transmission CHRYSLER ASPEN HYBRID 2008 2.G Warranty Booklet

5/100 POWERTRAIN WARRANTY
The following powertrain components are covered for5 years or 100,000
kilometres, whichever occurs first, measured from the vehicle’s original
warranty start date.
Vehicles placed in taxi, limousine, postal or ambulance service and all SRT
vehicles, are excluded from the 5-year or 100,000-kilometrePowertrain
Warranty and are covered only under the 3-year or 60,000-kilometreBasic
Warranty.
• Engine - Cylinder block and all internal parts; cylinder head assemblies;
timing case, timing chain, timing belt, gears and sprockets; vibration
damper; oil pump; water pump and housing; intake and exhaust
manifolds; flywheel with starter ring gear; core plugs; valve covers; oil
pan; turbocharger housing and internal parts; turbocharger wastegate
actuator; supercharger; serpentine belt tensioner; seals and gaskets for
listed components only. •
Transmission - Transmission case and all internal parts; torque con-
verter; drive/flex plate; transmission range switch; transmission control
module; bell housing; oil pan; seals and gaskets for listed components
only.
Note: Manual transmission clutch parts are not covered at any time.
• Rear-Wheel Drive - Rear axle housing and all internal parts; axle
shafts; axle shaft bearings; driveshaft assemblies; driveshaft centre
bearings; universal joints and yokes; seals and gaskets for listed
components only.
• 4-Wheel Drive (4x4) - Transfer case and all internal parts; transfer case
control module and shift mode motor assembly; axle housing and all
internal parts; axle shafts; axle shaft bearings; driveshaft assemblies
(front and rear); driveshaft centre bearings; universal joints and yokes;
disconnect housing assembly; seals and gaskets for listed components
only.
8
5/100 POWERTRAIN WARRANTY

EMISSION DEFECT WARRANTY
The 3/60 Basic Warranty covers all emission control components for3
years or 60,000 kilometres, whichever occurs first. The Emission Defect
Warranty provides longer coverage for specified components.
LIGHT-DUTY TRUCKS
For light-duty trucks, the Defect Warranty covers the following major
emission control parts, if so equipped, for 8 years or 130,000 kilometres,
whichever occurs first:
• catalytic converter
• powertrain control module
HEAVY-DUTY TRUCKS
Heavy-duty trucks are trucks over 4,536 kg (10,000 lb) GVW, designated
by an Min the fourth position of the Vehicle Identification Number
(VIN), or any truck equipped with a heavy-duty gasoline or diesel engine,
designated by a 5,6,7,or Win the eighth position of the VIN. For heavy-duty trucks, the Defect Warranty covers the following parts, if so
equipped, for
5 years or 80,000 kilometres, whichever occurs first:
• air system controls
• catalytic converter
• distributor and components
• electronic fuel injection system and injectors
• evaporative-emission canister and controls
• exhaust manifold
• EGR valve and control system
• exhaust pipes (exhaust manifold to catalyst)
• fuel cap and tank assembly, pump and fuel lines
• ignition coil and module
• intake manifold
• onboard diagnostic system components
• oxygen sensors
• PCV valve or orifice
• powertrain control module
• secondary ignition wires
• spark plugs
• throttle body
• transmission control module
• vacuum hoses, clamps, fittings and tubing used for these components
• vacuum, temperature, altitude, speed, and time-sensitive sensors, valves
and switches used in these components and systems
11
EMISSION DEFECT WARRANTY / EMISSION PERFORMANCE WARRANTY

OTHER THINGS YOU SHOULD KNOW
OPTIONAL SERVICE CONTRACT
DaimlerChrysler Canada has a service contract specially designed for most
new vehicles, to cover repair costs beyond your vehicle’s warranty.
Protection is available for almost every operating part of your vehicle, and
at reasonable cost.
DaimlerChrysler Canada stands fully behind its service contracts. Be sure
that the contract you buy is a genuine DaimlerChryslerService Contract.
We are notresponsible for other companies’ contracts. See page 26 for
details on available service contracts.
APPEARANCE ITEMS
Defects or damage to sheet metal, paint, trim and other appearance items
are normally found and corrected during new vehicle inspection. For your
protection, if you find any such defect or damage, you should tell your
selling retailer immediately, because if the problem worsens due to use and
exposure, repairs will not be covered by any warranty.
PRODUCTION CHANGES
DaimlerChrysler Canada and its retailers reserve the right to make changes
in vehicles built and/or sold at any time without incurring any obligations
to make the same or similar changes on vehicles which were built and/or
sold previously.
EXCHANGE PARTS
To reduce the amount of time your vehicle is out of service due to repairs,
DaimlerChrysler may offer exchange service on some parts. Mopar or
Autopar brand exchange parts may be new, remanufactured, recondi-
tioned or repaired, but all meet DaimlerChrysler standards and are
warranted the same as new parts. Examples of parts that may be serviced
by exchange include engines, transmissions, instrument clusters, radios,
tape and CD players, speedometers and various electronic modules.
17
OTHER THINGS YOU SHOULD KNOW

