tow CHRYSLER 300 2007 1.G Repair Manual

CAUTION!
•Using a transmission fluid other than the manu-
facturer’s recommended fluid may cause deterio-
ration in transmission shift quality and/or torque
converter shudder. Using a transmission fluid
other than that recommended by the manufac-
turer will result in more frequent fluid and filter
changes. Refer to “Fluids, Lubricants, and Genu-
ine Parts” for the correct fluid type.
•The fluid level is preset at the factory and it does
not require adjustment under normal operating
conditions. If a transmission fluid leak occurs,
visit your authorized dealer immediately. Severe
damage to the transmission may occur. Your au-
thorized dealer has the proper tools to adjust the
fluid level accurately.
Fluid and Filter Changes
Automatic transmission fluid and filter should be
changed as follows:
Normal Usage — No change necessarySevere Usage (fluid and filter) — Refer to Maintenance
Schedule “B”
Severe Usage is defined as:
•Police, taxi, limousine, commercial type operation, or
trailer towing where the vehicle is drivenregularlyfor
more than 45 minutes of continuous operation.
If the transmission is disassembled for any reason, the
fluid and filter should be changed.
Special Additives
Automatic Transmission Fluid (ATF) is an engineered
product and its performance may be impaired by supple-
mental additives. Therefore, do not add any fluid addi-
tives to the transmission. The only exception to this
policy is the use of special dyes to aid in detecting fluid
leaks. In addition, avoid using transmission sealers as
they may adversely affect seals.
MAINTAINING YOUR VEHICLE 357
7

All Wheel Drive (AWD) — If Equipped
The all wheel drive system consists of a Transfer Case
and Front Differential. The exterior surface of these
components should be inspected for evidence of fluid
leaks. Confirmed leaks should be repaired as soon as
possible.
The transfer case fluid inspection plug is located in the
middle of the rear housing. To inspect the transfer case
fluid level, remove the inspection plug. The fluid level
should be even with the bottom of the hole. The transfer
case fill plug is located on the rear housing near the
output shaft.
The front differential fill plug is located on the outer
cover near the halfshaft attachment. To inspect the differ-
ential fluid level, remove the fill plug. The fluid level
should be even with or slightly below the bottom of the
hole.
Fluid Changes
The fluid should be changed as follows:
Normal Usage
Front Differential No Service RequiredTransfer Case Refer to Maintenance
Schedule “A”
Severe Usage
Front Differential No Service Required
Transfer Case Refer to Maintenance
Schedule “B”
Severe Usage is defined as:
1. More than 50% of vehicle operation in stop and go
traffic where vehicle is driven regularly for more than 45
minutes of continuous operation, such as in heavy city or
in construction zone traffic.
2. Police, taxi, limousine, commercial type operation, or
trailer towing where the vehicle driven regularly for
more than 45 minutes of continuous operation.
Front and Rear Wheel Bearings
Front and rear wheel bearings are permanently sealed.
No regular maintenance is required for these compo-
nents.
358 MAINTAINING YOUR VEHICLE

cleaner. Use caution when cleaning the inside rear win-
dow equipped with electric defrosters or the right rear
quarter window equipped with the radio antenna. Do
not use scrapers or other sharp instruments, which may
scratch the elements.
When cleaning the rear view mirror, spray cleaner on the
towel or rag that you are using. Do not spray cleaner
directly on the mirror.
Cleaning Plastic Instrument Cluster Lenses
The lenses in front of the instruments in this vehicle are
molded in clear plastic. When cleaning the lenses, care
must be taken to avoid scratching the plastic.
1. Clean with a wet soft rag or micro-fiber towel. A mild
soap solution may be used, but do not use high alcohol
content or abrasive cleaners. If soap is used, wipe clean
with a clean damp rag.
2. Dry with a soft tissue.
Seat Belt Maintenance
Do not bleach, dye, or clean the belts with chemical
solvents or abrasive cleaners. This will weaken the fabric.
Sun damage can also weaken the fabric.If the belts need cleaning, use MoparTotal Clean, a mild
soap solution, or lukewarm water. Do not remove the
belts from the vehicle to wash them.
Replace the belts if they appear frayed or worn or if the
buckles do not work properly.
Cleaning the Center Console Cup Holders — 300
Models
Perform the following steps to clean the center console
cup holders:
•Grab the center of the rubber portion of the cup holder
firmly and lift upward to remove.
•Soak the rubber cup holder liner in a mixture of
medium hot tap water and one teaspoon of mild liquid
dish soap. Let soak for approximately one hour.
•After one hour pull the liner from the water and dip it
back into the water about six times. This will loosen
any remaining debris.
•Rinse the liner thoroughly under warm running water.
Shake the excess water from the liner and dry the
outer surfaces with a clean soft cloth.
362 MAINTAINING YOUR VEHICLE

