fuel cap CHRYSLER 300 SRT 2009 1.G User Guide

MAINTAINING YOUR VEHICLE
CONTENTS
Engine Compartment — 6.1L............. 395
Onboard Diagnostic System — OBD II...... 396
▫Loose Fuel Filler Cap................. 397
Emissions Inspection And Maintenance
Programs............................ 397
Replacement Parts..................... 399
Dealer Service........................ 399
Maintenance Procedures................. 399
▫Engine Oil......................... 400▫Engine Oil Filter..................... 402
▫Engine Air Cleaner Filter............... 403
▫Maintenance-Free Battery.............. 404
▫Air Conditioner Maintenance............ 405
▫A/C Air Filter...................... 406
▫Body Lubrication.................... 407
▫Windshield Wiper Blades............... 407
▫Windshield Washers.................. 408
▫Exhaust System..................... 408
7

Loose Fuel Filler Cap
If the vehicle diagnostic system determines that the fuel
filler cap is loose, improperly installed, or damaged, a
“Check Gascap” message will display in the Electronic
Vehicle Information Center (EVIC) (if equipped). If this
occurs, tighten the fuel filler cap properly and press the
TRIP ODOMETER button to turn off the message. If the
problem continues, the message will appear the next time
the vehicle is started.
A loose, improperly installed, or damaged fuel filler cap
may also turn on the MIL.
EMISSIONS INSPECTION AND MAINTENANCE
PROGRAMS
In some localities, it may be a legal requirement to pass
an inspection of your vehicle’s emissions control system.
Failure to pass could prevent vehicle registration.For states that require an Inspection and Mainte-
nance (I/M), this check verifies the Malfunction
Indicator Light (MIL) is functioning and is not on
when the engine is running, and that the OBD II system
is ready for testing.
Normally, the OBD II system will be ready. The OBD II
system maynotbe ready if your vehicle was recently
serviced, recently had a dead battery, or a battery replace-
ment. If the OBD II system should be determined not
ready for the I/M test, your vehicle may fail the test.
Your vehicle has a simple ignition key-actuated test,
which you can use prior to going to the test station. To
check if your vehicle’s OBD II system is ready, you must
do the following:
1. Insert your ignition key into the ignition switch.
2. Turn the ignition to the ON position, but do not crank
or start the engine.
MAINTAINING YOUR VEHICLE 397
7

FLUIDS AND CAPACITIES
U.S. Metric
Fuel (Approximate)19 Gallons 72 Liters
Engine Oil with Filter
6.1 Liter Engine (SAE 0W-40) 7 Quarts 6.6 Liters
Cooling System *
6.1 Liter Engine (MOPARAntifreeze/Coolant 5 Year/100,000 Mile
Formula) or equivalent15.2 Quarts 14.4 Liters
* Includes heater and coolant recovery bottle filled to MAX level.
438 MAINTAINING YOUR VEHICLE

Brake/Transmission Interlock............... 315
Break-In Recommendations, New Vehicle........ 75
Brightness, Interior Lights.................. 141
Bulb Replacement.....................432,433
Bulbs, Light..........................78,432
Calibration, Compass..................... 227
Capacities, Fluid........................ 438
Caps, Filler
Fuel................................ 371
Oil (Engine).......................... 401
Power Steering........................ 326
Radiator (Coolant Pressure)............... 414
Car Washes............................ 420
Carbon Monoxide Warning...............76,370
Cargo (Vehicle Loading)................... 373
Cellular Phone........................88,293
Certification Label....................... 373
Chains, Tire............................ 353Chart, Tire Sizing........................ 340
Check Engine Light
(Malfunction Indicator Light)............... 397
Checking Your Vehicle For Safety............. 76
Checks, Safety........................... 76
Child Restraint..................66,67,68,70,72
Child Restraint Tether Anchors.............69,70
Child Safety Locks........................ 33
Clean Air Gasoline....................... 367
Cleaning
Wheels............................. 421
Windshield Wiper Blades................. 407
Climate Control......................... 293
Clock.....................235,237,252,256,265
Coin Holder........................... 194
Compact Disc (CD) Maintenance............. 292
Compass.............................. 226
Compass Calibration..................... 227
Compass Variance....................... 227
472 INDEX

