coolant temperature CHRYSLER PACIFICA 2005 1.G Owners Manual

INSTRUMENT CLUSTER DESCRIPTIONS
1. Voltage Light
This light monitors the electrical system voltage.
The light should turn on momentarily as the
engine is started. If the light stays on or turns on while
driving, it indicates a problem with the charging system.
Immediate service should be obtained.
2. Temperature Gauge
The temperature gauge shows engine coolant tempera-
ture. Any reading within the normal range indicates that
the engine cooling system is operating satisfactorily.
The gauge pointer will likely indicate a higher tempera-
ture when driving in hot weather, up mountain grades,
or when towing a trailer. It should not be allowed to
exceed the upper limits of the normal operating range.
CAUTION!
Driving with a hot engine cooling system could
damage your vehicle. If temperature gauge reads (H),
Pull over in a safe area as soon as possible and stop
the vehicle. Idle the vehicle with the air conditioner
turned off until the pointer drops back into the
normal range. If the pointer remains on the“H”, and
you hear continuous chimes, turn the engine off
immediately, and call for service.
UNDERSTANDING YOUR INSTRUMENT PANEL 165
4

Whenever a change is noticed in the sound of the exhaust
system, when exhaust fumes can be detected inside the
vehicle, or when the underside or rear of the vehicle is
damaged, have a competent mechanic inspect the com-
plete exhaust system and adjacent body areas for broken,
damaged, deteriorated, or mispositioned parts. Open
seams or loose connections could permit exhaust fumes
to seep into the passenger compartment. In addition,
inspect the exhaust system each time the vehicle is raised
for lubrication or oil change. Replace as required.
WARNING!
Exhaust gases can injure or kill. They contain carbon
monoxide (CO) which is colorless and odorless.
Breathing it can make you unconscious and can
eventually poison you. To avoid breathing CO, fol-
low the preceding safety tips.
Cooling System
WARNING!
•When working near the radiator cooling fan, dis-
connect the fan motor lead or turn the ignition
switch to the OFF position. The fan is temperature
controlled and can start at any time the ignition
switch is in the ON position.
•You or others can be badly burned by hot coolant
or steam from your radiator. If you see or hear
steam coming from under the hood, don’t open
the hood until the radiator has had time to cool.
Never try to open a cooling system pressure cap
when the radiator is hot.
340 MAINTAINING YOUR VEHICLE

Coolant Checks
Check engine coolant (antifreeze) protection every 12
months (before the onset of freezing weather, where
applicable). If coolant is dirty or rusty in appearance, the
system should be drained, flushed and refilled with fresh
coolant. Check the front of the A/C condenser for any
accumulation of bugs, leaves, etc. If dirty, clean by gently
spraying water from a garden hose vertically down the
face of the condenser.
Check the coolant recovery bottle tubing for brittle rub-
ber, cracking, tears, cuts and tightness of the connection
at the bottle and radiator. Inspect the entire system for
leaks.
With the engine at normal operating temperature (but
not running), check the cooling system pressure cap for
proper vacuum sealing by draining a small amount of
coolant from the radiator drain cock. If the cap is sealing
properly, the engine coolant (antifreeze) will begin todrain from the coolant recovery bottle. DO NOT RE-
MOVE THE COOLANT PRESSURE CAP WHEN THE
COOLING SYSTEM IS HOT.
Cooling System—Drain, Flush and Refill
At the intervals shown on the Maintenance Schedules,
the system should be drained, flushed and refilled.
If the solution is dirty or contains a considerable amount
of sediment, clean and flush with a reliable cooling
system cleaner. Follow with a thorough rinsing to remove
all deposits and chemicals. Properly dispose of old
antifreeze solution.
Selection Of Coolant
Use only the manufacturers recommended coolant, refer
to Recommended Fluids, Lubricants and Genuine Parts
for correct coolant type.
MAINTAINING YOUR VEHICLE 341
7

