUR VEHICLE 449

5. Pull the bulb out of the socket and replace the bulb.
6. If the bulb comes in contact with any oily surface,wipe the bulb with a clean cloth and rubbing alcohol.
7. Reinsert the bulb and socket assembly and rotate clockwise one-quarter turn to secure. 8. Place bulb cover back and rotate one-quarter turn
clockwise to secure.
Front Turn Signal
1. Raise and prop open the hood.
2. Rotate the bulb’s electrical connector one-quarter turncounterclockwise and remove it from the headlamp
housing.
3. Remove the bulb from the connector socket and install the replacement bulb.
4. Install the bulb and connector assembly into the headlamp housing and rotate the connector one-
quarter turn clockwise to lock it in place.
474 MAINTAINING YOUR VEHICLE

4. Twist and remove socket from lamp.
5. Remove bulb from socket and replace.
6. Reinstall the tail lamp, fasteners, and trunk liner.License Plate Lamp
1. Using a small screwdriver, press inward the lockingtab on the side of the lamp assembly and pull down on
the lamp assembly for removal.
2. Pull bulb from socket, replace, and reinstall the lamp assembly into place ensuring the locking tab is secure.
FLUID CAPACITIES
U.S. Metric
Fuel (Approximate)
All Engines — (Except 2.4L PZEV) 16.9 Gallons64 Liters
2.4L PZEV (Partial Zero Emissions Vehicle) 18.5 Gallons70 Liters
Engine Oil With Filter
2.4L Engine (SAE 5W-20, API Certified) 4.5 Quarts4.26 Liters
3.6L Engine (SAE 5W-20, API Certified) 6 Quarts5.6 Liters
7
MAINTAINING YOUR VEHICLE 477

About Your Brakes....................... .327
ABS (Anti-Lock Brake System) ................329
Accessory Delay, Power ......................12
Adding Engine Coolant (Antifreeze) ............444
Adding Fuel ............................ .379
Adding Washer Fluid ..................... .438
Additives, Fuel .......................... .373
Airbag ..................................57
Airbag Deployment ........................66
Airbag Light .............................63
Airbag Maintenance ........................67
Airbag, Side ..............................60
Airbag, Window (Side Curtain) ................62
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . .432
Air Conditioner Maintenance .................435
Air Conditioning ......................... .283
Air Conditioning Controls ...................283
Air Conditioning Filter .....................295
Air Conditioning, Operating Tips ..............296Air Conditioning Refrigerant
.................435
Air Conditioning System ....................283
Air Pressure, Tires ........................ .350
Alarm System (Security Alarm) ................18
Alterations/Modifications, Vehicle ...............7
Antenna, Satellite Radio .....................270
Antifreeze (Engine Coolant) ..................443
Disposal ............................. .446
Anti-Lock Brake System (ABS) ................329
Anti-Lock Warning Light ....................329
Anti-Theft Security Alarm (Theft Alarm) ..........18
Appearance Care ........................ .454
Ashtray ............................... .204
Assistance Towing ........................ .143
Auto Down Power Windows ..................36
Automatic Dimming Mirror ..................125
Automatic Door Locks ......................33
Automatic Oil Change Indicator ...............225
Automatic Temperature Control (ATC) ..........287
500 INDEX

Fog .................................181
Headlights ........................... .178
Headlights On With Wipers ................179
Headlight Switch ...................... .178
High Beam ........................... .180
High Beam Indicator .....................232
High Beam/Low Beam Select ...............180
Illuminated Entry ........................21
Instrument Cluster ..................... .178
Interior ............................. .183
License ............................. .477
Lights On Reminder .....................179
Low Fuel ............................ .219
Malfunction Indicator (Check Engine) .........230
Map Reading ......................... .183
Oil Pressure .......................... .220
Passing ............................. .181
Seat Belt Reminder ..................... .219
Security Alarm (Theft Alarm) ................19Service
.............................. .471
Theft Alarm (Security Alarm) ...............227
Tire Pressure Monitoring (TPMS) ............229
Traction Control ....................... .336
Turn Signal ............................96
Voltage ............................. .219
Warning (Instrument Cluster Description) ......218
Loading Vehicle ......................... .382
Capacities ........................... .383
Tires ............................... .344
Locks ..................................32
Automatic Door .........................33
Auto Unlock ...........................34
Door .................................32
Power Door ............................33
Low Tire Pressure System ...................362
Lubrication, Body ........................ .437
Lumbar Support ......................... .170
10
INDEX 509

PretensionersSeat Belts ..............................51
Programmable Electronic Features .............244
Programming Transmitters (Remote Keyless Entry) . .21
Radial Ply Tires ......................... .352
Radiator Cap (Coolant Pressure Cap) ...........445
Radio Operation ......................... .282
Radio Remote Controls .....................280
Rear Cupholder ......................... .205
Rearview Mirrors ........................ .124
Rear Window Defroster .....................210
Rear Window Features .....................210
Recorder, Event Data .......................69
Recreational Towing ...................... .395
Reformulated Gasoline .....................371
Refrigerant ............................. .435
Release, Hood ........................... .175
Reminder, Seat Belt .........................56 Remote Control
Security Alarm ..........................18
Starting System .........................28
Remote Keyless Entry (RKE) ..................21
Remote Sound System (Radio) Controls .........280
Remote Starting System ......................28
Remote Trunk Release .......................38
Replacement Bulbs ....................... .470
Replacement Keys .........................16
Replacement Parts ........................ .427
Replacement Tires ........................ .359
Reporting Safety Defects ....................495
Resetting Oil Change Indicator ................225
Restraint, Head .......................... .171
Restraints, Child ...........................70
Restraints, Occupant ........................40
Rotation, Tires .......................... .361
Safety Checks Inside Vehicle ..................93
512 INDEX