transmission CHRYSLER 300 2014 2.G Manual PDF

Automatic Transmission Fluid (ATF) is an engineered
product and its performance may be impaired by supple-
mental additives. Therefore, do not add any fluid addi-
tives to the transmission. The only exception to this
policy is the use of special dyes for diagnosing fluid
leaks. Avoid using transmission sealers as they may
adversely affect seals.
CAUTION!
Do not use chemical flushes in your transmission as
the chemicals can damage your transmission compo-
nents. Such damage is not covered by the New
Vehicle Limited Warranty.
Fluid Level Check
The fluid level is preset at the factory and does not
require adjustment under normal operating conditions.
Routine fluid level checks are not required, therefore thetransmission has no dipstick. Your authorized dealer can
check your transmission fluid level using special service
tools.
If you notice fluid leakage or transmission malfunction,
visit your authorized dealer immediately to have the
transmission fluid level checked. Operating the vehicle
with an improper fluid level can cause severe transmis-
sion damage.
CAUTION!
If a transmission fluid leak occurs, visit your autho-
rized dealer immediately. Severe transmission dam-
age may occur. Your authorized dealer has the proper
tools to adjust the fluid level accurately.
Fluid And Filter Changes — 5-Speed Transmission
Refer to the “Maintenance Schedule” for the proper
maintenance intervals.
540 MAINTAINING YOUR VEHICLE

In addition, change the fluid and filter if the fluid
becomes contaminated (with water, etc.), or if the trans-
mission is disassembled for any reason.
Fluid And Filter Changes — 8-Speed Transmission
Under normal operating conditions, the fluid installed at
the factory will provide satisfactory lubrication for the
life of the vehicle. Routine fluid and filter changes are not
required. However, change the fluid and filter if the fluid
becomes contaminated (with water, etc.), or if the trans-
mission is disassembled for any reason.
All Wheel Drive (AWD) — If Equipped
The all wheel drive system consists of a transfer case and
front differential. The exterior surface of these compo-
nents should be inspected for evidence of fluid leaks.
Confirmed leaks should be repaired as soon as possible.
The transfer case fluid fill/inspection plug is located in
the middle of the rear housing. To inspect the transfercase fluid level, remove the fill/inspection plug. The
fluid level should be even with the bottom of the hole.
Use this plug to add fluid as required.
The front differential fill plug is located on the outer
cover near the halfshaft attachment. To inspect the differ-
ential fluid level, remove the fill plug. The fluid level
should be even with or slightly below the bottom of the
hole.
Fluid Changes
Refer to the “Maintenance Schedule” for the proper
maintenance intervals.
Rear Axle
For normal service, periodic fluid level checks are not
required. When the vehicle is serviced for other reasons the
exterior surfaces of the axle assembly should be inspected.
7
MAINTAINING YOUR VEHICLE 541

CavityCartridge Fuse Mini-Fuse Description
19 50 Amp Red –Power Steering #2
20 30 Amp Pink –Wiper Motor
21 30 Amp Pink –Headlamp Washers
22 –– Fuse – Spare
23 –– Fuse – Spare
24 –– Fuse – Spare
28 –25 Amp Natural Fuel Pump
29 –15 Amp Blue Transmission Shifter
30 –– Fuse – Spare
31 –25 Amp Natural Engine Module
32 –– Fuse – Spare
33 –– Fuse – Spare
34 –25 Amp Natural Powertrain #1
35 –20 Amp Yellow Powertrain #2
36 –10 Amp Red Anti-Lock Brake Module
7
MAINTAINING YOUR VEHICLE 551

