key CHRYSLER PACIFICA 2004 1.G Service Manual

If it is necessary to use the accessories while being towed
(wipers, defrosters, etc.), the key must be in the ON
position, not the ACCESSORY position. Make certain the
transmission remains in NEUTRAL.
Without The Ignition Key
Special care must be taken when the vehicle is towed
with the ignition in the LOCK position. The only ap-
proved method of towing with out the ignition key is
with a flat bed truck. Proper towing equipment is neces-
sary to prevent damage to the vehicle.
TOWING THIS VEHICLE BEHIND ANOTHER
VEHICLE (Flat towing with all four wheels on the
ground)
Flat towing of vehicles equipped with an automatic
transmission, is only permitted within the limitations
described in this section.
TOWING THIS VEHICLE BEHIND ANOTHER
VEHICLE WITH A TOW DOLLEY
The manufacturedoes not recommendthat you tow an
All-Wheel Drive (AWD) or front wheel drive vehicle on a
tow dolley. Vehicle damage may occur.
WHAT TO DO IN EMERGENCIES 263
6

EMISSIONS INSPECTION AND MAINTENANCE
PROGRAMS
In some localities, it may be a legal requirement to pass
an inspection of your vehicle's emissions control system.
Failure to pass could prevent vehicle registration.
For states which have an I/M (Inspection and
Maintenance) requirement, this check verifies the
following: the MIL (Malfunction Indicator Lamp)
is functioning and is not on when the engine is running,
and that the OBD (On Board Diagnostic) system is ready
for testing.
Normally, the OBD system will be ready. The OBD
system maynotbe ready if your vehicle was recently
serviced, if you recently had a dead battery, or a battery
replacement. If the OBD system should be determined
not ready for the I/M test, your vehicle may fail the test.Your vehicle has a simple ignition key actuated test
which you can use prior to going to the test station. To
check if your vehicle's OBD system is ready, you must do
the following:
1. Insert your ignition key into the ignition switch.
2. Turn the ignition to the ON position, but do not crank
or start the engine.
3. If you crank or start the engine, you will have to start
this test over.
4. As soon as you turn your key to the ON position, you
will see your MIL symbol come on as part of a normal
bulb check.
5. Approximately 15 seconds later, one of two things will
happen:
270 MAINTAINING YOUR VEHICLE

a. The MIL will flash for about 10 seconds and then
return to being fully illuminated until you turn off the
ignition key or start the engine. This means that your
vehicle's OBD system isnot readyand you shouldnot
proceed to the I/M station.
b. The MIL will not flash at all and will remain fully
illuminated until you turn off the ignition key or start
the engine. This means that your vehicle's OBD system
isreadyand you can proceed to the I/M station.
If your OBD system isnot ready,you should see your
authorized dealer or repair facility. If your vehicle was
recently serviced or had a battery failure or replacement,
you may need to do nothing more than drive your
vehicle as you normally would in order for your OBD
system to update. A recheck with the above test routine
may then indicate that the system is now ready.
Regardless of whether your vehicle's OBD system is
ready or not ready, if the MIL symbol is illuminatedduring normal vehicle operation, you should have your
vehicle serviced before going to the I/M station. The I/M
station can fail your vehicle because the MIL symbol is on
with the engine running.
REPLACEMENT PARTS
Use of genuine Mopartparts for normal/scheduled
maintenance and repairs is highly recommended to in-
sure the designed performance. Damage or failures
caused by the use of non-Mopartparts for maintenance
and repairs will not be covered by the manufacturer's
warranty.
DEALER SERVICE
Your dealer has the qualified service personnel, special
tools and equipment to perform all service operations in
an expert manner. Service Manuals are available which
include detailed service information for your vehicle.
Refer to these manuals before attempting any procedure
yourself.
MAINTAINING YOUR VEHICLE 271
7