1. POWERTRAIN PLANS*
Powertrain plans complement the factory powertrain warranty by provid-
ing enhanced roadside coverage and car rental allowance if your vehicle is
not drivable and must be kept overnight. Certain plans also provide
additional distance coverage.
Major components covered are:
• engine •transmission •front-wheel drive •rear-wheel drive •4-wheel
drive (4x4) •all-wheel drive vehicles
2. GOLDPLANS*
Each plan provides full mechanical repair protection to non-powertrain
(Gold) components. Certain plans also provide full mechanical protection
against powertrain component repairs beyond your vehicle’s Powertrain
Warranty coverage. Contracts are available with or without a deductible.
Major components covered are:
• steering •air conditioning •engine cooling and fuel •front suspension
• rear suspension •electrical •hydraulic brake components •anti-lock
brakes
* Maximum terms available on new vehicles registered in Canada only.
3. GOLDPLUSPLANS*
The most complete protection available for your new vehicle is a Gold
Plus  Service Contract which combines the benefits of Gold component
coverage (see GoldPlans), plus, the most important vehicle maintenance
functions:
• Engine oil and oil filter changes
• Tire rotation every other service
• Peace of Mind motoring with Tire Road Hazard Protection which
provides full, or pro-rata, replacement of the original four tires, or
their repair
• Rental car allowance for same-day warranty repairs - your vehicle
need not be kept overnight before eligibility for the rental allow-
ance is met
26
OPTIONAL DAIMLERCHRYSLER CANADA SERVICE CONTRACTS

❏Change the engine oil and engine oil filter.
❏ Rotate tires.
❏ Inspect the brake linings, replace if necessary.
❏ Inspect the CV joints.
❏ Inspect the exhaust system.
❏ Inspect the front suspension, tie rod ends and boot seals, replace if necessary.
❏ Replace the engine air cleaner filter.
❏ Inspect the transfer case fluid.
❏ Replace the top row of spark plugs on 4.7L engines. **
❏ Replace the spark plugs on 3.7L and 5.7L engines.
❏ Change the transfer case fluid if using your vehicle for any of the following:
police, taxi, fleet, off-road or frequent trailer towing.
❏ Change the manual transmission fluid if using your vehicle for any of the fol-
lowing: trailer towing, snowplowing, heavy loading, taxi, police, delivery ser-
vice (commercial service), off-road, desert operation or more then 50% of your
driving is at sustained high speeds during hot weather, above 32C°.
❏ Drain and refill automatic transmission fluid, change filter (3.7L engines).
❏ Drain and refill automatic transmission fluid and change main sump filter and
spin-on cooler return filter (4.7L/5.7L engines only).
❏ Replace accessory drive belt(s).
** Vehicles built with the 4.7L engine are equipped with sixteen spark plugs, one
set is located on the top of the engine under the coils and the second set is lo-
cated on the side of the engine. The spark plugs located under the coils are a stan-
dard plug and must be change every 50,000 kilometres. The spark plugs located
on the side of the engine are a premium plug and must be changed every
170,000 kilometres.
Perform Maintenance Every
200,000 km or 120 Months
Odometer Reading
Date
Repair Order No.
DAIMLERCHRYSLER
RETAILERSTAMP
Signature of authorized DaimlerChrysler Canada Retailer
................................................................................................

