cooling CHRYSLER 300 SRT 2005 1.G User Guide

•If frequent coolant additions are required, or if the
level in the coolant recovery bottle does not drop when
the engine cools, the cooling system should be pres-
sure tested for leaks.
•Maintain coolant concentration at 50% HOAT engine
coolant (minimum) and distilled water for proper
corrosion protection of your engine which contains
aluminum components.
•Make sure that the radiator and coolant recovery
bottle overflow hoses are not kinked or obstructed.
•Keep the front of the radiator clean. If your vehicle is
equipped with air conditioning, keep the front of the
condenser clean, also.
•Do not change the thermostat for summer or winter
operation. If replacement is ever necessary, install
ONLY the correct type thermostat. Other designs may
result in unsatisfactory coolant performance, poor gas
mileage, and increased emissions.
Hoses And Vacuum/Vapor Harnesses
Inspect surfaces of hoses and nylon tubing for evidence
of heat and mechanical damage. Hard or soft spots,
brittle rubber, cracking, tears, cuts, abrasions, and exces-
sive swelling indicate deterioration of the rubber.
Pay particular attention to those hoses nearest to high
heat sources such as the exhaust manifold. Inspect hose
routing to be sure hoses do not come in contact with any
heat source or moving component which may cause heat
damage or mechanical wear.
Insure nylon tubing in these areas has not melted or
collapsed.
Inspect all hose connections such as clamps and cou-
plings to make sure they are secure and no leaks are
present.
Components should be replaced immediately if there is
any evidence of wear or damage that could cause failure.
256 MAINTAINING YOUR VEHICLE

3. Replace the bulb and reinstall the bulb and socket
assembly.
4. Reattach the light to the rear fascia.FLUIDS AND CAPACITIES
U.S. Metric
Fuel (approximate)
6.1 Liter Engines (Premium 91
Octane)19 gal-
lons72 liters
Engine Oil-With Filter
6.1 Liter Engines (SAE 0W-40) 7 qts. 6.6 liters
Cooling System *
6.1 Liter Engines (Mopar
Antifreeze/Coolant 5 Year/
100,000 Mile Formula) or
equivalent.14.8 qts 14.0 li-
ters
* Includes heater and coolant recovery bottle filled to
MAX level.
MAINTAINING YOUR VEHICLE 275
7

Cooling System........................ 252
Adding Coolant (Antifreeze)............. 253
Coolant Capacity..................... 275
Coolant Level.....................252,255
Disposal of Used Coolant............... 255
Drain, Flush, and Refill................. 252
Inspection........................... 255
Points to Remember................... 255
Pressure Cap........................ 254
Radiator Cap........................ 254
Selection of Coolant.............253,275,276
Cruise Control (Speed Control)............. 111
Cup Holder........................125,264
Customer Assistance.................... 294
Data Recorder, Event..................... 47
Dealer Service......................... 240
Defroster, Windshield..................57,175
Delay (Intermittent) Wipers............... 104
Diagnostic System, Onboard............... 238
Dimmer Switch, Headlight................ 101
Disposal
Antifreeze (Engine Coolant)............. 255Door Locks............................ 15
Door Locks, Automatic................... 17
Door Opener, Garage.................... 115
Drive Belts............................ 244
Driver’s Seat Glide Feature................ 91
Driving
On Slippery Surfaces.................. 231
Electric Remote Mirrors................... 64
Electrical Power Outlets.................. 123
Electronic Speed Control.................. 111
Electronic Stability Program............... 109
Electronic Vehicle Information Center........ 140
Emergency, In Case of
Freeing Vehicle When Stuck............. 232
Hazard Warning Flasher................ 224
Jump Starting........................ 229
Overheating......................... 225
Towing............................. 233
Emission Control System Maintenance....239,278
Engine............................... 237
Air Cleaner.......................... 245
Air Cleaner Filter..................... 244
306 INDEX

Break-In Recommendations............... 56
Checking Oil Level.................... 241
Compartment........................ 237
Coolant (Antifreeze)................252,276
Cooling............................ 252
Exhaust Gas Caution................56,217
Fails to Start......................... 182
Fuel Requirements.................214,275
Oil ..........................241,275,276
Oil Change Interval................... 242
Oil Selection......................242,275
Overheating......................... 225
Temperature Gauge................... 137
Engine Oil Viscosity..................... 243
Engine Oil Viscosity Chart................ 243
Enhanced Accident Response Feature......... 46
Event Data Recorder..................... 47
Exhaust Gas Caution...............56,217,251
Exhaust System........................ 251
Exterior Folding Mirrors.................. 64
Filters
Air Cleaner.......................... 244Air Conditioning..................177,249
Engine Fuel......................... 245
Engine Oil.......................243,276
Engine Oil Disposal................... 243
Flashers
Hazard Warning...................... 224
Turn Signal.......................... 134
Flash-To-Pass.......................... 101
Floor Console.......................... 126
Fluid Capacities........................ 275
Fluid Leaks............................ 58
Fluid Level Checks
Brake.............................. 258
Cooling System....................... 252
Engine Oil.......................... 241
Power Steering....................... 249
Fluids............................... 276
Fog Lights.........................101,134
Folding Rear Seat....................... 93
Freeing A Stuck Vehicle.................. 232
Fuel................................. 214
Adding............................. 218
Additives........................... 216
INDEX 307
10