manual transmission CHRYSLER ASPEN HYBRID 2007 2.G Warranty Booklet

2007 Chrysler Aspen
8
5/100 POWERTR aiN W aRR aNTY
The following powertrain components are covered for 5 years or
100,000 kilometres, whichever occurs first, measured from the
vehicle’s original warranty start date.
Vehicles placed in police, taxi, limousine, postal or ambulance
service and all SRT vehicles , are excluded from the 5-year or
100,000-kilometre Powertrain Warranty and are covered only under
the 3-year or 60,000-kilometre Basic Warranty.
•
Engine – Cylinder block and all internal parts; cylinder head
assemblies; timing case, timing chain, timing belt, gears and
sprockets; vibration damper; oil pump; water pump and housing;
intake and exhaust manifolds; flywheel with starter ring gear; core
plugs; valve covers; oil pan; turbocharger housing and internal
parts; turbocharger wastegate actuator; supercharger; serpentine
belt tensioner; seals and gaskets for listed components only.
• Transmission – Transmission case and all internal parts;
torque converter; drive/flex plate; transmission range switch;
transmission control module; bell housing; oil pan; seals and
gaskets for listed components only.
Note: Manual transmission clutch parts are not covered at any time.
• Rear-Wheel Drive – Rear axle housing and all internal parts; axle
shafts; axle shaft bearings; driveshaft assemblies; driveshaft centre
bearings; universal joints and yokes; seals and gaskets for listed
components only.
• 4-Wheel Drive (4x4) – Transfer case and all internal parts;
transfer case control module and shift mode motor assembly;
axle housing and all internal parts; axle shafts; axle shaft bearings;
driveshaft assemblies (front and rear); driveshaft centre bearings;
universal joints and yokes; disconnect housing assembly; seals
and gaskets for the listed components.
5/100 POWERTRAIN WARRANTY

MAINTENANCE Scheduled maintenance must be completed to provide the best vehicle performance and reliability. The limited warranties in the warranty booklet DO NOT COVER repairs required due to improper maintenance. We strongly suggest you keep track of scheduled maintenance and keep receipts or other documents. Use only recommended Mopar lubricants and genuine Mopar parts. In the event that a condition arises between maintenance intervals, please contact your retailer. AVOID
P RO lONGED PERIODS Of I DlING .
NOTE:
WHERE TIME (MONTHS) AND METRAGE ARE INDICATED, FOLLOW THE INTERVAL THAT OCCURS FIRST.
AT EACH STOP FOR FUEL
•
Check the engine oil level about 5 minutes
after a fully warmed engine is shut off. Checking the oil level while the vehicle is on level ground will improve the accuracy of the oil level reading. Add oil only when the level is at or below the ADD or MIN mark.
•
Check the windshield washer solvent and
add if required.
ONCE A MONTH
•
Check the tire pressure and look for unusual
wear or damage.
•
Inspect the battery and clean and tighten the
terminals as required.
•
Check the fluid levels of coolant reservoir,
brake master cylinder and transmission and add as needed.
•
Check all the lights and all other electrical
items for correct operation.
•
Check and clean wiper blades. Replace if
required.
VISUA l INSPECTIONS –
INSPECT fOR SIGNS O f COMPONENT DETERIORATION
AND PHYSICA l DAMAGE.
There are two maintenance schedules contained in your Owner’s Manual. Schedule “B” best describes operating conditions in Canada and
is the recommended service schedule. for
your convenience, the scheduled maintenance intervals outlined in this booklet follow the Severe Service Schedule as described in your Owner’s Manual. Schedule “B” is for vehicles that are operated under one or more of the following conditions: day or night temperatures
below 0°C (32° f); stop-and-go driving; extensive
engine idling; driving in dusty conditions; short trips of less than 16 km (10 mi.); more than
50% of your driving is at sustained high speeds
during hot weather, above 32°C (90° f); trailer
towing; heavy loading; snowploughing; taxi, police, or delivery service (commercial service); off-road or desert driving; if equipped for and operating with E-85 (ethanol) fuel. Schedule “A” is for vehicles that are not operated under any of the conditions listed under Schedule “B.”The performance of all scheduled service work is required to maintain your vehicle in good operating condition. DaimlerChrysler Canada Inc. reserves the right to deny warranty coverage if the vehicle has not been properly maintained. While we do not insist that such work be performed by factory-authorized retailers, we strongly recommend that an authorized Chrysler, Jeep® or Dodge Retailer perform this work.
INTRODUCTION