engine coolant CHRYSLER 300 SRT 2010 1.G User Guide

Disposal of Used Coolant
Used ethylene glycol-based engine coolant (antifreeze) is
a regulated substance requiring proper disposal. Check
with your local authorities to determine the disposal
rules for your community. To prevent ingestion by ani-
mals or children, do not store ethylene glycol-based
engine coolant (antifreeze) in open containers or allow it
to remain in puddles on the ground. If ingested by a child
or pet, seek emergency assistance immediately. Clean up
any ground spills immediately.
Coolant Level
The coolant bottle provides a quick visual method for
determining that the engine coolant (antifreeze) level is
adequate. With the engine OFF and cold, the level of the
engine coolant (antifreeze) in the bottle should be be-
tween the ranges indicated on the bottle.
The radiator normally remains completely full, so there is
no need to remove the radiator cap unless checking forengine coolant (antifreeze) freeze point or replacing en-
gine coolant (antifreeze). Advise your service attendant
of this. As long as the engine operating temperature is
satisfactory, the coolant bottle need only be checked once
a month.
When additional engine coolant (antifreeze) is needed to
maintain the proper level, it should be added to the
coolant bottle. Do not overfill.
Points to Remember
NOTE:
When the vehicle is stopped after a few miles
(kilometers) of operation, you may observe vapor coming
from the front of the engine compartment. This is nor-
mally a result of moisture from rain, snow, or high
humidity accumulating on the radiator and being vapor-
ized when the thermostat opens, allowing hot engine
coolant (antifreeze) to enter the radiator.
386 MAINTAINING YOUR VEHICLE

If an examination of your engine compartment shows no
evidence of radiator or hose leaks, the vehicle may be
safely driven. The vapor will soon dissipate.
•Do not overfill the coolant recovery bottle.
•Check engine coolant (antifreeze) freeze point in the
radiator and in the coolant recovery bottle. If engine
coolant (antifreeze) needs to be added, contents of
coolant recovery bottle must also be protected against
freezing.
•If frequent engine coolant (antifreeze) additions are
required, or if the level in the coolant recovery bottle
does not drop when the engine cools, the cooling
system should be pressure tested for leaks.
•Maintain engine coolant (antifreeze) concentration at
50% HOAT engine coolant (antifreeze) (minimum)
and distilled water for proper corrosion protection of
your engine, which contains aluminum components.
•Make sure that the radiator and coolant recovery
bottle overflow hoses are not kinked or obstructed.
•Keep the front of the radiator clean. If your vehicle is
equipped with air conditioning, keep the front of the
condenser clean.
•Do not change the thermostat for Summer or Winter
operation. If replacement is ever necessary, install
ONLY the correct type thermostat. Other designs may
result in unsatisfactory engine coolant (antifreeze)
performance, poor gas mileage, and increased
emissions.
Brake System
In order to assure brake system performance, all brake
system components should be inspected periodically.
Refer to “Maintenance Schedule” for further information.7
MAINTAINING YOUR VEHICLE 387

FLUID CAPACITIES
U.S.Metric
Fuel (Approximate) 19 Gallons72 Liters
Engine Oil with Filter
6.1 Liter Engine (SAE 5W-40, API Certified) 7 Quarts6.6 Liters
Cooling System *
6.1 Liter Engine (MOPAR Antifreeze/Coolant 5 Year/100,000 Mile
Formula or equivalent) 15.2 Quarts 14.4 Liters
* Includes heater and coolant recovery bottle filled to MAX level.
412 MAINTAINING YOUR VEHICLE

