tire pressure CHRYSLER CONCORDE 2004 2.G Warranty Booklet
[x] Cancel search | Manufacturer: CHRYSLER, Model Year: 2004, Model line: CONCORDE, Model: CHRYSLER CONCORDE 2004 2.GPages: 131, PDF Size: 1.11 MB
Page 31 of 131
MAINTENANCE Scheduled maintenance must be completed to provide the best vehicle
performance and reliability . The limited warranties in the warranty booklet DO NOT COVER repairs
required due to improper maintenance. W e strongly suggest you keep track of scheduled maintenance and
keep receipts or other documents. Use only recommended Mopar lubricants and genuine Mopar parts.
NOTE: WHERE TIME (MONTHS) AND METRAGE ARE INDICA TED, FOLLOW THE INTERVAL
THA T OCCURS FIRST .
AT EACH STOP FOR FUEL
¥ Check the engine oil level about 5 minutes after
a fully warmed engine is shut off. Checking the oil level while the vehicle is on level ground willimprove the accuracy of the oil level reading.
Add oil only when the level is at or below the
ADD or MIN mark.
¥ Check the windshield washer solvent and add if required.
ONCE A MONTH
¥ Check the tire pressure and look for unusualwear or damage.
¥ Inspect the battery and clean and tighten theterminals as required.
¥ Check the fluid levels of coolant reservoir , brake
master cylinder , power steering and transmission
and add as needed.
¥ Check all the lights and all other electrical itemsfor correct operation.
¥ Check rubber seals on each side of the radiatorfor proper fit (all except Pacifica ).
¥ Check and clean wiper blades. Replace if required.
VISUAL INSPECTIONS Ð
INSPECT FOR SIGNS OF COMPONENT
DETERIORA TION AND PHYSICAL DAMAGE.
There are two maintenance schedules contained in your OwnerÕ s Manual. Schedule
ÒAÓ lists the scheduled maintenance to beperformed under normal operating conditions.Schedule ÒBÓ is for vehicles that are operatedunder one or more of the following conditions:day or night temperatures are below 0 ¡C; stop
and go driving; extensive engine idling; drivingin dusty conditions; short trips of less than 16.2 km; more than 50% of your driving is atsustained high speeds during hot weather ,
above 32 ¡C; trailer towing; taxi, police, or delivery service (commercial service); off-roador desert driving; if equipped for and operatingwith E-85 (ethanol) fuel. Schedule ÒBÓ bestdescribes operating conditions in Canada and isthe recommended service schedule. For yourconvenience, the scheduled maintenanceintervals outlined in this booklet follow theSevere Service Schedule as described in yourOwnerÕ
s Manual.
The performance of all scheduled service workis required to maintain your vehicle in goodoperating condition and to keep your warrantyvalid throughout the warranty period. Thespecified services are available at yourauthorized Chrysler , Dodge or Jeep
¨dealer
.
DaimlerChrysler Canada Inc. reserves theright to deny warranty coverage if the vehiclehas not been properly maintained.
INTRODUCTION
04 Early Launch Cover 1/15/03 10:28 AM Page 4
Page 34 of 131
Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
10,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-02-01 3N.
Maint enance Service Sc hedule ÒBÓ
1 0,0 00 km
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary (all models).
l Rotate tires and check tire pressure.
INSPECT THE FOLLOWING: l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
04 Early LaunchMaintenance Book 1/15/03 10:09 AM Page 33
Page 35 of 131
Odometer Reading
Date
Repair Order No.
DAIMLER CHR YSLER
D EALER STAMP
Signature of authorized DaimlerChrysler Canada dealer
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Inspect the engine air cleaner filter and replace ifnecessary (all models).
l Rotate tires and check tire pressure.
INSPECT THE FOLLOWING: l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.Maint enance Service Sc hedule ÒBÓ
1 0,0 00 km
04 Early LaunchMaintenance Book 1/15/03 10:09 AM Page 34
Page 38 of 131
Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
19,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-04-01 3N.
