tow CHRYSLER 300 2017 2.G Repair Manual

Seat Belt Maintenance
Do not bleach, dye, or clean the belts with chemical
solvents or abrasive cleaners. This will weaken the fabric.
Sun damage can also weaken the fabric.
If the belts need cleaning, use Mopar Total Clean, a mild
soap solution, or lukewarm water. Do not remove the belts
from the vehicle to wash them. Dry with a soft cloth.
Replace the belts if they appear frayed or worn or if the
buckles do not work properly.
WARNING!
A frayed or torn belt could rip apart in a collision and
leave you with no protection. Inspect the belt system
periodically, checking for cuts, frays, or loose parts.
Damaged parts must be replaced immediately. Do not
disassemble or modify the system. Seat belt assemblies
must be replaced after a collision if they have been
damaged (i.e., bent retractor, torn webbing, etc.).
Cleaning The Center Console Cupholders
Clean with a damp cloth or towel using a mild detergent
with the cupholder in the center console.
NOTE:The cupholder cannot be removed.
FUSES
WARNING!
•When replacing a blown fuse, always use an appro-
priate replacement fuse with the same amp rating as
the original fuse. Never replace a fuse with another
fuse of higher amp rating. Never replace a blown
fuse with metal wires or any other material. Failure
to use proper fuses may result in serious personal
injury, fire and/or property damage.
• Before replacing a fuse, make sure that the ignition is
off and that all the other services are switched off
and/or disengaged.
• If the replaced fuse blows again, contact an autho-
rized dealer.
• If a general protection fuse for safety systems (air
bag system, braking system), power unit systems
(engine system, gearbox system) or steering system
blows, contact an authorized dealer.
432 MAINTAINING YOUR VEHICLE

MAINTENANCE SCHEDULE
Your vehicle is equipped with an automatic oil change
indicator system. The oil change indicator system will
remind you that it is time to take your vehicle in for
scheduled maintenance.
Based on engine operation conditions, the oil change
indicator message will illuminate. This means that service
is required for your vehicle. Operating conditions such as
frequent short-trips, trailer tow, extremely hot or cold
ambient temperatures, and E85 fuel usage will influence
when the “Change Oil” or “Oil Change Required” message
is displayed. Severe Operating Conditions can cause the
change oil message to illuminate as early as 3,500 miles
(5,600 km) since last reset. Have your vehicle serviced as
soon as possible, within the next 500 miles (805 km).
The “Oil Change Required” message will be displayed in
the instrument cluster and a single chime will sound,
indicating that an oil change is necessary.Your authorized dealer will reset the oil change indicator
message after completing the scheduled oil change. If a
scheduled oil change is performed by someone other than
your authorized dealer, the message can be reset by
referring to the steps described under “Instrument Cluster
Display” in “Understanding Your Instrument Panel” for
further information.
NOTE:
Under no circumstances should oil change inter-
vals exceed 10,000 miles (16,000 km), twelve months or 350
hours of engine run time, whichever comes first. The 350
hours of engine run or idle time is generally only a concern
for fleet customers.
Severe Duty All Models
Change Engine Oil at 4,000 miles (6,500 km) if the vehicle
is operated in a dusty and off-road environment, or is
operated predominantly at idle or only very low engine
RPM’s. This type of vehicle use is considered Severe Duty.
454 MAINTENANCE SCHEDULES

Mileage or time passed (whichever comes first)
20,000
30,000
40,000
50,000
60,000
70,000
80,000
90,000
100,000
110,000
120,000
130,000
140,000
150,000
Or Years: 2 3 4 5 6 7 8 9 10 11 12 13 14 15
Or Kilometers:
32,000
48,000
64,000
80,000
96,000
112,000
128,000
144,000
160,000
176,000
192,000
208,000
224,000
240,000
Inspect the transfer case fluid. Change the transfer
case fluid; if using your vehicle for any of the follow-
ing: police, taxi, fleet, off-road, or frequent trailer tow-
ing. (All Wheel Drive Only). XX
Change the rear axle fluid and on models equipped
with All Wheel Drive (AWD) change the front axle
fluid if using your vehicle for any of the following: po-
lice, taxi, fleet, off-road, or frequent trailer towing. XX X
Inspect and replace PCV valve if necessary. X
** The spark plug change interval is mileage based only,
yearly intervals do not apply.
WARNING!
• You can be badly injured working on or around a
motor vehicle. Do only service work for which you
have the knowledge and the right equipment. If you
(Continued)
WARNING! (Continued)
have any doubt about your ability to perform a
service job, take your vehicle to a competent me-
chanic.
• Failure to properly inspect and maintain your vehicle
could result in a component malfunction and effect
vehicle handling and performance. This could cause
an accident.
8
MAINTENANCE SCHEDULES 457

