fuel cap CHRYSLER PACIFICA 2007 1.G User Guide

NOTE:When reinstalling the wheel center cap, insure
that the valve stem symbol on the back of the cap is
pointed toward the wheel valve stem. Install the center
cap using hand pressure only. Do not use a hammer.
Wheel Nuts
All wheel nuts should be tightened occasionally to elimi-
nate the possibility of wheel studs being sheared or the
bolt holes in the wheels becoming elongated. This is
especially important during the first few hundred miles
of operation, and after each time a tire is changed, to
allow the wheel nuts to become properly set. All nuts
should first be firmly seated against the wheel. The nuts
should then be tightened to recommended torque.
Tighten the nuts to final torque in increments. Progress
around the bolt circle, tightening the nut opposite to the
nut just previously tightened until final torque is
achieved. Recommended torque is 130 N·m (95 ft. lbs).
JUMP-STARTING PROCEDURE
WARNING!
•Do not attempt to push or tow your vehicle to get it started.
Vehicles equipped with an automatic transmission cannot be
started this way. Unburned fuel could enter the catalytic
converter and once the engine has started, ignite and damage
the converter and vehicle. If the vehicle has a discharged
battery, booster cables may be used to obtain a start from
another vehicle. This type of start can be dangerous if done
improperly, so follow this procedure carefully.
•Battery fluid is a corrosive acid solution; do not allow battery
fluid to contact eyes, skin or clothing. Don’t lean over battery
when attaching clamps or allow the clamps to touch each other.
If acid splashes in eyes or on skin, flush contaminated area
immediately with large quantities of water.
•A battery generates hydrogen gas which is flammable and
explosive. Keep flame or spark away from the vent holes. Do
not use a booster battery or any other booster source with an
output that exceeds 12 volts.
•Take care to avoid the radiator cooling fan whenever the hood
is raised. It can start anytime the ignition switch is on. You can
be hurt by the fan.
354 WHAT TO DO IN EMERGENCIES

MAINTAINING YOUR VEHICLE
CONTENTS

4.0L Engines..........................364

3.8L Engines..........................365

Onboard Diagnostic System — OBD II........366
▫Loose Fuel Filler Cap Message............366

Emissions Inspection And Maintenance
Programs............................367

Replacement Parts......................368

Dealer Service.........................369

Maintenance Procedures..................369▫Engine Oil..........................369
▫Engine Oil Filter......................374
▫Drive Belts — Check Condition And Tension . . 374
▫Spark Plugs.........................374
▫Engine Air Cleaner Filter................374
▫Catalytic Converter....................375
▫Maintenance-Free Battery................376
▫Air Conditioner Maintenance.............378
▫Power Steering — Fluid Check............379
7

ONBOARD DIAGNOSTIC SYSTEM — OBD II
Your vehicle is equipped with a sophisticated onboard
diagnostic system called OBD II. This system monitors
the performance of the emissions, engine, and automatic
transmission control systems. When these systems are
operating properly, your vehicle will provide excellent
performance and fuel economy, as well as engine emis-
sions well within current government regulations.
If any of these systems require service, the OBD II system
will turn on the “Malfunction Indicator Light.” It will
also store diagnostic codes and other information to
assist your service technician in making repairs. Al-
though your vehicle will usually be drivable and not
need towing, see your dealer for service as soon as
possible.CAUTION!
•Prolonged driving with the “Malfunction Indica-
tor Light” on could cause further damage to the
emission control system. It could also affect fuel
economy and driveability. The vehicle must be
serviced before any emissions tests can be per-
formed.
•If the “Malfunction Indicator Light” is flashing
while the engine is running, severe catalytic con-
verter damage and power loss will soon occur.
Immediate service is required.
Loose Fuel Filler Cap Message
After fuel is added, the vehicle diagnostic system can
determine if the fuel filler cap is loose, improperly
installed, or damaged. A loose fuel filler cap message will
be displayed in the instrument cluster. Tighten the gas
366 MAINTAINING YOUR VEHICLE