Perform Maintenance Every
200,000 km or 120 Months
❏ Change the engine oil and engine oil filter.
❏ Rotate tires.
❏ Inspect the brake linings, replace if necessary.
❏ Inspect the CV joints.
❏ Inspect the exhaust system.
❏ Inspect the front suspension, tie rod ends and boot seals, replace if necessary.
❏ Replace the engine air cleaner filter.
❏ Inspect the transfer case fluid.
❏ Replace the top row of spark plugs on 4.7L engines. **
❏ Replace the spark plugs on 3.7L and 5.7L engines.
❏ Change the transfer case fluid if using your vehicle for any of the following: police, taxi, fleet, off-road
or frequent trailer towing.
❏ Change the manual transmission fluid if using your vehicle for any of the following: trailer towing,
snowplowing, heavy loading, taxi, police, delivery service (commercial service), off-road, desert
operation or more then 50% of your driving is at sustained high speeds during hot weather, above 32C°.
❏ Drain and refill automatic transmission fluid, change filter (3.7L engines).
❏ Drain and refill automatic transmission fluid and change main sump filter and spin-on cooler return filter
(4.7L/5.7L engines only).
❏ Replace accessory drive belt(s).
** Vehicles built with the 4.7L engine are equipped with sixteen spark plugs, one set is located on the top of the
engine under the coils and the second set is located on the side of the engine. The spark plugs located under the
coils are a standard plug and must be change every 50,000 kilometres. The spark plugs located on the side of the
engine are a premium plug and must be changed every 170,000 kilometres.
Perform Maintenance
Every
120 Months or
200,000 km
Odometer Reading
DateRetailer Copy
Remove and attach to Repair Order
................................................................................................

❏Change the engine oil and engine oil filter.
❏ Rotate tires.
❏ Inspect the brake linings, replace if necessary.
❏ Replace the engine air cleaner filter.
❏ Inspect the transfer case fluid.
❏ Replace the top row of spark plugs on 4.7L engines. **
❏ Replace the spark plugs on 3.7L and 5.7L engines.
❏ Change the automatic transmission fluid and main sump filter, if using your
vehicle for any of the following: police, taxi, fleet, snow plowing, or frequent
trailer towing (3.7L, 4.7L, and 5.7L engines only).
❏ Change the transfer case fluid if using your vehicle for any of the following:
police, taxi, fleet, off-road or frequent trailer towing.
❏ Change the manual transmission fluid if using your vehicle for any of the fol-
lowing: trailer towing, snowplowing, heavy loading, taxi, police, delivery ser-
vice (commercial service), off-road, desert operation or more then 50% of your
driving is at sustained high speeds during hot weather, above 32C°.
** Vehicles built with the 4.7L engine are equipped with sixteen spark plugs, one
set is located on the top of the engine under the coils and the second set is lo-
cated on the side of the engine. The spark plugs located under the coils are a stan-
dard plug and must be change every 50,000 kilometres. The spark plugs located
on the side of the engine are a premium plug and must be changed every
170,000 kilometres.
Perform Maintenance Every
100,000 km or 60 Months
Odometer Reading
Date
Repair Order No.
DAIMLERCHRYSLER
RETAILERSTAMP
Signature of authorized DaimlerChrysler Canada Retailer
................................................................................................

Perform Maintenance Every
100,000 km or 60 Months
❏ Change the engine oil and engine oil filter.
❏ Rotate tires.
❏ Inspect the brake linings, replace if necessary.
❏ Replace the engine air cleaner filter.
❏ Inspect the transfer case fluid.
❏ Replace the top row of spark plugs on 4.7L engines. **
❏ Replace the spark plugs on 3.7L and 5.7L engines.
❏ Change the automatic transmission fluid and main sump filter, if using your vehicle for any of
the following: police, taxi, fleet, snow plowing, or frequent trailer towing (3.7L, 4.7L, and 5.7L
engines only).
❏ Change the transfer case fluid if using your vehicle for any of the following: police, taxi, fleet,
off-road or frequent trailer towing.
❏ Change the manual transmission fluid if using your vehicle for any of the following: trailer
towing, snowplowing, heavy loading, taxi, police, delivery service (commercial service),
off-road, desert operation or more then 50% of your driving is at sustained high speeds during
hot weather, above 32C°.
** Vehicles built with the 4.7L engine are equipped with sixteen spark plugs, one set is located on the top of the
engine under the coils and the second set is located on the side of the engine. The spark plugs located under the
coils are a standard plug and must be change every 50,000 kilometres. The spark plugs located on the side of the
engine are a premium plug and must be changed every 170,000 kilometres.
Perform Maintenance
Every
60 Months or
100,000 km
Odometer Reading
DateRetailer Copy
Remove and attach to Repair Order
................................................................................................