engine oil CHRYSLER 300 C 2005 1.G Owners Manual
[x] Cancel search | Manufacturer: CHRYSLER, Model Year: 2005, Model line: 300 C, Model: CHRYSLER 300 C 2005 1.GPages: 130, PDF Size: 0.72 MB
Page 8 of 130
8
5/100 POWERTRAIN WARRANTY
The following powertrain components are covered for 5 years or 100,000 kilometres, whichever occurs first, measured from thevehicleÕs original warranty start date.
Vehicles placed in Police, Taxi, Limousine, Postal or Ambulance
service, are excluded from the 5-year or 100,000-kilometre Powertrain
Warranty and are covered only under the 3-year or 60,000-kilometreBasic Warranty. ¥ Engine Ð Cylinder block and all internal parts; cylinder head
assemblies; timing case, timing chain, timing belt, gears and sprockets; vibration damper; oil pump; water pump and housing;intake and exhaust manifolds; flywheel with starter ring gear; coreplugs; valve covers; oil pan; turbocharger housing and internalparts; turbocharger wastegate actuator; supercharger; serpentinebelt tensioner; seals and gaskets for listed components only. ¥
Transmission Ð Transmission case and all internal parts; torque
converter; drive/flex plate; transmission range switch;transmission control module; bell housing; oil pan; seals andgaskets for listed components only.
Note: Manual transmission clutch parts are not covered at any time .
¥ Rear-Wheel Drive (RWD) Ð Rear axle housing and all internal
parts; axle shafts; axle shaft bearings; drive shaft assemblies; driveshaft centre bearings; universal joints and yokes; seals and gasketsfor listed components only.
5/100 POWERTRAIN WARRANTY
2005 Chrysler 300C, 300 and Dodge Magnum
2005 LX Maint Book 4/13/04 4:25 PM Page 8
Page 12 of 130
2005 Chrysler 300C, 300 and Dodge Magnum
12
WHAT IS NOT COVERED
WHA
T IS NOT COVERED
DAMAGE FROMMISUSE ORACCIDENT
The warranties in this booklet do not cover repairs required due to fire, accidents, abuse, negligence, objects striking your vehicle,carrying corrosive materials (such as chemicals, acids andfertilizers), misuse (such as driving over curbs, overloading,spinning wheels, etc.), racing or participating in a racing event,improper disconnection of components, modifying the exhaustsystem, tampering or making adjustments which do not complywith DaimlerChrysler specifications.
Disconnecting, tampering with or changing the reading of the
odometer will void your warranties. D AMAGE FROMTHEENVIRONMENT
The warranties in this booklet do not cover fading or deterioration caused by exposure to the elements, or repairs required due toairborne fallout, acid rain, chemicals, tree sap, insects, bird or insectdroppings, salt, sand, gravel, road hazards, hail, windstorms,lightning, floods or any other event of nature. Road salt, car washes, scuffs and scratches, and everyday
abrasion from sand and dirt can affect the appearance of a vehicleÕs wheels (steel, chrome and aluminum) and other undercarriageparts. Some surface corrosion with use is normal; it is not a defectand is not covered by any warranty. N ORMAL MAINTENANCE ANDWEAR
The warranties in this booklet do not cover normal maintenance services, such as oil and filter changes, generallubrication, tire rotation, engine tune-ups and replacing sparkplugs. Required maintenance services are described in detail inyour OwnerÕs Manual and herein. The warranties also do notcover light bulbs and fuses, worn wiper blades, clutch discs, brakerotors, pads, linings or drums, windshield and rear window,wheel alignment and wheel balancing (unless they are defective,
see page 7).
2005 LX Maint Book 4/13/04 4:25 PM Page 12
Page 25 of 130
2005 Chrysler 300C, 300 and Dodge Magnum25
OPTIONAL DAIMLERCHRYSLER CANADA SERVICE CONTRACT
S
1.
POWER TRAIN PLANS*
Powertrain plans complement the powertrain factory warranty by eliminating the deductible and providing a car rental allowance.Certain plans also provide additional distance coverage. Major components covered are: ¥ engine ¥ transmission ¥ front-wheel drive ¥ rear-wheel drive¥ four-wheel drive (4x4) ¥ all-wheel-drive vehicles 2. ÒG OLD Ó PLANS *
Each plan provides full mechanical repair protection to non-powertrain (Gold) components. Certain plansalso provide full mechanical
protection against powertrain component repairs beyond your vehicleÕspowertrain warranty coverage. Contracts are available with or withouta deductible. Major components covered are: ¥ steering ¥ air conditioning ¥ engine cooling and fuel ¥ frontsuspension ¥ rear suspension ¥ electrical ¥ hydraulic brakecomponents ¥ anti-lock brakes * Maximum terms available on new vehicles registered in Canada only. 3.
ÒG OLD PLUS Ó PLANS *
The most complete protection available for your new vehicle is one of three ÒGold PlusÓ Service Contracts which combines the benefitsof ÒGoldÓ ¥ Mechanical repair coverage for non-powertrain components
plus the most important vehicle maintenance function ¥ Engine oil and oil filter changes
plus ¥ Tire rotation every other service
plus ¥ ÒPeace-of-MindÓ motoring with Tire Road Hazard Protection which provides full, or pro rata, replacementof the original four tires, or their repair
plus ¥ Rental car allowance for same-day warranty repairs Ð your vehicle need not be kept overnight before eligibilityfor the rental allowance is met.
2005 LX Maint Book 4/13/04 4:25 PM Page 25
Page 30 of 130
MAINTENANCE Scheduled maintenance must be completed to provide the best vehicle
performance and reliability . The limited warranties in the warranty booklet DO NOT COVER repairs
required due to improper maintenance. W e strongly suggest you keep track of scheduled maintenance and
keep receipts or other documents. Use only recommended Mopar lubricants and genuine Mopar parts.