Engine Oil Viscosity (SAE Grade) — 3.8 Liter
Engines
SAE 5W-20 engine oil is recommended for all operating
temperatures. This engine oil improves low temperature
starting and vehicle fuel economy. Your engine oil filler
cap also shows the recommended engine oil viscosity for
your vehicle.
For information on engine oil filler cap location, refer to
the Engine Compartment illustration in this section.
Lubricants which do not have both, the engine oil certi-
fication mark and the correct SAE viscosity grade num-
ber should not be used.
Synthetic Engine Oils
There are a number of engine oils being promoted as
either synthetic or semi-synthetic. If you chose to use
such a product, useonlythose oils that are AmericanPetroleum Institute (API) Certified and have the recom-
mended SAE viscosity grade. Follow the maintenance
schedule that describes your driving type.
Materials Added to Engine Oil
The manufacture strongly recommends against the addi-
tion of any additives (other than leak detection dyes) to
the engine oil. Engine oil is an engineered product and
it’s performance may be impaired by supplemental ad-
ditives.
Disposing of Used Engine Oil And Oil Filters
Care should be taken in disposing of used engine oil and
oil filters from your vehicle. Used oil and oil filters,
indiscriminately discarded, can present a problem to the
environment. Contact your dealer, service station, or
governmental agency for advice on how and where used
oil and oil filters can be safely discarded in your area.
MAINTAINING YOUR VEHICLE 373
7

FLUIDS AND CAPACITIES
U.S. Metric
Fuel23 gallons 87 liters
Engine Oil-With Filter
4.0 Liter Engines (SAE 10W-30, API Certified) 5.5 qts 5.2 liters
3.8 Liter Engines (SAE 5W-20, API Certified) 5.0 qts 4.7 liters
Cooling System *
4.0 Liter Engines (MoparAntifreeze/Coolant 5 Year/
100,000 Mile Formula or equivalent)10.7 qts 10.1 liters
3.8 Liter Engines (MoparAntifreeze/Coolant 5 Year/
100,000 Mile Formula or equivalent)11.8 qts 11.2 liters
* Includes heater and coolant recovery bottle filled to MAX level.
MAINTAINING YOUR VEHICLE 411
7

FLUIDS, LUBRICANTS AND GENUINE PARTS
Engine
Component Fluids, Lubricants and Genuine Parts
Engine Coolant MoparAntifreeze/Coolant 5 Year/100,000 Mile Formula HOAT (Hybrid Or-
ganic Additive Technology) or equivalent
4.0 Liter Engine Oil Use API Certified SAE 10W-30 engine oil, refer to oil viscosity chart for cor-
rect SAE grade meeting DaimlerChrysler Material Standard MS-6395.
3.8 Liter Engine Oil Use API Certified SAE 5W-20 engine oil. Refer to your oil filler cap for cor-
rect SAE grade, meeting DaimlerChrysler Material Standard MS-6395.
Spark Plugs Refer to the Vehicle Emission Control Information label in the engine com-
partment.
Oil Filter, 4.0/3.8 Liter Engines Mopar5281090 or equiv.
Fuel Selection 89 Octane
412 MAINTAINING YOUR VEHICLE

Selection Of Lubricant................392,413
Shifting............................. 272
Special Additives...................... 394
Automatic Transmission................... 392
Adding Fluid......................... 393
Fluid and Filter Changes................. 394
Fluid Change......................... 394
Fluid Level Check...................... 393
Fluid Type........................... 392
Autostick...........................151,274
Ball Joints............................. 380
Battery............................... 376
Gas Caution.......................... 377
Jump Starting......................... 354
Keyless Transmitter Replacement (RKE)....... 25
Bearings.............................. 396
Belts, Drive............................ 374
Body Mechanism Lubrication............... 381B-Pillar Location........................ 293
Brake, Parking.......................... 276
Brake System........................278,389
Anti-Lock (ABS)....................... 279
Fluid Check.......................390,413
Hoses.............................. 389
Warning Light........................ 182
Brakes.............................278,389
Brake/Transmission Interlock............... 271
Break-In Recommendations, New Vehicle........ 79
Bulb Replacement....................... 406
Bulbs, Light............................ 406
Calibration, Compass..................... 197
Camera, Rear........................... 146
Capacities, Fluid........................ 411
Caps, Filler
Fuel................................ 321
Oil (Engine).......................372,373
INDEX 447
10

