wheel CHRYSLER 300 2007 1.G Repair Manual

Miles 39,000 42,000 45,000 48,000 51,000 54,000
(Kilometers) (65 000) (70 000) (75 000) (80 000) (85 000) (90 000)
Change engine oil and engine oil filter, if not
replaced at 3 months.XXXXX X
Inspect theair cleaner filterand replace if re-
quired.*XX XX X
Replace theair cleaner filter.X*
Inspect the front and rear brake linings and
rotors.X
Change the rear axle fluid. X
Replace the air conditioning filter. X
Rotate the tires. X X X
Change the Transfer Case Fluid - All Wheel
Drive (AWD) only.X
392 SCHEDULE “B”
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 93,000 96,000 99,000 102,000 105,000
(Kilometers) (155 000) (160 000) (165 000) (170 000) (175 000)
Change engine oil and engine oil filter, if not re-
placed at 3 months.XXXXX
Inspect theair cleaner filterand replace if re-
quired.*XXXX
Replace theair cleaner filter.X*
Inspect the front and rear brake linings and rotors. X
Replace theengine timing belt.3.5L Engine. X
Replace thespark plugs.2.7L, 3.5L Engines. X
Check and Inspect the accessory drive belt and ten-
sioner. Replace if required.X
Change the rear axle fluid. X
Replace the air conditioning filter. X
Flush and replace engine coolant at 102,000 miles if
not done at 60 months.X
Rotate the tires. X X
Change the Transfer Case Fluid - All Wheel Drive
(AWD) only.X
SCHEDULE “B” 395
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 138,000 141,000 144,000 147,000 150,000
(Kilometers) (230 000) (235 000) (240 000) (245 000) (250 000)
Change engine oil and engine oil filter, if not re-
placed at 3 months.XXXXX
Inspect theair cleaner filterand replace if re-
quired.*XXXX
Replace theair cleaner filter.X
Inspect the front and rear brake linings and rotors. X
Change the rear axle fluid. X
Replace the air conditioning filter. X
Rotate the tires. X X X
Change the Transfer Case Fluid - All Wheel Drive
(AWD) only.X
* This maintenance is recommended by the manufacture
to the owner but is not required to maintain the emis-
sions warranty.
‡ This maintenance is not required if previously replaced.Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
398 SCHEDULE “B”
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 42,000 48,000 54,000 60,000 66,000 72,000
(Kilometers) (70 000) (80 000) (90 000) (100 000) (110 000) (120 000)
[Months] [42] [48] [54] [60] [66] [72]
Change engine oil and engine oil filter. X X X X X X
Inspect theair cleaner filterand replace if
required.*XXX XX
Replace theair cleaner filter.X
Inspect the front and rear brake linings and
rotors.XX
Replace thespark plugs.5.7L Engine. X
Check and Inspect the accessory drive belt
and tensioner. Replace if required.X
Flush and replace engine coolant at 60 months
if not done at 102,000 miles.X
Check and replace, if necessary, thePCV
valve.*X
Replace the air conditioning filter. X X X
Rotate the tires. X X X X X X
Change the Transfer Case Fluid - All Wheel
Drive (AWD) only.X
400 SCHEDULE “A”
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 78,000 84,000 90,000 96,000 102,000
(Kilometers) (130 000) (140 000) (150 000) (160 000) (170 000)
[Months] [78] [84] [90] [96] [102]
Change engine oil and engine oil filter. X X X X X
Inspect theair cleaner filterand replace if re-
quired.*XX XX
Replace theair cleaner filter.X
Inspect the front and rear brake linings and rotors. X
Check and Inspect the accessory drive belt and ten-
sioner. Replace if required.X
Replace thespark plugs.2.7L, 3.5L Engines. X
Replace thespark plugs.5.7L Engine. X
Check and replace, if necessary, thePCV valve.*‡ X
Replace theengine timing belt.3.5L Engine. X
Change the Transfer Case Fluid - All Wheel Drive
(AWD) only.X
Flush and replace the engine coolant at 102,000
miles if not done at 60 months.X
Replace the air conditioning filter. X X
Rotate the tires. X X X X X
SCHEDULE “A” 401
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 138,000 144,000 150,000
(Kilometers) (230 000) (240 000) (250 000)
[Months] [138] [144] [150]
Change engine oil and engine oil filter. X X X
Inspect theair cleaner filterand replace if required.* X X
Replace theair cleaner filter.X
Inspect the front and rear brake linings and rotors. X
Replace the air conditioning filter. X
Rotate the tires. X X X
Change the Transfer Case Fluid - All Wheel Drive (AWD) only. X
* This maintenance is recommended by the manufacturer
to the owner but is not required to maintain the emis-
sions warranty.
