maintenance schedule CHRYSLER 300 SRT 2005 1.G User Guide

EMISSION CONTROL SYSTEM MAINTENANCE
The “Scheduled” maintenance services, listed inbold
typemust be done at the times or mileages specified to
assure the continued proper functioning of the emission
control system. These, and all other maintenance services
included in this manual, should be done to provide best
vehicle performance and reliability. More frequent main-
tenance may be needed for vehicles in severe operating
conditions such as dusty areas and very short trip
driving.
Inspection and service also should be done any time a
malfunction is suspected.
NOTE:Maintenance, replacement, or repair of the
emission control devices and systems on your vehicle
may be performed by any automotive repair establish-
ment or individual using any automotive part which has
been certified pursuant to U.S. EPA or, in the State of
California, California Air Resources Board regulations.
MAINTENANCE SCHEDULES
There are two maintenance schedules that show the
requiredservice for your vehicle.
First is Schedule“B”. It is for vehicles that are operated
under the conditions that are listed below and at the
beginning of the schedule. Change the automatic trans-
mission fluid and filter every 60,000 miles (96 000 km) if
the vehicle is usually operated under one or more of the
conditions marked with an.
•Day or night temperatures are below 32° F (0° C).
•Stop and go driving.
•Extensive engine idling.
•Driving in dusty conditions.
•Short trips of less than 10 miles (16 km).
•More than 50% of your driving is at sustained high
speeds during hot weather, above 90° F (32° C).
•Trailer towing.
278 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

•Taxi, police, or delivery service (commercial ser-
vice).
•Off-road or desert operation.
NOTE:IfANYof these apply to you then change your
engine oil every 3,000 miles (5 000 km) or 3 months,
whichever comes first and follow schedule “B” of the
Maintenance Schedulessection of this manual.
NOTE:IFANYof these apply to you then flush and
replace the engine coolant every 102,000 miles (164,000
km) or 60 months, whichever comes first, and follow
schedule B of theMaintenance Schedulessection of this
manual.
NOTE:Most vehicles are operated under the conditions
listed for ScheduleB.
Second is Schedule“A”. It is for vehicles that are not
operated under any of the conditions listed under Sched-
uleB.
Use the schedule that best describes your driving condi-
tions. Where time and mileage are listed, follow the
interval that occurs first.
NOTE:Under no circumstances should oil change
intervals exceed 6000 miles (10 000 km) or 6 months
whichever comes first.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
At Each Stop for Fuel
•
Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
•Check the windshield washer solvent and add if
required.
MAINTENANCE SCHEDULES 279
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Once a Month
•
Check tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of coolant reservoir, brake
master cylinder, and transmission and add as needed.
•Check all lights and all other electrical items for correct
operation.
•Check rubber seals on each side of the radiator for
proper fit.
At Each Oil Change
•
Change the engine oil filter.
•Inspect the exhaust system.
•Inspect the brake hoses.
•Inspect the CV joints and front and rear suspension
components.
•Check the automatic transmission fluid level.
•Check the coolant level, hoses, and clamps.
280 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