Whenever a change is noticed in the sound of the exhaust
system, when exhaust fumes can be detected inside the
vehicle, or when the underside or rear of the vehicle is
damaged, have a competent mechanic inspect the com-
plete exhaust system and adjacent body areas for broken,
damaged, deteriorated, or mispositioned parts. Open
seams or loose connections could permit exhaust fumes
to seep into the passenger compartment. In addition,
inspect the exhaust system each time the vehicle is raised
for lubrication or oil change. Replace as required.
WARNING!
Exhaust gases can injure or kill. They contain carbon
monoxide (CO) which is colorless and odorless.
Breathing it can make you unconscious and can
eventually poison you. To avoid breathing CO, fol-
low the preceding safety tips.
Cooling System
Inspection
WARNING!
²When working near the radiator cooling fan, turn
the ignition key to the OFF position. The fan is
temperature controlled and can start at any time
when the ignition key is in the ON position.
²You or others can be badly burned by hot coolant
or steam from your radiator. If you see or hear
steam coming from under the hood, don't open
the hood until the radiator has had time to cool.
Never try to open a cooling system pressure cap
when the radiator is hot.
286 MAINTAINING YOUR VEHICLE

CAUTION!
Do not touch the new bulb with your fingers. Oil
contamination will severely shorten bulb life. If the
bulb comes in contact with an oily surface, clean the
bulb with rubbing alcohol.
High Intensity Discharge Headlights (HID) Ð If
Equipped
The headlights are a type of high voltage discharge tube.
High voltage can remain in the circuit even with the
headlight switch off and the key removed.Because of
this, you should not attempt to service a headlight bulb
yourself. If a headlight bulb fails, take your vehicle to
an authorized dealer for service.
WARNING!
A transient high tension occurs at the bulb sockets of
High Intensity Discharge (HID) headlights when the
headlight switch is turned ON. It may cause serious
electrical shock or electrocution if not serviced prop-
erly. See your authorized dealer for service.
NOTE:On vehicles equipped with High Intensity Dis-
charge Headlights (HID), when the headlights are turned
on there is a blue hue to the lights. This diminishes and
becomes more white after approximately 10 seconds, as
the system charges.
308 MAINTAINING YOUR VEHICLE

Special Additives...................... 298
Autostick........................ 112,203,204
Ball Joints............................. 283
Battery............................... 279
Jump Starting......................... 258
Keyless Transmitter Replacement............ 23
Bearings.............................. 300
Belts, Drive............................ 276
Body Mechanism Lubrication............... 284
B-Pillar Location........................ 218
Brake, Parking.......................... 206
Brake System........................208,292
Anti-Lock........................... 208
Fluid Check.......................293,313
Hoses.............................. 292
Warning Light........................ 140
Brake/Transmission Interlock............... 201
Break-In Recommendations, New Vehicle........ 61Bulb Replacement....................... 307
Bulbs, Light............................ 306
Calibration, Compass..................... 152
Capacities, Fluid........................ 311
Caps, Filler
Fuel................................ 240
Radiator............................ 289
Car Washes............................ 301
Carbon Monoxide Warning................. 239
Cargo Area Cover....................... 127
Cargo Compartment
Luggage Carrier....................... 130
Cargo Tie-Downs........................ 128
Cassette Tape and Player Maintenance......... 180
Cassette Tape Player...................160,164
Catalytic Converter...................... 278
CD Changer......................159,168,170
CD Player..................155,157,160,166,170
INDEX 347
10

Holder, Cup........................... 126
Homelink Transmitter..................... 115
Hood Release.......................... 100
Hoses.............................291,294
Ignition
Key ................................. 11
Illuminated Entry........................ 15
Immobilizer............................ 12
Indicator, Traction Control................. 141
Infant Restraint.......................... 56
Information Center, Vehicle................. 145
Instrument Cluster....................137,138
Instrument Panel and Controls.............. 136
Instrument Panel Lens Cleaning............. 303
Integrated Power Module.................. 305
Interior Appearance Care.................. 302
Interior Fuses.......................... 305
Interior Lights.......................103,104Intermittent Wipers...................... 108
Introduction............................. 4
Jack Location........................... 253
Jack Operation.......................252,255
Jump Starting.......................... 258
Key, Programming........................ 14
Key, Replacement........................ 14
Key, Sentry............................. 12
Key-In Reminder......................... 12
Keyless Entry System...................... 19
Keys.................................. 11
Knee Bolster..........................47,50
Lap/Shoulder Belts....................... 32
LATCH (Lower Anchors and Tether
for CHildren).........................53,55
352 INDEX