Chassis
ComponentFluid, Lubricant, Or Genuine Part
Automatic Transmission – 8-Speed Transmission Use only MOPAR® ZF 8&9 Speed ATF™ Automatic Transmission
Fluid, or equivalent. Failure to use the correct fluid may affect the function or performance of your transmission.
Automatic Transmission – 5-Speed Transmission Use only ATF+4® Automatic Transmission Fluid. Failure to use
ATF+4® fluid may affect the function or performance of your trans- mission. We recommend MOPAR® ATF+4® fluid.
Brake Master Cylinder We recommend you use MOPAR® DOT 3 and SAE J1703. If DOT 3
brake fluid is not available, then DOT 4 is acceptable.
Power Steering Reservoir We recommend you use MOPAR® Hydraulic Fluid or equivalent
meeting MS-11655, such as Fuchs EG ZH 3044 or Pentosin CHF 11s.
Front Axle
We recommend you use API GL-5 SAE 75W90 Synthetic Gear Lubricant.
Rear AxleWe recommend you use API GL-5 SAE 75W140 Synthetic Gear Lubricant.
Transfer Case We recommend you use MOPAR® Transfer Case Lubricant for Borg-
Warner 44–40.
7
MAINTAINING YOUR VEHICLE 569

Mileage or time passed (whichever comes first)
20,000
30,000
40,000
50,000
60,000
70,000
80,000
90,000
100,000
110,000
120,000
130,000
140,000
150,000
Or Years: 2 3 4 5 6 7 8 9 10 11 12 13 14 15
Or Kilometers:
32,000
48,000
64,000
80,000
96,000
112,000
128,000
144,000
160,000
176,000
192,000
208,000
224,000
240,000
Flush and replace the engine coolant at 10 years
or 150,000 miles (240,000 km) whichever comes
first. XX
Change automatic transmission fluid and filter if
using your vehicle for any of the following: police,
taxi, fleet, off-road, or frequent trailer towing
(five-speed only). X
Change automatic transmission fluid and filter
(five-speed only). X
Change transfer case fluid if using your vehicle for
any of the following: police, taxi, fleet, off-road, or
frequent trailer towing (All Wheel Drive Only). XX
8
M
A I
N T
E
N
A
N
C E
S
C
H E
D
U L
E
S576 MAINTENANCE SCHEDULES

Automatic High Beams.....................196
Automatic Oil Change Indicator ...............324
Automatic Temperature Control (ATC) ..........357
Automatic Transmission ....................374
Adding Fluid ......................... .540
Autostick ............................ .391
Fluid and Filter Changes ..................540
Fluid Change ......................... .540
Fluid Level Check ...................... .539
Fluid Type ........................... .569
Special Additives ...................... .539
Automatic Transmission Limp Home Mode .......383
Autostick .............................. .391
Auto Unlock, Doors ........................33
Auto Up Power Windows ....................40
Axle Fluid ............................. .569
Axle Lubrication (Axle Fluid) .................569
Battery ................................ .521Keyless Transmitter Replacement (RKE)
........25
Location ............................. .521
Remote Battery Replacement ................25
Transmitter Battery Replacement .............25
Belts, Seat ...............................49
Bluetooth® Connecting To A Particular Mobile Phone Or Audio
Device After Pairing .....................136
Connect Or Disconnect Link Between the
Uconnect® Phone And Mobile Phone .........152
Pair (Link) Uconnect® Phone To A Mobile Phone. .132
Body Mechanism Lubrication .................526
B-Pillar Location ......................... .421
Brake Assist System ...................... .406
Brake Control System, Electronic ..............405
Brake Fluid ............................ .569
Brake, Parking .......................... .400
Brake System ........................... .536
Anti-Lock (ABS) ....................... .403
10
INDEX 591

Fluid Check.......................... .537
Master Cylinder ....................... .537
Parking ............................. .400
Warning Light ........................ .310
Brake/Transmission Interlock .................374
Brightness, Interior Lights ...................204
Bulb Replacement ........................ .560
Bulbs, Light ............................ .103
Camera, Rear ........................... .258
Capacities, Fluid ......................... .566
Caps, Filler Oil (Engine) .......................... .519
Radiator (Coolant Pressure) ................534
Carbon Monoxide Warning ..................100
Cargo Area Features ...................... .292
Cargo Compartment ...................... .292
Cargo (Vehicle Loading) ....................462
Car Washes ............................ .543Cellular Phone
.......................... .350
Certification Label ........................ .463
Chains, Tire ............................ .437
Changing A Flat Tire ...................... .484
Chart, Tire Sizing ........................ .416
Check Engine Light (Malfunction Indicator Light) . .307
Checking Your Vehicle For Safety ...............99
Checks, Safety ............................99
Child Restraint ............................75
Child Restraints Child Seat Installation .....................93
Install A LATCH-compatible Child Restraint .....88
Installing Child Restraints Using The Vehicle Seat
Belt ..................................90
Lower Anchors And Tethers For Children .......82
Child Safety Locks .........................33
Clean Air Gasoline ....................... .452
Cleaning Wheels .............................. .544
592 INDEX