NOTE: WHERE TIME (MONTHS) AND METRAGE ARE INDICA TED, FOLLOW THE INTERVAL
THA T OCCURS FIRST .
AT EACH STOP FOR FUEL
¥ Check the engine oil level about 5 minutes after a fully warmed engine is shut off. Checking theoil level while the vehicle is on level ground willimprove the accuracy of the oil level reading.
Add oil only when the level is at or below the
ADD or MIN mark.
¥ Check the windshield washer solvent and add if required.
ONCE A MONTH
¥ Check the tire pressure and look for unusualwear or damage.
¥ Inspect the battery and clean and tighten theterminals as required.
¥ Check the fluid levels of coolant reservoir , brake
master cylinder , power steering and transmission
and add as needed.
¥ Check all the lights and all other electrical itemsfor correct operation.
¥ Check rubber seals on each side of the radiatorfor proper fit .
¥ Check and clean wiper blades. Replace if required.
VISUAL INSPECTIONS Ð
INSPECT FOR SIGNS OF COMPONENT
DETERIORA TION AND PHYSICAL DAMAGE.
There are two maintenance schedules contained in your OwnerÕ s Manual. Schedule
ÒBÓ best describes operating conditions inCanada and is the recommended serviceschedule. For your convenience, the scheduledmaintenance intervals outlined in this bookletfollow the Severe Service Schedule as describedin your OwnerÕ s Manual. Schedule ÒBÓ is for
vehicles that are operated under one or more ofthe following conditions: day or night tempera -
tures are below 0 ¡C; stop and go driving;
extensive engine idling; driving in dustyconditions; short trips of less than 16.2 km; more than 50% of your driving is at sustainedhigh speeds during hot weather
, above 32¡C;
trailer towing; taxi, police, or delivery service(commercial service); off-road or desert driving;if equipped for and operating with E-85(ethanol) fuel. Schedule ÒAÓ is for vehicles thatare not operated under any of the conditionslisted under Schedule ÒB.Ó
The performance of all scheduled servicework is required to maintain your vehicle ingood operating condition. DaimlerChryslerCanada Inc. reserves the right to denywarranty coverage if the vehicle has not beenproperly maintained. While we do not insistthat such work be performed by factory-authorized dealers, we strongly recommendthat an authorized Chrysler , Jeep
¨or Dodge
dealer perform this work.
INTRODUCTION
2005 LX Maint Cover 4/13/04 4:16 PM Page 4
Page 31 of 130
2005 Chrysler 300C, 300 and Dodge Magnum
5,000 km
Maint enance Service
Sc hedule ÒBÓ
Odometer Reading
Date
Dealer copy.
Remove and attach to Repair Order 26-92-01-01 3N.
Maint enance Service Sc hedule ÒBÓ
5,0 00 km
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate, as required, all steering and suspension components.
lInspect the engine air cleaner filter and replace if necessary.
INSPECT THE FOLLOWING: l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Inspect the CV joints.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
2005 LX Maint Book 4/13/04 4:25 PM Page 29
Page 32 of 130
2005 Chrysler 300C, 300 and Dodge Magnum
Maintenance Service Sc hedule ÒBÓ
5,0 00 km
Odometer Reading
Date
Repair Order No.
D AIMLER CHR YSLER
D EALER STAMP
Signature of authorized DaimlerChrysler Canada dealer
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate, as required, all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary.
INSPECT THE FOLLOWING: l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Inspect the CV joints.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
2005 LX Maint Book 4/13/04 4:25 PM Page 30
Page 33 of 130
2005 Chrysler 300C, 300 and Dodge Magnum
Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
10,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-02-01 3N.
Maint enance Service Sc hedule ÒBÓ
1 0,0 00 km
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate, as required, all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary.
l Rotate tires and check tire pressure.
INSPECT THE FOLLOWING: l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Inspect the CV joints.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
2005 LX Maint Book 4/13/04 4:25 PM Page 31
Page 34 of 130
2005 Chrysler 300C, 300 and Dodge Magnum
Odometer Reading
Date
Repair Order No.
DAIMLER CHR YSLER
D EALER STAMP
Signature of authorized DaimlerChrysler Canada dealer
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate, as required, all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary.
l Rotate tires and check tire pressure.
INSPECT THE FOLLOWING: l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Inspect the CV joints.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.Maint enance Service Sc hedule ÒBÓ
1 0,0 00 km
2005 LX Maint Book 4/13/04 4:25 PM Page 32
Page 35 of 130
2005 Chrysler 300C, 300 and Dodge Magnum
Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
14,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-03-01 3N.
Maint enance Service Sc hedule ÒBÓ
14,0 00 km
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate, as required, all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary.
INSPECT THE FOLLOWING: l Inspect the front-and-rear brake linings and components (LX Magnum).
l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Inspect the CV joints.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
2005 LX Maint Book 4/13/04 4:25 PM Page 33
Page 36 of 130
2005 Chrysler 300C, 300 and Dodge Magnum
Odometer Reading
Date
Repair Order No.
DAIMLER CHR YSLER
D EALER STAMP
Signature of authorized DaimlerChrysler Canada dealer
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate, as required, all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary.
INSPECT THE FOLLOWING: l Inspect the front-and-rear brake linings and components (LX Magnum).
l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Inspect the CV joints.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.Maint enance Service Sc hedule ÒBÓ
14,0 00 km
2005 LX Maint Book 4/13/04 4:25 PM Page 34