engine coolant CHRYSLER PACIFICA 2008 1.G User Guide

WARNING!
²The warning words ªDO NOT OPEN HOTº on
the cooling system pressure cap are a safety pre-
caution. Never add coolant when the engine is
overheated. Do not loosen or remove the cap to
cool an overheated engine. Heat causes pressure to
build up in the cooling system. To prevent scald-
ing or injury, do not remove the pressure cap while
the system is hot or under pressure.
²Do not use a pressure cap other than the one
specified for your vehicle. Personal injury or en-
gine damage may result.
Disposal of Used Engine Coolant
Used ethylene glycol based engine coolant is a regulated
substance requiring proper disposal. Check with your
local authorities to determine the disposal rules for yourcommunity. To prevent ingestion by animals or children
do not store ethylene glycol based engine coolant in open
containers or allow it to remain in puddles on the
ground. If ingested by a child, contact a physician
immediately. Clean up any ground spills immediately.
Engine Coolant Level
The coolant bottle provides a quick visual method for
determining that the coolant level is adequate. With the
engine off and cold, the coolant level in the coolant
recovery bottle should be between the ranges indicated
on the bottle.
The radiator normally remains completely full, so there is
no need to remove the radiator cap unless checking for
coolant freeze point or replacing coolant. Advise your
service attendant of this. As long as the engine operating
temperature is satisfactory, the coolant bottle need only
be checked once a month.
392 MAINTAINING YOUR VEHICLE

When additional coolant is needed to maintain the
proper level, it should be added to the coolant bottle. Do
not overfill.
Points To Remember
NOTE:When the vehicle is stopped after a few miles (a
few kilometers) of operation, you may observe vapor
coming from the front of the engine compartment. This is
normally a result of moisture from rain, snow, or high
humidity accumulating on the radiator and being vapor-
ized when the thermostat opens, allowing hot coolant to
enter the radiator.
If an examination of your engine compartment shows no
evidence of radiator or hose leaks, the vehicle may be
safely driven. The vapor will soon dissipate.
²Do not overfill the coolant recovery bottle.
²Check coolant freeze point in the radiator and in the
coolant recovery bottle. If antifreeze needs to be
added, contents of coolant recovery bottle must also be
protected against freezing.
²If frequent coolant additions are required, or if the
level in the coolant recovery bottle does not drop when
the engine cools, the cooling system should be pres-
sure tested for leaks.
²Maintain coolant concentration at 50% HOAT engine
coolant (minimum) and distilled water for proper
corrosion protection of your engine which contains
aluminum components.
²Make sure that the radiator and coolant recovery
bottle overflow hoses are not kinked or obstructed.
²Keep the front of the radiator clean. If your vehicle is
equipped with air conditioning, keep the front of the
condenser clean, also.
MAINTAINING YOUR VEHICLE 393
7

FLUIDS AND CAPACITIES
U.S. Metric
FuelAll Engines23 gallons 87 liters
Engine Oil-With Filter
4.0 Liter Engines (SAE 10W-30, API Certified) 5.5 qts 5.2 liters
3.8 Liter Engines (SAE 5W-20, API Certified) 5.0 qts 4.7 liters
Cooling System *
4.0 Liter Engines (MopartAntifreeze/Coolant 5 Year/100,000 Mile Formula or equiva-
lent)10.7 qts 10.1 liters
3.8 Liter Engines (MopartAntifreeze/Coolant 5 Year/100,000 Mile Formula or equiva-
lent)11.8 qts 11.2 liters
* Includes heater and coolant recovery bottle filled to MAX level.
416 MAINTAINING YOUR VEHICLE

FLUIDS, LUBRICANTS AND GENUINE PARTS
Engine
Component Fluids, Lubricants and Genuine Parts
Engine Coolant MopartAntifreeze/Coolant 5 Year/100,000 Mile Formula HOAT (Hybrid Or-
ganic Additive Technology) or equivalent
3.8 Liter Engine Oil Use API Certified SAE 5W-20 engine oil. Refer to your oil filler cap for cor-
rect SAE grade, meeting DaimlerChrysler Material Standard MS-6395.
4.0 Liter Engine Oil Use API Certified SAE 10W-30 engine oil, refer to oil viscosity chart for cor-
rect SAE grade meeting DaimlerChrysler Material Standard MS-6395.
Oil Filter, 3.8L & 4.0L Engines Mopart5281090 or equivalent. Refer to your oil filler cap for correct SAE
grade.
Spark Plugs 3.8L & 4.0L Engines ZFR5LP-13G (Gap.050 in / 1.27 mm
Fuel Selection 3.8L 87 Octane
Fuel Selection 4.0L 89 Octane
MAINTAINING YOUR VEHICLE 417
7

