engine oil CHRYSLER ASPEN HYBRID 2008 2.G Warranty Booklet
[x] Cancel search | Manufacturer: CHRYSLER, Model Year: 2008, Model line: ASPEN HYBRID, Model: CHRYSLER ASPEN HYBRID 2008 2.GPages: 72, PDF Size: 1.4 MB
Page 6 of 72
5/100 POWERTRAIN WARRANTY
The following powertrain components are covered for5 years or 100,000
kilometres, whichever occurs first, measured from the vehicle’s original
warranty start date.
Vehicles placed in taxi, limousine, postal or ambulance service and all SRT
vehicles, are excluded from the 5-year or 100,000-kilometrePowertrain
Warranty and are covered only under the 3-year or 60,000-kilometreBasic
Warranty.
• Engine - Cylinder block and all internal parts; cylinder head assemblies;
timing case, timing chain, timing belt, gears and sprockets; vibration
damper; oil pump; water pump and housing; intake and exhaust
manifolds; flywheel with starter ring gear; core plugs; valve covers; oil
pan; turbocharger housing and internal parts; turbocharger wastegate
actuator; supercharger; serpentine belt tensioner; seals and gaskets for
listed components only. •
Transmission - Transmission case and all internal parts; torque con-
verter; drive/flex plate; transmission range switch; transmission control
module; bell housing; oil pan; seals and gaskets for listed components
only.
Note: Manual transmission clutch parts are not covered at any time.
• Rear-Wheel Drive - Rear axle housing and all internal parts; axle
shafts; axle shaft bearings; driveshaft assemblies; driveshaft centre
bearings; universal joints and yokes; seals and gaskets for listed
components only.
• 4-Wheel Drive (4x4) - Transfer case and all internal parts; transfer case
control module and shift mode motor assembly; axle housing and all
internal parts; axle shafts; axle shaft bearings; driveshaft assemblies
(front and rear); driveshaft centre bearings; universal joints and yokes;
disconnect housing assembly; seals and gaskets for listed components
only.
8
5/100 POWERTRAIN WARRANTY
Page 9 of 72
EMISSION DEFECT WARRANTY
The 3/60 Basic Warranty covers all emission control components for3
years or 60,000 kilometres, whichever occurs first. The Emission Defect
Warranty provides longer coverage for specified components.
LIGHT-DUTY TRUCKS
For light-duty trucks, the Defect Warranty covers the following major
emission control parts, if so equipped, for 8 years or 130,000 kilometres,
whichever occurs first:
• catalytic converter
• powertrain control module
HEAVY-DUTY TRUCKS
Heavy-duty trucks are trucks over 4,536 kg (10,000 lb) GVW, designated
by an Min the fourth position of the Vehicle Identification Number
(VIN), or any truck equipped with a heavy-duty gasoline or diesel engine,
designated by a 5,6,7,or Win the eighth position of the VIN. For heavy-duty trucks, the Defect Warranty covers the following parts, if so
equipped, for
5 years or 80,000 kilometres, whichever occurs first:
• air system controls
• catalytic converter
• distributor and components
• electronic fuel injection system and injectors
• evaporative-emission canister and controls
• exhaust manifold
• EGR valve and control system
• exhaust pipes (exhaust manifold to catalyst)
• fuel cap and tank assembly, pump and fuel lines
• ignition coil and module
• intake manifold
• onboard diagnostic system components
• oxygen sensors
• PCV valve or orifice
• powertrain control module
• secondary ignition wires
• spark plugs
• throttle body
• transmission control module
• vacuum hoses, clamps, fittings and tubing used for these components
• vacuum, temperature, altitude, speed, and time-sensitive sensors, valves
and switches used in these components and systems
11
EMISSION DEFECT WARRANTY / EMISSION PERFORMANCE WARRANTY
Page 11 of 72
WHAT IS NOT COVERED
DAMAGE FROM MISUSE OR ACCIDENT
The warranties in this booklet do not cover repairs required due to fire,
accidents, abuse, negligence, objects striking your vehicle, carrying corro-
sive materials (such as chemicals, acids and fertilizers), misuse (such as
driving over curbs, overloading, spinning wheels, etc.), racing or partici-
pating in a racing event, improper disconnection of components, modifying
the exhaust system, tampering or making adjustments which do not comply
with DaimlerChrysler specifications.
