cooling CHRYSLER 300 SRT 2006 1.G User Guide

Please note that it is the owner’s responsibility to main-
tain the proper level of protection against freezing ac-
cording to the temperatures occurring in the area where
the vehicle is operated.
NOTE:Mixing coolant types will decrease the life of the
engine coolant and will require more frequent coolant
changes.
Cooling System Pressure Cap
The cap must be fully tightened to prevent loss of
coolant, and to insure that coolant will return to the
radiator from the coolant recovery bottle.
The cap should be inspected and cleaned if there is any
accumulation of foreign material on the sealing surfaces.
WARNING!
•The warning words “DO NOT OPEN HOT” on
the cooling system pressure cap are a safety pre-
caution. Never add coolant when the engine is
overheated. Do not loosen or remove the cap to
cool an overheated engine. Heat causes pressure
to build up in the cooling system. To prevent
scalding or injury, do not remove the pressure cap
while the system is hot or under pressure.
•Do not use a pressure cap other than the one
specified for your vehicle. Personal injury or
engine damage may result.
Disposal of Used Engine Coolant
Used ethylene glycol based engine coolant is a regulated
substance requiring proper disposal. Check with your
local authorities to determine the disposal rules for your
community. To prevent ingestion by animals or children
do not store ethylene glycol based engine coolant in open
containers or allow it to remain in puddles on the
260 MAINTAINING YOUR VEHICLE

ground. If ingested by a child, contact a physician
immediately. Clean up any ground spills immediately.
Coolant Level
The coolant bottle provides a quick visual method for
determining that the coolant level is adequate. With the
engine off and cold, the level of the coolant in the bottle
should be between the ranges indicated on the bottle.
The radiator normally remains completely full, so there is
no need to remove the radiator cap unless checking for
coolant freeze point or replacing coolant. Advise your
service attendant of this. As long as the engine operating
temperature is satisfactory, the coolant bottle need only
be checked once a month.
When additional coolant is needed to maintain the
proper level, it should be added to the coolant bottle. Do
not overfill.
Points To Remember
NOTE:
When the vehicle is stopped after a few miles (a
few kilometers) of operation, you may observe vapor
coming from the front of the engine compartment. This is
normally a result of moisture from rain, snow, or highhumidity accumulating on the radiator and being vapor-
ized when the thermostat opens, allowing hot coolant to
enter the radiator.
If an examination of your engine compartment shows no
evidence of radiator or hose leaks, the vehicle may be
safely driven. The vapor will soon dissipate.
•Do not overfill the coolant recovery bottle.
•Check coolant freeze point in the radiator and in the
coolant recovery bottle. If antifreeze needs to be
added, contents of coolant recovery bottle must also be
protected against freezing.
•If frequent coolant additions are required, or if the
level in the coolant recovery bottle does not drop when
the engine cools, the cooling system should be pres-
sure tested for leaks.
•Maintain coolant concentration at 50% HOAT engine
coolant (minimum) and distilled water for proper
corrosion protection of your engine which contains
aluminum components.
MAINTAINING YOUR VEHICLE 261
7

License Lamp
1. Remove the screws securing the light to the rear fascia.
2. Remove the bulb and socket assembly and pull the
bulb from the socket.
3. Replace the bulb and reinstall the bulb and socket
assembly.
4. Reattach the light to the rear fascia.
FLUIDS AND CAPACITIES
U.S. Metric
Fuel (approximate)
6.1 Liter Engines (Premium 91
Octane)19 gal-
lons72 liters
Engine Oil-With Filter
6.1 Liter Engines (SAE 0W-40) 7 qts. 6.6 liters
Cooling System *
6.1 Liter Engines (Mopar
Antifreeze/Coolant 5 Year/
100,000 Mile Formula) or
equivalent.14.8 qts 14.0 li-
ters
* Includes heater and coolant recovery bottle filled to
MAX level.
MAINTAINING YOUR VEHICLE 281
7

Cooling System........................ 258
Adding Coolant (Antifreeze)............. 259
Coolant Capacity..................... 281
Coolant Level.....................258,261
Disposal of Used Coolant............... 260
Drain, Flush, and Refill................. 258
Inspection........................... 261
Points to Remember................... 261
Pressure Cap........................ 260
Radiator Cap........................ 260
Selection of Coolant (Antifreeze)....259,281,282
Cruise Control (Speed Control)............. 111
Cup Holder........................125,270
Customer Assistance.................... 300
Data Recorder, Event..................... 47
Dealer Service......................... 246
Defroster, Windshield..................57,177
Delay (Intermittent) Wipers............... 103
Diagnostic System, Onboard............... 244
Dimmer Switch, Headlight................ 101
Disposal
Antifreeze (Engine Coolant)............. 260Door Locks............................ 15
Door Locks, Automatic................... 17
Door Opener, Garage.................... 114
Drive Belts............................ 250
Driver’s Seat Glide Feature................ 92
Driving
On Slippery Surfaces.................. 237
DVD Player (Video Entertainment System).... 163
Electric Remote Mirrors................... 64
Electrical Power Outlets.................. 122
Electronic Speed Control.................. 111
Electronic Stability Program............... 109
Electronic Vehicle Information Center........ 140
Emergency, In Case of
Freeing Vehicle When Stuck............. 238
Hazard Warning Flasher................ 230
Jump Starting........................ 235
Overheating......................... 230
Towing............................. 239
Emission Control System Maintenance....245,284
Engine............................... 243
Air Cleaner.......................... 251
310 INDEX

Air Cleaner Filter..................... 251
Break-In Recommendations............... 56
Checking Oil Level.................... 247
Compartment........................ 243
Coolant (Antifreeze)................258,282
Cooling............................ 258
Exhaust Gas Caution................56,223
Fails to Start......................... 184
Fuel Requirements.................220,281
Oil ..........................247,281,282
Oil Change Interval................... 248
Oil Selection......................249,281
Overheating......................... 230
Temperature Gauge................... 137
Engine Oil Viscosity..................... 249
Engine Oil Viscosity Chart................ 249
Enhanced Accident Response Feature......... 46
Event Data Recorder..................... 47
Exhaust Gas Caution...............56,223,257
Exhaust System........................ 257
Exterior Folding Mirrors.................. 64Filters
Air Cleaner.......................... 251
Air Conditioning..................179,255
Engine Fuel......................... 251
Engine Oil.......................250,282
Engine Oil Disposal................... 250
Flashers
Hazard Warning...................... 230
Turn Signal.......................... 134
Flash-To-Pass.......................... 101
Floor Console.......................... 126
Fluid Capacities........................ 281
Fluid Leaks............................ 58
Fluid Level Checks
Brake.............................. 264
Cooling System....................... 258
Engine Oil.......................... 247
Power Steering....................... 255
Fluids............................... 282
Fluids, Lubricants and Genuine Parts........ 282
Fog Lights.........................100,134
Folding Rear Seat....................... 93
Freeing A Stuck Vehicle.................. 238
INDEX 311
10