maintenance CHRYSLER CONCORDE 2004 2.G Owner's Guide

NOTE:IfANYof these apply to you then change your
engine oil every 3,000 miles (5 000 km) or 3 months,
whichever comes first and follow schedule “B” of the
Maintenance Schedulessection of this manual.
NOTE:Most vehicles are operated under the conditions
listed for ScheduleB.
Second is Schedule“A”. It is for vehicles that are not
operated under any of the conditions listed under Sched-
uleB.
Use the schedule that best describes your driving condi-
tions. Where time and mileage are listed, follow the
interval that occurs first.
NOTE:Under no circumstances should oil change
intervals exceed 6000 miles (10 000 km) or 6 months
whichever comes first.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
At Each Stop for Fuel
•
Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
•Check the windshield washer solvent and add if
required.
MAINTENANCE SCHEDULES 237
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Once a Month
•
Check tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of coolant reservoir, brake
master cylinder, power steering and transaxle and add
as needed.
•Check all lights and all other electrical items for correct
operation.
•Check rubber seals on each side of the radiator for
proper fit.
At Each Oil Change
•
Change the engine oil filter.
•Inspect the exhaust system.
•Inspect the brake hoses.
•Inspect the CV joints and front and rear suspension
components.
•Check the automatic transmission fluid level.
•Check the coolant level, hoses, and clamps.
•Rotate the tires at each oil change interval shown on
Schedule “A” 6,000 miles (10 000 km) or every other
interval shown on Schedule “B” 6,000 miles (10 000
km).
238 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

SCHEDULE “B”
Follow schedule “B” if you usually operate your vehicle
under one or more of the following conditions. Change
the automatic transmission fluid and filter every 60,000
miles (96 000 km) if the vehicle is usually operated under
one or more of the conditions marked with an.
•Day or night temperatures are below 32° F (0° C).
•Stop and go driving.
•Extensive engine idling.
•Driving in dusty conditions.
•Short trips of less than 10 miles (16.2 km).
•More than 50% of your driving is at sustained high
speeds during hot weather, above 90° F (32° C).
•Trailer towing.
•Taxi, police or delivery service (commercial ser-
vices).
•Off-road or desert operation.
•If equipped for and operating with E-85 (ethanol)
fuel.
NOTE:IfANYof these apply to you then change your
engine oil every 3,000 miles (5 000 km) or 3 months,
whichever comes first and follow schedule “B” of the
Maintenance Schedulessection of this manual.
SCHEDULE “B” 239
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 93,000 96,000 99,000 100,000 102,000 105,000
(Kilometers) (149 000) (154 000) (158 000) (160 000) (163 000) (168 000)
Change engine oil and engine oil filter. X X X X X
Inspect theair cleaner filterand replace if re-
quired.*XXX X
Replace theair cleaner filter.X
Inspect the front and rear brake linings and
rotors.X
Flush and replace the engine coolant. X
Replace theengine timing belt(Federal Emis-
sions).X
Replace theengine timing belt(California
Emissions).X
Replace thespark plugs.X
Adjust the drive belt tension.X
Change the differential fluid. X
* This maintenance is recommended by the manufacture
to the owner but is not required to maintain the emis-
sions warranty.
‡ This maintenance is not required if previously replaced.Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
SCHEDULE “B” 245
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 78,000 84,000 90,000 96,000 102,000
(Kilometers) (125 000) (134 000) (144 000) (154 000) (163 000)
[Months] [78] [84] [90] [96] [102]
Change engine oil and engine oil filter. X X X X X
Inspect theair cleaner filterand replace if re-
quired.*XX XX
Replace theair cleaner filter.*X
Adjust the drive belt tension. X
Inspect the front and rear brake linings and rotors. X
Replace thespark plugs.X
Check and replace, if necessary, thePCV valve.*‡ X
Replace theengine timing belt(Federal Emissions
equipped vehicles only).X
Replace theengine timing belt(California Emis-
sions equipped vehicles only).X
Flush and replace the engine coolant at 60 months
or 100,000 miles.X
* This maintenance is recommended by the manufacture
to the owner but is not required to maintain the emis-
sions warranty.
‡ This maintenance is not required if previously replaced.Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
248 SCHEDULE “A”
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