Disconnecting, tampering with or changing the reading of the odometer
will void your warranties.
DAMAGE FROM THE ENVIRONMENT
The warranties in this booklet do not cover fading or deterioration caused
by exposure to the elements, or repairs required due to airborne fallout,
acid rain, chemicals, tree sap, insects, bird or insect droppings, salt, sand,
gravel, road hazards, hail, wind storms, lightning, floods or any other event
of nature. Road salt, car washes, scuffs and scratches, and everyday abrasion from
sand and dirt can affect the appearance of a vehicle’s wheels (steel, chrome
and aluminum) and other undercarriage parts. Some surface corrosion with
use is normal; it is not a defect and is not covered by any warranty.
NORMAL MAINTENANCE AND WEAR
The warranties in this booklet do not cover normal maintenance services,
such as oil and filter changes, general lubrication, tire rotation, engine
tune-ups and replacing spark plugs. Required maintenance services are
described in detail in your Owner’s Manual and herein. The warranties also
do not cover worn wiper blades, clutch discs, brake rotors, pads, linings or
drums, windshield and rear window, wheel alignment and wheel balancing
(unless they are defective, see page 7).
13
WHAT IS NOT COVERED
Page 24 of 72
1. POWERTRAIN PLANS*
Powertrain plans complement the factory powertrain warranty by provid-
ing enhanced roadside coverage and car rental allowance if your vehicle is
not drivable and must be kept overnight. Certain plans also provide
additional distance coverage.
Major components covered are:
• engine •transmission •front-wheel drive •rear-wheel drive •4-wheel
drive (4x4) •all-wheel drive vehicles
2. GOLDPLANS*
Each plan provides full mechanical repair protection to non-powertrain
(Gold) components. Certain plans also provide full mechanical protection
against powertrain component repairs beyond your vehicle’s Powertrain
Warranty coverage. Contracts are available with or without a deductible.
Major components covered are:
• steering •air conditioning •engine cooling and fuel •front suspension
• rear suspension •electrical •hydraulic brake components •anti-lock
brakes
* Maximum terms available on new vehicles registered in Canada only.
3. GOLDPLUSPLANS*
The most complete protection available for your new vehicle is a Gold
Plus Service Contract which combines the benefits of Gold component
coverage (see GoldPlans), plus, the most important vehicle maintenance
functions:
• Engine oil and oil filter changes
• Tire rotation every other service
• Peace of Mind motoring with Tire Road Hazard Protection which
provides full, or pro-rata, replacement of the original four tires, or
their repair
• Rental car allowance for same-day warranty repairs - your vehicle
need not be kept overnight before eligibility for the rental allow-
ance is met
26
OPTIONAL DAIMLERCHRYSLER CANADA SERVICE CONTRACTS
Page 33 of 72
❏Change the engine oil and engine oil filter.
❏ Rotate tires.
❏ Inspect the brake linings, replace if necessary.
❏ Inspect the CV joints.
❏ Inspect the exhaust system.
❏ Inspect the front suspension, tie rod ends and boot seals, replace if necessary.
❏ Replace the engine air cleaner filter.
❏ Inspect the transfer case fluid.
❏ Replace the top row of spark plugs on 4.7L engines. **
❏ Replace the spark plugs on 3.7L and 5.7L engines.
❏ Change the transfer case fluid if using your vehicle for any of the following:
police, taxi, fleet, off-road or frequent trailer towing.
❏ Change the manual transmission fluid if using your vehicle for any of the fol-
lowing: trailer towing, snowplowing, heavy loading, taxi, police, delivery ser-
vice (commercial service), off-road, desert operation or more then 50% of your
driving is at sustained high speeds during hot weather, above 32C°.
❏ Drain and refill automatic transmission fluid, change filter (3.7L engines).
❏ Drain and refill automatic transmission fluid and change main sump filter and
spin-on cooler return filter (4.7L/5.7L engines only).
❏ Replace accessory drive belt(s).
