brakes CHRYSLER ASPEN 2007 2.G User Guide

CAUTION!
•Avoid towing a trailer for the first 500 miles (805
km) of vehicle operation. Doing so may damage
your vehicle.
•During the first 500 miles (805 km) of trailer
towing, limit your speed to 50 mph (80 km/h).
Perform the maintenance listed in Section 8 of this
manual. When towing a trailer, never exceed the GAWR,
or GCWR, ratings.
WARNING!
Improper towing can lead to an injury accident.
Follow these guidelines to make your trailer towing
as safe as possible:
Make certain that the load is secured in the trailer
and will not shift during travel. When trailering
cargo that is not fully secured, dynamic load shifts
can occur that may be difficult for the driver to
control. You could lose control of your vehicle and
have an accident.
•When hauling cargo or towing a trailer, do not over-
load your vehicle or trailer. Overloading can cause a
loss of control, poor performance or damage to brakes,
axle, engine, transmission, steering, suspension, chas-
sis structure or tires.
332 STARTING AND OPERATING

Check for signs of tire wear or visible tire damage
before towing a trailer. Refer to the Tires–General
Information section of this manual on Tread Wear
Indicators for the proper inspection procedure.
When replacing tires refer to the Tires–General Infor-
mation section of this manual on Replacement Tires for
proper tire replacement procedures. Replacing tires
with a higher load carrying capacity will not increase
the vehicle’s GVWR and GAWR limits.
Towing Requirements — Trailer Brakes

Donotinterconnect the hydraulic brake system or
vacuum system of your vehicle with that of the trailer.
This could cause inadequate braking and possible
personal injury.
An electronically actuated trailer brake controller is
required when towing a trailer with electronicallyactuated brakes. When towing a trailer equipped with
a hydraulic surge actuated brake system, an electronic
brake controller is not required.
Trailer brakes are recommended for trailers over 1,000
lbs (454 kg) and required for trailers in excess of 2,000
lbs (907 kg).
CAUTION!
If the trailer weighs more than 1,000 lbs (454 kg)
loaded, it should have its own brakes and they
should be of adequate capacity. Failure to do this
could lead to accelerated brake lining wear, higher
brake pedal effort, and longer stopping distances.
334 STARTING AND OPERATING

WARNING!
Do not connect trailer brakes to your vehicle’s hy-
draulic brake lines. It can overload your brake sys-
tem and cause it to fail. You might not have brakes
when you need them and could have an accident.
Towing any trailer will increase your stopping dis-
tance. When towing you should allow for additional
space between your vehicle and the vehicle in front
of you. Failure to do so could result in an accident.
Towing Requirements — Trailer Lights & Wiring
Whenever you pull a trailer, regardless of the trailer size,
stop lights and turn signals on the trailer are required for
motoring safety.
The Trailer Tow Package may includea4and7pin
wiring harness. Use a factory approved trailer harness
and connector.NOTE:Do not cut or splice wiring into the vehicles
wiring harness.
The electrical connections are all complete to the vehicle
but you must mate the harness to a trailer connector.
Refer to the following illustrations.
4 - Pin Connector
STARTING AND OPERATING 335
5

Positive Crankcase Ventilation (PCV) Valve
Proper operation of the crankcase ventilation system
requires that the PCV valve be free of sticking or plug-
ging because of deposits. Deposits can accumulate in the
PCV valve and passage with increasing mileage. Have
the PCV valve, hoses, and passages checked for proper
operation at the intervals specified. If the valve is
plugged or sticking, replace with a new valve –Do not
attempt to clean the PCV valve!Check ventilating hose
for indication of damage or plugging with deposits.
Replace if necessary.
Brake System
Power Disc Brakes (Front and Rear)
Disc brakes do not require adjustment; however, several
hard stops during the break-in period are recommended
to seat the linings and wear off any foreign material.
Brake Master Cylinders
The fluid level in the master cylinders should be checked
whenever the vehicle is serviced, or immediately if the
brake system warning light is on. If necessary, add fluid
to bring level to the full mark on the side of the reservoir
of the brake master cylinder. Be sure to clean the top of
the master cylinder area before removing the cap. With
disc brakes, fluid level can be expected to fall as the brake
pads wear. Brake fluid level should be checked when
pads are replaced. If the brake fluid level is abnormally
low, check system for leaks.
Refer to Fluids, Lubricants and Genuine Parts for correct
fluid type.
MAINTAINING YOUR VEHICLE 387
7

