power steering CHRYSLER PACIFICA 2005 1.G User Guide

Refrigerant Recovery And Recycling
R-134a Air Conditioning Refrigerant is a hydrofluorocar-
bon (HFC) that is endorsed by the Environmental Pro-
tection Agency and is an ozone-saving product. How-
ever, the manufacturer recommends that air conditioning
service be performed by dealers or other service facilities
using recovery and recycling equipment.
NOTE:Air Conditioning systems found to be contami-
nated with A/C System Sealers, Stop Leak Products, Seal
Conditioners, Compressor Oil, or Refrigerants not ap-
proved by the manufacturer, voids the warranty for the
Air Conditioning system.
A/C Air Filter
The filter access door is located under the instrument
panel on the passenger side. To replace the filter slide the
lock toward the rear of the vehicle (unlock position).
Remove the access door and pull the filter downward.When installing a new filter, ensure its proper orienta-
tion. Align the black arrow on the bottom of the filter
frame with the direction of airflow (away from the
blower motor and towards the center of the car).
Refer to the “Maintenance Schedules” section of this
manual for the recommended air conditioning filter
replacement intervals.
Power Steering — Fluid Check
Checking the power steering fluid level at a defined
service interval is not required. The fluid should only be
checked if a leak is suspected, abnormal noises are
apparent, and/or the system is not functioning as antici-
pated. Coordinate inspection efforts through a certified
DaimlerChrysler Dealership.
294 MAINTAINING YOUR VEHICLE

WARNING!
Fluid level should be checked on a level surface and
with the engine off to prevent injury from moving
parts and to insure accurate fluid level reading. Do
not overfill. Use only manufacturers recommended
power steering fluid.
If necessary, add fluid to restore to the proper indicated
level. With a clean cloth, wipe any spilled fluid from all
surfaces. Refer to Recommended Fluids, Lubricants, and
Genuine Parts for correct fluid type.
Front & Rear Suspension Ball Joints
The suspension ball joints are permanently sealed. No
regular maintenance is required for these components.
Steering Shaft Seal
The steering shaft seal, at the point where the shaft passes
through the bulkhead, is lubricated when it is installed. If
the seal becomes noisy when the steering shaft is turned,
it should be lubricated with a multi-purpose grease.
Mopar multi-purpose lubricant is recommended.
Steering Linkage
The tie rod end ball joints are permanently lubricated and
do not require periodic maintenance.
Drive Shaft Universal Joints
Your vehicle has constant velocity universal joints. Peri-
odic lubrication of these joints is not required. However,
the joint boots should be inspected for external leakage or
damage when other maintenance is performed. If leakage
or damage is evident, the universal joint boot and grease
should be replaced immediately.
MAINTAINING YOUR VEHICLE 295
7

Brakes
In order to assure brake system performance, all brake
system components should be inspected periodically.
Suggested service intervals can be found in the Mainte-
nance Schedules.
WARNING!
Riding the brakes can lead to brake failure and
possibly an accident. Driving with your foot resting
or riding on the brake pedal can result in abnormally
high brake temperatures, excessive lining wear, and
possible brake damage. You wouldn’t have your full
braking capacity in an emergency.
Brake And Power Steering Hoses
When the vehicle is serviced for scheduled maintenance,
inspect surface of hoses and nylon tubing for evidence of
heat and mechanical damage. Hard and brittle rubber,cracking, tears, cuts, abrasion, and excessive swelling
indicate deterioration of the rubber. Particular attention
should be made to examining those hose surfaces nearest
to high heat sources, such as the exhaust manifold.
Insure nylon tubing in these areas has not melted or
collapsed.
Inspect all hose connections such as clamps and cou-
plings to make sure they are secure and no leaks are
present.
NOTE:Often, fluid such as oil, power steering fluid,
and brake fluid are used during assembly plant opera-
tions to facilitate the assembly of hoses to couplings.
Therefore, oil wetness at the hose-coupling area is not
necessarily an indication of leakage. Actual dripping of
hot fluid when systems are under pressure (during
vehicle operation), should be noted before a hose is
replaced based on leakage.
304 MAINTAINING YOUR VEHICLE