Engine Oil Viscosity...................... .519
Engine Oil Viscosity Chart ...................519
Enhanced Accident Response Feature ............70
Entry System, Illuminated ....................21
Ethanol ............................... .452
Event Data Recorder ........................74
Exhaust Gas Caution ...................... .100
Exhaust System .......................... .100
Exterior Folding Mirrors ....................113
Exterior Lighting ......................... .194
Exterior Lights .......................... .103
Filler Location Fuel ....................... .308
Filters Air Cleaner .......................... .521
Air Conditioning ...................... .360
Engine Oil ........................... .520
Engine Oil Disposal .....................520 Flashers
Hazard Warning ....................... .481
Turn Signal .......................... .103
Flash-To-Pass ........................... .201
Flexible Fuel Vehicles Cruising Range ........................ .458
Engine Oil ........................... .457
Fuel Requirements ..................... .456
Maintenance .......................... .459
Replacement Parts ...................... .458
Starting ............................. .458
Flooded Engine Starting ....................369
Floor Console ........................... .288
Fluid, Brake ............................ .569
Fluid Capacities ......................... .566
Fluid Leaks ............................ .103
Fluid Level Checks ....................... .542
Automatic Transmission ..................540
Brake ............................... .537
596 INDEX

Front Seat.............................49
Inspection ........................... .101
Operating Instructions ....................50
Pretensioners ...........................57
Rear Seat ..............................49
Untwisting Procedure .....................54
Seats ................................. .177
Adjustment .......................... .177
Easy Entry ........................... .191
Head Restraints ....................... .184
Heated .............................. .181
Height Adjustment ..................... .177
Memory ............................. .188
Power .............................. .177
Rear Folding ......................... .186
Seatback Release ....................... .186
Tilting .............................. .177
Security Alarm ............................18
Arm The System ........................19 Selection of Coolant (Antifreeze)
...............567
SENTRY KEY® FCC General Information ..................18
Key Programming .......................18
Sentry Key (Immobilizer) ....................16
Sentry Key Replacement .....................17
Service Assistance ........................ .581
Service Contract ......................... .583
Service Engine Soon Light (Malfunction Indicator) . .307
Service Manuals ......................... .586
Setting the Clock ......................... .346
Shifting ............................... .372
Automatic Transmission ..................372
Shift Lever Override ...................... .499
Shoulder Belts ............................49
Shoulder Belt Upper Anchorage ................54
Side Airbag ..............................69
Side View Mirror Adjustment .................113
Signals, Turn ........................... .103
606 INDEX

Snow Chains (Tire Chains)...................437
Snow Tires ............................. .430
Spare Tire .............................. .432
Spark Plugs ............................ .567
Specifications Fuel (Gasoline) ........................ .567
Oil................................. .567
Speed Control (Cruise Control) ................216
Speedometer ............................ .308
Sport Mode ............................ .309
Starting .................................27
Automatic Transmission ..................366
Cold Weather ......................... .369
Engine Fails to Start .....................369
Remote ...............................27
Starting and Operating .....................366
Starting Procedures ....................... .366
Steering Column Controls ...................... .200Column Lock
......................... .210
Power .............................. .399
Tilt Column .......................... .210
Wheel, Heated ........................ .213
Wheel, Tilt ........................... .210
Steering Wheel Audio Controls ...............348
Steering Wheel Mounted Sound System Controls . . .348
Storage ............................... .560
Storage, Vehicle .......................... .359
Storing Your Vehicle ...................... .560
Stuck, Freeing ........................... .498
Sunglasses Storage ....................... .262
Sun Roof .............................. .272
Supplemental Restraint System - Airbag ..........59
Synthetic Engine Oil ...................... .520
System, Remote Starting .....................27
Tachometer ............................. .304
Telescoping Steering Column .................210
10
INDEX 607