SUGGESTIONS FOR OBTAINING SERVICE FOR
YOUR VEHICLE
Prepare For The Appointment
If you’re having warranty work done, be sure to have the
right papers with you. Take your warranty folder. All
work to be performed may not be covered by the
warranty, discuss additional charges with the service
manager. Keep a maintenance log of your vehicle’s
service history. This can often provide a clue to the
current problem.
Prepare A List
Make a written list of your vehicle’s problems or the
specific work you want done. If you’ve had an accident,
or work done that is not on your maintenance log, let the
service advisor know.
Be Reasonable With Requests
If you list a number of items, and you must have your
vehicle by the end of the day, discuss the situation with the
service advisor and list the items in order of priority. At
many dealers you may obtain a rental vehicle at a minimal
daily charge. If you need a rental, it is advisable to make
these arrangements when you call for an appointment.
IF YOU NEED ASSISTANCE
The manufacturer and its dealers are vitally interested in
your satisfaction. We want you to be happy with our
products and services.
Your selling dealer is best equipped and most anxious to
provide prompt resolution for any warranty issue or
related matter that you may experience. The manufactur-
er’s dealers have the facilities, factory-trained techni-
cians, special tools, and the latest information to assure
your vehicle is fixed correctly and in a timely manner.
The manufacturer has empowered its dealers to make
warranty and repair decisions that ensure you are not
inconvenienced. There is no need for you to wait for a
decision from the manufacturer. If a special circumstance
occurs that requires information from the manufacturer,
we have asked the dealer’s service management to make
the contact on your behalf.
This is why you should always talk to your dealer’s
service manager first. Most matters can be resolved with
this process.
252 IF YOU NEED CONSUMER ASSISTANCE

About Your Brakes...................... 157
ABS (Anti-Lock Brake) System............. 112
Accident Damage....................... 221
Adding Engine Coolant (Antifreeze)......... 211
Adding Fuel.......................... 170
Air Cleaner, Engine..................... 202
Air Conditioning....................137,140
Air Conditioning Controls.............137,140
Air Conditioning, Operating Tips........... 146
Air Conditioning Refrigerant.............. 205
Air Conditioning System................. 204
Air Pressure, Tires...................159,161
Airbag................................ 33
Airbag Deployment....................37,38
Airbag Light....................37,41,49,111
Airbag Maintenance...................... 40
Alarm System.......................... 23
Alignment and Balance.................. 167
Antifreeze Disposal..................... 211
Antifreeze (Engine Coolant)............... 211
Anti-Lock Brake System.................. 157
Anti-Lock Warning Light................. 112
Anti-Theft Security Alarm................. 23Appearance Care....................... 220
Auto Down Power Windows............... 25
Automatic Dimming Mirror................ 56
Automatic Door Locks.................... 16
Automatic Headlights..................67,70
Automatic Off, Interior Lights.............. 65
Automatic Temperature Control............ 140
Automatic Transaxle..................153,217
Fluid and Filter Changes................ 219
Fluid Level Check..................... 218
Reset Mode......................... 154
Selection Of Lubricant................. 217
Shifting............................ 154
Special Additives..................... 219
Backfire, Engine........................ 202
Ball Joints............................ 207
Battery............................182,203
Emergency Starting.................... 182
Gas Caution......................182,203
Jump Starting........................ 182
Keyless Transmitter Replacement.......... 22
Location.........................183,203
262 INDEX

