transmission CHRYSLER ASPEN 2007 2.G Service Manual

a minimum of two (2) minutes for the oil to fully drain
into the transmission before rechecking the fluid level.
NOTE:If it is necessary to check the transmissionbelow
the operating temperature, the fluid level should be
between the two “COLD” (lower) holes on the dipstick
with the fluid at approximately 70°F ( 21°C) (room
temperature). If the fluid level is correctly established at
room temperature, it should be between the “HOT”
(upper) reference holes when the transmission reaches
180°F ( 82°C). Remember it is best to check the level at the
normal operating temperature.
CAUTION!
Be aware that if the fluid temperature is below 50°F
(10°C) it may not register on the dipstick. Do not add
fluid until the temperature is elevated enough to
produce an accurate reading.
7. Check for leaks. Release parking brake.
To prevent dirt and water from entering the transmission
after checking or replenishing fluid, make certain that the
dipstick cap is properly reseated. It is normal for the
dipstick cap to spring back slightly from its fully seated
position, as long as its seal remains engaged in the
dipstick tube.
Automatic Transmission Fluid And Filter Change
It is important that proper lubricant is used in the
transmission. Refer to Fluids, Lubricants and Genuine
Parts for correct fluid type. It is important that the
transmission fluid be maintained at the prescribed level
using the recommended fluid.
390 MAINTAINING YOUR VEHICLE

CAUTION!
Using a transmission fluid other than the manufac-
turers recommended fluid may cause deterioration
in transmission shift quality and/or torque converter
shudder. Using a transmission fluid other than the
manufacturers recommended fluid will result in
more frequent fluid and filter changes. Refer to
Fluids, Lubricants and Genuine Parts for correct
fluid type.
Special Additives
The manufacturer strongly recommends against the ad-
dition of any additives to the transmission. Exception to
this policy is the use of special dyes to aid in detecting
fluid leaks. The use of transmission sealers should be
avoided, since they may adversely affect seals.
Transfer Case
Inspect the transfer case for fluid leaks. If a fluid leak is
evident the transfer case fluid level may be low. Have the
transfer case serviced immediately.
CAUTION!
Damage may result from operation of the vehicle
with low transfer case fluid.
The transfer case fluid should be drained and refilled at
the intervals specified.
Lubricant Selection
Refer to Fluids, Lubricants and Genuine Parts for correct
fluid type.
MAINTAINING YOUR VEHICLE 391
7

Chassis
Component Fluids, Lubricants and Genuine Parts.
Automatic Transmission MoparATF+4, Automatic Transmission Fluid.
Transfer Case MoparATF+4, Automatic Transmission Fluid.
Front Axle SAE 75W-90 Multipurpose Type, GL-5 Gear Lubricant or equivalent.
Rear Axle SAE 75W-140 Synthetic Gear Lubricant or equivalent.
Brake Master Cylinder MoparDOT 3 and SAE J1703 should be used or equivalent. If DOT 3
brake fluid is not available, then DOT 4 is acceptable. Use only recom-
mended brake fluids.
Power Steering Reservoir MoparATF+4, Automatic Transmission Fluid.
416 MAINTAINING YOUR VEHICLE

At Each Stop for Fuel
•Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
•Check the windshield washer solvent and add if
required.
Once a Month
•Check tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of coolant reservoir, brake
master cylinder, and transmission and add as needed.
•Check all lights and all other electrical items for correct
operation.At Each Oil Change
•Change the engine oil filter.
•Inspect the exhaust system.
•Inspect the brake hoses.
•Inspect the CV joints (if equipped) and front suspen-
sion components.
•Check the automatic transmission fluid level.
•Check the coolant level, hoses, and clamps.
420 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 48,000 51,000 54,000 57,000 60,000
(Kilometers) (80 000) (85 000) (90 000) (95 000) (100 000)
Change engine oil and engine oil filter, or at 3 months
whichever comes first.X X XXX
Rotate tires. X X X
Check spare tire for proper pressure and correct stowage. X X X
Change front and rear axle fluid (4X4). X
Inspect brake linings. X
Inspect engine air cleaner filter, replace if necessary.X
Replace spark plugs.X
Inspect PCV valve, replace as necessary.**X
Inspect auto tension drive belt and replace if required. X
Drain and refill automatic transmission fluid and change
main sump filter. This applies only if your vehicle is used
for police, taxi, fleet, or frequent trailer towing.X
Inspect transfer case fluid (4X4).X
Flush and replace engine coolant at 60 months, or 102,
000 miles (170 000 km) whichever comes first.X
SCHEDULE “B” 425
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 105,000 108,000 111,000 114,000 117,000 120,000
(Kilometers) (175 000) (180 000) (185 000) (190 000) (195 000) (200 000)
Drain and refill automatic transmission fluid
and change main sump filter and spin-on
cooler return filter if equipped. This applies
only if your vehicle is used for police, taxi,
fleet, or frequent trailer towing.X
Flush and replace engine coolant at 120
months, if not replaced at 102,000 miles
(170 000 km).X
430 SCHEDULE “B”
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 141,000 144,000 147,000 150,000
(Kilometers) (235 000) (240 000) (245 000) (250 000)
Drain and refill automatic transmission fluid and change
main sump filter and spin-on cooler return filter if
equipped. This applies only if your vehicle is used for
police, taxi, fleet, or frequent trailer towing.X
Flush and replace engine coolant if not replaced at
120,000 miles (200 000 km).X
Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.** This maintenance is recommended by the manufac-
turer to the owner, but not required to maintain the
emissions warranty.
SCHEDULE “B” 433
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