About Your Brakes..................... .316, 317
Adaptive Cruise Control (ACC) (Cruise Control) . . . .135
Adding Engine Coolant (Antifreeze) .............420
Adding Fuel ............................. .364
Adding Washer Fluid ........................416
Additives, Fuel ............................360
Adjust Down .................................105
Forward ...............................105
Rearward ............................. .105
Up.................................. .105
AirBag ..................................49 Advance Front Air Bag .....................49
Air Bag Operation .........................51
Air Bag Warning Light .....................48
Driver Knee Air Bag .......................52
Enhanced Accident Response ..............58, 399
Event Data Recorder (EDR) .................399
FrontAirBag ............................49
If A Deployment Occurs ....................57
Knee Impact Bolsters .......................52
Maintaining Your Air Bag System ..............58
Redundant Air Bag Warning Light .............49
Side Air Bags ............................53
Transporting Pets .........................75 Air Bag Light
........................48, 77, 207
Air Bag Maintenance .........................58
Air Cleaner, Engine (Engine Air Cleaner Filter) ......411
Air Conditioner Maintenance ..................413
Air Conditioning .......................... .269
Air Conditioning Controls ....................269
Air Conditioning Filter ...................277, 414
Air Conditioning, Operating Tips ............276, 278
Air Conditioning Refrigerant ...............413, 414
Air Conditioning System ...............269, 275, 413
Air Pressure, Tires ..........................340
Alarm Arm The System .......................16, 17
Rearming The System ......................16
Alarm, Panic ...............................20
Alarm (Security Alarm) ....................16, 210
Alarm System (Security Alarm) .................16
All Wheel Drive Towing ............................... .397
All Wheel

Drive (AWD) ...................312, 426
Alterations/Modifications, Vehicle ................7
Antifreeze (Engine Coolant) ................419, 447
Disposal ...............................422
Anti-Lock Brake System (ABS) .................319
Anti-Lock Warning Light .....................220
466 INDEX

Appearance Care.......................... .427
Arming System (Security Alarm) ................16
Assist, Hill Start .......................... .321
Auto Down Power Windows ...................33
Automatic Door Locks ........................27
Automatic Headlights .......................117
Automatic High Beams ......................118
Automatic Temperature Control (ATC) ...........275
Automatic Transmission ..................302, 426
Adding Fluid .....................426, 449, 452
Fluid And Filter Changes ...................426
Fluid Change .......................... .426
Fluid Level Check .....................424, 425
Fluid Type ..........................449, 452
Gear Ranges ............................305
Special Additives ........................ .425
Autostick Operation ............................. .309
Auto Unlock, Doors .........................27
Auto Up Power Windows .....................33
AW D Towing ............................... .397
Axle Fluid ............................449, 452
Axle Lubrication ........................449, 452 Battery
...............................211,412
Charging System Light .....................211
Key Fob Battery Replacement .................21
Keyless Key Fob Replacement ................21
Location ...............................412
Remote Battery Replacement .................21
Belts, Seat .................................77
Beverage Holder Cooled (Cupholder) ............192
Beverage Holder Heated (Cupholder) ............192
Body Mechanism Lubrication ..................416
B-Pillar Location .......................... .334
Brake Assist System ........................ .320
Brake Control System, Electronic ................318
Brake Fluid .......................... .449, 452
Brake, Parking ............................ .316
Brakes ................................. .317
Brake System ..........................317,

423
Fluid Check ..................... .423, 449, 452
Master Cylinder ........................ .423
Parking ...............................316
Warning Light .......................208, 317
Brake/Transmission Interlock ..................302
Brightness, Interior Lights ....................124
Bulb Replacement .......................443, 44410
INDEX 467