Saving Feature....................65,66,68
Belts, Drive........................... 200
Belts, Engine.......................... 202
Body Mechanism Lubrication.............. 207
Brake, Parking......................... 156
Brake System.......................157,214
Anti-Lock........................... 157
Fluid Check......................... 216
Hoses.............................. 215
Master Cylinder...................... 216
Warning Light....................... 112
Brake/Transmission Interlock...........153,154
Break-In Recommendations, New Vehicle...... 48
Brightness, Interior Lights................. 65
Bulb Replacement...................... 227
Bulbs, Light........................226,227
Calibration, Compass..................... 98
Capacities, Fluid....................... 233
Capacity, Cargo Weight.................. 171
Car Washes........................220,221
Cargo Compartment
Capacity............................ 171Luggage Carrier...................... 172
Carpeting............................. 221
Cassette Tape and Player Maintenance....... 135
Cassette Tape Player............... 114,121,135
Catalytic Converter..................... 200
CD Changer.....................124,129,130
CD Player.................... 119,126,128,134
Central Door Locks...................... 15
Chains, Tire........................... 163
Changing A Flat Tire.................... 177
Charging System Light................... 112
Check Engine Light..................... 111
Checks, Safety.......................... 49
Child Restraint...................41,43,45,46
Child Restraint Tether Anchors...........44,45
Child Safety Locks....................... 15
Circuit Breakers........................ 224
Clean Air Gasoline...................... 168
Cleaning
Carpets............................. 221
Cloth.............................. 221
Glass.............................. 223
Headlights.......................... 222
INDEX 263
10

Instrument Panel..................... 223
Seat Belts........................... 223
Vinyl.............................. 221
Washing............................ 220
Waxing............................. 221
Wheels............................. 221
Windshield Wiper Blades............... 209
Climate Control........................ 137
Clock................................ 113
Coat Hook............................. 55
Compact Disc Maintenance............... 136
Compact Disc Player................. 114,119
Compact Spare Tire..................... 162
Compass............................94,98
Compass Calibration...................94,98
Compass Variance....................... 95
Computer, Trip/Travel..................93,96
Console, Overhead....................... 75
Contract, Service....................... 254
Cooling System........................ 210
Adding Coolant (Antifreeze)............. 211
Coolant Level........................ 213
Disposal of Used Coolant............... 211Drain, Flush, and Refill................. 211
Inspection........................... 210
Points to Remember................... 213
Pressure Cap........................ 212
Radiator Cap........................ 212
Rubber and Plastic Components.......... 214
Selection of Coolant................... 211
Corrosion Protection.................... 220
Courtesy Lights......................... 66
Crankcase Emission Control System......... 202
Cruise Light.........................73,110
Cup Holder............................ 55
Customer Assistance.................... 252
Daytime Brightness, Interior Lights.......... 65
Daytime Running Lights.................. 68
Dealer Service......................... 193
Defroster, Rear Window.................. 139
Defroster, Windshield...............50,138,143
Diagnostic System, Onboard............ 111,191
Dimmer Switch, Headlight................. 69
Disabled Vehicle Towing................. 186
264 INDEX

Disposal
Antifreeze........................... 211
Engine Oil.......................... 199
Door Locks..........................14,15
Door Locks, Automatic................... 16
Door Locks, Central...................... 15
Door Opener, Garage...................76,81
Drive Belts............................ 200
Drive Shaft Universal Joints............... 207
Driver’s Seat Glide Feature................ 60
Driving
On Slippery Surfaces.................. 185
With an Automatic Transaxle............ 153
Electric Remote Mirrors................... 57
Electronic Speed Control.................. 72
Electronic Vehicle Information Center......... 88
Emergency Flashers..................... 176
Emission Control System Maintenance. . 192,202,236
Engine
Backfire............................ 202
Block Heater......................... 153Break-In Recommendations............... 48
Checking Oil Level.................... 194
Compartment.....................189,190
Cooling.......................... 110,210
Fails to Start......................... 152
Oil .............................109,194
Oil Change Interval................... 197
Oil Selection......................... 198
Oil Synthetic......................... 199
Overheating...................... 110,176
Specifications........................ 232
Timing Belt.......................... 202
Entry System, Illuminated................. 14
Exhaust Gas Caution................49,82,210
Exhaust System........................ 210
Exterior Lights.......................66,227
Filters
Air Cleaner.......................... 202
Automatic Transaxle................... 219
Engine Fuel......................... 202
Engine Oil.......................... 200
INDEX 265
10