key CHRYSLER 300 LX 2007 Repair Manual

A loose, improperly installed, or damaged fuel filler cap
may also turn on the Malfunction Indicator Light (MIL).
EMISSIONS INSPECTION AND MAINTENANCE
PROGRAMS
In some localities, it may be a legal requirement to pass
an inspection of your vehicle’s emissions control system.
Failure to pass could prevent vehicle registration.
For states, which have an I/M (Inspection and
Maintenance) requirement, this check verifies the
following: the MIL (Malfunction Indicator Lamp)
is functioning and is not on when the engine is running,
and that the OBD (On Board Diagnostic) system is ready
for testing.
Normally, the OBD system will be ready. The OBD
system maynotbe ready if your vehicle was recently
serviced, if you recently had a dead battery, or a battery
replacement. If the OBD system should be determined
not ready for the I/M test, your vehicle may fail the test.Your vehicle has a simple ignition key actuated test,
which you can use prior to going to the test station. To
check if your vehicle’s OBD system is ready, you must do
the following:
1. Insert your ignition key into the ignition switch.
2. Turn the ignition to the ON position, but do not crank
or start the engine.
3. If you crank or start the engine, you will have to start
this test over.
4. As soon as you turn your key to the ON position, you
will see your MIL symbol come on as part of a normal
bulb check.
5. Approximately 15 seconds later, one of two things will
happen:
a. The MIL will flash for about 10 seconds and then
return to being fully illuminated until you turn off
the ignition key or start the engine. This means that
your vehicle’s OBD system isnot readyand you
shouldnotproceed to the I/M station.
MAINTAINING YOUR VEHICLE 333
7
ProCarManuals.com

b. The MIL will not flash at all and will remain fully
illuminated until you turn off the ignition key or
start the engine. This means that your vehicle’s OBD
system isreadyand you can proceed to the I/M
station.
If your OBD system isnot ready,you should see your
authorized dealer or repair facility. If your vehicle was
recently serviced or had a battery failure or replacement,
you may need to do nothing more than drive your
vehicle as you normally would in order for your OBD
system to update. A recheck with the above test routine
may then indicate that the system is now ready.
Regardless of whether your vehicle’s OBD system is
ready or not ready, if the MIL symbol is illuminated
during normal vehicle operation, you should have your
vehicle serviced before going to the I/M station. The I/M
station can fail your vehicle because the MIL symbol is on
with the engine running.
REPLACEMENT PARTS
Use of genuine Moparparts for normal/scheduled
maintenance and repairs is highly recommended to in-
sure the designed performance. Damage or failures
caused by the use of non-Moparparts for maintenance
and repairs will not be covered by the manufacturer’s
warranty.
DEALER SERVICE
Your dealer has the qualified service personnel, special
tools, and equipment to perform all service operations in
an expert manner. Service Manuals are available which
include detailed service information for your vehicle.
Refer to these manuals before attempting any procedure
yourself.
NOTE:Intentional tampering with emissions control
systems can result in civil penalties being assessed
against you.
334 MAINTAINING YOUR VEHICLE
ProCarManuals.com

Cavity Car-
tridge
FuseMini
FuseDescription
1 60 Amp
Yellow— Ignition Off Draw (IOD)
2 40 Amp
Green— Battery
3———
4 40 Amp
Green— Battery
5 30 Amp
Pink— Heated Seats - if
equipped
6 — 20 Amp
YellowFuel Pump
7———
8 — 15 Amp
BlueIgnition Switch/Airbag
Control Module (ACM)
9 — 20 Amp
YellowConsole Power Outlet
10———
11*———
12*———Cavity Car-
tridge
FuseMini
FuseDescription
13*———
14 — 10 Amp
RedAC Heater Control/
Cluster/Sentry Key Re-
mote Keyless Entry
15 — 20 Amp
YellowTrailer Tow Brake Mod-
ule - if equipped
16———
17 — 20 Amp
YellowCluster
18 — 20 Amp
YellowSelectable Power Outlet
19 — 10 Amp
RedStop Lights
20———
21———
22———
23———
24———
25———
MAINTAINING YOUR VEHICLE 367
7
ProCarManuals.com

Cavity Car-
tridge
FuseMini
FuseDescription
26———
27 — 10 Amp
RedAirbag/Airbag Control
Module (ACM)
28 — 10 Amp
RedCurtain Airbag - if
equipped
29 — 5 Amp
OrangeAnti-lock Brakes Module
- if equipped/Cluster/
Front Control Module
(FCM)/Powertrain Con-
trol Module (PCM)/
Sentry Key Remote Key-
less Entry/Stop Lights
30 — 10 Amp
RedDoor Modules/Power
Mirrors - if equipped/
Steering Control Module
31———
32———
33———
34———Cavity Car-
tridge
FuseMini
FuseDescription
35 — 5 Amp
OrangeAmplifier - if equipped/
Antenna/Ignition
Delay/Overhead
Console/Passenger Door
Lock & Express Power
Window Switch - if
equipped/Power Mir-
rors - if equipped/Rain
Sensor - if equipped/
Rear Defrost
36 — 20 Amp
YellowHands Free Phone - if
equipped/Media System
Monitor DVD - if
equipped/Radio/
Satellite Receiver - if
equipped
37 — 15 Amp
BlueTransmission - NAG1
38 — 5 Amp
OrangeAnalog Clock/Cargo
Light/Overhead Con-
sole
368 MAINTAINING YOUR VEHICLE
ProCarManuals.com