Axle Lubrication (Axle Fluid)............... 392
Ball Joints............................. 377
Battery..........................362,363,375
Charging............................ 354
Emergency Starting..................... 354
Gas Caution.......................... 354
Keyless Transmitter Replacement (RKE)....... 24
Saving Feature (Protection)............... 132
Belts, Drive............................ 372
Belts, Seat.............................. 39
Body Mechanism Lubrication............... 378
B-Pillar Location........................ 293
Brake Assist System...................... 280
Brake Control System, Electronic............. 279
Brake Fluid............................ 416
Brake System........................275,387
Anti-Lock (ABS)....................275,279
Disc Brakes.......................... 387Fluid Check.......................... 387
Hoses.............................. 388
Master Cylinder....................... 387
Parking............................. 273
Warning Light.....................190,193
Brakes............................... 275
Brake/Transmission Interlock............... 258
Break-In Recommendations, New Vehicle........ 71
Bulb Replacement....................... 407
Bulbs, Light............................ 407
Calibration, Compass..................... 158
Capacities, Fluid........................ 414
Caps, Filler
Fuel................................ 316
Oil (Engine).......................... 370
Power Steering........................ 377
Radiator (Coolant Pressure)............... 383
Car Washes............................ 393
INDEX 451
10

Pressure Cap......................... 383
Radiator Cap......................... 383
Selection of Coolant (Antifreeze)......382,414,415
Temperature Gauge..................... 187
Cruise Control (Speed Control).............. 142
Cup Holder............................ 173
Customer Assistance..................... 442
Data Recorder, Event...................... 60
Daytime Running Lights................... 134
Dealer Service.......................... 367
Defroster, Rear Window................... 250
Defroster, Windshield..........73,235,236,241,242
Delay (Intermittent) Wipers................. 138
Diagnostic System, Onboard................ 364
Dimmer Switch, Headlight................. 188
Dipsticks
Automatic Transmission................. 389
Oil (Engine).......................... 368Power Steering........................ 377
Disarming, Theft System................... 18
Disc Brakes............................ 387
Disposal
Antifreeze (Engine Coolant)............... 384
Door Locks............................. 27
Door Opener, Garage..................... 160
Drive Belts............................ 372
Drive Shaft Universal Joints................ 378
DVD Player (Video Entertainment System)...... 226
E-85 Fuel............................. 318
Electric Remote Mirrors.................... 81
Electrical Power Outlets................... 169
Electronic Brake Control System............. 279
Electronic Speed Control (Cruise Control)...... 142
Electronic Stability Program (ESP).........193,283
Electronic Vehicle Information Center (EVIC).... 152
INDEX 453
10

Pets.................................. 71
Pets, Transporting........................ 71
Phone, Cellular.......................... 83
Phone, Hands-Free (UConnect™)............. 83
Placard, Tire and Loading Information......... 293
Positive Crankcase Valve.................. 387
Power
Brakes.............................. 387
Distribution Center (Fuses)..........362,363,401
Door Locks.........................19,28
Lift Gate............................. 35
Mirrors.............................. 81
Outlet (Auxiliary Electrical Outlet).......169,170
Steering..........................277,377
Steering Filler Cap..................362,363
Sunroof............................. 167
Windows............................. 31
Power Steering Fluid..................... 416
Pregnant Women and Seat Belts.............. 50Preparation for Jacking.................... 350
Pretensioners
Seat Belts............................. 48
Programmable Electronic Features......155,162,165
Programming Transmitters
(Remote Keyless Entry)...............23,162,165
Radial Ply Tires......................... 300
Radiator Cap (Coolant Pressure Cap).......381,383
Radio Broadcast Signals................... 198
Radio, Navigation....................... 222
Radio Operation...................200,208,232
Radio, Satellite.......................222,226
Radio (Sound Systems).................200,208
Rear Axle (Differential).................... 392
Rear Cup Holder........................ 175
Rear Liftgate............................ 34
Rear Window Defroster................... 250
Rear Window Features.................... 249
INDEX 461
10