Bulbs, Light............................79, 443
Camera, Rear ............................ .174
Capacities, Fluid .......................... .447
Caps, Filler Oil (Engine) ............................410
Radiator (Coolant Pressure) .................421
Carbon Monoxide Warning .................76, 361
Cargo Area Features ........................197
Cargo Compartment ........................197
Cargo (Vehicle Loading) ..................... .366
Car Washes ...............................427
Certification Label ..........................367
Chains, Tire ............................. .348
Changing A Flat Tire ........................382
Chart, Tire Sizing .......................... .330
Check Engine Light (Malfunction Indicator Light). . . .406
Checking Your Vehicle For Safety ................75
Checks, Safety .............................75
Child Restraint .............................60
Child Restraints Booster Seats ............................63
Child Restraints ..........................60
Child Seat Installation ......................71
How To Stow An Unused ALR Seat Belt .........69Infants And Child Restraints
.................62
Lower Anchors And Tethers For Children ........65
Older Children And Child Restraints ...........62
Seating Positions ..........................64
Child Safety Locks ..........................27
Clean Air Gasoline ........................ .358
Cleaning Wheels ............................... .428
Climate Control ............................268
Clock .................................. .241
Coin Holder ............................. .194
Cold Weather Operation ..................... .299
Compact Spare Tire ........................ .344
Connector UCI ..................................265
Universal Consumer Interface (UCI) ...........265
Console, Floor ............................ .194
Contract, Service .......................... .462
Coolant Pr

essure Cap (Radiator Cap) .............421
Cooling System ............................419
Adding Coolant (Antifreeze) .................420
Coolant Capacity ........................ .447
Coolant Level ........................419, 422
Disposal Of Used Coolant ..................422
Drain, Flush, And Refill ....................419
468 INDEX

Inspection............................. .422
Points To Remember ..................... .422
Pressure Cap ............................421
Radiator Cap .......................... .421
Selection Of Coolant (Antifreeze) .419, 447, 449, 450, 451
Corrosion Protection ........................427
Cruise Control (Speed Control) .................135
Cruise Light ........................226, 227, 228
Cupholders .......................... .191, 432
Customer Assistance ........................460
Customer Programmable Features ...............242
Daytime Brightness, Interior Lights ..............125
Daytime Running Lights .....................120
Dealer Service ............................ .407
Deck Lid, Emergency Release ...................36
Deck Lid, Power Release ......................35
Defroster, Rear Window ..................... .198
Defroster, Windshield ........................77
Delay (Intermittent) Wipers ...................126
Diagnostic System, Onboard ...................405
Dimmer Switch, Headlight ....................121
Dipsticks Oil (Engine) ........................ .408, 409
Disabled Vehicle Towing .....................396 Disposal
Antifreeze (Engine Coolant) .................422
Door Ajar ............................... .214
Door Ajar Light ............................214
Door Locks Child-Protection Door Lock — Rear Doors .......27
Door Locks .......................... .20, 25
KeyFob................................25
Key Fob Emergency Key ....................21
Remote ................................25
Remote Keyless Entry ......................25
Door Locks, Automatic .......................27
Driving Through Flowing, Rising, Or Shallow Standing
Water .................................313
E-85 Fuel ............................... .361
Electrical Power Outlets ..................... .188
Electric Rear Window Defrost ..................198
Electric Remote

Mirrors .......................93
Electronic Brake Control System ................318
Anti-Lock Brake System ....................319
Electronic Roll Mitigation ...................327
Traction Control System ....................323
Electronic Power Distribution Center (Fuses) .......433
10
INDEX 469

Electronic Speed Control (Cruise Control)......132, 135
Electronic Stability Control (ESC) ...............323
Electronic Throttle Control Warning Light .........212
Emergency Deck Lid Release ...................36
Emergency, In Case Of Freeing Vehicle When Stuck .................392
Hazard Warning Flasher ...................380
Jacking ............................... .382
Jump Starting ....................389, 390, 391
Overheating ............................380
Towing ............................... .396
Emergency Trunk Release .....................36
Emission Control System Maintenance ............406
Engine ................................. .404
Air Cleaner .............................411
Block Heater ............................300
Break-In Recommendations ..................75
Checking Oil Level ....................408, 409
Compartment ........................403, 404
Compartment Identification .................403
Coolant (Antifreeze) .............419, 449, 450, 451
Cooling ...............................419
Exhaust Gas Caution ...................76, 361
Fails To Start ............................299
Flooded, Starting ........................ .299Fuel Requirements
........................357
Jump Starting ....................389, 390, 391
Oil......................408, 447, 449, 450, 451
Oil Filler Cap .......................... .410
Oil Filter ...............................411
Oil Selection ........................ .409, 447
Oil Synthetic ............................410
Overheating ............................380
Starting ...............................297
Engine Oil Viscosity ........................ .410
Engine Oil Viscosity Chart ....................410
Enhanced Accident Response Feature ..........58,399
Entry

