steering CHRYSLER 300 C 2008 1.G Workshop Manual

Brake and Power Steering Hoses
When the vehicle is serviced for scheduled maintenance,
inspect surface of hoses and nylon tubing for evidence of
heat and mechanical damage. Hard and brittle rubber,
cracking, tears, cuts, abrasion, and excessive swelling
indicate deterioration of the rubber. Particular attention
should be made to examining those hose surfaces nearest
to high heat sources, such as the exhaust manifold.
Insure nylon tubing in these areas has not melted or
collapsed.
Inspect all hose connections such as clamps and cou-
plings to make sure they are secure and no leaks are
present.
NOTE:
•Often, fluid such as oil, power steering fluid, and
brake fluid are used during assembly plant operations
to facilitate the assembly of hoses to couplings. There-
fore, oil wetness at the hose-coupling area is notnecessarily an indication of leakage. Actual dripping
of hot fluid when systems are under pressure (during
vehicle operation), should be noted before a hose is
replaced based on leakage.
•Inspect the brake hoses whenever the brake system is
serviced and at every engine oil change. Inspect hy-
draulic brake hoses for surface cracking, scuffing, or
worn spots. If there is any evidence of cracking,
scuffing, or worn spots, the hose should be replaced
immediately! Eventual deterioration of the hose can
take place resulting in a possibility of a burst failure.
WARNING!
Worn brake hoses can burst and cause brake failure.
You could have an accident. If you see any signs of
cracking, scuffing, or worn spots, have the brake
hoses replaced immediately.
442 MAINTAINING YOUR VEHICLE

Cavity Car-
tridge
FuseMini
FuseDescription
29 — 5 Amp
OrangeAdaptive Cruise Control
(ACC) - if equipped/
Cluster/Electronic Sta-
bility Program (ESP) - if
equipped/Powertrain
Control Module (PCM)/
Stop Light Switch
30 — 10 Amp
RedDoor Modules/Power
Mirrors/Steering Con-
trol Module (SCM)
31———
32———
33———
34———Cavity Car-
tridge
FuseMini
FuseDescription
35 — 5 Amp
OrangeAntenna Module - if
equipped/Power
Mirrors/Rain Sensor - if
equipped
36 — 20 Amp
YellowHands Free Phone - if
equipped/Video Moni-
tor - if equipped/Radio
37 — 15 Amp
BlueTransmission
38 — 10 Amp
RedAnalog Clock/Cargo
Light/Satellite Receiver
(SDARS) Video - if
equipped/Vehicle Infor-
mation Module - if
equipped
456 MAINTAINING YOUR VEHICLE

Component Fluids, Lubricants, and Genuine Parts
Oil Filter (3.5 Liter) Mopar\205281090 or equivalent.
Oil Filter (5.7 Liter) Mopar\205281090 or equivalent.
Fuel Selection (2.7 Liter) 87 Octane
Fuel Selection (3.5 Liter) 87 to 89 Octane
Fuel Selection (5.7 Liter) 87 to 89 Octane
Chassis
Component Fluids, Lubricants, and Genuine Parts
Automatic Transmission Mopar\2ATF+4 Automatic Transmission Fluid.
Brake Master Cylinder Mopar\2DOT 3, SAE J1703 or equivalent should be used. If DOT 3 brake
fluid is not available, then DOT 4 is acceptable. Use only recommended
brake fluids.
Front Axle API GL-5 SAE 75W90 Synthetic Gear Lubricant or equivalent.
Power Steering Reservoir Mopar\2Power Steering Fluid + 4, Mopar\2ATF+4 Automatic Transmission
Fluid.
Rear Axle API GL-5 SAE 75W140 Synthetic Gear Lubricant or equivalent.
Transfer Case Mopar\2Transfer Case Lubricant LX, P/N 05170055AA, or equivalent.
476 MAINTAINING YOUR VEHICLE