FLUIDS, LUBRICANTS, AND GENUINE PARTS
Engine
ComponentFluid, Lubricant, or Genuine Part
Engine Coolant MOPARAntifreeze/Coolant 5 Year/100,000 Mile Formula HOAT (Hy-
brid Organic Additive Technology) or equivalent.
Engine Oil For best performance and maximum protection under all types of operat-
ing conditions, the manufacturer only recommends full synthetic engine
oils that meet the requirements of Chrysler Material Standard MS-10725
and are approved to MB 229.3 or MB 229.5. The manufacturer recom-
mends the use of a full synthetic 5W-40 or equivalent engine oil.
Engine Oil Filter MOPAREngine Oil Filter or equivalent.
Spark Plugs PLZTR5A-13 (Gap 0.040 in [1.01 mm])
Fuel Selection Premium Unleaded 91 Octane Only or higher.
7
MAINTAINING YOUR VEHICLE 413

•Check the fluid levels of the coolant reservoir, brake
master cylinder, and power steering, add as needed.
•Check all lights and other electrical items for correct
operation.
At Each Oil Change
•Change the engine oil filter.
•Inspect the brake hoses and lines.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
Required Maintenance Intervals
Refer to the Maintenance Schedules on the following
pages for the required maintenance intervals.
8
M A I
N T
E
N A
N CE
S
C
H E
D
U L
E
S418 MAINTENANCE SCHEDULES

54,000 Miles (90,000 km) or
54 Months Maintenance
Service Schedule
❏Change the engine oil and engine oil
filter.
❏ Rotate tires.
❏ Inspect the rear axle fluid.
Odometer Reading Date
Repair Order #Dealer Code
Signature Authorized Chrysler Dealer
60,000 Miles (100,000 km) or 60 Months Maintenance Service
Schedule
❏Change the engine oil and engine oil filter.
❏ Rotate tires.
❏ Replace the engine air cleaner filter.
❏ Replace the air conditioning filter.
❏ Inspect the brake linings, and replace if necessary.
❏ Adjust parking brake on vehicles equipped with four-wheel disc brakes.
❏ Inspect the CV joints.
❏ Inspect the exhaust system.
❏ Change the automatic transmission fluid and filter if using your vehicle for any of the
following: police, taxi, fleet, or frequent trailer towing.
❏ Flush and replace the engine coolant at 60 months if not done at 102,000 miles
(170 000 km).
❏ Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for
damage, wear, improper looseness or end play; replace if necessary.
Odometer Reading Date
Repair Order #Dealer Code
Signature Authorized Chrysler Dealer
8
M
A I
N T
E
N A
N CE
S
C
H E
D
U L
E
SMAINTENANCE SCHEDULES 423

102,000 Miles (170,000 km) or
102 Months Maintenance
Service Schedule
❏Change the engine oil and engine oil
filter.
❏ Rotate tires.
❏ Replace the spark plugs.
❏ Flush and replace the engine coolant if
not done at 60 months.
Odometer Reading Date
Repair Order #Dealer Code
Signature Authorized Chrysler Dealer
108,000 Miles (180,000 km) or 108 Months Maintenance Service
Schedule
❏Change the engine oil and engine oil filter.
❏ Rotate tires.
❏ If you are using your vehicle in dusty or off-road conditions, inspect the engine air cleaner
filter, and replace if necessary.
❏ Replace the air conditioning filter.
❏ Inspect the brake linings, and replace if necessary.
❏ Inspect the CV joints.
❏ Inspect the exhaust system.
❏ Inspect the rear axle fluid.
❏ Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for
damage, wear, improper looseness or end play; replace if necessary.
Odometer Reading Date
Repair Order #Dealer Code
Signature Authorized Chrysler Dealer
8
M
A I
N T
E
N A
N CE
S
C
H E
D
U L
E
SMAINTENANCE SCHEDULES 427