System, Illuminated .....................18
Ethanol ............................. .358, 361
Exhaust Gas Caution .....................76, 361
Exhaust System ........................ .76, 417
Exterior Folding Mirrors ......................92
Exterior Lighting ...........................116
Exterior Lights .............................79
Filters Air Cleaner .............................411
Air Conditioning .....................277, 414
Engine Oil ....................411, 449, 450, 451
Engine Oil Disposal .......................411
470 INDEX

Gross Axle Weight Rating.................367, 369
Gross Vehicle Weight Rating ...............367, 369
GVWR ................................. .367
Hazard Driving Through Flowing, Rising, Or Shallow Standing
Water .................................313
Hazard Warning Flasher ..................... .380
Headlights ...............................444
Automatic ..............................117
Cleaning ...............................431
Delay .................................118
High Beam/Low Beam Select Switch ...........121
Lights On Reminder ..................... .120
On With Wipers ......................117,127
Passing ............................... .122
Switch ................................116
Time Delay .............................118
Washers ...............................416
Headlight Washers ..........................416
Head Restraints ........................109, 110
Head Rests ............................109, 110
Heated Mirrors .............................95
Heated Seats ............................. .106
Heater ................................. .269Heater, Engine Block
........................300
High Beam/Low Beam Select (Dimmer) Switch .....121
Hill Start Assist ............................321
Hitches Trailer Towing .......................... .371
Holder, Coin ............................. .194
Hood Release .............................115
Ignition Key ...................................11
Illuminated Entry ...........................18
Immobilizer (Sentry Key) ......................14
Inside Rearview Mirror .......................86
Instrument Cluster ............204, 210, 213, 222, 226
Instrument Cluster Display Information Display .......................229
Instrument Cluster Display ..................233
Instrument Panel And Controls .................203
Instrument Panel Lens Cleaning ................431
Interior Appearance

Care .....................430
Interior Lights ............................ .123
Intermittent Wipers (Delay Wipers) ..............126
Introduction ................................4
iPod/USB/MP3 Control ..................... .265
472 INDEX

Jacking Instructions........................ .385
Jack Location ............................ .383
Jack Operation ........................ .382, 385
Jump Starting ..................... .389, 390, 391
KeyFob..................................12 Arm The Alarm ..........................17
Lock The Doors ..........................20
Panic Alarm .............................20
Programming Additional Key Fobs ..........16, 21
Remote Battery Replacement .................21
Towing ............................... .398
Unlatch The Trunk ........................20
Unlock The Doors .........................19
Key Fob Battery Service (Remote Keyless Entry) .....21
Key Fob Programming (Remote Keyless Entry) . . . .18, 21
Key Fob, Remote Keyless Entry .................18
Key-In Reminder ............................13
Keyless Enter-N-Go ..................... .28, 298
Enter The Trunk ..........................20
Lock The Vehicle’s Doors ................20, 255
Passive Entry ............................28
Passive Entry Programming ..............28, 255
Unlock From The Driver’s Side ...............19
Unlock From The Passenger Side ..............19Keyless Entry System
........................18
Keyless Go ................................11
Key, Replacement ...........................15
Keys ....................................11
Key, Sentry (Immobilizer) ......................14
Lane Change And Turn Signals .................121
Lane Change Assist ........................ .121
LaneSense ............................... .157
Lap/Shoulder Belts ..........................39
Latches ..................................79
Hood .................................115
Lead Free Gasoline ........................ .357
Leaks, Fluid ...............................79
Life Of Tires ............................. .347
Light Bulbs ............................79, 443
Lights ............................... .79, 116
AirBag ......................... .48, 77, 207
Automatic Headlights .....................117
Brake Assist Warning ..................... .326
Brake W

arning .......................208, 317
Bulb Replacement ........................444
Cruise ..........................226, 227, 228
Daytime Running ........................120
Dimmer Switch, Headlight ..................121
10
INDEX 473