‡ This maintenance is not required if previously replaced.
Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
WARNING!
You can be badly injured working on or around a
motor vehicle. Only do service work for which you
have the knowledge and the right equipment. If you
have any doubt about your ability to perform a
service job, take your vehicle to a competent me-
chanic.
SCHEDULE “A” 403
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Treadwear
The treadwear grade is a comparative rating based on the
wear rate of the tire when tested under controlled con-
ditions on a specified government test course. For ex-
ample, a tire graded 150 would wear one and a half (1
1/2) times as well on the government course as a tire
graded 100. The relative performance of tires depends
upon the actual conditions of their use, however, and
may depart significantly from the norm due to variations
in driving habits, service practices and differences in road
characteristics and climate.
Traction Grades
The traction grades, from highest to lowest, are AA, A, B,
and C. Those grades represent the tire’s ability to stop on
wet pavement as measured under controlled conditions
on specified government test surfaces of asphalt and
concrete. A tire marked C may have poor traction perfor-
mance.
WARNING!
The traction grade assigned to this tire is based on
straight-ahead braking traction tests, and does not
include acceleration, cornering, hydroplaning, or
peak traction characteristics.
Temperature Grades
The temperature grades are A (the highest), B, and C,
representing the tire’s resistance to the generation of heat
and its ability to dissipate heat when tested under
controlled conditions on a specified indoor laboratory
test wheel. Sustained high temperature can cause the
material of the tire to degenerate and reduce tire life, and
excessive temperature can lead to sudden tire failure. The
grade C corresponds to a level of performance which all
passenger car tires must meet under the Federal Motor
Vehicle Safety Standard No. 109. Grades B and A repre-
sent higher levels of performance on the laboratory test
wheel than the minimum required by law.
IF YOU NEED CONSUMER ASSISTANCE 411
9

ABS (Anti-Lock Brake System)............. 253
Adaptive Cruise Control (ACC)
(Cruise Control)........................ 121
Adding Engine Coolant (Antifreeze)......... 351
Adding Fuel.......................... 293
Adding Washer Fluid.............. 112,114,347
Adjustable Pedals....................... 117
Air Cleaner, Engine
(Engine Air Cleaner Filter)................ 341
Air Conditioner Maintenance.............. 344
Air Conditioning....................219,221
Air Conditioning Controls................ 219
Air Conditioning Filter................227,345
Air Conditioning, Operating Tips........... 228
Air Conditioning Refrigerant...........344,345
Air Conditioning System...........219,221,344
Air Pressure, Tires...................169,272
Airbag................................ 41
Airbag Deployment....................45,47
Airbag Light....................46,49,60,165
Airbag Maintenance...................... 48
Airbag, Side........................... 46
Airbag, Window (Side Curtain)...........42,46Alarm (Security Alarm).................. 168
Alarm System (Security Alarm)............. 15
Alignment and Balance.................. 278
All Wheel Drive (AWD)...............250,358
Alterations/Modifications, Vehicle............ 7
Antenna, Satellite Radio.................. 214
Antifreeze (Engine Coolant).........350,351,382
Disposal............................ 352
Anti-Lock Brake System (ABS)............. 253
Anti-Lock Warning Light..............164,255
Anti-Theft Security Alarm (Theft Alarm)...... 15
Anti-Theft System...................... 168
Appearance Care....................... 359
Auto Down Power Windows............... 28
Auto Up Power Windows................. 28
Automatic Dimming Mirror................ 68
Automatic Door Locks..................24,25
Automatic Headlights................... 103
Automatic Temperature Control (ATC)....... 221
Automatic Transaxle
Special Additives..................... 357
Automatic Transmission.........240,245,356,357
Adding Fluid.....................