•Carefully tuck the front, followed by the rear, then side
edges of the cup holder into the center console.
Cleaning the Center Console Cup Holders —
300C and 300 Touring Models
Clean with a damp cloth or towel using a mild detergent
with the cup holder in the center console.
NOTE:The cup holder cannot be removed.
FUSES (POWER DISTRIBUTION CENTERS)
Fuses (Front Power Distribution Center)
A power distribution center is located in the engine
compartment. This center contains fuses and relays.Front Power Distribution Center
MAINTAINING YOUR VEHICLE 363
7

Cavity Car-
tridge
FuseMini
FuseDescription
1 60 Amp
Yellow— Ignition Off Draw (IOD)
2 40 Amp
Green— Battery
3———
4 40 Amp
Green— Battery
5 30 Amp
Pink— Heated Seats - if
equipped
6 — 20 Amp
YellowFuel Pump
7———
8 — 15 Amp
BlueIgnition Switch/Airbag
Control Module (ACM)
9 — 20 Amp
YellowConsole Power Outlet
10———
11*———
12*———Cavity Car-
tridge
FuseMini
FuseDescription
13*———
14 — 10 Amp
RedAC Heater Control/
Cluster/Sentry Key Re-
mote Keyless Entry
15 — 20 Amp
YellowTrailer Tow Brake Mod-
ule - if equipped
16———
17 — 20 Amp
YellowCluster
18 — 20 Amp
YellowSelectable Power Outlet
19 — 10 Amp
RedStop Lights
20———
21———
22———
23———
24———
25———
MAINTAINING YOUR VEHICLE 367
7

•Extensive engine idling.
•Driving in dusty conditions.
•Short trips of less than 10 miles (16 km).
•More than 50% of your driving is at sustained high
speeds during hot weather, above 90°F (32°C).
•Trailer towing.

•Taxi, police, or delivery service (commercial ser-
vice).

•Off-road or desert operation.
NOTE:IfANYof these apply to you, then change your
engine oil every 3,000 miles (5 000 km) or 3 months,
whichever comes first, and follow the maintenance rec-
ommendations in Schedule “B” in this section.
NOTE:IfANYof these apply to you, then flush and
replace the engine coolant every 102,000 miles (170 000
km) or 60 months, whichever comes first, and follow the
maintenance recommendations in Schedule “B” in this
section.
NOTE:Most vehicles are operated under the conditions
listed for ScheduleB.
Second is Schedule“A.”It is for vehicles that are not
operated under any of the conditions listed under Sched-
uleB.
Use the schedule that best describes your driving condi-
tions. Where time and mileage are listed, follow the
interval that occurs first.
NOTE:Under no circumstances should oil change
intervals exceed 6,000 miles (10 000 km) or 6 months
whichever comes first.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
MAINTENANCE SCHEDULES 387
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

SCHEDULE “B”
Follow Schedule “B” if you usually operate your vehicle
under one or more of the following conditions.
Change the automatic transmission fluid and filter every
60,000 miles (100 000 km) if the vehicle is usually
operated under one or more of the conditions marked
with an
.
•Day or night temperatures are below 32°F (0°C).
•Stop and go driving.
•Extensive engine idling.
•Driving in dusty conditions.
•Short trips of less than 10 miles (16 km).
•More than 50% of your driving is at sustained high
speeds during hot weather, above 90°F (32°C).
•Trailer towing.

•Taxi, police or delivery service (commercial ser-
vices).