Chassis
Component Fluids, Lubricants and Genuine Parts
Automatic Transmission MoparATF+4 Automatic Transmission Fluid.
AWD Power Transfer Unit MoparGear Lubricant 75W-90.
AWD Overrunning Clutch MoparATF+4 Automatic Transmission Fluid.
AWD Rear Carrier MoparGear Lubricant 75W-90.
Brake Master Cylinder MoparDOT 3 and SAE J1703 should be used. If DOT 3 brake fluid is not
available, then DOT 4 or DOT 4+ is acceptable. Use only recommended
brake fluids.
Power Steering Reservoir MoparATF+4 Automatic Transmission Fluid.
MAINTAINING YOUR VEHICLE 327
7

Block Heater......................... 212
Break-In Recommendations................ 59
Checking Oil Level..................... 284
Compartment......................... 280
Coolant............................. 326
Cooling............................. 298
Exhaust Gas Caution..................29,251
Fails to Start.......................... 211
Fuel Requirements..................248,325
Oil ...........................284,325,326
Oil Change Interval.................... 286
Oil Selection.......................286,325
Oil Synthetic......................... 288
Overheating.......................... 263
Temperature Gauge..................... 144
Engine Oil Viscosity Chart................. 287
Exhaust Gas Caution..............29,60,251,298
Exhaust System......................... 297
Extender, Seat Belt........................ 41Exterior Folding Mirrors................... 68
Filters
Air Cleaner.......................... 289
Air Conditioning....................204,294
Automatic Transaxle.................... 309
Engine Fuel.......................... 289
Engine Oil........................288,326
Engine Oil Disposal.................... 288
Flashers
Hazard Warning....................... 262
Turn Signal.....................145,322,324
Floor Console.......................... 133
Fluid Capacities......................... 325
Fluid Leaks............................. 62
Fluid Level Checks
Automatic Transaxle.................... 308
Brake............................... 327
Power Steering.....................294,327
364 INDEX

Overhead Travel Information Center.......... 122
Overheating, Engine...................144,263
Owner’s Manual.......................4,356
Panic Alarm............................ 21
Parking Brake.......................... 218
Parking On Hill......................... 218
Passing Light........................... 113
Pedals, Adjustable....................... 118
Pets.................................. 59
Phone, Cellular.......................... 71
Phone, Hands-Free....................... 71
Placard, Tire and Loading Information......... 229
Power
Brakes.............................. 219
Distribution Center..................... 316
Door Locks........................... 16
Lift Gate............................. 27
Mirrors.............................. 69Outlet.............................. 131
Seats................................ 93
Steering............................. 222
Steering, Checking..................... 294
Sunroof............................. 129
Windows............................. 29
Pregnant Women and Seat Belts.............. 41
Preparation for Jacking.................... 266
Pretensioners
Seat Belts............................. 39
Programmable Electronic Features......124,128,154
Programming Transmitters............21,124,128
Radial Ply Tires......................... 237
Radiator Cap........................... 301
Radio.............................161,165
Radio Broadcast Signals................... 191
Radio Operation......................166,194
Radio Remote Controls.................178,190
370 INDEX

Starting and Operating.................... 210
Starting Procedures...................... 210
Steering
Linkage............................. 295
Power...........................222,294
Shaft Seal............................ 295
Tilt Column.......................... 116
Steering Wheel Mounted Sound System
Controls............................. 190
Storage............................133,319
Storage, Vehicle......................203,319
Storing Your Vehicle...................... 319
Sulfur in Gasoline....................... 250
Sun Roof.............................. 129
Sun Visor Extension....................... 70
Sunglass Storage........................ 122
Sunroof Maintenance..................... 131
Supplemental Restraint System - Airbag........ 42
System, Navigation...................... 194Tachometer............................ 148
Tape Player............................ 170
Temperature Control, Automatic............. 195
Temperature Gauge, Engine Coolant.......144,263
Tether Anchor, Child Restraint.............52,54
Theft Alarm............................ 24
Theft System............................ 24
Theft System Arming...................... 24
Theft System Disarming.................... 25
Tie Down Hooks, Cargo................... 135
Tilt Steering Column..................... 116
Tire and Loading Information Placard......... 229
Tire Identification Number (TIN)............. 228
Tire Markings.......................... 224
Tire Safety Information.................... 224
Tires ............................62,233,357
Air Pressure.......................... 233
Alignment........................... 241
Chains.............................. 245
INDEX 373
10