** Vehicles built with the 4.7L engine are equipped with sixteen spark plugs, one
set is located on the top of the engine under the coils and the second set is lo-
cated on the side of the engine. The spark plugs located under the coils are a stan-
dard plug and must be change every 50,000 kilometres. The spark plugs located
on the side of the engine are a premium plug and must be changed every
170,000 kilometres.
Perform Maintenance Every
200,000 km or 120 Months
Odometer Reading
Date
Repair Order No.
DAIMLERCHRYSLER
RETAILERSTAMP
Signature of authorized DaimlerChrysler Canada Retailer
................................................................................................
Page 34 of 72
Perform Maintenance Every
200,000 km or 120 Months
❏ Change the engine oil and engine oil filter.
❏ Rotate tires.
❏ Inspect the brake linings, replace if necessary.
❏ Inspect the CV joints.
❏ Inspect the exhaust system.
❏ Inspect the front suspension, tie rod ends and boot seals, replace if necessary.
❏ Replace the engine air cleaner filter.
❏ Inspect the transfer case fluid.
❏ Replace the top row of spark plugs on 4.7L engines. **
❏ Replace the spark plugs on 3.7L and 5.7L engines.
❏ Change the transfer case fluid if using your vehicle for any of the following: police, taxi, fleet, off-road
or frequent trailer towing.
❏ Change the manual transmission fluid if using your vehicle for any of the following: trailer towing,
snowplowing, heavy loading, taxi, police, delivery service (commercial service), off-road, desert
operation or more then 50% of your driving is at sustained high speeds during hot weather, above 32C°.
❏ Drain and refill automatic transmission fluid, change filter (3.7L engines).
❏ Drain and refill automatic transmission fluid and change main sump filter and spin-on cooler return filter
(4.7L/5.7L engines only).
❏ Replace accessory drive belt(s).
** Vehicles built with the 4.7L engine are equipped with sixteen spark plugs, one set is located on the top of the
engine under the coils and the second set is located on the side of the engine. The spark plugs located under the
coils are a standard plug and must be change every 50,000 kilometres. The spark plugs located on the side of the
engine are a premium plug and must be changed every 170,000 kilometres.
Perform Maintenance
Every
120 Months or
200,000 km
Odometer Reading
DateRetailer Copy
Remove and attach to Repair Order
................................................................................................
Page 35 of 72
❏Change the engine oil and engine oil filter.
❏ Rotate tires.
Perform Maintenance Every
190,000 km or 114 Months
Odometer Reading
Date
Repair Order No.
DAIMLERCHRYSLER
RETAILERSTAMP
Signature of authorized DaimlerChrysler Canada Retailer
................................................................................................
Page 36 of 72
Perform Maintenance Every
190,000 km or 114 Months
❏ Change the engine oil and engine oil filter.
❏ Rotate tires.Perform Maintenance
Every
114 Months or
190,000 km
Odometer Reading
DateRetailer Copy
Remove and attach to Repair Order
................................................................................................
Page 37 of 72
❏Change the engine oil and engine oil filter.
❏ Rotate tires.
❏ If using your vehicle for any of the following: Dusty or
off-road conditions. Inspect the engine air cleaner filter,
replace if necessary.
❏ Inspect the brake linings, replace if necessary.
❏ Inspect the front & rear axle fluid, change if using your
vehicle for police, taxi, fleet, off-road or frequent trailer
towing.
Perform Maintenance Every
180,000 km or 108 Months
Odometer Reading
Date
Repair Order No.
DAIMLERCHRYSLER
RETAILERSTAMP
Signature of authorized DaimlerChrysler Canada Retailer
................................................................................................
Page 38 of 72
Perform Maintenance Every
180,000 km or 108 Months
❏ Change the engine oil and engine oil filter.
❏ Rotate tires.
❏ If using your vehicle for any of the following: Dusty or off-road conditions. Inspect
the engine air cleaner filter, replace if necessary.
❏ Inspect the brake linings, replace if necessary.
❏ Inspect the front & rear axle fluid, change if using your vehicle for police, taxi,
fleet, off-road or frequent trailer towing.Perform Maintenance
Every
108 Months or
180,000 km
Odometer Reading
DateRetailer Copy
Remove and attach to Repair Order
................................................................................................