CAUTION!
Mixing of coolants other than specified HOAT en-
gine coolants, may result in engine damage and may
decrease corrosion protection. If a non-HOAT cool-
ant is introduced into the cooling system in an
emergency, it should be replaced with the specified
coolant as soon as possible.
Do not use plain water alone or alcohol base engine
coolant (antifreeze) products. Do not use additional
rust inhibitors or antirust products, as they may not
be compatible with the radiator engine coolant and
may plug the radiator.
This vehicle has not been designed for use with
Propylene Glycol based coolants. Use of Propylene
Glycol based coolants is not recommended.
Adding Coolant
Your vehicle has been built with an improved engine
coolant that allows extended maintenance intervals. This
coolant can be used up to 5 Years or 100,000 miles before
replacement. To prevent reducing this extended mainte-
nance period, it is important that you use the same
coolant throughout the life of your vehicle. Please review
these recommendations for using Hybrid Organic Addi-
tive Technology (HOAT) coolant.
When adding coolant, a minimum solution of 50% rec-
ommended Mopar Antifreeze/ Coolant 5 Year/100,000
Mile Formula HOAT (Hybrid Organic Additive Technol-
ogy), or equivalent, in water should be used. Use higher
concentrations (not to exceed 70%) if temperatures below

34°F(
37°C ) are anticipated.
Use only high purity water such as distilled or deionized
water when mixing the water/engine coolant solution.
342 MAINTAINING YOUR VEHICLE

The use of lower quality water will reduce the amount of
corrosion protection in the engine cooling system.
Please note that it is the owner’s responsibility to main-
tain the proper level of protection against freezing ac-
cording to the temperatures occurring in the area where
the vehicle is operated.
NOTE:Mixing coolant types will decrease the life of the
engine coolant and will require more frequent coolant
changes.
Cooling System Pressure Cap
The cap must be fully tightened to prevent loss of
coolant, and to insure that coolant will return to the
radiator from the coolant recovery bottle.
The cap should be inspected and cleaned if there is any
accumulation of foreign material on the sealing surfaces.
WARNING!
•The warning words“DO NOT OPEN HOT”on
the cooling system pressure cap are a safety pre-
caution. Never add coolant when the engine is
overheated. Do not loosen or remove the cap to
cool an overheated engine. Heat causes pressure
to build up in the cooling system. To prevent
scalding or injury, do not remove the pressure cap
while the system is hot or under pressure.
•Do not use a pressure cap other than the one
specified for your vehicle. Personal injury or
engine damage may result.
MAINTAINING YOUR VEHICLE 343
7

Disposal of Used Engine Coolant
Used ethylene glycol based engine coolant is a regulated
substance requiring proper disposal. Check with your
local authorities to determine the disposal rules for your
community. To prevent ingestion by animals or children
do not store ethylene glycol based engine coolant in open
containers or allow it to remain in puddles on the
ground. If ingested by a child, contact a physician
immediately. Clean up any ground spills immediately.
Coolant Level
The coolant bottle provides a quick visual method for
determining that the coolant level is adequate. With the
engine off and cold, the coolant level in the coolant
recovery bottle should be between the ranges indicated
on the bottle.
The radiator normally remains completely full, so there is
no need to remove the radiator cap unless checking for
coolant freeze point or replacing coolant. Advise yourservice attendant of this. As long as the engine operating
temperature is satisfactory, the coolant bottle need only
be checked once a month.
When additional coolant is needed to maintain the
proper level, it should be added to the coolant bottle. Do
not overfill.
Points To Remember
NOTE:When the vehicle is stopped after a few miles (a
few kilometers) of operation, you may observe vapor
coming from the front of the engine compartment. This is
normally a result of moisture from rain, snow, or high
humidity accumulating on the radiator and being vapor-
ized when the thermostat opens, allowing hot coolant to
enter the radiator.
If an examination of your engine compartment shows no
evidence of radiator or hose leaks, the vehicle may be
safely driven. The vapor will soon dissipate.
344 MAINTAINING YOUR VEHICLE

Adding Fuel........................... 290
Adding Washer Fluid..................128,339
Additives, Fuel......................... 289
Adjustable Pedals....................... 133
Air Conditioner Maintenance............... 335
Air Conditioning.....................223,228
Air Conditioning Controls................. 223
Air Conditioning Filter.................243,336
Air Conditioning Refrigerant............... 335
Air Conditioning System..........223,228,232,335
Air Conditioning System, Zone Control........ 224
Air Pressure, Tires....................... 273
Airbag................................ 44
Airbag Deployment....................... 56
Airbag Light...................48,50,58,69,173
Airbag Maintenance....................... 58
Airbag, Window......................... 45
Alarm System........................... 25
Alignment and Balance................... 280All Wheel Drive...................255,281,352
Alterations/Modifications, Vehicle............. 7
Antenna, Satellite Radio................... 217
Antifreeze (Engine Coolant)...........341,342,368
Disposal............................ 344
Anti-Lock Brake System (ABS).............. 258
Anti-Lock Warning Light.................. 166
Anti-Theft Security Alarm.................. 25
Appearance Care........................ 354
Arming Theft System...................... 25
Auto Down Power Windows................ 31
Automatic Dimming Mirror................. 76
Automatic Door Locks...................17,18
Automatic Headlights.................... 123
Automatic Temperature Control............. 232
Automatic Transaxle...................... 251
Adding Fluid......................... 370
Interlock System....................... 252
Reset Mode.......................... 252
404 INDEX