ABS (Anti-Lock Brake System)............190,275
Adding Fuel........................... 316
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . 373
Air Conditioner Maintenance............233,376
Air Conditioning........................ 233
Air Conditioning, Operating Tips............ 246
Air Conditioning, Rear Zone................ 237
Air Conditioning Refrigerant.............376,377
Air Conditioning System................233,376
Air Filter........................362,363,373
Air Pressure, Tires....................298,306
Airbag.............................51,196
Airbag Light..........................59,73
Alarm, Panic............................ 22
Alarm (Security Alarm).................17,190
Alignment and Balance................... 305
Alterations/Modifications, Vehicle............. 8
Antenna, Satellite Radio................... 229
Antifreeze (Engine Coolant)...........382,383,414Disposal............................ 384
Anti-Lock Brake System (ABS)............275,279
Anti-Lock Warning Light.................. 190
Anti-Theft System.....................17,190
Appearance Care........................ 393
Arming Theft System (Security Alarm)......... 18
Automatic Dimming Mirror...............80,83
Automatic Door Locks..................... 28
Automatic Headlights.................... 133
Automatic Transaxle....................12,258
Automatic Transmission.............255,258,389
Adding Fluid......................... 389
Fluid and Filter Changes................. 390
Fluid Level Check...................... 389
Fluid Type........................390,416
Gear Ranges.......................... 258
Special Additives...................... 391
Torque Converter...................... 262
Axle Fluid............................. 416
450 INDEX

Axle Lubrication (Axle Fluid)............... 392
Ball Joints............................. 377
Battery..........................362,363,375
Charging............................ 354
Emergency Starting..................... 354
Gas Caution.......................... 354
Keyless Transmitter Replacement (RKE)....... 24
Saving Feature (Protection)............... 132
Belts, Drive............................ 372
Belts, Seat.............................. 39
Body Mechanism Lubrication............... 378
B-Pillar Location........................ 293
Brake Assist System...................... 280
Brake Control System, Electronic............. 279
Brake Fluid............................ 416
Brake System........................275,387
Anti-Lock (ABS)....................275,279
Disc Brakes.......................... 387Fluid Check.......................... 387
Hoses.............................. 388
Master Cylinder....................... 387
Parking............................. 273
Warning Light.....................190,193
Brakes............................... 275
Brake/Transmission Interlock............... 258
Break-In Recommendations, New Vehicle........ 71
Bulb Replacement....................... 407
Bulbs, Light............................ 407
Calibration, Compass..................... 158
Capacities, Fluid........................ 414
Caps, Filler
Fuel................................ 316
Oil (Engine).......................... 370
Power Steering........................ 377
Radiator (Coolant Pressure)............... 383
Car Washes............................ 393
INDEX 451
10

Pressure Cap......................... 383
Radiator Cap......................... 383
Selection of Coolant (Antifreeze)......382,414,415
Temperature Gauge..................... 187
Cruise Control (Speed Control).............. 142
Cup Holder............................ 173
Customer Assistance..................... 442
Data Recorder, Event...................... 60
Daytime Running Lights................... 134
Dealer Service.......................... 367
Defroster, Rear Window................... 250
Defroster, Windshield..........73,235,236,241,242
Delay (Intermittent) Wipers................. 138
Diagnostic System, Onboard................ 364
Dimmer Switch, Headlight................. 188
Dipsticks
Automatic Transmission................. 389
Oil (Engine).......................... 368Power Steering........................ 377
Disarming, Theft System................... 18
Disc Brakes............................ 387
Disposal
Antifreeze (Engine Coolant)............... 384
Door Locks............................. 27
Door Opener, Garage..................... 160
Drive Belts............................ 372
Drive Shaft Universal Joints................ 378
DVD Player (Video Entertainment System)...... 226
E-85 Fuel............................. 318
Electric Remote Mirrors.................... 81
Electrical Power Outlets................... 169
Electronic Brake Control System............. 279
Electronic Speed Control (Cruise Control)...... 142
Electronic Stability Program (ESP).........193,283
Electronic Vehicle Information Center (EVIC).... 152
INDEX 453
10