•Off-road or desert operation.
NOTE:IfANYof these apply to you, then change your
engine oil every 3,000 miles (5 000 km) or 3 months,
whichever comes first, and follow the maintenance rec-
ommendations in Schedule “B” in this section.
NOTE:IfANYof these apply to you, then flush and
replace the engine coolant every 102,000 miles (170 000
km) or 60 months, whichever comes first, and follow the
maintenance recommendations in Schedule “B” in this
section.
SCHEDULE “B” 389
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Dealer Service......................... 334
Defroster, Rear Window.................. 229
Defroster, Windshield...............61,220,225
Delay (Intermittent) Wipers............... 110
Diagnostic System, Onboard............... 332
Dimmer Switch, Headlight................ 107
Disposal
Antifreeze (Engine Coolant)............. 352
Door Locks............................ 22
Door Locks, Automatic................... 24
Door Opener, Garage.................... 141
Drive Belts............................ 340
Driving
On Slippery Surfaces.................. 250
DVD Player (Video Entertainment System).... 210
Electric Remote Mirrors................... 70
Electrical Power Outlets.................. 149
Electronic Speed Control (Cruise Control) . . 118,121
Electronic Stability Program (ESP).......... 259
Electronic Throttle Control Warning Light..... 168
Electronic Vehicle Information Center (EVIC) . . 171Emergency, In Case of
Freeing Vehicle When Stuck............. 324
Hazard Warning Flasher................ 312
Jacking............................. 314
Jump Starting........................ 322
Overheating......................... 312
Towing............................. 325
Emission Control System Maintenance....333,386
Engine.........................329,330,331
Air Cleaner.......................... 341
Block Heater......................... 237
Break-In Recommendations............... 58
Checking Oil Level.................335,336
Compartment..................329,330,331
Coolant (Antifreeze)................349,383
Cooling............................ 349
Exhaust Gas Caution................59,292
Fails to Start......................... 235
Flooded, Starting..................... 235
Fuel Requirements.................289,382
Oil ..........................335,382,383
Oil Change Interval................... 337
Oil Filler Cap.....................338,339
INDEX 417
10

High Beam/Low Beam Select (Dimmer)
Switch............................... 107
Hitches
Trailer Towing....................... 301
Holder, Cup........................... 151
HomeLink(Garage Door Opener)
Transmitter........................... 141
Hood Release.......................... 101
Hoses............................353,354
Ignition............................... 11
Key ................................ 11
Ignition Key Removal.................... 11
Illuminated Entry....................... 17
Immobilizer (Sentry Key).................. 13
Indicator, Traction Control................ 257
Infant Restraint.......................50,51
Inflation Pressure Tires................... 169
Information Center, Vehicle............... 171
Inside Rearview Mirror................... 68
Instrument Cluster................161,162,163
Instrument Panel and Controls............. 160
Instrument Panel Lens Cleaning............ 362Interior Appearance Care................. 361
Interior Fuses.......................... 363
Interior Lights......................... 108
Intermittent Wipers (Delay Wipers).......... 110
Introduction............................ 4
Jack Location.......................... 315
Jack Operation......................... 317
Jacking Instructions..................... 317
Jump Starting......................... 322
Key, Programming....................... 14
Key, Replacement....................... 14
Key, Sentry (Immobilizer).................. 13
Key-In Reminder........................ 12
Keyless Entry System..................... 17
Keys................................. 11
Knee Bolster........................... 41
Lane Change and Turn Signals............. 107
Lap/Shoulder Belts...................... 33
LATCH
(Lower Anchors and Tether for CHildren) . . . 54,55
420 INDEX

Outlet (Auxiliary Electrical Outlet)........ 149
Seats............................... 92
Steering.........................255,346
Steering, Checking.................... 346
Sunroof............................ 146
Tilt/Telescoping Steering Column......... 116
Windows............................ 27
Pregnant Women and Seat Belts............. 40
Preparation for Jacking................... 314
Pretensioners
Seat Belts............................ 38
Programmable Electronic Features....142,145,182
Programming Transmitters
(Remote Keyless Entry).............21,142,145
Radial Ply Tires........................ 274
Radiator Cap (Coolant Pressure Cap)........ 351
Radio Broadcast Signals.................. 187
Radio, Navigation...................... 206
Radio Operation..................188,195,219
Radio Remote Controls.................. 215
Radio, Satellite......................207,212
Radio (Sound Systems)................188,195Rain Sensitive Wiper System............... 111
Rear Park Assist System.................. 136
Rear Seat, Folding....................... 97
Rear Window Defroster.................. 229
Rear Window Features................... 229
Rearview Mirrors........................ 68
Reclining Front Seats..................... 93
Recorder, Event Data..................... 49
Recreational Towing..................... 309
Reformulated Gasoline................... 290
Refrigerant............................ 345
Reminder, Seat Belt...................... 38
Remote Keyless Entry (RKE)............... 17
Remote Sound System (Radio) Controls...... 215
Remote Trunk Release.................... 31
Replacement Parts...................... 334
Replacement Tires...................... 277
Reporting Safety Defects................. 409
Restraint, Head......................... 94
Restraints, Child........................ 50
Restraints, Occupant..................... 32
Rocking Vehicle When Stuck.............. 324
Rotation, Tires......................... 280
424 INDEX