radiator CHRYSLER CONCORDE 2004 2.G User Guide

•Maintain coolant concentration of a minimum of 50%
ethylene glycol and high quality water with recom-
mended antifreeze for proper corrosion protection of
your engine cooling system that contains aluminum
components.
•Make sure that the radiator and coolant bottle hoses
are not kinked or obstructed.
•Keep the front of the radiator and air conditioning
condenser clean.
•Do not change the thermostat for summer or winter
operation. If replacement is ever necessary, install
ONLY the correct type thermostat. Other designs may
result in unsatisfactory engine cooling performance,
poor gas mileage, and increased emissions.
Hoses and Vacuum/Vapor Harnesses
Inspect surfaces of hoses and nylon tubing for evidence
of heat and mechanical damage. Hard or soft spots,
brittle rubber, cracking, checking, tears, cuts, abrasions,
and excessive swelling indicate deterioration of the rub-
ber.Pay particular attention to those hoses nearest to high
heat sources such as the exhaust manifold. Inspect hose
routing to be sure hoses do not touch any heat source or
moving component that may cause heat damage or
mechanical wear.
Insure nylon tubing in these areas has not melted or
collapsed. Inspect all hose connections such as clamps
and couplings to make sure they are secure and no leaks
are present. Components should be replaced immedi-
ately if there is any evidence of degradation that could
cause failure.
Brake System
In order to assure brake system performance, all brake
system components should be inspected periodically.
Suggested service intervals can be found in Section 8.
214 MAINTAINING YOUR VEHICLE

Once a Month
•
Check tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of coolant reservoir, brake
master cylinder, power steering and transaxle and add
as needed.
•Check all lights and all other electrical items for correct
operation.
•Check rubber seals on each side of the radiator for
proper fit.
At Each Oil Change
•
Change the engine oil filter.
•Inspect the exhaust system.
•Inspect the brake hoses.
•Inspect the CV joints and front and rear suspension
components.
•Check the automatic transmission fluid level.
•Check the coolant level, hoses, and clamps.
•Rotate the tires at each oil change interval shown on
Schedule “A” 6,000 miles (10 000 km) or every other
interval shown on Schedule “B” 6,000 miles (10 000
km).
238 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Instrument Panel..................... 223
Seat Belts........................... 223
Vinyl.............................. 221
Washing............................ 220
Waxing............................. 221
Wheels............................. 221
Windshield Wiper Blades............... 209
Climate Control........................ 137
Clock................................ 113
Coat Hook............................. 55
Compact Disc Maintenance............... 136
Compact Disc Player................. 114,119
Compact Spare Tire..................... 162
Compass............................94,98
Compass Calibration...................94,98
Compass Variance....................... 95
Computer, Trip/Travel..................93,96
Console, Overhead....................... 75
Contract, Service....................... 254
Cooling System........................ 210
Adding Coolant (Antifreeze)............. 211
Coolant Level........................ 213
Disposal of Used Coolant............... 211Drain, Flush, and Refill................. 211
Inspection........................... 210
Points to Remember................... 213
Pressure Cap........................ 212
Radiator Cap........................ 212
Rubber and Plastic Components.......... 214
Selection of Coolant................... 211
Corrosion Protection.................... 220
Courtesy Lights......................... 66
Crankcase Emission Control System......... 202
Cruise Light.........................73,110
Cup Holder............................ 55
Customer Assistance.................... 252
Daytime Brightness, Interior Lights.......... 65
Daytime Running Lights.................. 68
Dealer Service......................... 193
Defroster, Rear Window.................. 139
Defroster, Windshield...............50,138,143
Diagnostic System, Onboard............ 111,191
Dimmer Switch, Headlight................. 69
Disabled Vehicle Towing................. 186
264 INDEX

Seats............................... 59
Steering............................ 158
Steering, Checking.................... 205
Sunroof............................. 87
TrunkLid ............................ 25
Windows............................ 25
Pregnant Women and Seat Belts............. 32
Programmable Electronic Features.....77,80,82,86
Programming Transmitters........20,77,80,82,86
Radial Ply Tires........................ 162
Radiator Cap.......................... 212
Radio.......................... 114,121,126
Radio Operation.....................134,136
Radio Remote Controls.................. 133
Rear Window Defroster.................. 139
Reclining Front Seats..................... 59
Recommended Fluids, Lubricants and Genuine
Parts............................... 233
Reformulated Gasoline................... 168
Refrigerant............................ 205
Reminder, Lights On..................... 67Remote Keyless Entry.................... 18
Remote Trunk Release.................... 25
Replacement Bulbs...................... 226
Replacement Tires...................... 165
Reporting Safety Defects................. 255
Restraint, Head......................... 63
Restraints, Occupant..................... 27
Rotation, Tires......................... 166
Safety Checks Inside Vehicle............... 49
Safety Checks Outside Vehicle.............. 50
Safety, Exhaust Gas...................... 49
Safety Tips............................. 49
Schedule, Maintenance................... 236
Scheduled Maintenance.................. 194
Seat Belt Maintenance................... 223
Seat Belts............................27,28
Adjustable Upper Shoulder Anchorage...... 32
Child Restraint........................ 46
Extender............................ 32
Inspection........................... 49
Reminder........................... 110
270 INDEX