²Check the fluid levels of coolant reservoir, brake
master cylinder, power steering and transmission and
add as needed.
²Check all lights and other electrical items for correct
operation.At Each Oil Change
²Change the engine oil filter.
²Inspect the brake hoses and lines.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
422 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Perform Maintenance Every(Where time and mileage
are listed, follow the interval that occurs first.)
Maintenance Items Miles Kilometers or Months
Change Rear Drive Assembly (RDA) fluid. 60,000 100 000 60
Change Power Transfer Unit (PTU) fluid. 60,000 100 000 60
Change the automatic transmission fluid & filter if
using your vehicle for any of the following: police,
taxi, fleet or frequent trailer towing.60,000 100 000 60
Inspect and replace PCV valve if necessary.90,000 150 000 90
Flush and replace the engine coolant. 102,000 170 000 60
Replace the ignition cables on 3.3L and 3.8L engines.102,000 170 000 102
Replace the spark plugs on 3.8L, 4.0L engines.102,000 170 000 102
Replace the timing belt on 4.0L engine.102,000 170 000 102
Change the automatic transmission fluid & filter. 120,000 200 000 120
Replace Accessory Drive Belt(s). 120,000 200 000 120
424 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Adding Fuel........................... 329
Adding Washer Fluid..................142,387
Additives, Fuel......................... 327
Adjustable Pedals....................... 159
Air Conditioner Maintenance............... 383
Air Conditioning.....................251,256
Air Conditioning Controls................. 251
Air Conditioning Filter.................269,384
Air Conditioning Refrigerant............... 383
Air Conditioning System..........251,256,259,383
Air Conditioning System, Zone Control........ 252
Air Pressure, Tires....................... 304
Airbag................................ 50
Airbag Deployment....................... 62
Airbag Light...................54,55,64,79,197
Airbag Maintenance....................... 64
Airbag, Window (Side Curtain)............... 51
Alarm (Security Alarm).................... 18
Alignment and Balance.................... 311All Wheel Drive (AWD)................284,400
Alterations/Modifications, Vehicle............. 7
Antenna, Satellite Radio................... 248
Antifreeze (Engine Coolant)...........390,391,416
Disposal............................ 392
Anti-Lock Brake System (ABS)............153,288
Anti-Lock Warning Light.................. 188
Anti-Theft System........................ 18
Appearance Care........................ 401
Auto Down Power Windows................ 32
Auto Up Power Windows.................. 33
Automatic Dimming Mirror................. 86
Automatic Door Locks...................27,28
Automatic Headlights.................... 137
Automatic Oil Change Indicator..........192,202
Automatic Temperature Control (ATC)......... 259
Automatic Transaxle....................12,278
Adding Fluid......................... 418
Interlock System.....................15,280
438 INDEX

Caps, Filler
Fuel................................ 329
Oil (Engine).......................... 378
Radiator (Coolant Pressure)............... 391
Car Washes............................ 402
Carbon Monoxide Warning................. 328
Cargo Area Cover....................... 176
Cargo Compartment
Luggage Carrier....................... 178
Cargo Tie-Downs........................ 177
Catalytic Converter...................... 380
Caution, Exhaust Gas...................78,388
CD (Compact Disc) Changer..........218,228,232
CD (Compact Disc) Player......212,216,222,226,232
CD (Compact Disc) Player Maintenance........ 250
Cellular Phone........................89,250
Chains, Tire............................ 312
Changing A Flat Tire..................... 352
Chart, Tire Sizing........................ 296Check Engine Light (Malfunction Indicator
Light).............................193,373
Child Restraint........................67,69
Child Restraint Tether Anchors.............71,74
Child Safety Locks........................ 30
Child Seat.............................. 75
Clean Air Gasoline....................... 326
Cleaning
Wheels............................. 403
Climate Control......................... 250
Clock................................ 209
Compact Disc (CD) Maintenance............. 250
Compact Spare Tire...................... 307
Compass.............................. 207
Compass Calibration..................... 207
Compass Variance....................... 207
Computer, Trip/Travel.................... 208
Console.............................. 175
Console, Floor.......................... 175
440 INDEX

Console, Overhead....................... 168
Contract, Service........................ 430
Coolant Pressure Cap (Radiator Cap).......... 391
Cooling System......................... 389
Adding Coolant (Antifreeze).............. 391
Coolant Capacity...................... 416
Coolant Level......................389,392
Disposal of Used Coolant................ 392
Drain, Flush, and Refill.................. 390
Inspection........................... 392
Points to Remember.................... 393
Pressure Cap......................... 391
Radiator Cap......................... 391
Selection of Coolant (Antifreeze)......390,416,417
Cruise Control (Speed Control).............. 144
Cruise Light........................... 193
Cup Holder.........................174,406
Customer Assistance..................... 428Data Recorder, Event...................... 65
Dealer Service.......................... 375
Defroster, Rear Window................... 269
Defroster, Windshield................79,256,265
Delay (Intermittent) Wipers................. 141
Diagnostic System, Onboard................ 372
Digital Video Disc (DVD) Player............. 232
Dimmer Switch, Headlight................. 139
Dipsticks
Automatic Transmission................. 399
Oil (Engine).......................... 376
Disabled Vehicle Towing................... 363
Disposal
Antifreeze (Engine Coolant)............... 392
Engine Oil........................... 379
Door Ajar Light......................... 197
Door Locks............................. 26
Door Locks, Automatic.................... 27
Door Opener, Garage..................... 146
INDEX 441
10

Drive Belts............................ 379
Drive Shaft Universal Joints................ 386
Driving
On Slippery Surfaces.................... 291
Through Flowing, Rising, or Shallow Standing
Water.............................. 292
DVD Player (Video Entertainment System)...... 232
Electric Remote Mirrors.................... 88
Electrical Power Outlets................... 172
Electronic Brake Control System............. 154
Brake Assist System.................... 154
Electronic Stability Program............... 155
Traction Control System................. 154
Electronic Speed Control (Cruise Control)...... 144
Electronic Stability Program (ESP)............ 155
Electronic Vehicle Information Center
(EVIC).............................166,199Emergency, In Case of
Hazard Warning Flasher................. 350
Jacking............................. 352
Jump Starting......................... 360
Overheating.......................... 351
Emission Control System Maintenance......373,420
Engine..........................77,370,371
Air Cleaner.......................... 380
Air Cleaner Filter...................... 380
Block Heater......................... 278
Break-In Recommendations................ 77
Checking Oil Level..................... 376
Compartment......................370,371
Coolant (Antifreeze).................... 417
Cooling............................. 389
Exhaust Gas Caution..................37,328
Flooded, Starting...................... 277
Fuel Requirements..................325,416
Oil ...........................376,416,417
442 INDEX