Maint enance Service Sc hedule ÒBÓ
1 9,0 00 km
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary (all models).
l Replace the air conditioning filter (Pacifica only).
l Rotate tires and check tire pressure.
INSPECT THE FOLLOWING: l Inspect the front and rear brake linings and components (Sebring and Sebring Convertible only).
l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
04 Early LaunchMaintenance Book 1/15/03 10:09 AM Page 37
Page 39 of 131
Odometer Reading
Date
Repair Order No.
DAIMLER CHR YSLER
D EALER STAMP
Signature of authorized DaimlerChrysler Canada dealer
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Inspect the engine air cleaner filter and replace ifnecessary (all models).
l Replace the air conditioning filter (Pacifica only).
l Rotate tires and check tire pressure.
INSPECT THE FOLLOWING: l Inspect the front and rear brake linings and components (Sebring and Sebring Convertible only).
l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plugcondition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.Maint enance Service Sc hedule ÒBÓ
1 9,0 00 km
04 Early LaunchMaintenance Book 1/15/03 10:09 AM Page 38
Page 42 of 131
Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
29,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-06-01 3N.
Maint enance Service Sc hedule ÒBÓ
29,0 00 km
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary (all models).
l Rotate tires and check tire pressure.
INSPECT THE FOLLOWING: l Inspect the front and rear brake linings and components (Concorde, Intrepid, 300M and Pacifica only).
l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
04 Early LaunchMaintenance Book 1/15/03 10:09 AM Page 41
Page 43 of 131
Odometer Reading
Date
Repair Order No.
DAIMLER CHR YSLER
D EALER STAMP
Signature of authorized DaimlerChrysler Canada dealer
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Inspect the engine air cleaner filter and replace ifnecessary (all models).
l Rotate tires and check tire pressure.
INSPECT THE FOLLOWING: l Inspect the front and rear brake linings and components (Concorde, Intrepid, 300M and Pacifica only).
l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plugcondition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.Maint enance Service Sc hedule ÒBÓ
29,0 00 km
04 Early LaunchMaintenance Book 1/15/03 10:09 AM Page 42
Page 46 of 131
Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
38,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-08-01 3N.
Maint enance Service Sc hedule ÒBÓ
38,0 00 km
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary (all models).
l Replace the air conditioning filter (Pacifica only).
l Rotate tires and check tire pressure.
INSPECT THE FOLLOWING: l Inspect the front and rear brake linings and components (Sebring and Sebring Convertible only).
l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
04 Early LaunchMaintenance Book 1/15/03 10:09 AM Page 45
Page 47 of 131
Odometer Reading
Date
Repair Order No.
DAIMLER CHR YSLER
D EALER STAMP
Signature of authorized DaimlerChrysler Canada dealer
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary (all models).
l Replace the air conditioning filter (Pacifica only).
l Rotate tires and check tire pressure.
INSPECT THE FOLLOWING: l Inspect the front and rear brake linings and components (Sebring and Sebring Convertible only).
l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plugcondition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.Maint enance Service Sc hedule ÒBÓ
38,0 00 km
04 Early LaunchMaintenance Book 1/15/03 10:09 AM Page 46
Page 50 of 131
Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
48,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-10-01 3N.
Maint enance Service Sc hedule ÒBÓ
48,0 00 km
lChange engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Replace the engine air cleaner filter if required (all models).
l Replace the spark plugs (2.4L).
l Inspect the PCV valve and replace as necessary.
l Adjust the drive belt tension (Concorde, Intrepid and 300M only).
l Change the all-wheel drive power transfer unit fluid.*
l Rotate tires and check tire pressure.
INSPECT THE FOLLOWING: l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
* All-wheel-drive power transfer unit fluid and overrunning clutch/rear carrier fluid must be changed at more frequent intervals than shown in Schedule B if the vehicle is operated more than 50% atsustained high speeds during hot weather, above 32 ¡C (90 ¡F) or if used for trailer tow or commercial service.
04 Early LaunchMaintenance Book 1/15/03 10:09 AM Page 49