Mirrors.............................. 72
Outlet.............................. 124
Seats................................ 85
Steering............................. 211
Steering, Checking..................... 282
Sunroof............................. 121
Windows............................. 30
Pregnant Women and Seat Belts.............. 41
Pretensioners
Seat Belts............................. 40
Programmable Electronic Features...... 116,120,148
Programming Transmitters.............. 116,120
Radial Ply Tires......................... 226
Radiator Cap........................... 289
Radio.............................155,160
Radio Broadcast Signals................... 179
Radio Operation......................160,182
Radio Remote Controls.................172,178Rear Liftgate............................ 26
Rear Seating Flexibility.................... 96
Rear Window Defroster................... 193
Rear Window Features.................... 108
Rear Wiper/Washer...................... 108
Rearview Mirrors........................ 69
Reclining Front Seats...................... 91
Recommended Fluids, Lubricants and Genuine
Parts............................... 312
Reminder, Seat Belt....................... 40
Remote Keyless Entry..................... 19
Remote Sound System Controls.............. 178
Replacement Tires....................228,230
Reporting Safety Defects................... 340
Restraint, Head.......................... 86
Restraints, Child.......................53,59
Restraints, Infant......................... 56
Retractable Cargo Area Cover............... 127
Rocking Vehicle When Stuck................ 260
356 INDEX

Roof Rack............................. 130
Rotation, Tires.......................... 234
Safety Checks Inside Vehicle................. 62
Safety Checks Outside Vehicle............... 63
Safety, Exhaust Gas....................... 29
Safety Information, Tire................... 213
Safety Tips............................. 62
Schedule, Maintenance.................... 316
Seat Belt Maintenance.................... 304
Seat Belt Reminder....................... 40
Seat Belts.............................. 31
Adjustable Shoulder Belt.................. 37
Adjustable Upper Shoulder Anchorage........ 37
And Pregnant Women................... 41
Child Restraint......................... 53
Extender............................. 42
Front Seat............................ 32
Pretensioners.......................... 40Rear Seat............................. 32
Reminder............................ 144
Untwisting Procedure.................... 38
Seats................................. 85
Adjustment........................... 92
Easy Entry............................ 93
Heated.............................. 86
Memory............................. 88
Power............................... 85
Reclining............................. 91
Tilting............................... 93
Security Alarm.......................... 24
Selection of Coolant...................... 312
Sentry Key............................. 12
Service Assistance....................... 336
Service Contract......................... 338
Service Engine Soon Light................. 143
Service Manuals........................ 340
Setting the Clock........................ 154
INDEX 357
10

Selection of Lubricant................295,313
Transmission.....................See Transaxle
Transmitter Battery Service.................. 23
Transmitter, Garage Door Opener............ 115
Transmitter, Remote Keyless Entry............ 19
Transporting Pets........................ 61
Tread Wear Indicators.................... 228
Trip Odometer.......................... 142
Trip Odometer Reset Button................ 142
Turn Signals...................106,139,309,310
Uniform Tire Quality Grades................ 342
Universal Joints......................... 283
Universal Transmitter..................... 115
Unleaded Gasoline....................... 235
Vanity Mirrors........................... 73
Variance, Compass....................... 152
Vehicle Certification Label................. 241Vehicle Identification Number................ 6
Vehicle Loading......................241,243
Vehicle Modifications/Alterations.............. 7
Vehicle Storage.......................192,306
Vehicle Theft Alarm....................... 24
Video Entertainment System................ 170
Warning Flasher, Hazard.................. 250
Warnings and Cautions..................... 6
Warranty Information..................... 339
Washer, Adding Fluid..................109,285
Washers, Windshield..................... 107
Washing Vehicle......................... 301
Wheel Alignment and Balance............... 229
Wheel and Wheel Trim.................... 302
Wheel Bearings......................... 300
Wind Buffeting.......................31,123
Window Fogging........................ 192
Windows.............................. 30
360 INDEX