About Your Brakes.................... 295,297
ABS (Anti-Lock Brake System) ............298,301
Adding Engine Coolant (Antifreeze) .......... 384
Adding Fuel ........................... 337
Adding Washer Fluid ..................... 379
Additives, Fuel ......................... 335
Adjustable Pedals ....................... 153
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . 372
Air Conditioner Maintenance ............... 375
Air Conditioning Filter .................269,376
Air Conditioning, Operating Tips ............ 270
Air Conditioning Refrigerant .............375,376
Air Conditioning System ................263,375
Air Pressure, Tires ....................... 318
Airbag .............................. 53,62
Airbag Deployment ....................... 64
Airbag Light ..................... 61,66,81,191
Airbag Maintenance ....................... 65
Airbag, Side .......................... 60,62Airbag, Window (Side Curtain)
...........56,60,62
Alarm, Panic ............................ 22
Alarm (Security Alarm) .................17,195
Alarm System (Security Alarm) ............... 17
Alterations/Modifications, Vehicle ............. 7
Antenna, Satellite Radio ................... 253
Antifreeze (Engine Coolant) ..............383,412
Disposal ............................ 386
Anti-Lock Brake System (ABS) ............298,301
Anti-Lock Warning Light ...............190,300
Anti-Theft Security Alarm (Theft Alarm) ........ 17
Anti-Theft System ....................... 195
Appearance Care ........................ 392
Arming Theft System (Security Alarm) ......... 17
Assistance Towing ....................... 108
Auto Down Power Windows ................ 38
Auto Unlock, Doors ....................... 30
Auto Up Power Windows .................. 38
Automatic Dimming Mirror ................. 90
444 INDEX

Brightness, Interior Lights.................. 147
Bulb Replacement ..................... 406,407
Bulbs, Light .......................... 83,406
Calibration, Compass ..................... 213
Capacities, Fluid ........................ 412
Caps, Filler Fuel ............................... 337
Oil (Engine) .......................... 371
Power Steering ........................ 294
Radiator (Coolant Pressure) ............... 385
Car Washes ............................ 393
Carbon Monoxide Warning ...............80,337
Cargo (Vehicle Loading) ................... 340
Cellular Phone ........................ 93,263
Certification Label ....................... 340
Chart, Tire Sizing ........................ 309
Check Engine Light
(Malfunction Indicator Light) ............... 367Checking Your Vehicle For Safety
............. 79
Checks, Safety ........................... 79
Child Restraint .................. 69,70,71,74,76
Child Restraint Tether Anchors .............73,74
Child Safety Locks ........................ 34
Clean Air Gasoline ....................... 333
Cleaning Wheels ............................. 394
Windshield Wiper Blades ................ 378
Climate Control ......................... 263
Clock ..................... 221,222,224,227,236
Coin Holder ........................... 178
Cold Weather Operation ................... 278
Compact Disc (CD) Maintenance ............. 262
Compass .............................. 213
Compass Calibration ..................... 213
Compass Variance ....................... 214
Computer, Trip/Travel .................... 206
446 INDEX

ConnectorUCI ................................ 247
Universal Consumer Interface (UCI) ......... 247
Console, Floor .......................... 178
Console, Overhead ....................... 163
Contract, Service ........................ 437
Coolant Pressure Cap (Radiator Cap) .......... 385
Cooling System ......................... 382
Adding Coolant (Antifreeze) .............. 384
Coolant Capacity ...................... 412
Coolant Level ...................... 382,386
Disposal of Used Coolant ................ 386
Drain, Flush, and Refill .................. 383
Inspection ........................... 386
Points to Remember .................... 386
Pressure Cap ......................... 385
Radiator Cap ......................... 385
Selection of Coolant (Antifreeze) ......383,412,413
Corrosion Protection ..................... 392 Cruise Control (Speed Control)
.............. 155
Cruise Light ........................... 189
Cupholders ......................... 177,397
Customer Assistance ..................... 435
Customer Programmable Features ............ 216
Daytime Brightness, Interior Lights ........... 148
Daytime Running Lights ................... 144
Dealer Service .......................... 368
Deck Lid, Emergency Release ................ 42
Deck Lid, Power Release ................... 40
Defroster, Rear Window ................... 181
Defroster, Windshield ................... 81,267
Delay (Intermittent) Wipers ................. 149
Diagnostic System, Onboard ................ 366
Dimmer Switch, Headlight ................. 146
Dipsticks Oil (Engine) .......................... 370
Power Steering ........................ 294
10
INDEX 447