357,384
414 INDEX

Cassette Tape and Player Maintenance....... 217
Catalytic Converter..................... 341
CD (Compact Disc) Player.............188,195
Cellular Phone.......................... 72
Chains, Tire........................... 279
Changing A Flat Tire.................... 314
Chart, Tire Sizing....................... 264
Check Engine Light
(Malfunction Indicator Light).............. 333
Child Restraint...................50,52,55,56
Child Restraint Tether Anchors...........54,55
Child Safety Locks....................... 25
Clean Air Gasoline...................... 290
Cleaning
Wheels............................. 360
Climate Control........................ 219
Clock.......................186,190,196,207
Compact Disc (CD) Maintenance........... 218
Compact Spare Tire..................... 274
Compass............................. 178
Compass Calibration.................... 178
Compass Variance...................... 179
Computer, Trip/Travel................... 175Console.............................. 153
Console, Floor......................... 153
Console, Overhead...................... 140
Contract, Service....................... 408
Coolant Pressure Cap (Radiator Cap)........ 351
Cooling System........................ 349
Adding Coolant (Antifreeze)............. 351
Coolant Capacity..................... 382
Coolant Level.....................349,352
Disposal of Used Coolant............... 352
Drain, Flush, and Refill................. 350
Inspection........................... 352
Points to Remember................... 352
Pressure Cap........................ 351
Radiator Cap........................ 351
Selection of Coolant (Antifreeze)....350,382,383
Cruise Control (Speed Control).......... 118,121
Cruise Light........................... 163
Cup Holder.....................151,362,363
Customer Assistance.................... 406
Data Recorder, Event..................... 49
Daytime Running Lights................. 106
416 INDEX

Oil Selection......................337,382
Oil Synthetic......................... 339
Overheating......................... 312
Temperature Gauge................... 166
Enhanced Accident Response Feature......... 48
Ethanol.............................. 290
Event Data Recorder..................... 49
Exhaust Gas Caution.............59,60,292,348
Exhaust System......................59,348
Exterior Folding Mirrors.................. 69
Exterior Lighting....................... 103
Filters
Air Cleaner.......................... 341
Air Conditioning..................227,345
Engine Fuel......................... 341
Engine Oil.......................340,383
Engine Oil Disposal................... 340
Flashers
Hazard Warning...................... 312
Turn Signal.......................107,163
Flash-To-Pass.......................... 107
Flat Tire Changing...................... 314Flooded Engine Starting.................. 235
Floor Console.......................... 153
Fluid Capacities........................ 382
Fluid Leaks............................ 61
Fluid Level Checks
Brake.............................. 355
Cooling System....................... 349
Engine Oil.......................335,336
Power Steering....................... 346
Fluids............................... 383
Fluids, Lubricants and Genuine Parts........ 383
Fog Lights.........................106,163
Folding Rear Seat....................... 97
Freeing A Stuck Vehicle.................. 324
Front Suspension Ball Joints............... 346
Front Wheel Bearings.................... 358
Fuel................................. 289
Adding............................. 293
Clean Air........................... 290
Ethanol............................. 290
Filler Cap (Gas Cap)................... 293
Filter.............................. 341
Gasoline............................ 289
418 INDEX