CAUTION!
Do not touch the new bulb with your fingers. Oil
contamination will severely shorten bulb life. If the
bulb comes in contact with an oily surface, clean the
bulb with rubbing alcohol.
Low Beam Headlight, High Beam Headlight, and
Park/Turn Light – 300C
High Intensity Discharge Headlights (HID) — If
Equipped
The headlights are a type of high voltage discharge tube.
High voltage can remain in the circuit even with the
headlight switch off and the key removed.Because of
this, you should not attempt to service a headlight bulb
yourself. If a headlight bulb fails, take your vehicle to
an authorized dealer for service.
WARNING!
A transient high tension occurs at the bulb sockets of
High Intensity Discharge (HID) headlights when the
headlight switch is turned ON. It may cause serious
electrical shock or electrocution if not serviced prop-
erly. See your authorized dealer for service.
NOTE:On vehicles equipped with High Intensity Dis-
charge Headlights (HID), when the headlights are turned
on, there is a blue hue to the lights. This diminishes and
becomes more white after approximately 10 seconds, as
the system charges.
1. Open the hood.
NOTE:Removal of the air cleaner filter housing may be
necessary prior to replacing bulbs in the headlight assem-
bly on the driver side of the vehicle.
2. Twist the appropriate bulb and socket assembly
counter-clockwise, and then pull it out of the headlight
assembly.
3. Pull the bulb out of the socket assembly.
374 MAINTAINING YOUR VEHICLE
ProCarManuals.com

Autostick........................... 249
Fluid and Filter Changes................ 357
Fluid Change........................ 357
Fluid Level Check..................... 356
Fluid Type.......................... 384
Gear Ranges......................... 241
Shifting..........................240,245
Special Additives..................... 357
Torque Converter..................... 243
Automatic Transmission Limp Home Mode . . . 244
Autostick..........................247,249
Ball Joints............................ 346
Battery............................... 343
Emergency Starting.................... 322
Jump Starting........................ 322
Keyless Transmitter Replacement (RKE)..... 21
Location.........................322,343
Bearings.............................. 358
Belts, Drive........................... 340
Belts, Seat............................. 33
Body Mechanism Lubrication.............. 346
B-Pillar Location....................... 267Brake Assist System..................... 258
Brake, Parking......................... 251
Brake System.......................253,354
Anti-Lock (ABS)...................... 253
Fluid Check......................355,384
Hoses.............................. 354
Master Cylinder...................... 355
Parking............................ 251
Warning Light....................165,253
Brakes............................... 253
Brake/Transmission Interlock.............. 240
Break-In Recommendations, New Vehicle...... 58
Bulb Replacement...................... 372
Bulbs, Light........................... 371
Calibration, Compass.................... 178
Capacities, Fluid....................... 382
Caps, Filler
Fuel............................... 293
Oil (Engine)......................338,339
Radiator (Coolant Pressure).............. 351
Car Washes........................... 359
Carbon Monoxide Warning.............59,292
INDEX 415
10
ProCarManuals.com

High Beam/Low Beam Select (Dimmer)
Switch............................... 107
Hitches
Trailer Towing....................... 301
Holder, Cup........................... 151
HomeLink(Garage Door Opener)
Transmitter........................... 141
Hood Release.......................... 101
Hoses............................353,354
Ignition............................... 11
Key ................................ 11
Ignition Key Removal.................... 11
Illuminated Entry....................... 17
Immobilizer (Sentry Key).................. 13
Indicator, Traction Control................ 257
Infant Restraint.......................50,51
Inflation Pressure Tires................... 169
Information Center, Vehicle............... 171
Inside Rearview Mirror................... 68
Instrument Cluster................161,162,163
Instrument Panel and Controls............. 160
Instrument Panel Lens Cleaning............ 362Interior Appearance Care................. 361
Interior Fuses.......................... 363
Interior Lights......................... 108
Intermittent Wipers (Delay Wipers).......... 110
Introduction............................ 4
Jack Location.......................... 315
Jack Operation......................... 317
Jacking Instructions..................... 317
Jump Starting......................... 322
Key, Programming....................... 14
Key, Replacement....................... 14
Key, Sentry (Immobilizer).................. 13
Key-In Reminder........................ 12
Keyless Entry System..................... 17
Keys................................. 11
Knee Bolster........................... 41
Lane Change and Turn Signals............. 107
Lap/Shoulder Belts...................... 33
LATCH
(Lower Anchors and Tether for CHildren) . . . 54,55
420 INDEX
ProCarManuals.com