SCHEDULE “B”
Follow schedule “B” if you usually operate your vehicle
under one or more of the following conditions. Change
the automatic transmission fluid and filter every 60,000
miles (96 000 km) if the vehicle is usually operated under
one or more of the conditions marked with an.
•Day or night temperatures are below 32° F (0° C).
•Stop and go driving.
•Extensive engine idling.
•Driving in dusty conditions.
•Short trips of less than 10 miles (16.2 km).
•More than 50% of your driving is at sustained high
speeds during hot weather, above 90° F (32° C).
•Trailer towing.
•Taxi, police or delivery service (commercial ser-
vices).
•Off-road or desert operation.
•If equipped for and operating with E-85 (ethanol)
fuel.
NOTE:IfANYof these apply to you then change your
engine oil every 3,000 miles (5 000 km) or 3 months,
whichever comes first and follow schedule “B” of the
Maintenance Schedulessection of this manual.
NOTE:IFANYof these apply to you then flush and
replace the engine coolant every 102,000 miles (164,000
km) or 60 months, whichever comes first, and follow
schedule B of theMaintenance Schedulessection of this
manual.
SCHEDULE “B” 281
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 93,000 96,000 99,000 100,000 102,000 105,000
(Kilometers) (155 000) (160 000) (165 000) (170 000) (175 000) (180 000)
Change engine oil and engine oil filter, if not re-
placed at 3 months.XXX X X
Inspect theair cleaner filter
and replace if re-
quired.*XXX
Inspect theair cleaner filter
and replace if re-
quired.X
Replace theair cleaner filter.X
Replace thespark plugs.X
Inspect the front and rear brake linings and rotors. X
Check and Inspect the accessory drive belt and ten-
sioner. Replace if required.X
Change the rear axle fluid. X
Replace the air conditioning filter.X
Flush and replace engine coolant at 102,000 miles if
not done at 60 months.X
Rotate the tires. X X
* This maintenance is recommended by the manufacture
to the owner but is not required to maintain the emis-
sions warranty.
‡ This maintenance is not required if previously replaced.Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
SCHEDULE “B” 287
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 78,000 84,000 90,000 96,000 100,000 102,000
(Kilometers) (130 000) (140 000) (150 000) (160 000) (170 000) (180 000)
[Months] [78] [84] [90] [96] [102]
Change engine oil and engine oil filter. X X X X X
Inspect theair cleaner filter
and replace if re-
quired.*XXXX
Replace theair cleaner filter.X
Replace thespark plugs.X
Inspect the front and rear brake linings and ro-
tors.X
Check and Inspect the accessory drive belt and
tensioner. Replace if required.X
Check and replace, if necessary, thePCV valve.
*‡
X
Flush and replace the engine coolant at 102,000
miles if not done at 60 months.X
Replace the air conditioning filter. X X
Rotate the tires. X X X X X
* This maintenance is recommended by the manufacturer
to the owner but is not required to maintain the emis-
sions warranty.
‡ This maintenance is not required if previously replaced.Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
290 SCHEDULE “A”
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Headlight Switch...................... 99
Headlights........................99,270
Headlights On With Wipers..........100,104
High Beam.......................... 101
High Beam Indicator................... 138
Illuminated Entry...................... 15
Instrument Cluster..................... 99
Interior.............................. 97
License............................. 274
Lights On Reminder................... 100
Malfunction Indicator.................. 139
Oil Pressure......................... 134
Reading............................ 114
Seat Belt Reminder.................... 138
Service..........................269,270
Service Engine Soon (Malfunction Indicator) . 139
Turn Signal........................99,101
Voltage............................. 139
Loading Vehicle.....................219,220
Capacities........................... 220
Tires ............................... 201
Locks
Door............................... 15Lower Anchors and Tether for CHildren
(LATCH).............................. 53
Lubrication, Body....................... 250
Lumbar Support........................ 88
Maintenance Free Battery................. 247
Maintenance Procedures.................. 241
Maintenance Schedule................... 278
ScheduleA......................... 288
ScheduleB......................... 281
Malfunction Indicator Light............139,239
Manual, Service........................ 299
Memory Feature........................ 89
Mini-Trip Computer..................... 142
Mirrors............................... 63
Automatic Dimming.................... 63
Electric Remote....................... 64
Exterior Folding....................... 64
Heated.............................. 65
Outside............................. 64
Vanity.............................. 65
Modifications/Alterations, Vehicle............ 7
Mopar Parts........................240,299
310 INDEX

Pregnant Women and Seat Belts............. 34
Pretensioners
Seat Belts............................ 33
Programmable Electronic Features..... 115,119,147
Programming Transmitters............. 115,119
Radial Ply Tires........................ 208
Radiator Cap (Coolant Pressure Cap)........ 254
Radio Broadcast Signals.................. 168
Radio Operation.....................151,171
Radio Remote Controls.................. 166
Radio, Satellite......................... 163
Radio (Sound Systems)................... 151
Rain Sensitive Wiper System.............. 103
Rear Park Assist System................... 85
Rear Seat, Folding....................... 93
Reclining Front Seats..................... 88
Recommended Fluids, Lubricants and Genuine
Parts............................... 276
Recorder, Event Data..................... 47
Recreational Towing..................... 222
Refrigerant............................ 249
Reminder, Seat Belt...................... 33Remote Keyless Entry.................... 19
Remote Sound System Controls............ 166
Remote Trunk Release.................... 26
Replacement Tires...................... 209
Reporting Safety Defects................. 299
Restraint, Head......................... 92
Restraints, Occupant..................... 28
Rocking Vehicle When Stuck.............. 232
Rotation, Tires......................... 212
Safety Checks Inside Vehicle............... 57
Safety Checks Outside Vehicle.............. 57
Safety Defects, Reporting................. 299
Safety Information, Tire.................. 197
Safety Tips............................. 56
Satellite Radio......................... 163
Satellite Radio Antenna.................. 165
Schedule, Maintenance................... 278
Seat Belt Maintenance................... 263
Seat Belt Reminder...................... 33
Seat Belts.............................. 29
Adjustable Upper Shoulder Anchorage...... 32
And Pregnant Women.................. 34
312 INDEX