if it has been 6 months since your last oil change even
if the oil change indicator message is NOT illumi-
nated.
•Change your engine oil more often if you drive your
vehicle off-road for an extended period of time.
•Under no circumstances should oil change intervals
exceed 6,000 miles (10,000 km) or 6 months, whichever
comes first.
Your dealer will reset the oil change indicator message
after completing the scheduled oil change. If a scheduled
oil change is performed by someone other than your
dealer, the message can be reset by referring to the steps
described under “Oil Change Required” under “Elec-
tronic Vehicle Information Center (EVIC)” in Section 3 of
this manual or under “Odometer/Trip Odometer” under
“Instrument Cluster Descriptions” in Section 3 of this
manual.At Each Stop for Fuel
•Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
•Check the windshield washer solvent and add if
required.
Once a Month
•Check tire pressure and look for unusual wear or
damage.
•Inspect the battery, and clean and tighten the terminals
as required.
•Check the fluid levels of coolant reservoir, brake
master cylinder, power steering, and transmission,
and add as needed.
MAINTENANCE SCHEDULES 479
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Cooling System....................... 436
Engine Oil........................421,422
Power Steering........................ 432
Transfer Case......................... 445
Fluids................................ 475
Fluids, Lubricants and Genuine Parts.......... 475
Fog Lights..........................134,202
Folding Rear Seat........................ 123
Freeing A Stuck Vehicle................... 407
Front Suspension Ball Joints................ 432
Front Wheel Bearings..................... 446
Fuel................................. 365
Adding............................. 369
Additives............................ 367
Clean Air............................ 366
Conserving.......................... 219
Ethanol............................. 366
Filler Cap (Gas Cap).................... 369
Filter............................... 426Gasoline............................ 365
Gauge.............................. 209
Hoses.............................. 441
Materials Added....................... 367
Methanol............................ 366
Octane Rating......................365,475
Requirements......................... 365
Saver Mode.......................... 219
Specifications......................... 475
Tank Capacity........................ 473
Fuel System Caution..................... 370
Fueling............................... 369
Fuses................................ 451
Garage Door Opener (HomeLink\2) ........... 177
Gas Cap (Fuel Filler Cap)...............369,417
Gasoline, Clean Air...................... 366
Gasoline (Fuel)......................... 365
Conserving.......................... 219
INDEX 503
10

Parking On Hill......................... 322
Passing Light........................... 136
Pedals, Adjustable....................... 147
Personal Settings........................ 227
Pets.................................. 76
Phone, Cellular....................91,252,253
Phone, Hands-Free (UConnect™)........91,252,253
Placard, Tire and Loading Information......... 340
Port
Universal Serial Bus (USB).............234,252
USB .............................234,252
Power
Brakes.............................. 324
Deck Lid Release....................... 40
Distribution Center (Fuses)............... 451
Door Locks........................... 30
Mirrors.............................. 89
Outlet (Auxiliary Electrical Outlet).......... 187
Seats............................... 117Steering............................. 327
Steering, Checking..................... 432
Sunroof............................. 184
Tilt/Telescoping Steering Column........... 145
Windows............................. 36
Power Steering Fluid..................432,476
Pregnant Women and Seat Belts.............. 51
Preparation for Jacking.................... 395
Pretensioners
Seat Belts............................. 48
Programmable Electronic Features............ 227
Programming Transmitters
(Remote Keyless Entry).................... 20
Radial Ply Tires......................... 347
Radiator Cap (Coolant Pressure Cap).......... 438
Radio Broadcast Signals................... 232
Radio, Navigation....................... 252
Radio Operation...................234,253,281
510 INDEX

Starting and Operating.................... 299
Starting Procedures...................... 299
Steering
Column Controls...................... 134
Column Lock......................... 144
Linkage............................. 433
Power...........................327,432
Tilt Column.......................144,145
Wheel, Tilt........................144,145
Steering Wheel Mounted Sound System
Controls.............................. 279
Storage............................190,458
Storage, Vehicle......................291,458
Storing Your Vehicle...................... 458
Stuck, Freeing.......................... 407
Sun Roof.............................. 184
Sunglasses Storage....................... 177
Sunroof Maintenance..................... 186
Supplemental Restraint System - Airbag........ 52Sway Control, Trailer..................... 377
Synthetic Engine Oil...................... 424
System, Navigation...................... 252
System, Remote Starting.................... 27
Tachometer............................ 204
Telescoping Steering Column.............144,145
Temperature Control, Automatic (ATC)........ 284
Temperature Gauge, Engine Coolant.......207,393
Tether Anchor, Child Restraint............... 71
Theft Alarm (Security Alarm)................ 18
Theft System (Security Alarm)............... 18
Tilt Steering Column...................144,145
Time Delay, Headlight.................... 133
Tip Start............................... 14
Tire and Loading Information Placard......... 340
Tire Identification Number (TIN)............. 338
Tire Markings.......................... 334
Tire Safety Information.................... 334
514 INDEX