Outlet (Auxiliary Electrical Outlet)........ 149
Seats............................... 92
Steering.........................255,346
Steering, Checking.................... 346
Sunroof............................ 146
Tilt/Telescoping Steering Column......... 116
Windows............................ 27
Pregnant Women and Seat Belts............. 40
Preparation for Jacking................... 314
Pretensioners
Seat Belts............................ 38
Programmable Electronic Features....142,145,182
Programming Transmitters
(Remote Keyless Entry).............21,142,145
Radial Ply Tires........................ 274
Radiator Cap (Coolant Pressure Cap)........ 351
Radio Broadcast Signals.................. 187
Radio, Navigation...................... 206
Radio Operation..................188,195,219
Radio Remote Controls.................. 215
Radio, Satellite......................207,212
Radio (Sound Systems)................188,195Rain Sensitive Wiper System............... 111
Rear Park Assist System.................. 136
Rear Seat, Folding....................... 97
Rear Window Defroster.................. 229
Rear Window Features................... 229
Rearview Mirrors........................ 68
Reclining Front Seats..................... 93
Recorder, Event Data..................... 49
Recreational Towing..................... 309
Reformulated Gasoline................... 290
Refrigerant............................ 345
Reminder, Seat Belt...................... 38
Remote Keyless Entry (RKE)............... 17
Remote Sound System (Radio) Controls...... 215
Remote Trunk Release.................... 31
Replacement Parts...................... 334
Replacement Tires...................... 277
Reporting Safety Defects................. 409
Restraint, Head......................... 94
Restraints, Child........................ 50
Restraints, Occupant..................... 32
Rocking Vehicle When Stuck.............. 324
Rotation, Tires......................... 280
424 INDEX
ProCarManuals.com

Safety Checks Inside Vehicle............... 60
Safety Checks Outside Vehicle.............. 61
Safety Defects, Reporting................. 409
Safety Information, Tire.................. 262
Safety Tips............................. 59
Satellite Radio......................207,212
Satellite Radio Antenna.................. 214
Schedule, Maintenance................... 386
Seat Belt Maintenance................... 362
Seat Belt Reminder...................... 38
Seat Belts............................32,33
Adjustable Upper Shoulder Anchorage...... 37
And Pregnant Women.................. 40
Child Restraint.................50,51,52,56
Extender............................ 40
Front Seat.........................33,34
Operating Instructions.................. 34
Pretensioners......................... 38
Rear Seat............................ 33
Reminder........................... 168
Untwisting Procedure................... 38
Seats................................. 92
Easy Entry.......................... 100Heated.............................. 95
Lumbar Support....................... 94
Memory............................. 98
Power.............................. 92
Rear Folding......................... 97
Reclining............................ 93
Security Alarm (Theft Alarm)............15,168
Selection of Coolant (Antifreeze).........350,383
Self-Sealing Tires....................... 279
Sentry Key (Immobilizer).................. 13
Service Assistance...................... 406
Service Contract........................ 408
Service Engine Soon Light
(Malfunction Indicator).................. 170
Service Manuals........................ 409
Setting the Clock..............186,190,196,207
Settings, Personal....................... 182
Shifting.............................. 237
Automatic Transmission..........237,240,245
Shoulder Belt Upper Anchorage............. 37
Shoulder Belts.......................... 33
Side Airbag............................ 46
Signals, Turn.......................107,163
INDEX 425
10
ProCarManuals.com

Transmitter Battery Service
(Remote Keyless Entry)................... 21
Transmitter, Garage Door Opener
(HomeLink) .......................... 141
Transmitter Programming
(Remote Keyless Entry)................... 21
Transmitter, Remote Keyless Entry (RKE)...... 17
Transporting Pets........................ 58
Tread Wear Indicators................... 276
Trip Odometer......................... 167
Trunk Release, Emergency................. 32
Trunk Release Remote Control.............. 31
Turn Signals........................107,163
UConnect™ (Hands-Free Phone)............ 72
Uniform Tire Quality Grades.............. 410
Universal Transmitter.................... 141
Unleaded Gasoline...................... 289
Untwisting Procedure, Seat Belt............. 38
Vanity Mirrors.......................... 71
Variance, Compass...................... 179
Vehicle Certification Label................ 295Vehicle Identification Number (VIN).......... 6
Vehicle Loading..................268,295,297
Vehicle Modifications/Alterations............ 7
Vehicle Storage......................226,370
Vehicle Theft Alarm (Security Alarm)......... 15
Video Entertainment System
(Rear Seat Video System)................. 210
Warning Flasher, Hazard................. 312
Warning Lights
(Instrument Cluster Description)............ 163
Warnings and Cautions.................... 6
Warranty Information.................... 408
Washer, Adding Fluid.............. 112,114,347
Washers, Headlight..................... 113
Washers, Windshield................. 110,347
Washing Vehicle........................ 359
Wheel Alignment and Balance............. 278
Wheel and Wheel Trim................... 360
Wheel and Wheel Trim Care............... 360
Wheel Bearings........................ 358
Wind Buffeting......................30,148
Window Airbag (Side Curtain)............42,46
428 INDEX
ProCarManuals.com