Driving
On Slippery Surfaces.................... 287
DVD Player (Video Entertainment System)...... 221
E-85 Fuel............................. 324
Electric Remote Mirrors.................... 90
Electrical Power Outlets................... 163
Electronic Speed Control (Cruise Control)...... 150
Electronic Vehicle Information Center (EVIC) . 146,191
Emergency, In Case of
Hazard Warning Flasher................. 344
Jacking............................. 346
Jump Starting......................... 354
Overheating.......................... 345
Emission Control System Maintenance......367,416
Engine............................364,365
Air Cleaner.......................... 375
Air Cleaner Filter...................... 374
Block Heater......................... 270Break-In Recommendations................ 79
Checking Oil Level..................... 369
Compartment......................364,365
Coolant (Antifreeze).................... 412
Cooling............................. 383
Exhaust Gas Caution..................39,321
Flooded, Starting...................... 268
Fuel Requirements...................318,411
Oil ...........................369,411,412
Oil Change Interval.................... 371
Oil Disposal.......................... 373
Oil Filler Cap......................372,373
Oil Filter Disposal...................... 373
Oil Selection.......................371,411
Oil Synthetic......................... 373
Overheating.......................... 345
Temperature Gauge..................... 180
Event Data Recorder...................... 65
Exhaust Gas Caution..............39,79,321,383
450 INDEX

Exhaust System......................... 382
Extender, Seat Belt........................ 49
Exterior Folding Mirrors................... 89
Filters
Air Cleaner.......................... 374
Air Conditioning....................259,379
Automatic Transaxle.................... 394
Engine Oil........................374,412
Engine Oil Disposal.................... 373
Flashers
Hazard Warning....................... 344
Turn Signal.....................181,408,409
Flexible Fuel Vehicles
Cruising Range........................ 326
Engine Oil........................... 325
Fuel Requirements..................... 324
Maintenance.......................... 326
Replacement Parts..................... 326Starting............................. 325
Flooded Engine Starting................... 268
Floor Console.......................... 166
Fluid Capacities......................... 411
Fluid Leaks............................. 81
Fluid Level Checks
Automatic Transmission................. 393
Brake............................390,413
Power Steering.....................379,413
Fluids................................ 412
Fluids, Lubricants and Genuine Parts.......... 412
Fog Light Service........................ 409
Fog Lights.......................137,186,409
Folding Rear Seat........................ 124
Freeing A Stuck Vehicle................... 356
Fuel................................. 318
Adding............................. 321
Additives............................ 320
Clean Air............................ 318
INDEX 451
10

Filler Cap (Gas Cap).................... 321
Gasoline............................ 318
Gauge.............................. 181
Hoses.............................. 391
Octane Rating......................318,412
Requirements......................318,411
Tank Capacity........................ 411
Fuel, Flexible.............See Flexible Fuel Vehicles
Fuel System Caution..................... 320
Fueling............................... 321
Fuses................................ 402
Garage Door Opener (HomeLink) ........... 154
Gas Cap (Fuel Filler Cap)............321,323,366
Gasoline, Clean Air...................... 318
Gasoline (Fuel)......................... 318
Gasoline, Reformulated................... 319
Gauges
Coolant Temperature.................... 180Fuel................................ 181
Speedometer......................... 181
Tachometer.......................... 184
Gearshift.............................. 272
General Information..................18,26,317
Glass Cleaning.......................... 400
Grocery Bag Retainer..................... 126
Gross Axle Weight Rating...............327,330
Gross Vehicle Weight Rating.............327,330
Hands-Free Phone (UConnect™).............. 91
Hazard Warning Flasher................... 344
Head Phones........................... 230
Head Restraints......................... 115
Headlights............................ 407
Bulb Replacement...................... 406
High Beam........................... 138
High Beam/Low Beam Select Switch........ 138
Passing............................. 138
452 INDEX