Compartment......................... 395
Coolant (Antifreeze)................. 411,439
Cooling............................. 411
Exhaust Gas Caution..................76,370
Fails to Start.......................... 311
Flooded, Starting...................... 311
Fuel Requirements..................... 367
Jump Starting......................... 385
Oil ...........................400,438,439
Oil Change Interval.................... 400
Oil Filler Cap......................... 401
Oil Filter............................ 402
Oil Filter Disposal...................... 402
Oil Selection.......................400,438
Oil Synthetic......................... 402
Overheating.......................... 379
Starting............................. 307
Temperature Gauge..................... 209
Engine Oil Viscosity...................... 401Enhanced Accident Response Feature.......... 62
Entry System, Illuminated.................. 20
Ethanol............................... 367
Event Data Recorder...................... 64
Exhaust Gas Caution................76,370,409
Exhaust System.......................76,408
Exterior Folding Mirrors................... 85
Exterior Lighting........................ 134
Exterior Lights.......................... 78
Filler Location Fuel...................... 371
Filters
Air Cleaner.......................... 403
Air Conditioning....................300,406
Engine Oil........................402,439
Engine Oil Disposal.................... 402
Flashers
Hazard Warning....................... 378
Turn Signal......................78,139,205
INDEX 475
10

Flash-To-Pass........................... 139
Flooded Engine Starting................... 311
Floor Console.......................... 194
Fluid, Brake........................... 440
Fluid Capacities......................... 438
Fluid Leaks............................. 78
Fluid Level Checks
Automatic Transmission................. 418
Brake............................... 417
Cooling System....................... 411
Engine Oil........................... 400
Power Steering........................ 326
Fluids................................ 439
Fluids, Lubricants and Genuine Parts.......... 439
Fog Lights..........................138,205
Folding Rear Seat........................ 127
Freeing A Stuck Vehicle................... 389
Fuel................................. 367
Adding............................. 371Additives............................ 369
Clean Air............................ 367
Ethanol............................. 367
Filler Cap (Gas Cap).................... 371
Gasoline............................ 367
Gauge.............................. 211
Materials Added....................... 369
Methanol............................ 367
Octane Rating......................367,439
Requirements......................... 367
Specifications......................... 439
Tank Capacity........................ 438
Fuel System Caution..................... 371
Fueling............................... 371
Fuses................................ 424
Garage Door Opener (HomeLink) ........... 181
Gas Cap (Fuel Filler Cap)...............371,397
Gasoline, Clean Air...................... 367
476 INDEX

Memory Feature (Memory Seat)............. 128
Memory Seat........................... 128
Memory Seats and Radio.................. 128
Methanol............................. 367
Mini-Trip Computer...................... 220
Mirrors................................ 84
Automatic Dimming..................... 84
Electric Powered....................... 86
Electric Remote........................ 86
Exterior Folding........................ 85
Heated.............................. 87
Outside.............................. 85
Vanity............................... 87
Modifications/Alterations, Vehicle............. 7
Monitor, Tire Pressure System............... 356
Mopar Parts.........................399,464
MTBE/ETBE........................... 367
Multi-Function Control Lever............... 138New Vehicle Break-In Period................ 75
Occupant Restraints....................... 41
Octane Rating, Gasoline (Fuel)............367,439
Odometer............................. 210
Trip ................................ 210
Oil, Engine.........................400,439
Capacity............................ 438
Change Interval....................... 400
Checking............................ 400
Dipstick............................. 400
Disposal............................ 402
Filter............................402,439
Filter Disposal........................ 402
Materials Added to..................... 402
Recommendation...................400,438
Synthetic............................ 402
Viscosity..........................401,438
Oil Filter, Change........................ 402
INDEX 481
10