DVD Player............................ 203
Electric Remote Mirrors.................... 78
Electrical Power Outlets................... 148
Electronic Speed Control................... 134
Electronic Vehicle Information Center......... 174
Emergency, In Case of
Hazard Warning Flasher................. 300
Jacking............................. 302
Jump Starting......................... 309
Overheating.......................... 301
Emission Control System Maintenance......323,372
Engine............................320,321
Air Cleaner.......................... 331
Air Cleaner Filter...................... 331
Block Heater......................... 250
Break-In Recommendations................ 67
Checking Oil Level..................... 326
Compartment......................320,321Coolant (Antifreeze).................... 369
Cooling............................. 340
Exhaust Gas Caution..................30,290
Fails to Start.......................... 249
Fuel Requirements..................287,368
Oil ...........................326,368,369
Oil Change Interval.................... 327
Oil Disposal.......................... 330
Oil Filler Cap......................328,329
Oil Filter Disposal...................... 330
Oil Selection.......................328,368
Oil Synthetic......................... 330
Overheating.......................... 301
Temperature Gauge..................... 165
Exhaust Gas Caution..............30,68,290,340
Exhaust System......................... 339
Extender, Seat Belt........................ 43
Exterior Folding Mirrors................... 76
408 INDEX

Garage Door Opener..................... 138
GasCap ...........................290,323
Gasoline.............................. 287
Gasoline, Clean Air...................... 287
Gasoline, Reformulated................... 288
Gauges
Coolant Temperature.................... 165
Fuel................................ 166
Speedometer......................... 166
Tachometer.......................... 169
Gearshift.............................. 253
General Information..................15,23,284
Glass Cleaning.......................... 357
Grocery Bag Retainer..................... 115
Gross Axle Weight Rating.................. 292
Gross Vehicle Weight Rating................ 292
Hands-Free Phone........................ 79
Hazard Warning Flasher................... 300Head Phones........................... 211
Head Restraints......................... 104
Headlights............................ 365
Bulb Replacement...................... 364
High Beam........................... 125
High Beam/Low Beam Select Switch........ 125
Passing............................. 125
Replacing............................ 364
Switch.............................. 122
Time Delay.......................... 124
Heated Seats........................... 105
Heater............................... 223
Heater, Engine Block..................... 250
Holder, Cup........................... 150
Homelink Transmitter.................... 138
Hood Release.......................... 119
Hoses.............................345,349
410 INDEX

System, Navigation...................... 222
Tachometer............................ 169
Tape Player............................ 198
Temperature Control, Automatic............. 232
Temperature Gauge, Engine Coolant.......165,301
Tether Anchor, Child Restraint.............59,61
Theft Alarm............................ 25
Theft System............................ 25
Theft System Arming...................... 25
Theft System Disarming.................... 26
Tie Down Hooks, Cargo................... 153
Tilt Steering Column..................... 129
Tire and Loading Information Placard......268,269
Tire Identification Number (TIN)............. 267
Tire Markings.......................... 263
Tire Safety Information.................... 263
Tires ............................69,272,401
Air Pressure.......................... 272Alignment........................... 280
Chains.............................. 284
Changing............................ 302
Compact Spare........................ 276
General Information.................... 272
High Speed.......................... 275
Inflation Pressures..................... 273
Jacking............................. 302
Load Capacity.....................268,269
Pressure Monitor System................. 281
Quality Grading....................... 401
Radial.............................. 276
Replacement.......................279,281
Rotation............................. 286
Safety...........................263,272
Sizes............................... 265
Snow Tires........................... 285
Spare Tire........................... 304
Spinning............................ 278
418 INDEX